36e Operator's Manual 2011.pdf - Marlow-Hunter, LLC

More documents

Recommendations

Info

Fig. 2.1 Documents and Forms DEALER: _____________________________ ENGINE:_________________________________ MAKE:_______________________________ OWNER: ________________________________ PORT ENGINE NO: ____________________ STBD. ENGINE NO: _______________________ BOAT NAME:__________________________REGISTRYR NO:_________________________ ___ OPERATION___________INITIALS________ OPERATION____________ INITIALS_________ BEFORE LAUNCHING BEFORE STARTINGT ENGINES 1. Hull Side Clean and Gelcoat 23. All engine wiring in good order & tight 2. Bright work clean and finish 24. Throttle control and cable travel 3. Decks cleaned and gelcoat 25. Clutch control and cable travel 4. Interior Finish 26. Crankcase oil level at FULL mark 5. Upholstery clean and carpet in place 27. Reverse gear oil level at FULL mark 6. Bilge cleaned. 7. Bottom clean and paint 28. No fuel leaks in fuel lines, at fittings, at 8. Both shafts turn freely fuel filter, fuel pump 9. Engines and Generator intakes installed 29. No engine water or oil leaks 10. All hull fittings sealed 11. All drain plugs tight, (hull, engines, generator, muffler) 30. Oil pressure and exhaust water flow 12. Sacrificial Anodes installed10 31. Idling speed set at 700-800 RPM and is in proper adjustment WITH BOAT IN WA TER 13. Hose test for cabin and window leaks 14. No water leaks at thru hull fitting with seacocks 15. No water leaks at shaft or rudder 16. With all switches off - no spark when battery cable touched to post 17. All electrical equipment operating including: horn( ); running light( ); bilge pump( ) 18. Toilet operates 19. Water (pressure) system operates 20. Galley stove operates 21. With fuel tanks full, no fuel leaks at fill pipes, overflow vent, or at any fuel line connections 22. With coupling disconnected, engine and shaft alignment INSPECTION DATE:____________________ ___ DEALERS SIGNATURE: _______________________________________________________ OWNERS SIGNATURE: Pre-delivery Service Record WA TER TEST BOAT 33. Engine performance 34. Instruments are registering properly 35. Top RPM wide open throttle for one minute after warm-up 36. Boat performance FINAL CHECK: 37. All accessory equipment operating 38. Carpets and drapes installed and clean 39. All loose equipment on boat ready for new owner. ___________________________________________________________ COMMENTS:____________________________ __________________________________________ _______________________________________________________________________________ 2.10
Documents and Forms Float Plan Name of Operator____________________________________________________Age____________________ Address____________________________________________________________________________________ Phone______________________________________________________________________________________ Boat Make ________________________________ Model__________________________________ Length _______________________ Hull Color_________________Deck Color___________________________ Registration No._____________________________Home Port________________________________________ Radio frequencies____________________________________________________________________________ Equipment on Board, PFDs, Flares, Anchor ______________________________________________________ ___________________________________________________________________________________________ Fuel Capacity ______________________________ Water Capacity____________________________________ Distinguishing Features________________________________________________________________________ ____________________________________________________________________________________________ Departed from_______________________________________________________________________________ Date____________________________________________ Time________________________________________ Destination__________________________________________________________________________________ Stops_______________________________________________________________________________________ Estimated time of Arrival: Date_______________________Time________________________________________ Name, age, address and phone number of other persons on board: _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ _______________________________________________________________________________________ 2.11
Page 1: Operator's Manual e36 V 090310
Page 4 and 5: Operator's Manual As the owner of a
Page 6 and 7: Operator's Manual How do I prevent
Page 8 and 9: Operator's Manual 10. Sanitary Syst
Page 10 and 11: Introduction 1.1 The Manual Packet
Page 12 and 13: Introduction Hunter recommends that
Page 14 and 15: Introduction Notes: 1.6
Page 16 and 17: Documents and Forms Your Hunter dea
Page 18 and 19: Documents and Forms Preliminary car
Page 20 and 21: Documents and Forms ____ Smoke dete
Page 22 and 23: Documents and Forms ____ Alternator
