- Page 1 and 2: Part No. 90743SL, Rev. G Service Ma
- Page 3: Table Of Contents Chapter 1 - Safet
- Page 7 and 8: Maintenance and Service 21. Before
- Page 9 and 10: Table of Contents Chapter 2 Product
- Page 11 and 12: Torque Specifications Groundsmaster
- Page 13 and 14: Chapter 3 Engine (Model 30580) Tabl
- Page 15: Stopping the Engine Important: Befo
- Page 37: Cone removing Tool 34791-01100 For
- Page 140 and 141:
This page is intentionally blank.
- Page 142 and 143:
Specifications Item Make / Designat
- Page 144 and 145:
Specifications Item Make / Designat
- Page 146:
Specifications Item Traction Drive
- Page 166 and 167:
Deck drive test ports on newer mode
- Page 168 and 169:
Deck drive test ports on newer mode
- Page 170 and 171:
TEST NO. 5: Counterbalance Pressure
- Page 172 and 173:
This page is intentionally blank. T
- Page 174 and 175:
Deck Motor Internal Leakage Test NO
- Page 176 and 177:
NOTE: The Traction Control Neutral
- Page 180 and 181:
NOTE: Refer to the Sauer/Sundstrand
- Page 182 and 183:
Torque to 35 Ft-lbs (47.1 N-m) Torq
- Page 184 and 185:
PTO Solenoid Valve Service (S/N 500
- Page 187 and 188:
PTO Pump Repair (Models 30580 and 3
- Page 191 and 192:
Deck Motor Repair (P/N 94-4907) 7 4
- Page 193 and 194:
Wing Deck Hose Replacement (S/N 500
- Page 196 and 197:
Torque all cartridges to 35 Ft-lbs
- Page 199 and 200:
Steering/Auxiliary Pump Repair (Mod
- Page 201:
(Models 30580 and 30581) Rev. E
- Page 212:
9. Carefully slide the spool out of
- Page 217 and 218:
0 1 Front Deck Engage 2 Right Deck
- Page 219 and 220:
Groundsmaster 580 - D Page 5 - 5 Re
- Page 221 and 222:
Page 5 - 7 Rev. E
- Page 223 and 224:
Page 5 - 9 Rev. E
- Page 225 and 226:
Page 5 - 11 Rev. E
- Page 227 and 228:
Page 5 - 13 Rev. E
- Page 229 and 230:
Page 5 - 15 Rev. E
- Page 231 and 232:
Page 5 - 17 Rev. E
- Page 233 and 234:
Page 5 - 19 Rev. E
- Page 235 and 236:
Note: If machine is equipped with C
- Page 237 and 238:
Page 5 - 23 Rev. E
- Page 239 and 240:
Page 5 - 25 Rev. E
- Page 241 and 242:
Page 5 - 27 Rev. E
- Page 243 and 244:
Page 5 - 29 Rev. E
- Page 245 and 246:
Page 5 - 31 Rev. E
- Page 247 and 248:
Page 5 - 33 Rev. E
- Page 249 and 250:
Page 5 - 35 Rev. E
- Page 251 and 252:
Older model shown. Note: For models
- Page 253 and 254:
Page 5 - 39 Rev. E
- Page 255 and 256:
Page 5 - 41 Rev. E
- Page 257 and 258:
Page 5 - 43 Rev. E
- Page 259 and 260:
Page 5 - 45 Rev. E
- Page 262:
Specifications Planetary Wheel Driv
- Page 284 and 285:
Belt Tension Adjustment IMPORTANT:
- Page 287:
Note: If machine is equipped with a
- Page 291:
9. Check and adjust the drive pulle
- Page 294 and 295:
2. Using an arbor press, push outer
- Page 296 and 297:
ACTIONS 1) Start Run (with operator
- Page 298 and 299:
WIRING DIAGRAM: CONSOLE GAUGE PANEL
- Page 300 and 301:
Diagnostic ACE Display The diagnost
- Page 302 and 303:
Troubleshooting For all electrical
- Page 304 and 305:
Retrieving Stored Faults Note: The
- Page 306 and 307:
Seat Switch (S/N Between 30101 and
- Page 308 and 309:
Service and Repairs See Chapter 5 -
- Page 310 and 311:
2. Conduct a hydrometer test of the
- Page 312 and 313:
Alternator The alternator used on t
- Page 314 and 315:
This page is intentionally blank. F
- Page 316 and 317:
Groundsmaster 580--D (4WD Machines)
- Page 318 and 319:
RED GRAY/WHITE WHITE YELLOW RED RED
- Page 320 and 321:
Page 9 - 8 (Rev. G) Groundsmaster 5
- Page 322 and 323:
Page 9 - 10 (Rev. G) Groundsmaster
- Page 324 and 325:
Page 9 - 12 (Rev. G) Groundsmaster
- Page 326 and 327:
Wire Harness Drawing Groundsmaster
- Page 328 and 329:
GREEN BLACK ORANGE BLACK GREEN WHIT