Owner's Manual - Hunter Fan

hunterfan.com
  • No tags were found...

Owner's Manual - Hunter Fan

Total Air PurificationHEPAAir PurifierOwner’s ManualEnglishModel30847Form# 44030-0120100616©2010 Hunter Fan Co.


Table of ContentsIntroduction ............................................................. 3Safety Instructions ..................................................... 3Setting Up Your Air Purifier ....................................... 5How The System Works ............................................ 6Operating Your Air Purifier ....................................... 7Air Purifier Maintenance ........................................... 7Check or Clean Your Pre-Filter 7Check or Replace Your Filters 8Replace The UVC Bulb 8Clean the Unit 9Troubleshooting ...................................................... 10Technical Support ................................................... 10Filter Ordering ....................................................... 11Warranty ............................................................... 11Products ................................................................ 11Filter and UVC Calendar ........................................ 14Notes .................................................................... 14©2010 Hunter Fan Co. 244030-01 20100616


IntroductionThank you for purchasing the Total Air Purification Systemfrom Hunter Fan Company. You have purchased ourlatest development in Portable Air Purification Systems.This system has been developed to improve the quality ofthe air you breathe.Our HEPA Air Purification System out performs other airpurification systems by quickly and effectively removingdust, smoke, and pollen particles as small as 0.3 micronsin size. The following innovative features are included inyour Hunter Air Purifier.33High Particulate Efficiency: The HEPA filterswill remove up to 99.9% of particles as small as 0.3micron particles from the air that passes through thefilter.33Washable Pre-Filter: The washable pre-filter ispermanent and can be cleaned and reused.33UVC Lamp: This Hunter Air Purifier is equippedwith a UVC germicidal lamp. UVC technology is aproven germicide that is accepted by the FDA andEPA as having the ability to kill pathogens in air thatare exposed to UVC light.33Photocatalitic Oxidation: Reduces the amountof toxic VOCs in the air caused by household cleanersand products.33Oxygenating Catalyst: Converts ozone andsmog into oxygen for cleaner air and peace of mind.Safety InstructionsIMPORTANT!READ ALL INSTRUCTIONS BEFORE USING THIS AIRPURIFIER.1. WARNING: This Air Purifier emits UVC radiation thatmay cause eye and/or skin irritation. RG-3. Avoidexposing eyes and skin to unshielded UVC Lamp.2. Caution: The UVC Lamp may shatter and causeinjury if it is dropped or sustains impact. Wear safetyglasses and gloves when handling the UVC Lamp.Do not use excessive force when handling the UVCLamp. Dispose of the UVC bulb in accordance withlocal or State guidelines as trace amounts of Mercuryare present.©2010 Hunter Fan Co. 344030-01 20100616


3. This Air Purifier is designed for use on a level floor andmay not work properly on an uneven floor. ALWAYSplace the Air Purifier on a firm, level floor. ALWAYSplace the Air Purifier at least six (6) inches away fromwalls and heat sources such as stoves, radiators, orheaters.4. Place the Air Purifier in an area that is out of the reachof children.5. Before using the Air Purifier, extend the cord andinspect for any signs of damage. DO NOT use theproduct if the cord has been damaged.6. To reduce the risk of electric shock, this product hasa polarized plug (one blade is wider than the other)as a safety feature. This plug will fit into a polarizedoutlet only one way. If the plug does not fit fully intothe outlet, reverse the plug. If it still does not fit, contacta qualified electrician. DO NOT attempt to defeat oroverride this safety feature.7. ALWAYS UNPLUG the Air Purifier while it is beingcleaned.8. DO NOT move or tilt the Air Purifier while it is inoperation. Turn off and unplug before moving.9. DO NOT immerse the Air Purifier in water at any timebecause permanent damage will occur. To properlyclean your Air Purifier, follow the instructions in theMaintenance section of this manual “Air PurifierMaintenance” on page 7.10. This equipment should be inspected frequently andcollected dirt removed from it regularly to preventexcessive accumulation that could result in flashoveror risk of fire.©2010 Hunter Fan Co. 444030-01 20100616


