- Page 3: (12)Fuel tank, oil tank 5.Electric
- Page 11: C. Wheel bearing part
- Page 14 and 15: 2.Weak acceleration: Check and Adju
- Page 17 and 18: 4.Engine running unsmoothly (high s
- Page 20 and 21: 9.Oil indicator malfunction (a)The
- Page 22 and 23: (b)Fuel gauge needle is not steady
- Page 24 and 25: (b)Starting motor running slowly or
- Page 27: 3.Checking and Adjustment: (1)Regul
- Page 34: (5)Spark plug 1.Remove spark plug 2
- Page 40 and 41: 4.Dismantling, maintaining, repairi
- Page 42 and 43: 3.Removing oil pump. Clean the oil
- Page 44 and 45: (2)Dismantling & assembling of plas
- Page 46 and 47: 6.Screwing out the screws of left s
- Page 48 and 49: 9.Take off the upper & lower handle
- Page 50 and 51: 13.Disconnect the negative cable fi
- Page 52 and 53: 4.Remove the cap of spark plug. 5.R
- Page 54 and 55:
(4)Drive pulley, starter, clutch, d
- Page 56 and 57:
3.Remove the fixing nut of clutch.
- Page 58 and 59:
9.Assenbke driving pulley, please r
- Page 60 and 61:
D. Starter dismantling 1.Dismantle
- Page 62 and 63:
c. Check driven spring free length:
- Page 64 and 65:
C-2. PISTON & CYLINDER DATAS for 50
- Page 66 and 67:
6.Screwing out the two M6-nut of mu
- Page 68 and 69:
E. Check for the flatness of cylind
- Page 70 and 71:
4.Piston outer diameter measurement
- Page 72 and 73:
8.Check connecting rod small end (1
- Page 74 and 75:
5.Remove the flywheel. 6.Remove the
- Page 76 and 77:
3.Remove the bolt in gear box cover
- Page 78 and 79:
(8)Crankcase, Crankshaft: A. Disass
- Page 80 and 81:
D. Dismantle the crankcase and cran
- Page 82 and 83:
7.Remove cylinder, AC flywheel magn
- Page 84 and 85:
3.measure the swingness of crank sh
- Page 87 and 88:
C. Troubleshooting: a. Engine can n
- Page 89 and 90:
F. Reed valve 1.Dismantling reed va
- Page 91 and 92:
(10)Steering column, front wheel, f
- Page 93 and 94:
D. Steering handlebar. 1.Remove the
- Page 95 and 96:
F. Front wheel: 1.Remove the lockin
- Page 97 and 98:
F. Front Brake 1.Disassembling and
- Page 99 and 100:
G. Front fork 1.Front fork system d
- Page 101 and 102:
C. Disassembling and assembling the
- Page 103 and 104:
F. Rear damper 1.Rear damper disass
- Page 105 and 106:
C. Fuel tank dismantling and assemb
- Page 107 and 108:
D. Oil tank disassembling diagram:
- Page 109 and 110:
(1)Troubleshooting: A. Recharge sys
- Page 111 and 112:
2.Testing the recharging performanc
- Page 113 and 114:
2.Check A.C. Generator a. Open the
- Page 116:
2.check the starter Connect green/w