cps screenwash a8 - FUJIFILM Australia

products.fujifilm.com.au

cps screenwash a8 - FUJIFILM Australia

CPS SCREEN WASH A8Chemwatch Independent Material Safety Data SheetIssue Date: 25-Jul-2013 CHEMWATCH 4861-169317SP(cs)Version No:2.1.1.1CD 2013/2 Page 1 of 7Section 1 - CHEMICAL PRODUCT AND COMPANY IDENTIFICATIONPRODUCT NAMECPS SCREEN WASH A8PRODUCT USEInk cleaner for printing inks.SUPPLIERCompany: FUJIFILM Australia Pty LtdAddress:114 Old Pittwater RoadBrookvaleNSW, 2100AustraliaTelephone: +61 2 9466 2600Emergency Tel:+61 1800 039 008Emergency Tel:+61 3 9573 3112Fax: +61 2 9938 1975Section 2 - HAZARDS IDENTIFICATIONSTATEMENT OF HAZARDOUS NATURENON-HAZARDOUS SUBSTANCE. NON-DANGEROUS GOODS. According to NOHSC Criteria, and ADG Code.COMBUSTIBLE LIQUID, regulated under AS1940 for Bulk Storage purposes only.CHEMWATCH HAZARD RATINGSFlammabilityToxicityBody ContactReactivityChronicSCALE: Min/Nil=0 Low=1 Moderate=2 High=3 Extreme=4RISKRisk CodesRisk PhrasesR52/53 • Harmful to aquatic organisms, may cause long- term adverseeffects in the aquatic environment.Section 3 - COMPOSITION / INFORMATION ON INGREDIENTSNAME CAS RN %solvent naphtha petroleum, heavy aromatic 64742-94-5 5-10dipropylene glycol monomethyl ether 34590-94-8 1-5gamma- butyrolactone 96-48-0 1-5alcohols C12- 18 ethoxylated 68213-23-0 1-5alcohols C9- 11 ethoxylated 68439-46-3 1-5continued...


CPS SCREEN WASH A8Chemwatch Independent Material Safety Data SheetIssue Date: 25-Jul-2013 CHEMWATCH 4861-169317SP(cs)Version No:2.1.1.1CD 2013/2 Page 4 of 7Section 8 - EXPOSURE CONTROLS / PERSONAL PROTECTIONSOLVENT NAPHTHA PETROLEUM, HEAVY AROMATIC:■ Odour threshold: 0.25 ppm.The TLV-TWA is protective against ocular and upper respiratory tract irritation and is recommended for bulk handling ofgasoline based on calculations of hydrocarbon content of gasoline vapour.REL TWA: 100 ppm [Manufacturer]CEL TWA: 100 ppm, 550 mg/m3DIPROPYLENE GLYCOL MONOMETHYL ETHER:■ for dipropylene glycol monomethyl ether:The TLV-TWA and STEL recommendations were thought to be sufficiently low to prevent objectionable irritation and provide aconsiderable safety factor against CNS impairment. In view of the large dose required to cause weight loss and narcosis inrabbits the skin notation is being reviewed.Probable minimum concentration that may cause minor nasal irritation is about 35 ppm.Probable minimum concentration that may cause tolerable eye, throat, and respiratory irritation is about 75 ppm.PERSONAL PROTECTIONRESPIRATOR•Type A-P Filter of sufficient capacity. (AS/NZS 1716 & 1715, EN 143:2000 & 149:2001, ANSI Z88 or national equivalent)EYE• Safety glasses with side shields.• Chemical goggles.• Contact lenses may pose a special hazard; soft contact lenses may absorb and concentrate irritants. A written policy document,describing the wearing of lens or restrictions on use, should be created for each workplace or task. This should include areview of lens absorption and adsorption for the class of chemicals in use and an account of injury experience. Medical andfirst-aid personnel should be trained in their removal and suitable equipment should be readily available. In the event ofchemical exposure, begin eye irrigation immediately and remove contact lens as soon as practicable. Lens should be removed atthe first signs of eye redness or irritation - lens should be removed in a clean environment only after workers have washedhands thoroughly. [CDC NIOSH Current Intelligence Bulletin 59], [AS/NZS 1336 or national equivalent].HANDS/FEET• Wear chemical protective gloves, e.g. PVC.• Wear safety footwear or safety gumboots, e.g. Rubber.The selection of the suitable gloves does not only depend on the material, but also on further marks of quality which vary frommanufacturer to manufacturer. Where the chemical is a preparation of several substances, the resistance of the glove material cannot be calculated in advance and has therefore to be checked prior to the application.The exact break through time for substances has to be obtained from the manufacturer of the protective gloves andhas to be observed when making a final choice.Suitability and durability of glove type is dependent on usage. Important factors in the selection of gloves include:OTHER• Overalls.• P.V.C. apron.• Barrier cream.• Skin cleansing cream.ENGINEERING CONTROLS■ Engineering controls are used to remove a hazard or place a barrier between the worker and the hazard. Well-designedengineering controls can be highly effective in protecting workers and will typically be independent of worker interactions toprovide this high level of protection.The basic types of engineering controls are:Process controls which involve changing the way a job activity or process is done to reduce the risk.Enclosure and/or isolation of emission source which keeps a selected hazard "physically" away from the worker and ventilationthat strategically "adds" and "removes" air in the work environment.Section 9 - PHYSICAL AND CHEMICAL PROPERTIESAPPEARANCEClear colourless liquid with a characteristic odour; emulsifies with water.continued...


