BRIGHT GALV ASOL.pdf

chemodex.co.uk

BRIGHT GALV ASOL.pdf

PRODUCT SAFETY DATA SHEET1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND COMPANYName of Manufacturer/Supplier: Chemodex LimitedCanal Road, Worksop, Notts, S80 2EH.Tel: (01909) 473301 Fax: (01909) 500961Product Name: BRIGHT GALV AEROSOL2. COMPOSITION/INFORMATION ON INGREDIENTSName EC No. Cas No. Content ClassificationPropane 200-827-9 74-98-6 5-10% F+;R12Butane 203-448-7 106-97-8 30-60% F+;R12Xylene-ortho 30-60% Xn;R10, R20/21, R383. HAZARDS IDENTIFICATIONExtremely flammable. Harmful by inhalation and in contact with the skin. Irritating to skin.PRESSURISED CONTAINER - increase in temperature than 50°C will cause internal pressure to risepotentially causing bursting/explosion.4. FIRST AID MEASURESInhalationIngestionSkin contactEye ContactMove the exposed person to fresh air at once. Keep the affected personwarm and at rest. Get prompt medical attention. For breathingdifficulties oxygen may be necessary.Rinse mouth thoroughly. Drink plenty of water. Get medical attention.Wash the skin immediately with soap and water. Get medical attention ifany discomfort continues.Promptly wash eyes with plenty of water while lifting the eyelids.Continue to rinse for at least 15 minutes. Get medical attention if anydiscomfort continues.5. FIRE FIGHTING MEASURESExtinguishing Media Use: Powder, Dry chemicals, sand, dolomite etc., water spray fog or mist.Special Fire Fighting Containers close to fire should be removed or cooled with water. UseProcedureswater to keep fire exposed containers cool and disperse vapours.Unusual Fire and Explosion Aerosols may explode in a fire.Hazards6. ACCIDENTAL RELEASE MEASURESEnvironmental Precautions Any spillage needs to be contained and not allowed to enter watercourses.Spill Clean Up Methods Wear necessary protective equipment. Extinguish all ignition sources.Avoid sparks, flames, heating and smoking. Ventilate. If leakage cannotbe stopped, evacuate area.7. HANDLING & STORAGEUsage Precautions Keep away from heat, sparks and open flame. Avoid spilling, skin andeye contact. Ventilate well, avoid breathing vapours. Use approvedrespirator if air contamination is above accepted level.Storage Precautions Aerosol cans; must not be exposed to direct sunlight or temperatureabove 50°C.


Product Name: BRIGHT GALV AEROSOL8. EXPOSURE CONTROL/PERSONAL PROTECTIONName Cas No. Std LT EXP 8 hrs ST EXP 15 minsPropane 74-98-6 WEL Asphyxiating AsphyxiatingButane 106-97-8 WEL 600 ppm 750 ppmIngredient Comments WEL = Workplace Exposure Limits.Engineering MeasuresRespiratory ProtectionHand ProtectionEye ProtectionOther ProtectionHygiene MeasuresProvide adequate general and local exhaust ventilation.No specific recommendation made, but respiratory protection must beused if the general level exceeds the Recommended Workplace ExposureLimit. Use chemical cartridge protection with appropriate cartridge.Use protective gloves made of: Nitrile.Wear approved chemical safety goggles where eye exposure is reasonablyprobable.Wear appropriate clothing to prevent any possibility of liquid contact andrepeated or prolonged vapour contact.DO NOT SMOKE IN WORK AREA! Wash at the end of each workshift and before eating, smoking or using the toilet. Promptly remove anyclothing that becomes contaminated. No eating or drinking whileworking with this material.9. PHYSICAL AND CHEMICAL PROPERTIESAppearance Aerosol Flash Point -74°CPhysical Data Comments Information given Auto Ignition Temperature + 405°Crelates to total aerosol Flammability Limit - Lower 1.8%container contents Flammability Limit - Upper 10.0%10. STABILITY AND REACTIVITYStabilityNormally stable.Conditions to Avoid Avoid heat, flames and other sources of ignition. Increase in temperatureto greater than 50 degrees will cause rise in internal pressure withlikelihood of bursting/explosion.Hazardous Decomposition Fire creates: Vapours/gases/fumes of carbon monoxide (CO) andProductscarbon dioxide (CO2).11. TOXICOLOGICAL INFORMATIONInhalationHarmful by inhalation.Skin ContactHarmful in contact with skin.Eye ContactIrritation of eyes and mucous membranes.12. ECOLOGICAL INFORMATIONEcotoxicityNot regarded as dangerous to the environment.13. DISPOSAL RECOMMENDATIONSDisposal Methods Empty containers must not be burned because of explosion hazard.Dispose of waste and residues in accordance with local authorityrequirements.


Product Name: BRIGHT GALV AEROSOL14. TRANSPORT INFORMATIONUK Road Transport Class 2.1 Proper Shipping Name AerosolsADR Class 2.1 ADR Classification Code 5FUN No. Sea 1950 IMDG Class 2.1UN No. Air 1950 ICAO Class 2.115. REGULATORY INFORMATIONLabellingHarmful, Extremely FlammableRisk Phrases R12: Extremely FlammableR20/21: Harmful by inhalation and in contact with skin.R38: Irritating to skinSafety Phrases S16: Keep away from sources of ignition - No smokingS2: Keep out of reach of childrenS23: Do not breath vapour/sprayS24: Avoid contact with skin.S51: Use only in well ventilated areas.Statutory Requirements Control of Substances Hazardous to Health. Chemicals (HazardInformation and Packaging) Regulations.Approved Codes of Practice Classification and Labelling of Substances and Preparations Dangerousfor Supply.Guidance NotesWorkplace Exposure Limits EH40. Introduction to Local ExhaustVentilation HS(G)37. CHIP for everyone HSG(108).16. OTHER INFORMATIONGeneral Information The following risk phrases relate to the raw materials in the product andnot the product itself.Risk Phrases in Full R10: FlammableR12: Extremely FlammableR20/21: Harmful by inhalation and in contact with skin.R38: Irritating to skinRevision No.3Revision Date: 30/06/03

More magazines by this user
Similar magazines