Padgett Catalog - Integra Miltex

More documents

Recommendations

Info

• Cutting edge instruments and knives should be sharp and free of damage. • After scrubbing, rinse instruments thoroughly under running water. While rinsing, open and close scissors, hemostats, needle holders and other hinged instruments to ensure that hinged areas are rinsed out and that no debris remains. 4. aftEr cLEaning Separate dissimilar metals prior to sterilizing/autoclaving. If instruments will be stored, allow them to air-dry and store them in a clean and dry environment. 5. autocLaVing A. Lubricate all hinged instruments which have any “metal to metal” action at the screw or box lock. A non-silicone, water-soluble surgical lubricant such as Miltex ® Lube (3-700 or 3-705) is recommended. Do not use industrial oils or lubricants. b. sterilize instruments either individually or in sets. • individual instruments: Disposable paper or plastic pouches are ideal. Make sure to use a wide enough pouch for instruments with ratchet locks so instruments can be sterilized in an open (unlocked) position. Instruments locked during autoclaving can develop cracked hinges (box locks) or other problems because of heat expansion. If wrapping instruments, make sure the towel does not contain detergent residue which can stain instruments. • instrument sets: Unlock all instruments and sterilize in an open position. Place heavy instruments on the bottom of set (when two layers are required). Do not overload the chamber because an air pocket that hinders steam penetration may form. caution: With most portable tabletop autoclaves, unlock the door and open it no more than a crack, about 1/4” (6.4 mm).(at the end of the autoclave cycle and before the drying cycle). Then run the dry cycle for the period recommended by the autoclave manufacturer. If the autoclave door is fully opened before the drying cycle, cold air will rush into the chamber and will cause condensation on the instruments, potentially resulting in water stains or causing wet packs. Make sure autoclave filters and chambers are cleaned as recommended by the manufacturer. Miltex ® Surgical Instrument Stain remover (3-740) is effective in removing stains and in cleaning the autoclave chamber. If you have any unusual staining on your instruments after sterilization, obtain our Instrument Care System DVD (3-810) or contact your local Miltex ® representative. 378 integralife.com/integra-miltex INSTrUMENT MAINTENANCE & CArE Recommended Steps in Cleaning, Sterilization & Maintenance of Miltex ® & Padgett ® Surgical Instruments 6. cHEMicaL/coLd stEriLiZation Most chemical/cold sterilization solutions render instruments sterile only after 10-hour immersion. This prolonged chemical action can be more detrimental to instruments than the usual 20-minute autoclave cycle. If the instruments need to be “disinfected” only, a chemical/cold sterilization soak is acceptable, as disinfection will take approximately 10 minutes or more. Check manufacturers’ specifications. Also see our warning in using bleach (paragraph 3). Keep in mind the difference between: • Sterile - an absolute term (no living organism survives); and • Disinfected - basically clean. Some organisms may survive. Always use the proper sterilization/cleaning technique to render the instrument in the required condition for use. caution: for instruments with tungsten carbide insert jaws, the use of chemical/cold sterilization solutions is not recommended as it may deteriorate the instrument’s jaw. We recommend these Miltex products to properly safeguard and care for your quality instruments. rEf description use during 3-760 Instrument Prep Enzyme foam 24 oz. spray • holding & presoak 3-750 EZ-Zyme ® , All Purpose Enzyme Cleaner box 32 - 3/4 oz. packets • holding & presoak • Soak cleaning 3-755 EZ-Zyme • Ultrasonic cleaning • Manual cleaning • Laundry presoak ® , All Purpose Enzyme Cleaner 1-gallon pump bottle 3-700 Spray Lube 8 oz. spray bottle 3-705 Surgical Instrument Lubricant 1-gallon pump bottle • before autoclaving 3-710 Surgical Instrument Cleaner & Lubricant 1-gallon pump bottle • Manual cleaning • Washer/decontaminator • Ultrasonic cleaning 3-720 3-725 Surgical Instrument Cleaner 8 oz. spray bottle Surgical Instrument Cleaner 1-gallon pump bottle • Soak cleaning • Ultrasonic cleaning • Manual cleaning 3-740 Surgical Instrument Stain remover 3 oz. jar • Stain removal 3-1000 Nylon Instrument Cleaning brushes 3-pack • Manual cleaning of 3-1001 Stainless Steel Instrument Cleaning brushes 3-pack instruments 3-800 Instrument Care System • Complete instrument care 3-810 Instrument Care DVD • Training personnel in the care of instruments
