SAFETY DATA SHEET ULTIMEG 2000/T4 - AMI-CON

REVISION DATE: 13.08.03SPILL CLEAN UP METHODSULTIMEG 2000/T4Extinguish all ignition sources. Avoid sparks, flames, heat and smoking. Ventilate. Clean-up personnel should use respiratory and/or liquidcontact protection. Absorb in vermiculite, dry sand or earth and place into containers.7 HANDLING AND STORAGEUSAGE PRECAUTIONSAvoid spilling, skin and eye contact. Keep away from heat, sparks and open flame. Ventilate well, avoid breathing vapours. Use approvedrespirator if air contamination is above accepted level. Use explosion proof electric equipment.8 EXPOSURE CONTROLS/PERSONAL PROTECTIONNameXYLENEPROTECTIVE EQUIPMENTStd LT - ppm LT - mg/m3 ST - ppm ST - mg/m3OES 50 ppm(Sk) 220 mg/m3(Sk) 100 ppm(Sk) 441mg/m3(Sk)ENGINEERING MEASURESWell-ventilated area.RESPIRATORY EQUIPMENTRespiratory protection must be used if air contamination exceeds acceptable level.HAND PROTECTIONUse protective gloves.EYE PROTECTIONUse approved safety goggles or face shield.OTHER PROTECTIONWear appropriate clothing to prevent any possibility of liquid contact and repeated or prolonged vapour contact.HYGIENE MEASURESDO NOT SMOKE IN WORK AREA! Wash at the end of each work shift and before eating, smoking and using the toilet. Wash promptly withsoap & water if skin becomes contaminated. Promptly remove any clothing that becomes contaminated. Use appropriate skin cream toprevent drying of skin. When using do not eat, drink or smoke.9 PHYSICAL AND CHEMICAL PROPERTIESAPPEARANCECOLOURODOURSOLUBILITYLiquidColourlessOrganic solvents.Insoluble in waterBOILING POINT (°C) 138 - - 142 760 mm Hg RELATIVE DENSITY 0.87 23VAPOUR DENSITY (air=1) 3.7 VAPOUR PRESSURE 0.93VAPOUR PRESSURE 20 VISCOSITY 0.93 20 0.5FLASH POINT (°C) 27 FLASH POINT (°C) Not noted.AUTO IGNITION TEMPERATURE (°C)490 FLAMMABILITY LIMIT - LOWER(%) 1FLAMMABILITY LIMIT - UPPER(%) 6.610 STABILITY AND REACTIVITYSTABILITYStable under normal temperature conditions.CONDITIONS TO AVOIDAvoid heat. Avoid contact with oxidisers or reducing agents.HAZARDOUS DECOMPOSITION PRODUCTSFire creates: Toxic gases/vapours/fumes of: Carbon monoxide (CO). Carbon dioxide (CO2).11 TOXICOLOGICAL INFORMATIONINHALATIONHarmful by inhalation. Vapours may cause headache, fatigue, dizziness and nausea.2 / 4

REVISION DATE: 13.08.03INGESTIONHarmful if swallowed. May cause internal injury.SKIN CONTACTMay be absorbed through the skin. Product has a defatting effect on skin.EYE CONTACTIrritation of eyes and mucous membranes.HEALTH WARNINGSULTIMEG 2000/T4INHALATION. Gas or vapour is harmful on prolonged exposure or in high concentration. SKIN CONTACT. Irritating to skin. Acts as adefatting agent on skin. May cause cracking of skin, and eczema. EYE CONTACT. Irritating to eyes. INGESTION. May cause stomach painor vomiting.ROUTE OF ENTRYInhalation. Skin absorption.12 ECOLOGICAL INFORMATIONECOTOXICITYNot regarded as dangerous for the environment.13 DISPOSAL CONSIDERATIONSDISPOSAL METHODSDispose of waste and residues in accordance with local authority requirements.14 TRANSPORT INFORMATIONPROPER SHIPPING NAMEPAINT or PAINT RELATED MATERIALUN NO. ROAD1263ADR CLASSUN NO. SEA 1263IMDG CLASS3.3IMDG PACK GR.IIIMARINE POLLUTANTUN NO. AIR 1263ICAO CLASS3AIR PACK GR.15 REGULATORY INFORMATIONIIIClass 3: Flammable liquids.No.LABELLINGHarmfulCONTAINSXYLENERISK PHRASESR10Flammable.R38Irritating to skin.R20/21 Harmful by inhalation and in contact with skin.SAFETY PHRASESS24Avoid contact with skin.S36/37 Wear suitable protective clothing and gloves.S51Use only in well-ventilated areas.UK REGULATORY REFERENCESPetroleum (Consolidation) Act, as amended 1984 SI 1244. Highly Flammable Liquid Regulations 1972.ENVIRONMENTAL LISTINGRivers (Prevention of Pollution) Act 1961. Control of Pollution (Special Waste Regulations) Act 1980.3 / 4

REVISION DATE: 13.08.03EU DIRECTIVESULTIMEG 2000/T4System of specific information relating to Dangerous Preparations. 2001/58/EEC.STATUTORY INSTRUMENTSChemicals (Hazard Information and Packaging) Regulations. Control of Substances Hazardous to Health.APPROVED CODE OF PRACTICEClassification and Labelling of Substances and Preparations Dangerous for Supply.GUIDANCE NOTESOccupational Exposure Limits EH40. Introduction to Local Exhaust Ventilation HS(G)37. CHIP for everyone HSG(108).16 OTHER INFORMATIONREVISION DATE 13.08.03SDS NO. 1RISK PHRASES IN FULLR10R20/21R38Flammable.Harmful by inhalation and in contact with skin.Irritating to skin.4 / 4