Master Fleet List 11.03.15.xlsx

Recommendations

Info

H476 - CRC39 - 2005 - FODEN / A3-8R 8x4 RIGID TRUCK-T4476 Entry Date Work Order Description 12.07.2010 Replace seat adjuster 10.07.2010 H47605 - Foden A3-8R Service 10.07.2010 H47605 - Foden A3-8R Service 07.07.2010 Lite switch & wiring 01.07.2010 starter fault 29.06.2010 jump start truck 26.06.2010 seat shock broken 22.06.2010 To overhaul 50mm coupling 20.06.2010 reset radio stations 11.06.2010 replace airdryer 04.06.2010 overhaul splitter cylinder 04.06.2010 replace air dryer 02.06.2010 fit filtered vents 27.05.2010 repair work lamp 17.05.2010 replacelh & rh 1st axle wheels. 17.05.2010 replace battery bracket repair same 13.05.2010 15k Lube service. 13.05.2010 Top tune.O/haul jake's 13.05.2010 Replace compressor.Leaking head gasket. 04.05.2010 Replace ringfeeder 22.04.2010 To waitoa, Bulbs etc 17.04.2010 replace lh cab roof marker light 15.04.2010 Carry out COF Pre Check 15.04.2010 Replace 2nd axle RH tie rod end. 15.04.2010 Replace front joint on steering ram. 15.04.2010 Tighten bolts on rear diff head. 14.04.2010 PRE COF REPAIRS 13.04.2010 PRESENT FOR COF 08.04.2010 pre cof check 07.04.2010 Repair nite light / park bulbs 30k lube/service.Check steering vibration.tyres to be change.Replace idler pulley bearings.Replace lever 24-Mar-10 balljoint. 743,288kms 10-Mar-10 Replace leaking hyd hose. 3-Mar-10 15K lube/service.Adjust clutch & replace air line to mini-pak.733,858kms Collect from YTOA.Test run & pressure intake system (131kpa).Cracked feed pipe.Swap H452.Test run again 1-Mar-10 (200kpa).Have pipe repaired @ Gordies. 1-Mar-10 Replace hubo.(27/02) 1-Mar-10 Repair headlight & ECM wiring loom. 26-Feb-10 Replace sampler door seal. 26-Feb-10 Test for boost leak.Locate leak.Replace hose & clamp. 26-Feb-10 Check coolant leak.Replace header tank hose. 22-Feb-10 Replace light plug. 16-Feb-10 steam clean radiators & intercooler 16-Feb-10 replace bulbs in dash- secure gear lever- 16-Feb-10 replace worn jack shaft 16-Feb-10 repair sampler unit 10-Feb-10 Rd/Call:YTOA.Jump start. Check for low boost pressure. To be check when off for next service. 10-Feb-10 Rd/Call:YTOA.Replace headlight bulbs. 8-Feb-10 Rd/Call:Hautapu.Repair boost leak. 8-Feb-10 Rd/Call:Check coolant leak.Replace coolant feed pipe to compressor. 4-Feb-10 Rd/Call:Straighten load sensor arm. Remove cracked inlet mainfold.Have crack welded @ Piako Stainless.Refit.replace turbo,all exhaust 4-Feb-10 studs,gaskets & centre manifold. 726,881kms Page 2
H476 - CRC39 - 2005 - FODEN / A3-8R 8x4 RIGID TRUCK-T4476 Entry Date Work Order Description 28-Jan-10 MAKE NEW BATTERY CONNECTOR CABLE 26-Jan-10 replace exhaust manifold studs 26-Jan-10 replace shock bushes 25-Jan-10 REPLACE BATTERY CABLE 25-Jan-10 30K LUBE SERVICE 25-Jan-10 ROAD CALL - REPLACE DRIVING LAMP 22-Jan-10 Replace l/h headlight bulb 19-Jan-10 REPLACE AIR/CON FILTER-CLEAN RADIATORS AND CONDENSOR 15-Jan-10 Rd/Call:Meet truck @ Hautapu clear ICS screen fault. 12-Jan-10 Replace RT speaker Rd/Call:SWap trucks @ Tirau factory.Flush truck out.Test pump & check for bubble sensor fault.Replace 12-Jan-10 sensor.Test pump again & deliver back to site. 11-Jan-10 Supply driiver with bulb for night light. 11-Jan-10 BARTEC:Talk driver through "Locked" ICS screen. 11-Jan-10 Secure sample tray slides. 11-Jan-10 Repair air L/F under cab. 8-Jan-10 Top up oil. 8-Jan-10 Check splitter light switch fault.Replace switch. 8-Jan-10 Check ABS light fault.Test wheel sensors.Replace L4 sensor. 7-Jan-10 Rd/Call:Coroglen.Swap truck @ supplier.Strip wiirng looom @ MSC & repair PTO wiring fault. 6-Jan-10 Check A/con fault. 5-Jan-10 Repair wiring to R/H driving light. 5-Jan-10 Rd/Call:Repair headlight fault. 31-Dec-09 Check fuel gauge fault.Replace tank sender unit. 30-Dec-09 Rd/Call:YTOA.Jump start.Replace battery @ MSC. 29-Dec-09 Replace headlight bulb.Repair wiring short. 29-Dec-09 Replace R2 brake chamber. 29-Dec-09 Foden Service 75,000km 29-Dec-09 Rd/Call:BARTEC. 2 vat issue. 29-Dec-09 Check vibration @ 70-90kph.Check drive train & tyes.Replace R1 tyre. 16-Dec-09 Rd/Call:YTOA.BARTEC.Driver unable to log-on.Log-on through maintance,log out & relog back onto day shift. 30 k Lube/service.Blow out rad & intercooler.Make up new battery retaining bolts.Replace bulbs. 10-Dec-09 694,980kms 8-Dec-09 Rd/Call:Jump start @ YTOA. 4-Dec-09 Check fault to roller switch.Adjust. 2-Dec-09 Repair & rebolt milk hose shute. 27-Nov-09 repair cab lights 26-Nov-09 Check purge valve operation. 26-Nov-09 Repair air leak L/H side under cab. 25-Nov-09 Replace seat base. Call out to top of Kopu Hikuwais to sort out electrical engine malfunctution(engine in limp mode) strip loom back and try to find broken or rubbed through wire, couldnt see any. bring back to Waitoa unload truck then 25-Nov-09 bring to workshop 22-Nov-09 REMOVE SUSPENSION TOWER AND REBUILD - REFIT 22-Nov-09 REPAIR HEAD LIGHTS 22-Nov-09 CHECK UNIT FOR BARTEC MSS FAULT 22-Nov-09 RETORQUE L/H 3RD WHEELS 16-Nov-09 REPAIR SPRING SLIPPER MOUNTS 16-Nov-09 O/HAUL SPLITTER CYLINDER 16-Nov-09 15K LUBE SERVICE 10-Nov-09 Rd/Call:Tills Rd:Check clutch loss fault.Replace main clutch pipe down chassis rail.Bleed clutch. 6-Nov-09 Replace driver seat squab. Page 3
Page 1: Entry Date H476 - CRC39 - 2005 - FO
Page 5 and 6: H476 - CRC39 - 2005 - FODEN / A3-8R

Master Fleet List 11.03.15.xlsx

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?