Instrument Stain Guide INSTrUMENT MAINTENANCE & CArE color cause of stain What to do Orange-brown to reddish stain (looks like rust) black, brown & Pitting rainbow or Multi-Color bluish-Green bluish-black bluish-Gray (w/possible pitting) Perform eraser test. If the stain rubs off and no pitting exists, problem is most likely from: • Detergent residue on towels or high alkaline >8 ph detergent which leaves a phosphate surface deposit • Dried blood • Iodine or betadine residue Subjected to an Acidic Low
Page 1 and 2:
Integra Miltex® P l aS t i C S u r
Page 3:
introduction Integra Miltex® Padge
Page 6 and 7:
iv integralife.com/integra-miltex T
Page 8 and 9:
Brauer Rocking Nasal Chisel 2 integ
Page 10 and 11:
Cottle Chisel 4 integralife.com/int
Page 12 and 13:
Clodius Bone Chisel Catalog# Length
Page 14 and 15:
French Pattern Osteotome 8 integral
Page 16 and 17:
10 integralife.com/integra-miltex O
Page 18 and 19:
Heden Bone Gouge Catalog# Length Wi
Page 20 and 21:
14 integralife.com/integra-miltex r
Page 22 and 23:
16 integralife.com/integra-miltex b
Page 24 and 25:
Volkmann Scoop 18 integralife.com/i
Page 26 and 27:
DIssectors anD elevators
Page 28 and 29:
Page 30 and 31:
Page 32 and 33:
Page 34 and 35:
Silverstein Breast Dissector Catalo
Page 36 and 37:
Read Periosteal Elevator Clodius El
Page 38 and 39:
Read Periosteal Elevator 32 integra
Page 40 and 41:
Miltex Periosteal Elevator Lempert
Page 42 and 43:
Halle Septum Elevator Freer Septum
Page 44 and 45:
Pennington Septum Elevator Molt Dis
Page 46 and 47:
Cottle Skin Elevator Very versatile
Page 48 and 49:
Mitchell Trimmer Knife blade and sp
Page 50 and 51:
fOrCEPS - TUNGSTEN CArbIDE anatoMy
Page 52 and 53:
46 integralife.com/integra-miltex f
Page 54 and 55:
Evans Pelvic Dressing Forceps Catal
Page 56 and 57:
Page 58 and 59:
Page 60 and 61:
Brown Tissue Forceps 54 integralife
Page 62 and 63:
Thumb Dressing Forceps Lanes Tissue
Page 64 and 65:
Cushing Dressing Forceps Semken Tis
Page 66 and 67:
Page 68 and 69:
McIndoe Dissecting Forceps 62 integ
Page 70 and 71:
Von Graefe Tissue Forceps Nelson Ti
Page 72 and 73:
Page 74 and 75:
Page 76 and 77:
Page 78 and 79:
Micro Suture Forceps 72 integralife
Page 80 and 81:
Page 82 and 83:
Adson Bipolar Forceps Catalog# Leng
Page 84 and 85:
Allis Tissue Forceps 78 integralife
Page 86 and 87:
Simal Rib Forceps Catalog# Length P
Page 88 and 89:
Brand Tendon Grasping Forceps Catal
Page 90 and 91:
Miltex Ear Forceps 84 integralife.c
Page 92 and 93:
86 integralife.com/integra-miltex S
Page 94 and 95:
Page 96 and 97:
Weil Nasal Forceps 90 integralife.c
Page 98 and 99:
Page 100 and 101:
McKenty Sphenoid Punch Forceps 94 i
Page 102 and 103:
Kerrison-Costen Rongeur 96 integral
Page 104 and 105:
Nigro-Hamra Septum Forceps 98 integ
Page 106 and 107:
Fredrick Face Lift Forceps 100 inte
Page 108 and 109:
Hartman Mosquito Forceps Catalog# D
Page 110 and 111:
Kocher Forceps Catalog# Description
Page 112 and 113:
Lariche Forceps Catalog# Descriptio
Page 114 and 115:
Hooks anD retractors Hooks Retracto
Page 116 and 117:
Guthrie Hook 110 integralife.com/in
Page 118 and 119:
Kleinert-Kutz Skin Hook 112 integra
Page 120 and 121:
Gillies Skin Hook Ideal for manipul
Page 122 and 123:
Chamberlain-Fries Hook 116 integral
Page 124 and 125:
Cottle Nasal Retractor Cottle Retra
Page 126 and 127:
Fomon Ball End Retractor 120 integr
Page 128 and 129:
Mathieu Retractor 122 integralife.c
Page 130 and 131:
Clodius Orbital Retractor Commonly
Page 132 and 133:
Knapp Retractor Converse Retractor
Page 134 and 135:
Skin Retractor Kilner Alae Retracto
Page 136 and 137:
Deaver Retractor Padgett-Deaver Ret
Page 138 and 139:
132 integralife.com/integra-miltex
Page 140 and 141:
Freeman Flap Rake Retractor 134 int
Page 142 and 143:
Barsky Nasal Retractor Catalog# Len
Page 144 and 145:
Kasdan Hand Retractor 138 integrali
Page 146 and 147:
Ferreira Face Lift Retractor Catalo
Page 148 and 149:
Millard-Dingman Mouth Gag Catalog#
Page 150 and 151:
Mouth Prop 144 integralife.com/inte
Page 152 and 153:
Cronin Lip and Nostril Retractor Ca
Page 154 and 155:
Killian Septum Speculum 148 integra
Page 156 and 157:
Page 158 and 159:
Surgical Blades, Sterile CS* Catalo
Page 160 and 161:
Freer Septum Knife 154 integralife.