CPS SCREEN WASH A8Chemwatch Independent Material Safety Data SheetIssue Date: 25-Jul-2013 CHEMWATCH 4861-169317SP(cs)Version No:2.1.1.1CD 2013/2 Page 5 of 7Section 9 - PHYSICAL AND CHEMICAL PROPERTIESPHYSICAL PROPERTIESLiquid.Mixes with water.State Liquid Molecular Weight Not ApplicableMelting Range (°C) Not Available Viscosity Not AvailableBoiling Range (°C) 180- 240 Solubility in water (g/L) MiscibleFlash Point (°C) 81 (Setaflash CC) pH (1% solution) Not AvailableDecomposition Temp (°C) Not Available pH (as supplied) Not AvailableAutoignition Temp (°C) 230 Vapour Pressure (kPa) Not AvailableUpper Explosive Limit (%) 15.6 Specific Gravity (water=1) 1.05Lower Explosive Limit (%) 0.6 Relative Vapour Density Not Available(air=1)Volatile Component (%vol) Not Available Evaporation Rate 1Section 10 - STABILITY AND REACTIVITYCONDITIONS CONTRIBUTING TO INSTABILITY• Presence of incompatible materials.• Product is considered stable.• Hazardous polymerisation will not occur.For incompatible materials - refer to Section 7 - Handling and Storage.Section 11 - TOXICOLOGICAL INFORMATIONPOTENTIAL HEALTH EFFECTSACUTE HEALTH EFFECTSSWALLOWED■ Accidental ingestion of the material may be damaging to the health of the individual.Ingestion may result in nausea, abdominal irritation, pain and vomiting.EYE■ There is some evidence to suggest that this material can cause eye irritation and damage in some persons.Non-ionic surfactants can cause numbing of the cornea, which masks discomfort normally caused by other agents and leads tocorneal injury. Irritation varies depending on the duration of contact, the nature and concentration of the surfactant.SKIN■ There is some evidence to suggest that this material can cause inflammation of the skin on contact in some persons.One of the mechanisms of skin irritation caused by surfactants is considered to be denaturation of the proteins of skin. It hasalso been established that there is a connection between the potential of surfactants to denature protein in vitro and theireffect on the skin.Open cuts, abraded or irritated skin should not be exposed to this material.Entry into the blood-stream, through, for example, cuts, abrasions or lesions, may produce systemic injury with harmful effects.Examine the skin prior to the use of the material and ensure that any external damage is suitably protected.INHALED■ The material is not thought to produce adverse health effects or irritation of the respiratory tract (as classified by ECDirectives using animal models). Nevertheless, good hygiene practice requires that exposure be kept to a minimum and thatsuitable control measures be used in an occupational setting.CHRONIC HEALTH EFFECTS■ There has been some concern that this material can cause cancer or mutations but there is not enough data to make an assessment.Substance accumulation, in the human body, may occur and may cause some concern following repeated or long-term occupationalexposure.TOXICITY AND IRRITATION■ Not available. Refer to individual constituents.CARCINOGENdipropylene glycol Australia Exposure Standards Carcinogen Category Skmonomethyl ethercontinued...


CPS SCREEN WASH A8Chemwatch Independent Material Safety Data SheetIssue Date: 25-Jul-2013 CHEMWATCH 4861-169317SP(cs)Version No:2.1.1.1CD 2013/2 Page 6 of 7Section 11 - TOXICOLOGICAL INFORMATIONgamma- International Agency for Group 3 Not classifiable asbutyrolactone Research on Cancer (IARC) - to itsAgents Reviewed by the IARCcarcinogenicity toMonographshumansSKINdipropylene glycol Australia Exposure Standards - Skin Notes Skmonomethyl ethergamma- butyrolactone GESAMP/EHS Composite List - GESAMP Hazard D1: skin 0Profilesirritation/corrosionSection 12 - ECOLOGICAL INFORMATIONHarmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment.EcotoxicityIngredient Persistence: Persistence: Air Bioaccumulation MobilityWater/Soilsolvent naphtha petroleum, heavy No Data No Data No Data No Dataaromatic Available Available Available Availabledipropylene glycol monomethyl HIGH No Data LOW HIGHetherAvailablegamma- butyrolactone LOW No Data LOW HIGHAvailablealcohols C12- 18 ethoxylated No Data No Data No Data No DataAvailable Available Available Availablealcohols C9- 11 ethoxylated No Data No Data No Data No DataAvailable Available Available AvailableSection 13 - DISPOSAL CONSIDERATIONS• Recycle wherever possible or consult manufacturer for recycling options.• Consult State Land Waste Authority for disposal.• Bury or incinerate residue at an approved site.• Recycle containers if possible, or dispose of in an authorised landfill.Section 14 - TRANSPORTATION INFORMATIONLabels Required: COMBUSTIBLE LIQUID, regulated under AS1940 for Bulk Storage purposes only.HAZCHEM:None (ADG7)NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS: ADG7, IATA, IMDGSection 15 - REGULATORY INFORMATIONPOISONS SCHEDULE NoneREGULATIONSRegulations for ingredientssolvent naphtha petroleum, heavy aromatic (CAS: 64742-94-5) is found on the followingregulatory lists;"Australia Exposure Standards","Australia FAISD Handbook - First Aid Instructions, Warning Statements, and General Safetycontinued...

More magazines by this user
Similar magazines