2010 POLICE PREP PACKAGES - Crown North America

More documents

Recommendations

Info

TABLE OF CONTENTSOption Content 65A and 65P Packages……………………………………………………Option Content 68P and 65W Packages…………………….……………………………..Option Content 65U Package ……………………………………………………………….About Crown North America…………………………………..……………………………..Police Prep and Visibility Packages…………………………..…………………………….Base Police Prep Package ……. …………………………..………………………….….Strobe Bulbs……………………………………..………………………………...Console Wiring…………………………………………………………………….Engine Compartment Wiring…………………………………..…………………Trunk Wiring………………………..……………………………………………...Headlight Flasher (Wig-Wag)……………………………………………………Complete Police Prep Package …………………………..………………………...…….Console Mounting Platform …………………………..……….………………...Center Wiring Conduit………………………………………..…………………..Hidden Manual Rear Door Lock Plungers …….…………...………………….Trunk Air Circulation Fan …………………..………………...………………….Permanent Rubber Tie-Down Strap ………………….…….………………….Dual Trunk Storage Boxes ………………….……………….………………….Rear Communications Service Tray ………………….……..…………………Battery Saver Circuit & Vehicle Speed Signal…………………………………Visibility Packages …………………………………………..…………………………….Strobe Power Unit (65U and 65W)……………………..………………………Strobe Power unit for 65P……………………………………………..………..Flashing Rear Deck LED Lights ……………………………...……………...…New Rear LED Deck Lights……………………………………………………..Switch Control Panel …………………...…………………….………………….Schematics………………………………………………….………………….……….……Key to Wire Color Codes……………………………………...…………………Ford Engine Compartment Fuse Block……………………..………………….Power Connection Placement…………………………………………………...Power Circuits Placement ………………….………………..………………….Power Circuits Placement …………………………..……….………………….Spare Circuit Placement……………………………………...………………….Ground Circuits Placement…………………………………..…………………..Strobe Power Supply Assembly …………………………...……………………Console Pin outs ………………..……………………..………………………….Alternating Headlight Flasher Circuit………………………...………………….Horn/Siren Relay Amplifier Circuit (Amplifier at Console)….…………………Horn/Siren Relay Amplifier Circuit (Amplifier in Trunk)……..………………...Glove Box Power Distribution Center……………………….…………………..Trunk Power Distribution Center…………………..…………………………….Lighting Relay Center (8-Relay Panel) ………………………….……………..Removal of Police Prep Packages………………………………………………………….General Guidelines……….…………..……………………………………………………….Technical Service Numbers…………………………………..……………………………...SPECIAL NOTE:Although the total current capacity of the harness on the following pages states that the harnessis capable of handling over 350 Amps of fused power, it is recommended that total vehicleloads to the 2010 Crown Victoria Police Interceptor be limited to 110 Amps, at idle, to supportalternator/battery capacity. Electrical loads above this level may degrade battery/ starting capacity.345678891011121313141516171819202121222324252626272831333537384041424344454647482
OPTION CONTENT 65A and 65P Packages2010 Ford Police Interceptor Equipment PackagesThe Base Package 65A Wiring Harness has increased to 350 amps of battery and ignition power. There should be noneed for any additional wires to be connected to the battery with the added amperage in 2010. Customer feedback hasbeen implemented and there have been improvements to the versatility and usability of the Base Package Harness. Therevised Base Lighting Package 65P has been created to supply plug and play lighting components to the Base Package65A maximizing police car identification and visibility.BasePackage(65A)BaseLightingPackage(65P)Two (2) Front Strobe Bulbs and Two (2) Rear Strobes, installed in marker light and taillight lenses. *Strobe PowerSupply required to flash Strobe Bulbs. X XWiring Harness including the following items: X X- Six (6) Strobe Cables - Shielded and Grounded pre-run to the front marker lights, taillights lenses and two (2) to thefront grill. Strobe Cables are industry standard gender and color configuration for connection to customer suppliedaftermarket Strobe Power Supplies.XXGlove Box Power Distribution