VW Golf IV/Bora - Westfalia

More documents

Recommendations

Info

Installation Instructions: Electrical System for Towing Hitch Installation Overview Note The installation of the cable harness is described on the basis of the example of the Golf IV Variant. Except for some slight deviations, the installation procedure is nearly the same for all other models. 1 2 3 4 5 6 7 8 9 Fig. 1: Installation Overview 1 Constant plus 6 Cable leadthrough 2 Fuse holder 7 Trailer socket 3 Trailer module 8 Right tail light 4 Ground point 9 PDC control line 5 Left tail light 18 321 457 391 101 - 50/02 VW Golf IV/Bora
Installation Instructions: Electrical System for Towing Hitch Installing the electrical kit 1. Disconnect the negative battery terminal. 2. Remove the following coverings: • In the luggage trunk - Covering of luggage trunk bottom - Covering of the rear end plate - Right-hand and left-hand side covering of the luggage trunk • From the rear end plate - Covering for the cable leadthrough on the left-hand side 3. Starting in the luggage trunk, lead the cable end through the vehicle’s cable leadthrough to the outside up to the socket holder plate (Fig. 1/7). 4. Fit the rubber grommet and insert it into the cable leadthrough (Fig. 1/6). Socket installation 5. Fit the socket gasket and connect the cable harness to the socket housing in accordance with the pin assignment plan (Fig. 1/7) and push the rubber grommet against the socket. 6. Screw the socket onto the holding plate (Fig. 1/7) using the supplied screws and nuts. Connecting the tail lights 7. Unplug the plug of the left-hand tail light (Fig. 1/5) and connect it to its counterpart on the cable harness. Make sure that the plug locks firmly into place. Plug the residual plug back into the tail light. 8. Lay the cable end with the two 6-pin plugs along the rear end plate to the right-hand tail light (Fig. 1/8). 9. Secure the cable on the rear end plate. 10. Unplug the plug of the right-hand tail light (Fig. 1/8) and connect it to its counterpart on the cable harness. Make sure that the plug locks firmly into place. Plug the residual plug back into the tail light. VW Golf IV/Bora 321 457 391 101 - 50/02 19
Page 1 and 2: ...................................
Page 3 and 4: Einbauanleitung: Elektroanlage für
Page 9 and 10: Instructions de montage: Installati
Page 17: Installation Instructions: Electric
Page 21 and 22: Installation Instructions: Electric
Page 23 and 24: Istruzioni per l'installazione: Imp
Page 31 and 32: Inbouwinstructie: Elektrische insta
Page 37 and 38: Návod k montáži: Elektrické za
Page 43: Návod k montáži: Elektrické za

VW Golf IV/Bora - Westfalia

Create successful ePaper yourself

Delete template?

Save as template?