Product Name: HONEY WAX 250 - Advanced Plastics

More documents

Recommendations

Info

Product Name: HONEY WAX 250 Revision Date: 25 MAY 2011 Page 2 of 5 Protection of First-aiders Use personal protective equipment. Remove all sources of ignition. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media Use Foam Carbon dioxide (CO2 ) Dry chemical Cool containers with flooding quantities of water until well after fire is out. Extinguishing Media Which Must not be Used for Safety Reasons Do not use a solid water stream as it may scatter and spread fire. Special exposure hazards arising from the substance or preparation itself, combustion products, resulting gases Flammable. May be ignited by heat, sparks, or flames. In the event of fire and/or explosion do not breathe fumes. Special Protective Equipment for Fire-fighters As in any fire, wear self-contained breathing apparatus pressure demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Environmental Precautions Prevent entry into waterways, sewers, basements or confined areas. Do not flush into surface water or sanitary sewer system. Personal Precautions Remove all sources of ignition. Use personal protective equipment. Ensure adequate ventilation. Take precautionary measures against static discharge. Methods for Cleaning Up Prevent product from entering drains. Contain spillage, and then collect with non-combustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite) and place in container for disposal according to local / national regulations (see section 13). Other Information See Section 12 for additional information 7. HANDLING AND STORAGE Handling Keep away from open flames, hot surfaces and sources of ignition. Wash thoroughly after handling. Storage Keep container tightly closed in a cool, dry and well-ventilated place. Incompatible with oxidizing agents. Keep away from heat and sources of ignition. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION EXPOSURE LIMIT FOR NAPHTHA (PETROLEUM) HYDROTREATED HEAVY 300 ppm (1800 mg/m3) for an 8-hour workday. Recommended by the manufacturer of the solvent. VENTILATION Use only with ventilation sufficient to prevent exceeding recommended exposure No smoking or use of flame or other ignition sources. PROTECTIVE GLOVES Use chemical-resistant gloves, if needed, to avoid prolonged or repeated skin contact EYE PROTECTION Use splash goggles when eye contact may occur. 9. PHYSICAL AND CHEMICAL PROPERTIES General Information Physical State Odor Appearance Solid Aromatic Tan Important Health, Safety and Environmental Information Flash Point Boiling Point/Range pH Auto-ignition Temperature Vapor Pressure VOC Content Viscosity 41 o C 159-198°C Not applicable No information available No information available 517-556 g/L No information available
Product Name: HONEY WAX 250 Revision Date: 25 MAY 2011 Page 3 of 5 Solubility Soluble in hydrocarbons Water Solubility Negligible Evaporation Rate No information available Specific Gravity 0.797 Flammability Limits in Air No information available Other Information Melting Point/Range 90°C 10. STABILITY AND REACTIVITY Stability Conditions to Avoid Materials to Avoid Hazardous Decomposition Products Stable under normal conditions Heat, flames, and sparks. Strong oxidizing agents. None under normal use 11. TOXICOLOGICAL INFORMATION Acute Toxicity Product Information Inhalation Eye Contact Skin Contact Ingestion Chronic Toxicity Carcinogenicity No known effect based on information supplied. No known effect based on information supplied. Prolonged skin contact may de-fat the skin and produce dermatitis. Potential for aspiration if swallowed. Aspiration may cause pulmonary oedema and pneumonitis. The substance has delayed effects. Contains no ingredient listed as a carcinogen. NATURE OF HAZARD AND TOXICITY INFORMATION Prolonged or repeated skin contact with this product tends to remove skin oils, possibly leading to irritation and dermatitis; however, based on human experience and available toxicological data, this product is judged to be neither a "corrosive" nor an "irritant" by OSHA criteria. Product contacting the eyes may cause eye irritation. Product has a low order of acute oral and dermal toxicity, but minute amounts aspirated into the lungs during ingestion or vomiting may cause mild to severe pulmonary injury and possibly death. This product is judged to have an acute oral LD50 (rat) greater than 5 g/kg of body weight, and an acute dermal LD50 (rabbit) greater than 3.16 g/kg of body weight. The toxicity information is based on data available for Naphtha (Petroleum) Hydro-treated Heavy, a solvent component of the product. Data for Finished product is not available. 12. ECOLOGICAL INFORMATION Ecotoxicity Harmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment. Persistence and Degradability No information available Bioaccumulative Potential No information available Mobility No information available Do not discharge this product into public waters or waterways. Regulatory Requirements: Follow applicable OSHA regulations (29 CFR 1910.120).
Page 1: Product Name: HONEY WAX 250 Revisio
Page 5: Product Name: HONEY WAX 250 Revisio

Product Name: HONEY WAX 250 - Advanced Plastics

Create successful ePaper yourself

Delete template?

Save as template?