Setting Up Your Air Purifier1. Take the Air Purifier out of the box and remove theclear plastic protective bag and place the unit on afirm, level surface.2. Before turning on the Air Purifier, you need to confirmthat the filters are firmly in place and have not becomeloose during shipping. To check the filters, push downon the tab under the handle. Figure 1.3. Gently pull the rear grill away from the unit and liftaway. Figure 2.TabFigure 1.4. The washable Pre-Filter is mounted inside the backgrill of the unit. Confirm that it properly covers thegrill vents.5. The HEPA Filters will be resting inside the unit. Ifpresent, remove the plastic bag surrounding the filterand place the filters back into the Air Purifier. Thefilters should have arrows on the side to indicate airflow and the direction the filter should be placed backinto the unit. Figure 3.6. Set the tab on the bottom of the rear grill into the slotin the base of the unit and rock the grill up until thetop tab snaps into place. Figure 4.Figure 2.7. Plug the unit into a 120V electrical outlet.HEPA FiltersFigure 3.Figure 4.©2010 Hunter Fan Co. 544030-01 20100616


How The System WorksDust and other irritants are pulled into the Air Purifier by the fan. The Washable Pre-Filterattracts larger particles like pet dander and hair and traps them on the Pre-Filter. Smallerparticles such as dust, mold, and pollen pass through the Pre-Filter and are captured by theHEPA filters. Up to 99.9% of particles can be captured.The UVC Light helps kill particles not trapped on the HEPA Filters and the PhotocatalyticOxidation screen removes harmful VOC’s. Clean, purified air is then released into the roomthrough the front grill as the Oxygenating Catalyst converts smog and ozone back intooxygen. Figure 5.UnitUVCLightPhotocatalyticOxidizerWashablePre-FilterGrillOxygenating CatalystHEPA FiltersFigure 5.©2010 Hunter Fan Co. 644030-01 20100616


OFFOperating Your Air PurifierUnit offLow speed - Recommended for use when softbackground noise is unwanted.Medium speed - Typical usage setting. Softbackground noise is not an issue.High speed - Use when quick, efficient resultsto a room’s air quality are desired.UVC ON/OFFUVCIndicatorSpeedcontrolON/OFFON/OFFIndicatorFigure 6.The fan speed can be adjusted at any time by rotating thedial so the indicator light aligns with the desired speed.Press the UVC Light Button to turn on and off the UVCfunction of your Air Purifier.NOTE: The ON/OFF Indicator and the UVC Indicatorwill stay lit while the fan and/or UVC is running.Air Purifier MaintenanceIt is necessary to periodically check your Air Purifierfor performance. If the Pre-Filter and/or HEPA Filtersare covered in dust and other captured particles, it willbe necessary to clean or replace one and or both. ThePre-Filter and Filters should be checked at least every 6months. The UVC Light should be replaced every year.NOTE: Some environments may require more frequentcleaning of each filter. In these situations, adjust the timeyou check your filters to ensure the filters stay clog free tooptimize performance.Check or Clean Your Pre-Filter1. Turn the Air Purifier off and disconnect from the wall.PressDownFigure 7.2. Remove the rear grill on the back of the unit bypressing the tab at the top of the unit, under thehandle and pull the rear grill outward. Figure 7.3. Turn the Rear grill over and gently remove the Pre-Filter from the grill.4. Check the Pre-Filter side facing the grill for particlecoverage.©2010 Hunter Fan Co. 744030-01 20100616


5. If the Pre-Filter needs to be cleaned, It may besubmerged in warm soapy water to clean. Gently liftand submerge the filter several times to clean.6. When complete, rinse the filter with warm water andallow to dry completely.Note: Wet parts placed into the unit can cause damageto the filters and or the motor of the Air Purifier.Check or Replace Your Filters1. Turn the Air Purifier off and disconnect from the wall.2. Remove the rear grill on the back of the unit bypressing the tab at the top of the unit, under thehandle and pull the rear grill outward. Figure 7.3. Remove the HEPA Filters from the unit.4. Check the Filters for particle build-up.Screws5. The HEPA filter should be removed every 12 monthsof use and matched to the color indicator on the insideof the filter compartment. When the filter matches thedark, charcoal gray indicator, it should be replaced. Figure 9.Replace The UVC BulbThe UVC light should be replaced once yearly. Followthese instructions to remove and replace the UVC bulb.1. Unplug the unit from the wall outlet and remove theback grill by pressing down on the top tab.Screws2. Remove the 2 screws holding the Photcatalytic Screenin place and remove the screen. Figure 9.3. Remove the 3 screws holding the UVC Guard in placeand remove it from the unit. Figure 10. & 11.4. Grasp the bulb with your thumbs and forefingers atthe plastic top and bottom and gently roll the bulb tothe left. Figure 12.Figure 10.5. When the bulb releases, slide the top of the bulb outof the bracket and remove.6. Partially remove the new UVC Bulb from it’s packagingbeing careful not to let the bulb come in contact withyour skin.Figure 11.©2010 Hunter Fan Co. 844030-01 20100616


