Views
3 months ago

O & M Manual

Heat 45 & 55 User

Heat 45 & 55 User Instructions FAN POWERED HIGH EFFICIENCY MODULATING CONDENSING GAS BOILER When replacing any part on this appliance, use only spare parts that you can be assured conform to the safety and performance specification that we require. Do not use reconditioned or copy parts that have not been clearly authorised by Keston. For the very latest copy of literature for specification and maintenance practices visit our website www.keston.co.uk where you can download the relevant information in PDF format.

Keston Heat 45 & 55 Natural Gas PI No. 86 CN 69 Destination Countries: GB, IE, RO Important Notes • This appliance must not be operated without the casing correctly fitted and forming an adequate seal. • If the boiler is installed in a compartment then the compartment MUST NOT be used for storage purposes. • Do not store objects around or on the boiler, and keep access clear at all times. • Do not obstruct ventilation ducts, grilles or openings in the boiler room, room space or compartment that the appliance is installed in, or the passage of combustion and ventilation to the boiler. • Do not turn off the boiler if it is to be left unattended in frosty weather. • If it is known or suspected that a fault exists on the boiler then it MUST NOT BE USED until the fault has been corrected by a Gas Safe Registered Engineer or in IE a competent person. • Flammable materials must not be placed in close proximity to the appliance. Materials giving off flammable vapours must not be stored in the same room as the appliance. Introduction The Keston Heat is a wall mounted, room sealed, super efficient condensing boiler featuring full sequence automatic spark ignition and fan assisted combustion. Due to the very high efficiency, condensate is produced from the flue gases and this is drained to a suitable disposal point through the plastic waste pipe at the bottom of the boiler. A condensate ‘plume’ will also often be visible at the flue terminal. Safety Current Gas Safety (Installation & Use) Regulations or rules in force. In your own interest, and that of safety, it is the law that this boiler must be installed and maintained by a Gas Safe Registered Engineer or in IE a competent person, in accordance with the above regulations. The appliance should be serviced at least once a year by a Gas Safe Registered Engineer or in IE a competent person. It is essential that the instructions in this booklet are strictly followed, for safe and economical operation of the boiler. Electricity Supply The appliance must be earthed. Supply 230 V - 50 Hz. The fusing should be 5A. This appliance is intended to be connected to the supply via a double-pole switch, having a 3mm contact separation in both poles, serving only the boiler and system controls. Alternatively, a 3-pin UNSWITCHED socket may be used. • This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Children shall not play with the appliance. Cleaning and user maintenance shall not be made by children without supervision In cases of repeated or continuous shutdown a Gas Safe Registered Engineer or in IE a competent person should be called to investigate and rectify the condition causing this and carry out an operational test after each intervention on the device. Only the manufacturers original parts should be used for replacement. Minimum Clearances Clearances of 300mm (12”) below, 25mm (1”) at the sides and 450mm (17 3/4”) at the front of the boiler casing must be allowed for servicing. To light the boiler (Refer to Frame 1) 1. CHECK THAT THE ELECTRICITY SUPPLY TO THE BOILER IS OFF. 2. Set the boiler to standby. 3. Switch on the electricity supply to the boiler and check that all external controls, e.g. programmer, room thermostat, etc are on. Allow the boiler to carry out a self check. 4. Set the boiler to winter. The boiler will commence the ignition sequence, supplying heat to the system when required. All Gas Safe Registered Engineers carry a Gas Safe Register ID card, and have a registration number. Both should be recorded in your Log Book. You can check your installer by calling Gas Safe Register direct on 0800 4085500. CAUTION. To avoid the possibility of injury during the installation, servicing or cleaning of this appliance care should be taken when handling edges of sheet steel components. 2 Keston Heat - User’s

  • Page 1 and 2:

    Health & Safety File including Oper

  • Page 3 and 4:

    Health & Safety File Introduction T

  • Page 5 and 6:

    Health & Safety File Health and Saf

  • Page 7 and 8:

    Health & Safety File Description of

  • Page 9 and 10:

    Health & Safety File Material Suppl

  • Page 11 and 12:

    Quote 1055856 Customer name: Graham

  • Page 13 and 14:

    Quote 1056741 Customer name: Graham

  • Page 15 and 16:

    Health & Safety File Drawings and S

  • Page 17 and 18:

    Ivy Cottage Bathrooms Fixtures and

  • Page 19 and 20:

    Ivy Cottage Bathrooms Fixtures and

  • Page 21 and 22:

    Ivy Cottage Bathrooms Fixtures and

  • Page 23 and 24:

    Ivy Cottage Bathrooms Fixtures and

  • Page 25 and 26:

    Ivy Cottage Bathrooms Fixtures and

  • Page 27 and 28:

    Ivy Cottage Paints and Wall Paper S

  • Page 29 and 30:

    Ivy Cottage Paints and Wall Paper S

  • Page 31 and 32:

    Ivy Cottage Paints and Wall Paper S

  • Page 33:

    Health & Safety File Certification

  • Page 44 and 45:

    Riverside Environmental Services Lt

  • Page 46 and 47:

    Job No: J112167 Section 1: Executiv

  • Page 48 and 49:

    Job No: J112167 Locations containin

  • Page 50 and 51:

    Job No: J112167 Section 2: Contact

  • Page 52 and 53:

    Job No: J112167 3.1.1 Description,

  • Page 54 and 55:

    Job No: J112167 G.02 Store Cupboard

  • Page 56 and 57:

    Job No: J112167 1.07 Shower Room Iv

  • Page 59:

    Job No: J112167 Sample number Locat

  • Page 62 and 63:

    Job No: J112167 Sample N o Location

  • Page 64 and 65:

    Job No: J112167 Sample N o VC CE001

  • Page 66 and 67:

    Job No: J112167 Section 7: Appendic

  • Page 68 and 69:

    Job No: J112167 IV - Certificates o

  • Page 70:

    Job No: J112167 V - Site Drawings P

  • Page 78 and 79:

    Job No: J112167 VII - Glossary of T

  • Page 80 and 81:

    Health & Safety File Operation, Car

  • Page 90 and 91: Health & Safety File QBS Electrical
  • Page 92 and 93: CONTENTS INTRODUCTION 1 HEALTH & SA
  • Page 94 and 95: ELEC O&M Ivy Cottage SECTION 2 HEAT
  • Page 96 and 97: ELEC O&M Ivy Cottage Accidents Invo
  • Page 98 and 99: ELEC O&M MANUAL: Ivy Cottage SECTIO
  • Page 100 and 101: FAULT FINDING/PERIODIC TEST AND EME
  • Page 102 and 103: EMERGENCY LIGHTING QBS ELECTRICAL L
  • Page 104 and 105: SMALL POWER QBS ELECTRICAL LTD 168
  • Page 106 and 107: ELEC O&M MANUAL: Ivy Cottage SECTIO
  • Page 108 and 109: ELEC O&M MANUAL: Ivy Cottage SECTIO
  • Page 110: QBS ELECTRICAL LTD 168 Whitton Aven
  • Page 120: ELEC O&M MANUAL: Ivy Cottage SECTIO
  • Page 123 and 124: DATA SHEET: UCL series ISSUE: BADEC
  • Page 125 and 126: Crown Flooring Operation & Maintena
  • Page 127 and 128: 5. Cleaning and Maintenance Registe
  • Page 129 and 130: Registered in England and Wales: Co
  • Page 131 and 132: Registered in England and Wales: Co
  • Page 133 and 134: Registered in England and Wales: Co
  • Page 138 and 139: 1 BOILER CONTROLS / DISPLAY 1st STA
  • Page 140 and 141: To shut Down the Boiler 1. For shor
  • Page 142 and 143: Keston Heat - User’s 7
  • Page 144 and 145: Health & Safety File Cambridge Stov
  • Page 146 and 147: CONTENTS INDEX: WARRANTY………
  • Page 148 and 149: PLEASE READ THESE INSTRUCTIONS PRIO
  • Page 150 and 151: REMOVING INTERNAL COMPONENTS All in
  • Page 152 and 153: RE-ASSEMBLING THE STOVE Front Dimen
  • Page 154 and 155: LEGAL REQUIREMENTS Hunter Stoves Gr
  • Page 156 and 157: COMMISSIONING & HANDOVER APPLIANCE
  • Page 158 and 159: B) To operate pull the air control
  • Page 160 and 161: FIREBRICKS In normal use, these can
  • Page 162 and 163: OPERATION SMOKE PROBLEMS ADVERSE WE
  • Page 164 and 165: STOVE CARE PRODUCTS All replacement
  • Page 166 and 167: BODY ASSEMBLY SPARES ASPECT COMPACT
  • Page 168 and 169: SERVICE RECORDS 1 st Service Date o
  • Page 170 and 171: For both Solid Fuel and Gas Stoves:
  • Page 172 and 173: CONTENTS INDEX: WARRANTY………
  • Page 174 and 175: PLEASE READ THESE INSTRUCTIONS PRIO
  • Page 176 and 177: REMOVING INTERNAL COMPONENTS All in
  • Page 178 and 179: RE-ASSEMBLING THE STOVE Refit all t
  • Page 180 and 181: comply with current Building Regula
  • Page 182 and 183: COMMISSIONING & HANDOVER APPLIANCE
  • Page 184 and 185: B) To operate pull the air control
  • Page 186 and 187:

    FIREBRICKS In normal use, these can

  • Page 188 and 189:

    OPERATION SMOKE PROBLEMS ADVERSE WE

  • Page 190 and 191:

    STOVE CARE PRODUCTS All replacement

  • Page 192 and 193:

    BODY ASSEMBLY SPARES ASPECT 5 SLIML

  • Page 194 and 195:

    SERVICE RECORDS 1 st Service Date o

  • Page 196:

    For both Solid Fuel and Gas Stoves:

  • Page 200 and 201:

    R and N Construction 135 Sunnymead

  • Page 202 and 203:

    7 YEAR LIFE CARBON MONOXIDE POISONO

  • Page 204 and 205:

    CONTENTS Features 4 Carbon monoxide

  • Page 206 and 207:

    CO enters the body through the lung

  • Page 208 and 209:

    WARNING: This carbon monoxide detec

  • Page 210 and 211:

    WHERE TO INSTALL YOUR DETECTOR This

  • Page 212 and 213:

    In addition to the above the follow

  • Page 214 and 215:

    To mount on a wall or ceiling: Plea

  • Page 216 and 217:

    This should be continued for the li

  • Page 218 and 219:

    test for the sounder, power pack an

  • Page 220 and 221:

    15cm (6”) Step 4 Turn the detecto

  • Page 222 and 223:

    • Within 3 minutes when exposed t

  • Page 224 and 225:

    WHAT TO DO IN THE EVENT OF AN ALARM

  • Page 226 and 227:

    The alarm will sound: • Between 6

  • Page 228 and 229:

    This warranty does not affect your

  • Page 230 and 231:

    Electrical WARNING - THIS APPLIANCE

  • Page 232 and 233:

    Energy Saving Tips The energy we us

  • Page 234 and 235:

    Technical Information SPM 150W/m²

  • Page 236 and 237:

    Do’s and Don’ts DO Carefully re

  • Page 238 and 239:

    Electrical Safety Considerations As

  • Page 240 and 241:

    Installing the Mat (Continued) Step

  • Page 242 and 243:

    Control Card Place this card in a v

  • Page 244:

    Warmup plc., United Kingdom 702 & 7

  • Page 247 and 248:

    Contents Contents Safety informatio

  • Page 249 and 250:

    Safety information Congratulations

  • Page 251 and 252:

    Safety information 4. If the supply

  • Page 253 and 254:

    Safety information This appliance s

  • Page 255 and 256:

    Safety information Do not let child

  • Page 257 and 258:

    Safety information • The liquid d

  • Page 259 and 260:

    Safety information Instructions abo

  • Page 261 and 262:

    Installation Spanner Bolt caps Hose

  • Page 263 and 264:

    Installation Installation Flooring

  • Page 265 and 266:

    Installation STEP 3 Adjust the leve

  • Page 267 and 268:

    Installation 8. Connect the other e

  • Page 269 and 270:

    Installation STEP 5 Position the dr

  • Page 271 and 272:

    Before you start Initial settings R

  • Page 273 and 274:

    Before you start STEP 6 Apply a pro

  • Page 275 and 276:

    Before you start NOTE The actual ap

  • Page 277 and 278:

    Before you start To use liquid dete

  • Page 279 and 280:

    Operations Operations Press to chan

  • Page 281 and 282:

    Operations Cycle overview Standard

  • Page 283 and 284:

    Operations Options Option Pre Wash

  • Page 285 and 286:

    Operations Settings Child Lock To p

  • Page 287 and 288:

    Maintenance Smart Check To enable t

  • Page 289 and 290:

    Maintenance Cleaning Surface of the

  • Page 291 and 292:

    Maintenance Detergent drawer A 1. W

  • Page 293 and 294:

    Troubleshooting Checkpoints If you

  • Page 295 and 296:

    Troubleshooting Troubleshooting Sto

  • Page 297 and 298:

    Troubleshooting Information codes I

  • Page 299 and 300:

    Troubleshooting Code AC6 Action Che

  • Page 301 and 302:

    Specifications Protecting the envir

  • Page 303 and 304:

    Specifications Power consumption Ty

  • Page 305 and 306:

    Specifications According to Regulat

  • Page 307 and 308:

    Specifications According to Regulat

  • Page 309 and 310:

    Specifications According to Regulat

  • Page 311 and 312:

    Memo Untitled-1 66 2017-06-26 3:17:

  • Page 313 and 314:

    QUESTIONS OR COMMENTS? COUNTRY CALL

  • Page 315 and 316:

    Contents Contents Safety informatio

  • Page 317 and 318:

    Safety information Congratulations

  • Page 319 and 320:

    Safety information 7. For use in Eu

  • Page 321 and 322:

    Safety information Safety informati

  • Page 323 and 324:

    Safety information When gas (city g

  • Page 325 and 326:

    Safety information • This may res

  • Page 327 and 328:

    Installation Accessories (supplied)

  • Page 329 and 330:

    Installation Location requirements

  • Page 331 and 332:

    Installation Drain hose (if necessa

  • Page 333 and 334:

    Installation By using the drain pip

  • Page 335 and 336:

    Installation 2. Use a thin object t

  • Page 337 and 338:

    Installation 8. Remove the 2 screws

  • Page 339 and 340:

    Installation 2. Remove 2 screws (A)

  • Page 341 and 342:

    Installation 8. Move the bottom scr

  • Page 343 and 344:

    Operations Displays all cycle infor

  • Page 345 and 346:

    Operations Cycle overview Operation

  • Page 347 and 348:

    Operations Cycle chart NOTE For bes

  • Page 349 and 350:

    Operations Rack Dry (applicable mod

  • Page 351 and 352:

    Operations Cycle guide Always follo

  • Page 353 and 354:

    Maintenance WARNING • Do not clea

  • Page 355 and 356:

    Maintenance Water tank To avoid lea

  • Page 357 and 358:

    Maintenance 4. Clean the heat excha

  • Page 359 and 360:

    Troubleshooting Symptom Lint on clo

  • Page 361 and 362:

    Appendix Iron dry or steam temperat

  • Page 363 and 364:

    Appendix DV9*M50****, DV8*M50****,

  • Page 365 and 366:

    Appendix Sheet of household tumble

  • Page 367 and 368:

    Appendix NOTE 1. Energy consumption

  • Page 369:

    QUESTIONS OR COMMENTS? COUNTRY CALL

Isolator Row O&M Manual
GRUNFOS FIRE SYSYTEMS O & M MANUALS - Xact
a f m o a f m o o
l ’ O l m o
Electronic O&M Manuals Information at Your ... - NC AWWA-WEA
Grease Interceptor O & M Manual (PDF) - National Precast Concrete ...
O wners M anual
M A N G O
O wners M anual
O verlay M u lticast M o b ility
S A M M O D E
SMUD O&M Experience
M O S T Y
O+02+M O + N O + M NO2 03+NO OH+ N02 R H - - > NO - EMEP
M O T I O N & C O N T R O L