OFS-0503.qxp:Inert Air System Flyer 040310.qxd - SPX Transformer ...

LTC OIL FILTERPOWER ONLTC OIL FILTERTIMERONL1TIMERBYPASSL2LTC OIL FILTERLOW FLOWL3LTC OIL FILTERHIGH PRESSURELTC OIL FILTEROFF/RESET ON60402 0080100120180140160LTC OIL FILTERTIMERONL1LTC OIL FILTERPOWER ONTIMERBYPASSL2LTC OIL FILTERLOW FLOWL3LTC OIL FILTERHIGH PRESSURELTC OIL FILTEROFF/RESET ON60402 0080100120180140160TIMERONL1LTC OIL FILTERPOWER ONLTC OIL FILTERTIMERBYPASSL2LTC OIL FILTERLOW FLOWL3LTC OIL FILTERHIGH PRESSURELTC OIL FILTEROFF/RESETON60402 0080100120180140160Build Your Own Part Number Using Configuration Below:O F -SYSTEM TYPEOPTION ADDFor More Informationcall 800-338-5526e-mail HVSinfo@waukesha.spx.comINSTALLATION KITSCUSTOMER INPUT RELAYSRETROFIT1/5 HP MOTOR1.8 GPM PUMPWES STD FILTERASTANDARDCONTROL 0CONTROLSNONE0ENTRANCE TUBEONLY0NONE 0RETROFIT1/5 HP MOTOR1.8 GPM PUMP7" X 18" FILTERBSTANDARD WITHRUNTIME METERSTANDARD WITHBYPASS CONTROL12OIL LEVELSHUTDOWN 120VOIL LEVELSHUTDOWN 230V12ENTRANCE TUBE& FLEX HOSE (20')KIT1120V TO 240VCONVERSION1RETROFIT PLUS1/2 HP MOTOR5.0 GPM PUMP7" X 18" FILTERCSTANDARD WITHRUNTIME METERBYPASS CONTROL313.5(C/C MOUNTINGHOLES)13.5(C/C MOUNTINGHOLES)15.6(C/C MOUNITNGHOLES) 15.16.9 (C/CMOUNTINGHOLES)34.034.011.5 (C/CMOUNTINGHOLES)37.313.822.2513.831.4(APPROX. 34.50 WIDE)19.8RETROFIT SYSTEM - ARETROFIT SYSTEM - BRETROFIT PLUS SYSTEM - CLTC Oil Filtration System Specifications: Standard Retrofit Customizable Retrofit-PlusPower Requirements 120 VAC, 60 Hz 120/240 VAC, 60 HzWeight 120 lbs. 120 to 180 lbs.Motor Size 1/5 HP 1700 RPM 1/5 to 1/2 HP 1700 RPMMaximum Flow Rate 1.8 GPM 3 to 5 GPMMaximum Operating Pressure 68 psi 68 psiLow Flow Shutoff 0.9 GPM 0.9 GPMFirst Pass Moisture Absorption 200 to < 5 PPM Defined by Filter TypeOptional Daily Timer Settings Every 1, 2, 7 or 14 days Customer ConfigurableOptional Hourly Timer Settings Every 2, 4, 8 or 24 hours Customer ConfigurableParticle Filtration Rating Not more than 1 micron Defined by Filter TypeContinuous Run Mode (Control Bypass) Available Upon Request Available Upon RequestSTANDARD FILTERWAUKESHA ® FILTERWaukesha ® Standard Filter Offers Long Filter Element LifeWaukesha Electric System’s depth-type filter element (in Standard Retrofit System) features a unique fluid flow path: fluid runs parallel with thecenter tube (axial flow) rather than the conventional outside-to-inside flow (radial flow) of most depth-type filters. The depth of fluid flow is optimizedand provides the capability to filter more efficiently than conventional filters. Filter media is constructed as four rolls of filter paper. Oil flows betweenthe layers of media until it reaches one of two collector plates. The collector plates route oil to the center of the element where it is discharged outof the element. Because the filter media has a much greater resistance to flow from outside to center (radial flow) than it does between the layers(axial flow) of filter material, WES’ filter maintains a high degree of filter efficiency, filtering to less than 1 micron and absorbing water from wetoils. Integrity of the filter element is maintained even as it accumulates contaminants and the Delta-p (pressure across the filter) goes up. Hydraulicpressure of the fluid compressing the layers of media together prevents a channel from forming that could allow oil to pass through the elementunfiltered. Recommended pressure limit to change filter is 65 psi.Removes Both Dirt and Moisture- Filter material is dried cellulose fiber - Filter can decrease water to under 5 PPM - Micron rating: 1.0- Rated for particles as well as free and emulsified water - Total water holding capacity: 0.5 kg - Beta X rating: 75 at 3 microns- High rate of absorption enables oil to be reduced from 200 to less than 5 PPM in one pass®9011 Governors RowDallas, TX 75247800-338-5526www.HighVoltageSupply.comWaukesha ® LTC Oil Filtration Systems are manufactured and distributed by High Voltage Supply, a division ofWaukesha Electric Systems, Inc. Retrofit-Plus U.S. Patent No. 7,033,513 B2.To continually improve its products and services, Waukesha Electric Systemsreserves the right to change specifications and features without notice. Pleasecontact HVS for certified dimensions and drawings.© 2009 Waukesha Electric Systems, Inc.OFS-0503 (Rev. 3/09)