Note: Oils from your skin can cause damage to the bulband will prevent it from working.7. Using the bag the bulb came in to prevent skin contactwith the bulb, insert the base of the bulb into the lowerUVC socket in the unit, with the flat side of the basefacing the opening of the unit. Figure 13.8. Insert the top part of the UVC bulb into the top socketand roll the bulb to the right util it locks into place.Note: If the UVC Bulb Guard is not re-installed correctly,the unit will not run.Figure 12.9. Reattach the UVC Guard by inserting the back tabsinto the Air Purifier and secure the 3 screws holding itback in place. Figure 14.10. Align the Photocatalytic Screen over the 2 holes inthe unit and screw it back into place.11. Set the tab on the bottom of the rear grill into the slotin the base of the unit and rock the grill up until thetop tab snaps into place.Clean the UnitClean the outside of the unit with a soft, damp cloth.The rear grill can be cleaned in soapy water after it hasbeen removed from the unit and the pre-filter has beenremoved.Figure 13.NOTE: Ensure the grill is completely dry beforereinstalling it on the unit. Failure to do so could causedamage to the filters or motor.Figure 14.Figure 15.©2010 Hunter Fan Co. 944030-01 20100616


TroubleshootingProblem:No Operation.Solution:33Confirm that the unit is plugged in.33Check the installation of the Rear grill.33Check the installation of the UVC Lamp Cover.Problem:Unit has reduced air flow or increased noise.Solution:33The filter may be clogged and needs to becleaned. See “Check or Replace Your Filter” onpage 10.Problem:The UVC Lamp is not operating.Solution:33Check the installation of the UVC Bulb.33Replace the UVC Bulb. See “Replace The UVC Bulb”on page 8.Technical SupportIf you have any additional questions or problems withyour Hunter Air Purifier, please call:USA: 1-888-830-1326Canada: 1-866-268-1936Hours of operation are from 7:00 am to 7:00 pmMonday - Friday and 8:00 am to 5:00 pm on Saturday,Central Time. You may also contact us over the Internet atwww.hunterfan.com.©2010 Hunter Fan Co. 1044030-01 20100616


Filter OrderingDepending on usage and the environment, your Hepafilter should be replaced once a year.Replacement filters are available at most retailers thatcarry Hunter Air Purifiers. You may also purchasedirectly from Hunter Fan Company by:Phone: 1-888-830-1326Website: www.hunterfan.com* Applicable state and local taxes may apply.ProductsCeiling FansHumidifiers* Prices are subject to change without notice.* All orders will be shipped USPS or UPS Ground,allow 12-15 working days for delivery.Part#Type30904 HEPA Filter30851 UVC BulbWarrantyHunter Fan CompanyTotal Air Purification System5 YEAR LIMITED WARRANTYThe Hunter Fan Company makes the following limitedwarranty to the original residential user or consumerpurchaser of the Total Air Purification System:If any part of your Total Air Purification System (“AirPurifier”) motor fails during the first five (5) years fromthe date of installation due to a defect in material orworkmanship, we will provide a replacement Air Purifierfree of charge. Installation is deemed to occur at the dateof purchase.If the Air Purifier cord, ionizer, or rear grill fails anytime within one (1) year after installation due to a defectin material or workmanship, we will replace or, at ouroption, repair the unit free of charge at our nearestservice center or at our Service Department in Memphis,Tennessee. You will be responsible for all parts and laborcosts after this one-year period.Air PurifiersThermostatsBath FansOscillating Fans©2010 Hunter Fan Co. 1144030-01 20100616