Page 162 and 163:
Joseph Button End Knife for planing
Page 164 and 165:
19-2522 158 integralife.com/integra
Page 166 and 167:
mallets anD cartIlage Instruments M
Page 168 and 169:
Fowler Aluminum Mallet Lucae Mallet
Page 170 and 171:
Cottle Cartilage Crusher 164 integr
Page 172 and 173:
Wright-Rubin Septum Morselizer 166
Page 174 and 175:
The Miltex Repair and Service Team
Page 176 and 177:
Page 178 and 179:
Webster Needle Holder, Tungsten Car
Page 180 and 181:
Swedish Needle Holder, Tungsten Car
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Noe-Webster Needle Holder Catalog#
Page 190 and 191:
neeDles, proBes anD passers Needles
Page 192 and 193:
Kelsey-Fry Bone Awl 186 integralife
Page 194 and 195:
Page 196 and 197:
Worst Pigtail Probe 190 integralife
Page 198 and 199:
asps, FIles anD saws Tungsten Carbi
Page 200 and 201:
Maltz Nasal Rasp, Tungsten Carbide
Page 202 and 203:
Peet Nasal Rasp Peet-Cottle Nasal R
Page 204 and 205:
Maltz Double-Sided Rasp 198 integra
Page 206 and 207:
Lewis Nasal Rasp 200 integralife.co
Page 208 and 209:
Page 210 and 211:
Joseph Bayonet Nasal Saw 204 integr
Page 212 and 213:
scIssors Ceramic SuperCut Tungsten
Page 214 and 215:
Page 216 and 217:
fEATUrES AND bENEfITS anatoMy of cE
Page 218 and 219:
Kaye Face Lift Scissors (CC/SC/TC)
Page 220 and 221:
Fomon Dorsal Scissors (SC/TC) Catal
Page 222 and 223:
Gorney Rhytidectomy Scissors (SC/TC
Page 224 and 225:
Mayo Dissecting Scissors (SC) Catal
Page 226 and 227:
Gorney Platysma Scissors (SC) 220 i
Page 228 and 229:
Fomon Lateral Scissors (SC) Catalog
Page 230 and 231:
Operating Scissors (TC) Catalog# De
Page 232 and 233:
Mayo Scissors (TC), Rounded Blades
Page 234 and 235:
Page 236 and 237:
Knight Nasal Scissors (TC) Catalog#
Page 238 and 239:
Greenberg Par Scissors (TC) Catalog
Page 240 and 241:
Hinderer Rhytidectomy Scissors (TC)
Page 242 and 243:
Fine Pointed Scissors Alar Cartilag
Page 244 and 245:
Aufricht Dissecting Scissors 238 in
Page 246 and 247:
Kilner Scissors McIndoe Scissors 24
Page 248 and 249:
Padgett Iris Scissors, Ribbon Type
Page 250 and 251:
Mayo-Noble Dissecting Scissors 244
Page 252 and 253:
OR Scissors 246 integralife.com/int
Page 254 and 255:
Page 256 and 257:
Spencer Stitch Scissors Catalog# De
Page 258 and 259:
Freeman Face Lift Scissors Gorney T
Page 260 and 261:
Frederick Scissors Catalog# Descrip
Page 262 and 263:
Joseph Nasal Scissors Catalog# Desc
Page 264 and 265:
Page 266 and 267:
Taylor Dural Scissors Catalog# Leng
Page 268 and 269:
Page 270 and 271:
Bellucci Alligator Scissors 264 int
Page 272 and 273:
Lister Bandage Scissors 266 integra
Page 274 and 275:
Sheen Grid Catalog# Description PM-
Page 276 and 277:
ENT Packing Line 270 integralife.co
Page 278 and 279:
Sinus Catalog# Description 272 inte
Page 280 and 281:
Page 282 and 283:
Bunnell Bone Drill Catalog# Descrip
Page 284 and 285:
Unna Comedone Extractor Catalog# De
Page 286 and 287:
Keyes Dermal Punch Catalog# Descrip
Page 288 and 289:
Magill Suction Tube 282 integralife
Page 290 and 291:
Page 292 and 293:
Suture Wire, 4 oz. (118g) Spool for
Page 294 and 295:
Pin & Wire Puller, Tungsten Carbide
Page 296 and 297:
Suture Wire Cutting Scissors (TC) P
