Material Safety Data Sheets - Turbochef

MATERIAL SAFETY DATA SHEETTURBOCHEF OVEN CLEANEREssentially similar to Form OMB No. 1218-0072SECTION 1 – COMPANY NAMESECTION 8 – EXPOSURE CONTROLS/PERSONAL PROTECTIONCHEMCO CORPORATIONRESPIRATION PROTECTION: Use any purifying respirator when air concen-300 Canal Street • Lawrence, MA 01840 tration exceed TLV limits.Tel (978) 687-9000 • (800) 458-8010 • Fax (978) 794-2012 VENTILATION: Local exhuast. Mechanical required for confined spaces.PROTECTIVE GLOVES RecommendedHazard Rating Scale EYE PROTECTION:RecommendedEMERGENCY TELEPHONE:0 = Minimal WORK/HYGIENIC PRACTICES: Keep away from food and drink. Do not eatHealth 1 1 = Slight or drink while using product.CHEMTEL: (800) 255-3924 Flammability 0 2 = Moderate SECTION 9 – PHYSICAL AND CHEMICAL PROPERTIESReactivity 0 3 = Serious BOILING POINT: 212ºF SPECIFIC GRAVITY: 1.034 = Severe VAPOR PRESSURE: N/D MELTING POINT: N/AVAPOR DENSITY: N/D EVAPORATION RATE: >1COMPOSITION & SOLUBILITY IN WATER: Complete pH:9.5-10SECTION 2 – INFORMATION ON INGREDIENTSAPPEARANCE and Odor: Clear red, non-scented odor characteristic of productChemical Name CAS No. OSHA PEL ACGIH TLV VOC:1%Ethanolamine 4-6% 141-43-5 3 PPM 3 PPM SECTION 10 – STABILITY AND REACTIVITYDipropylene glycol monobutyl ether 1% 29911-28-2 N/E 100 PPM STABILITY:CONDITIONS TO AVOID:StableReaction with nitrates may produceSECTION 3 – HAZARDS IDENTIFICATIONnitrosaminesPOSSIBLE ROUTES OF ENTRY: Eyes, Skin, Inhalation, Ingestion INCOMPATIBILITY:Will react with acidic productsEYES: Slight irritationHAZARDOUS DECOMPOSITION: Nitrogen oxidesSKIN: Redness and irritationHAZARDOUS POLYMERIZATION: Will not occurINHALATION:Respiratory irritationINGESTION: Gastrointestinal irritation and throat/mouth burnsSECTION 11 – TOXICOLOGICAL INFORMATIONACUTE AND CHRONIC: Will cause skin and eye irritation. Avoid breathingvapors.SECTION 4 – FIRST AID MEASURES CARCINOGENICITY: No NTP: NoEYES: Flush with water for 15 minutes. If irritation persists, seek IARC MONOGRAPHS: No OSHA REGULATED: Nomedical aid.SKIN: Flush with water for 15 minutes. If irritation persists, seek SECTION 12 – ECOLOGICAL INFORMATIONmedical aid.Product is biodegradable in biological waste water treatment plants.INHALATION: Move person to fresh airProduct is safe for septic tanksINGESTION: Drink large amounts of water, get prompt medical attentionSECTION 13 – DISPOSAL CONSIDERATIONSSECTION 5 – FIRE & EXPLOSION HAZARD DATADispose of in accordance with Federal, State and Local regulations.FLASH POINT: None at the boiling FLAMMABLE LIMITSpointLEL: N/A UEL: N/A SECTION 14 – TRANSPORTATION INFORMATIONEXTINGUISHING MEDIA: This is a water based material, not expected DOT SHIPPING NAME: Not regulatedto burn.FIRE FIGHTING PROCEDURES None RequiredSECTION 15 – REGULATORY INFORMATIONFIRE & EXPLOSION HAZARD:NoneAll components are listed on the US TSCA InventorySECTION 6 – ACCIDENTAL RELEASE MEASURESSoak up with absorbent material or sand. Collect in appropriate containers SECTION 16 – OTHER INFORMATIONPREPARED BY: Jay Chapin, Chemco CorporationSECTION 7 – HANDLING AND STORAGEDATE PREPARED: 02/17/09Keep from freezing. For industrial use only. Do not mix with any other SUPERSEDES: 06/22/07chemical. Wash hands after use. If spilled on clothing remove and wash REVISION NO.: 3before re-use. KEEP OUT OF REACH OF CHILDREN.We believe the statements, technical information and recommendations contained hereinare reliable, but they are given without warranty or guarantee of any kind, express or implied,and we assume no responsibility for any loss, damage, or expense, direct or consequentialarising out of their use.N/A = Not Applicable N/D = Not Determined MS TCOCNA 0209 V31