5.5 initial diagnostic check: efi - harley-davidson-sweden.se
5.5 initial diagnostic check: efi - harley-davidson-sweden.se
5.5 initial diagnostic check: efi - harley-davidson-sweden.se
Create successful ePaper yourself
Turn your PDF publications into a flip-book with our unique Google optimized e-Paper software.
HOME<br />
Diagnostic Check (Part 1 of 2)<br />
Does engine<br />
start?<br />
YES.<br />
Starts and<br />
runs.<br />
YES.<br />
Starts, then<br />
stalls.<br />
NO.<br />
Cranks, but<br />
will not start.<br />
NO.<br />
Engine will not<br />
crank.<br />
Check for trouble<br />
codes. See 5.6<br />
SPEEDOMETER<br />
SELF DIAGNOSTICS<br />
Codes found?<br />
See 5.12 STARTS, THEN<br />
STALLS.<br />
See 5.10 ENGINE CRANKS,<br />
BUT WILL NOT START.<br />
See 1.2 STARTING SYSTEM<br />
DIAGNOSIS.<br />
YES<br />
Refer to applicable trouble code priority chart.<br />
All <strong>diagnostic</strong> codes are listed on page 5-11<br />
in Table 5-5. Codes are listed by priority.<br />
NO<br />
Unable to enter <strong>diagnostic</strong> mode.<br />
With ignition switch OFF, press and<br />
relea<strong>se</strong> odometer re<strong>se</strong>t switch.<br />
Does odometer display appear with<br />
display backlighting?<br />
1<br />
NO<br />
No codes displayed. For<br />
symptoms that may not <strong>se</strong>t<br />
<strong>diagnostic</strong> trouble codes,<br />
refer to table 5-2, Table 5-3<br />
and Table 5-4.<br />
YES<br />
NO<br />
STOP<br />
Go to Diagnostic<br />
Check (Part 2 of 2).<br />
Check for continuity to ground on terminal 7<br />
of speedometer. Wiggle harness during continuity<br />
<strong>check</strong>. Continuity pre<strong>se</strong>nt?<br />
YES<br />
NO<br />
Check for battery voltage at<br />
terminal 5 of speedometer<br />
while wiggling harness. Battery<br />
voltage continuously<br />
pre<strong>se</strong>nt?<br />
Locate and repair open<br />
between terminal 7<br />
and ground.<br />
YES<br />
NO<br />
Check continuity (with ignition<br />
switch OFF) between terminals<br />
8 and 11 on breakout box. Continuity<br />
pre<strong>se</strong>nt when speedometer<br />
re<strong>se</strong>t switch is depres<strong>se</strong>d?<br />
Locate and repair open<br />
between terminal 5 and<br />
battery fu<strong>se</strong>.<br />
Replace speedometer.<br />
Replace speedometer<br />
re<strong>se</strong>t switch.<br />
2004 Touring: Engine Management (EFI) 5-15