IF THE ORIGINAL RESIDENTIAL USER OR CONSUMERPURCHASER CEASES TO OWN THE AIR PURIFIER,THIS WARRANTY AND ANY IMPLIED WARRANTYWHICH THEN REMAINS IN EFFECT, INCLUDINGBUT NOT LIMITED TO ANY IMPLIED WARRANTY OFMERCHANTABILITY OR FITNESS FOR A PARTICULARPURPOSE, ARE VOIDED. NO WARRANTY, EXPRESSEDOR IMPLIED, INCLUDING ANY WARRANTY OFMERCHANTABILITY OR FITNESS FOR A PARTICULARPURPOSE, IS MADE IN RESPECT TO THE FILTERMATERIAL OR WASHABLE FILTER. THIS WARRANTY ISIN LIEU OF ALL OTHER EXPRESS WARRANTIES. THEDURATION OF ANY IMPLIED WARRANTY, INCLUDINGBUT NOT LIMITED TO ANY IMPLIED WARRANTY OFMERCHANTABILITY OR FITNESS FOR A PARTICULARPURPOSE, IN RESPECT TO THE MOTOR IS EXPRESSLYLIMITED TO THE PERIOD OF THE EXPRESS WARRANTYSET FORTH ABOVE.WarrantyThis warranty is voided if the air purifier is not purchasedand used in the USA or Canada.This warranty excludes and does not cover defects,malfunctions or failures of the Air Purifier which werecaused by repairs by persons not authorized by us, use ofparts or accessories not authorized by us, mishandling,modifications, or damage to the Air Purifier while inyour possession, or unreasonable use, including failureto provide reasonable and necessary maintenance. Thiswarranty does not cover Air Purifiers used in commercialapplications. There are no express or implied warrantiesas to commercial purchasers or users.To obtain service, contact the nearest Hunter authorizedservice center or the Hunter Fan Company ServiceDepartment, 7130 Goodlett Farms Pkwy., Suite 400,Memphis, TN 38016, 1-888-830-1326. For the nameof our nearest authorized Hunter Fan Company ServiceCenter, write to the Hunter Fan Company at the precedingaddress. You will be responsible for insurance and freightor other transportation to our factory service center. Wewill return the Air Purifier freight prepaid. The Air Purifiershould be properly packaged to avoid damage in transitsince we will not be responsible for any such damage.Proof of purchase is required when requesting warrantyservice. The purchaser must present sales receipt or otherdocument that establishes proof of purchase.©2010 Hunter Fan Co. 1244030-01 20100616


IN NO EVENT SHALL HUNTER FAN COMPANY BE LIABLEFOR DIRECT, INDIRECT, SPECIAL CONSEQUENTIAL ORINCIDENTAL DAMAGES IN EXCESS OF THE PURCHASEPRICE OF THE AIR PURIFIER. YOUR SOLE REMEDYWILL BE REPAIR OR REPLACEMENT AS PROVIDEDABOVE. SOME AMERICAN STATES AND CANADIANPROVINCES DO NOT ALLOW LIMITATIONS ON HOWLONG AN IMPLIED WARRANTY LASTS, SO THE ABOVELIMITATION MAY NOT APPLY TO YOU.WarrantySOME AMERICAN STATES AND CANADIANPROVINCES DO NOT ALLOW THE EXCLUSIONOR LIMITATION OF DIRECT, INDIRECT SPECIAL,INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THEABOVE LIMITATION MAY NOT APPLY TO YOU. SOMEAMERICAN STATES AND CANADIAN PROVINCESDO NOT ALLOW THE EXCLUSION OR INVALIDITYOF EXPRESS OR IMPLIED WARRANTIES IF THE USERCEASES TO OWN THE AIR PURIFIER, SO THE ABOVELIMITATION MAY NOT APPLY TO YOU.THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS,AND YOU MAY ALSO HAVE OTHER RIGHTS WHICHVARY FROM STATE TO STATE OR PROVINCE TOPROVINCE.Fan Company7130 Goodlett Farms Pkwy., Suite 400Memphis, Tennessee 38016To learn more about HunterFan Company products,please see our Web page at:www.hunterfan.com©2010 Hunter Fan Co. 1344030-01 20100616


Filter and UVC CalendarNotesDate of Replacement or CleaningPre-Filter HEPA Filters UVC BulbPrinted in china and Taiwan©2010 Hunter Fan Co. 1444030-01 20100616

More magazines by this user
Similar magazines