Page 26 and 27: Documents and Forms Maintenance Log
Page 28 and 29: Documents and Forms (Several copies
Page 30 and 31: Documents and Forms Power Squadron
Page 32 and 33: Documents and Forms List of onboard
Page 34 and 35: Documents and Forms Dates of practi
Page 36 and 37: Documents and Forms Notes: 2.22
Page 38 and 39: Hunter • Limited Warranty This Pa
Page 40 and 41: Hunter • Limited Warranty Hunter
Page 42 and 43: Hunter • Limited Warranty OWNER I
Page 44 and 45: Hunter • Limited Warranty SAMPLE
Page 46 and 47: Hunter • Limited Warranty GRAPHIC
Page 48 and 49: Boating Safety As you read your own
Page 50 and 51: Boating Safety • • • • •
Page 52 and 53: Boating Safety • As always, you c
Page 54 and 55: Boating Safety DANGER ! D Figure 4.
Page 56 and 57: Boating Safety • For minimum prot
Page 58 and 59: Boating Safety immediate concern. H
Page 60 and 61: Boating Safety One Prolonged Blast
Page 62 and 63: Boating Safety Interior Arrangement
Page 64 and 65: Boating Safety FEET METERS HULL LEN
Page 66 and 67: Boating Safety ! CAUTION ! be aware
Page 68 and 69: Boating Safety Notes: 4.22
Page 70 and 71: Fuel Systems FUEL SAFETY CHECKLIST
Page 72 and 73: Fuel Systems ! WARNING ! Fuel leaki
Page 74 and 75:
Fuel Systems 1. Make sure the engin
Page 76 and 77:
! DANGER ! Explosive fuel vapors ca
Page 78 and 79:
Fuel Systems 5.5.12 Environmental I
Page 80 and 81:
Fuel Systems Fuel System ! DANGER !
Page 82 and 83:
Fuel Systems Notes: 5.14
Page 84 and 85:
Underwater Gear Underwater Gear You
Page 86 and 87:
Underwater Gear 6.2.2 Rudders Your
Page 88 and 89:
Underwater Gear NOTE: THE FORWARD "
Page 90 and 91:
Underwater Gear Thru Hulls Port and
Page 92 and 93:
Underwater Gear Notes: 6.10
Page 94 and 95:
DC Electric DC Electric Systems Thi
Page 96 and 97:
DC Electric 7.2.3 Battery Charging
Page 98 and 99:
12V DC PORT DC AMPS STBD START-STOP
Page 100 and 101:
DC Electric tery switch panel suppl
Page 102 and 103:
DC Electric Troubleshooting Problem
Page 104 and 105:
DC Electric Notes: 7.12
Page 106 and 107:
Notes: DC Electric 7.14
Page 108 and 109:
AC Electric Systems AC Electric Sys
Page 110 and 111:
E F AC Electric Systems repellent b
Page 112 and 113:
AC Electric Systems charged. After
Page 114 and 115:
AC Electric Systems Troubleshooting
Page 116 and 117:
AC Electric Systems This Page Inten
Page 118 and 119:
AC Electric Systems Notes: 8.12
Page 120 and 121:
Water Systems The fresh and raw wat
Page 122 and 123:
Water Systems 9.3 Pickups and Strai
Page 124 and 125:
Water Systems Troubleshooting Probl
Page 126 and 127:
Water Systems This Page Intentional
Page 128 and 129:
Water Systems This Page Intentional
Page 130 and 131:
Water Systems Notes: 9.12
Page 132 and 133:
Waste and Sanitation Systems This s
Page 134 and 135:
Waste and Sanitation Systems shower
Page 136 and 137:
Waste and Sanitation Systems 10.5.2
Page 138 and 139:
Waste and Sanitation Systems Troubl
Page 140 and 141:
Waste and Sanitation Systems This P
Page 142 and 143:
Waste and Sanitation Systems This P
Page 144 and 145:
Waste and Sanitation Systems Notes:
Page 146 and 147:
Engines and Transmissions The follo
Page 148 and 149:
Engines and Transmissions The raw w
Page 150 and 151:
Engines and Transmissions Troublesh
Page 152 and 153:
High oil pressure Sludge in oil Eng
Page 154 and 155:
Engines and Transmissions This Page
Page 156 and 157:
Sails and Rigging Sails & Rigging M
Page 158 and 159:
Sails and Rigging — the lazy shee
Page 160 and 161:
Sails and Rigging 12.12 Protecting
Page 162 and 163:
Sails and Rigging Standing Rigging
Page 164 and 165:
Sails and Rigging Mast Upper Spread
Page 166 and 167:
Sails and Rigging Standing Rigging
Page 168 and 169:
Sails and Rigging HUNTER e36 FURL S
Page 170 and 171:
Sails and Rigging Typical Boom Reef
Page 172 and 173:
Sails and Rigging Optional Vang Det
Page 174 and 175:
Sails and Rigging Boat: HUNTER 36 C
Page 176 and 177:
Sails and Rigging Bridle Configurat
Page 178 and 179:
Sails and Rigging Lazy Jack Install
Page 180 and 181:
Sails and Rigging Notes: 12.26
Page 182 and 183:
Getting Underway Before you go on t
Page 184 and 185:
Getting Underway ! WARNING ! In ord
Page 186 and 187:
Getting Underway harness or Bosun
Page 188 and 189:
Getting Underway Notes: 13.8
Page 190 and 191:
Maintenance Maintenance (The inform
Page 192 and 193:
Maintenance ish out the stainless f
Page 194 and 195:
Maintenance is easy to keep clean.
Page 196 and 197:
Maintenance tion. * Realign propell
Page 198 and 199:
Maintenance on board to allow good
Page 200 and 201:
Diesel Engines Maintenance Routine
Page 202 and 203:
Maintenance Notes: 14.14
Page 204 and 205:
Maintenance This Page Intentionally
Page 206 and 207:
Glossary A Aback: describes a sail
Page 208 and 209:
Glossary Leech: 1, the after edge o
Page 210:
line; two transit give position fix
show all

36e Operator's Manual 2011.pdf - Marlow-Hunter, LLC

Create successful ePaper yourself

Delete template?

Save as template?