Page 298 and 299:
Bird Beak Wire Forming Pliers Catal
Page 300 and 301:
Lingual Arch Forming Pliers Catalog
Page 302 and 303:
Nance Wire Forming Pliers 296 integ
Page 304 and 305:
measurIng anD markIng Instruments
Page 306 and 307:
Ginsberg Caliper Catalog# Descripti
Page 308 and 309:
Polk Finger Goniometer Measures fin
Page 310 and 311:
Grossman Areola Marker, Aluminum Ca
Page 312 and 313:
Ackerman Areola Marker Catalog# Wid
Page 314 and 315:
Pitanguy Small Flap Demarcator for
Page 316 and 317:
FIBer optIc Instruments
Page 318 and 319:
TBTS-Style Endoplastic Retractor wi
Page 320 and 321:
Ferreira Face Lift Retractor with A
Page 322 and 323:
Padgett-Deaver Retractor with ACMI,
Page 324 and 325:
Page 326 and 327:
Page 328 and 329:
Bellucci Ear Forceps Catalog # Desc
Page 330 and 331:
Paparella-Weitlaner Retractor Lempe
Page 332 and 333:
Rosen Picks with Octagonal Handle C
Page 334 and 335: 19-2522 328 integralife.com/integra
Page 336 and 337: Catalog # Size Working Length 19-55
Page 338 and 339: Suction Nasal Forceps 332 integrali
Page 340 and 341: Wilde Nasal Forceps 334 integralife
Page 342 and 343: Nasal Forceps with Luer Lock Port &
Page 344 and 345: Nasal Rotating Back-Biting Forceps
Page 346 and 347: Circular Cutting Punch Catalog # Sh
Page 348 and 349: Wright-Rubin Septum Morselizer Jans
Page 350 and 351: St. Clair-Thompson Adenoid Forceps
Page 352 and 353: Millard-Dingman Mouth Gag Catalog#
Page 354 and 355: Biopsy Punch, Sterile Biopsy Punch
Page 356 and 357: Safety Scalpels, Sterile • Compli
Page 358 and 359: Surgical Blades, Sterile carbon, st
Page 360 and 361: Surgi-Clamp, Plastic • Non-steril
Page 362 and 363: Nasal 356 integralife.com/integra-m
Page 364 and 365: staInless steelware anD Instrument
Page 366 and 367: Catalog# Size 3-915 1-19/64” x 3-
Page 368 and 369: Instrument Stringers Catalog# Descr
Page 370 and 371: Miltex ® Instrument Care & Cleanin
Page 372 and 373: 366 integralife.com/integra-miltex
Page 374 and 375: Silitone Color Bands 368 integralif
Page 378 and 379: Miltex ® Sterilization Trays Catal
Page 380 and 381: Bunt Holder Catalog# Description 3-
Page 382 and 383: Sterilization Products 376 integral
Page 386 and 387: INSTRUMENT WARRANTY 380 integralife
Page 390 and 391: Blepharoplasty Set Qty Catalog# Des
Page 394 and 395: Qty Catalog# Description 388 integr
Page 398 and 399: Rhinoplasty Set Gruber Set Qty Cata
Page 400 and 401: Cleft Palate Set Qty Catalog# Descr
Page 402 and 403: A Abdominal Demarcator ............
Page 404 and 405: Dahlgren Iris Scissors.............
Page 406 and 407: Gruber Rhinoplasty Retractor ......
Page 408 and 409: McKenty Sphenoid Punch Forceps ....
Page 410 and 411: Retractors, Flap ..................
Page 412 and 413: Troutman-Barraquer Mini Blade Break
Page 414 and 415: 4-310 .............................
Page 416 and 417: 10-14-NS ..........................
Page 418 and 419: 20-1020 ...........................
Page 420 and 421: PM-0504 ...........................
Page 422 and 423: PM-4670 ...........................
Page 424 and 425: PM-898FO...........................
show all

Padgett Catalog - Integra Miltex

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?