Center 50 amps, fused in the engine compartment. Five (5) power and ground wires forcustomer use. Five (5) fuses - Two (2) battery and three (3) ignition powered. X XTrunk Power Distribution Center 50 amps, fused in the engine compartment. Five (5) power and ground wires forcustomer use. Five (5) fuses - Two (2) battery and three (3) ignition powered. *One ignition fuse position utilized byOptions 65P / 65W / 65U.XX- 50 amp battery circuit and ground accessible at console base only X X- 50 amp battery circuit and ground accessible at console base or trunk. Available in trunk from pigtail harness (utilizedby Options 65W / 65U). X X- Two (2) 50 amp battery circuit and ground accessible at trunk only. Available in trunk from pigtail harness (utilized byOptions 65W / 65U). X X- 50 amp battery circuit and battery ground accessible at console base or trunk, for radio communications. X X- 30 amp ignition circuit accessible at trunk only. Available in trunk from pigtail harness (utilized by Options 65W /65U). X X- Siren/speaker wiring pre-run to front of vehicle with waterpack connector. Available in trunk from pigtail harness(utilized by Ready for the Road Package 65U). X X- Two (2) Extra circuits pre-run to front of vehicle accessible at console or trunk. X X- Horn/siren relay circuit accessible at console base or trunk (utilized by Ready for the Road Package 65U). X X- Four (4) Extra circuits pre-run from the engine compartment to console base. One circuit is heavy gauge for additionalbattery or ground connection. X X- Four (4) Extra circuits pre-run from the console base to trunk. X XAlternating Headlight Flasher with control wire accessible at console for optional connection to customer suppliedpositive control switch box. Extra relay and control wire available for overriding alternating headlight flasher at nightwhen headlights are in use.XXStrobe Power Supply, Six (6) outlets with front shut down. Additional control wire accessible at trunk for connectionto customer supplied positive control switch box. *Required to flash strobe bulbs.Two High Intensity Flashing Rear Deck LED Lights, with matching interior color housings (Charcoal, Medium LightStone, Light Camel). Red & Blue color configuration is standard. Additional control wire accessible at trunk for connectionto customer supplied positive control switch box.XXFord Warranty is 3 years / 36,000 miles on all components except the following:Strobe Lights 1 year (Front Marker Light & Taillight Strobes)X Indicates included in option— Indicates utilized by option and not available for customer use3
Page 1: 2010 POLICEPREP PACKAGESOWNER’S M
Page 5 and 6: OPTION CONTENT 65U Package2010 Ford
Page 7 and 8: POLICE PREP AND VISIBILITY PACKAGES
Page 9 and 10: BASE POLICE PREP PACKAGE (65A)GLOVE
Page 11 and 12: BASE POLICE PREP PACKAGE (65A)TRUNK
Page 13 and 14: COMPLETE POLICE PREP PACKAGEConsole
Page 15 and 16: COMPLETE POLICE PREP PACKAGEHidden
Page 17 and 18: COMPLETE POLICE PREP PACKAGEPermane
Page 19 and 20: COMPLETE POLICE PREP PACKAGERear Co
Page 21 and 22: VISIBILITY PACKAGE (65W), and READY
Page 23 and 24: VISIBILITY PACKAGEFlashing Rear Dec
Page 25 and 26: VISIBILITY PACKAGE (65W)Switch Cont
Page 27 and 28: SCHEMATICSFord Engine Compartment F
Page 29 and 30: SCHEMATICSPower Connection Placemen
Page 31 and 32: SCHEMATICSPower Circuit Placement (
Page 33 and 34: SCHEMATICSPower Circuit Placement (
Page 35 and 36: SCHEMATICSSpare Circuit Placement35
Page 37 and 38: SCHEMATICSGround Circuit Placement3
Page 39 and 40: SCHEMATICSStrobe Power Supply Assem
Page 41 and 42: SCHEMATICSAlternating Headlight Fla
Page 43 and 44: SCHEMATICSHorn / Siren Relay Circui
Page 45 and 46: SCHEMATICSTrunk Power Distribution
Page 47 and 48: REMOVAL OF POLICE PREP PACKAGESNote
Page 49 and 50: GENERAL GUIDELINESpossibility of a
Page 51 and 52: GENERAL GUIDELINES5. Solder wires t
Page 53 and 54:
GENERAL GUIDELINESconductors which
show all

2010 POLICE PREP PACKAGES - Crown North America

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?