COSHH 2018 Rev.1

More documents

Recommendations

Info

COSHH SUMMARY SHEET www.alcumusgroup.com FACILITY ENGIE MAIN TFL SUB 131423 MATERIAL/PROCESS RIGID AEROSOL THREADING OIL SUPPLIER KEYWORD CONTENTS LOW HAZARD AEROSOL RIDGE TOOL CO. Oil (Aerosol) Propane 7.00 - 13.00%, n-Butane 7.00 - 13.00%, Distillates (petroleum), hydrotreated heavy paraffinic 15.00 - 40.00%, Distillates (petroleum), solvent-dewaxed heavy paraffinic 10.00 - 30.00%, Mineral Oil, Zinc compounds 1-5%. METHOD CONTROL MEASURES SIGNAL WORD EXP LIMIT DANGER Propane 1800mg/m3 8hTWA 7200mg/m3 15mSTEL OEL, n-Butane 1450mg/m3 8hTWA 1810mg/m3 15mSTEL 600ppm 8hTWA 750pp EXPOSURE TIME Spraying (Aerosol) AREA Inside Well Ventilated 1/2 to 2 hours per shift LOW ACUTE RISK - FULL EXPOSURE LOW ACUTE RISK - INDIVIDUAL ACTIVITY LOW CHRONIC RISK - FULL EXPOSURE LOW CHRONIC RISK - INDIVIDUAL ACTIVITY HEALTH HAZARDS Extremely flammable aerosol Excessive inhalation may cause ill health Avoid inhalation of aerosol Skin - irritation and dermatitis may result from prolonged contact May cause eye irritation SPILLAGE Not applicable when intact In case of leakage or loss of containment: Ventilate area and exclude all sources of ignition Wear protective clothing if whole container is spilt Allow to dissipate Wear butyl or nitrile gloves Ensure area is safe before re-entry CONSIDERATIONS KEEP SKIN COVERED BUTYL OR NITRILE IF CONTACT LIKELY WASH AFTER EXPOSURE PRESSURISED FIRST AID Inhalation - remove to fresh air; get immediate medical attention after significant exposure or if feeling ill Ingestion - do not induce vomiting, wash out mouth with water If feeling unwell consult your doctor immediately Eye - irrigate with water until irritation subsides Skin - wash with soap/cleanser and rinse with water If irritation persists then consult a doctor FIRE Keep aerosol cans cool, do not burn for disposal Isolated small scale fire: Vapour may spread - distant ignition is possible Water fog - carbon dioxide - powder - foam Large fire: evacuate area, call fire brigade or follow site procedure Wear self-contained breathing apparatus and protective clothing Keep containers cool with water spray Risk of explosion if involved in a fire ACTIVITY COMMENTS Intermittent use of aerosol. This assessment was compiled by Alcumus Sypol Limited from supplier's safety data sheets where appropriate. Safety in the use of assessments is the responsibility of the subscriber. For advice call the helpdesk on 01296 678464 Printed 23/07/2018 DATE ASSESSMENT REVIEWED 26/05/2017 LATEST SAFETY DATA SHEET REFERENCE 08/08/2013
COSHH SUMMARY SHEET www.alcumusgroup.com FACILITY ENGIE MAIN TFL SUB 1153 MATERIAL/PROCESS PROPANE INSTRUMENT GRADE N2.5 SUPPLIER KEYWORD CONTENTS MEDIUM HAZARD Propane 100%, GAS BOC GASES Gas HEALTH HAZARDS Asphyxiant properties Extremely flammable gas Contains gas under pressure; may explode if heated May cause eye irritation CONSIDERATIONS SIGNAL WORD EXP LIMIT DANGER Propane 1800mg/m3 8hTWA 7200mg/m3 15mSTEL OEL METHOD Igniting AREA Inside Well Ventilated EXPOSURE TIME Up to 1/2 hour per shift MEDIUM ACUTE RISK - FULL EXPOSURE LOW CHRONIC RISK - FULL EXPOSURE CONTROL MEASURES MEDIUM ACUTE RISK - INDIVIDUAL ACTIVITY LOW CHRONIC RISK - INDIVIDUAL ACTIVITY SPILLAGE Large spillages – evacuate area – assess situation from a safe area Ventilate area and exclude all sources of ignition Shut off at source Allow to dissipate If leakage or loss of containment can not be controlled evacuate area All spills to be handled by designated responders AVOID SKIN CONTACT IF OVEREXPOSUR E LIKELY IF CONTACT LIKELY WASH AFTER EXPOSURE IF HEAVILY SOILED FIRST AID Inhalation - remove to fresh air; get immediate medical attention after significant exposure or if feeling ill Eye - irrigate with water until irritation subsides; if irritation persists then consult a doctor Skin - wash with soap/cleanser and rinse with water; if irritation persists then consult a doctor FIRE Isolated small scale fire: Risk of explosion if involved in a fire Shut off at source if safe to do so Keep containers cool with water spray Do not extinguish leaking gas flame unless absolutely necessary In the event of large fires contact the local fire service immediately Vapour may spread - distant ignition is possible Evacuate area ACTIVITY COMMENTS Refer to Pressure Systems Safety Regulations 2000 / DSEA Regulations for further precautions. This assessment was compiled by Alcumus Sypol Limited from supplier's safety data sheets where appropriate. Safety in the use of assessments is the responsibility of the subscriber. For advice call the helpdesk on 01296 678464 Printed 23/07/2018 DATE ASSESSMENT REVIEWED 26/05/2017 LATEST SAFETY DATA SHEET REFERENCE 16/05/2018
Page 2 and 3: Assessment Index for TFL ( ) Search
Page 4 and 5: Assessment Index for TFL ( ) ENGIE
Page 6 and 7: Assessment Index for TFL ( ) ENGIE
Page 8 and 9: COSHH SUMMARY SHEET www.alcumusgrou
Page 22 and 23: Work Area Work Area Code TFL Sub Ar
Page 24 and 25: WORKER REFERENCE SHEET www.alcumusg
Page 26 and 27: Have users been informed, instructe
Page 68 and 69:
COSHH SUMMARY SHEET www.alcumusgrou
Page 70 and 71:
Page 72 and 73:
Page 74 and 75:
Page 76 and 77:
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
show all

COSHH 2018 Rev.1

Create successful ePaper yourself

Delete template?

Save as template?