Adly Gazelle (TB-50, TB-100) servicemanual - Scootergrisen

More documents

Recommendations

Info

INSTALLATION OF LUBRICATION Attention of Operation Pay attention to avoid dust enter to the interior of engine and motor oil pipe when disassembly the motor oil pump. Never disassembly motor oil pump. Must draw out the air on the pump if there have air in the pump when disassembly pipe of carburetor. After disassembling the motor oil connection tube, must fulfill the motor oil in the connection pipe, then, connect the tube. Diagnosis of Troubles Too much smoke, means too much carbon muck piping up the spark plug. Poor synchronizing adjust of motor oil pump (too much exhaust). Bad quality of engine motor oil. Overheating Poor synchronizing adjustment of motor oil pump (too much exhaust). Bad quality of engine motor oil. Piston burnt Short of engine oil, or engine oil pipe is clogged. Poor adjustment of motor oil pump (lesser the exhaust). There have air in the motor oil pipes system. ADLY MOTO 3-4
Bad motor oil pump. Clogging oil from oil tank Vent of motor oil case’s cap is clogged. Filter of motor oil is clogged. Preparation standard Use separating motor oil appointed (use for 2-stroke). Content of motor oil tank : 1.1 liter INSTALLATION OF LUBRICATION Disassembly of Motor Oil Pump Remove right side cover. Remove stator cover. Remove A.C.G ✱WARNNING: Operating after cleaning motor oil pump around and no entering to the crank shaft case. ADLY MOTO 3-4
Page 1 and 2: ADLY MOTO SERVICE MANUAL TB-50 (Gaz
Page 3 and 4: ADLY MOTO I N D E X Information of
Page 5 and 6: INFORMATION FOR PREPARATION Attenti
Page 7 and 8: INFORMATION FOR PREPARATION LOCKING
Page 9 and 10: ADLY MOTO 1-5
Page 11 and 12: INFORMATION FOR PREPARATION REVOLUT
Page 13 and 14: INFORMATION FOR PREPARATION REVOLUT
Page 15 and 16: INFORMATION FOR PREPARATION SPARK P
Page 17 and 18: CHECK AND ADJUST Way of Check & Adj
Page 19 and 20: Transmission Electril device Leve
Page 21 and 22: CHECK AND ADJUST Disassembly of Ped
Page 23 and 24: Ensuring the joint of tail light ho
Page 25: CHECK AND ADJUST Adjustment of Moto
Page 29 and 30: Assembly 51 INSTALLATION OF LUBRICA
Page 31 and 32: FUEL INSTALLATION Attention in Oper
Page 33 and 34: FUEL INSTALLATION 1 Operation / Par
Page 35 and 36: FUEL INSTALLATION Disassembly / Ass
Page 37 and 38: FUEL INSTALLATION Disassembly of In
Page 39 and 40: 6 7 8 9 8 Petrol gauge ass’y Join
Page 41 and 42: Assembly 91 ADLY MOTO 4-2 Operatin
Page 43 and 44: DISASSEMBLY OF ENGINE Operation / P
Page 45 and 46: CYLINDER HEAD / CYLINDER / PISTON D
Page 47 and 48: ADLY MOTO 6-2
Page 49 and 50: Starter / Driving Disc / Clutch / T
Page 57 and 58: Final Transmission Mechanism Attent
Page 59 and 60: 1 2 3 4 5 6 7 8 Disassembly Bolt Mi
Page 61 and 62: Crank Case / Crank Shaft Attention
Page 63 and 64: 1 2 3 4 5 6 7 8 9 10 11 12 13 Disas
Page 65 and 66: Put new crank shaft into right cran
Page 67 and 68: Front Wheel / Front Suspension / Fr
Page 75 and 76: 10 7 4 Assembly 11 Steering handle
Page 77 and 78:
REAR WHEEL / SUSPENSION / BRAKE Dia
Page 79 and 80:
REAR WHEEL / SUSPENSION / BRAKE Dis
Page 81 and 82:
ELECTRICAL DEVICE Attention of Oper
Page 83 and 84:
ELECTRICAL DEVICE Solid Wiring Diag
Page 85 and 86:
ELECTRICAL DEVICE Check Voltage of
Page 87 and 88:
ELECTRICAL DEVICE WARNNING: Check i
Page 89 and 90:
ELECTRICAL DEVICE Ignition Coil Dis
Page 91 and 92:
ELECTRICAL DEVICE Check Fuel Gage
Page 93 and 94:
ADLY MOTO 12-13 ELECTRICAL DEVICE R
Page 95 and 96:
ELECTRICAL DEVICE Attention of Oper
Page 97 and 98:
ELECTRICAL DEVICE Solid Wiring Diag
Page 99 and 100:
ELECTRICAL DEVICE Check Voltage of
Page 101 and 102:
ELECTRICAL DEVICE ✱WARNNING: Chec
Page 103 and 104:
ELECTRICAL DEVICE Ignition Coil Dis
Page 105 and 106:
1 2 3 4 5 6 7 Separation Bolt set C
Page 107 and 108:
ELECTRICAL DEVICE Rear light bulb /
show all

Adly Gazelle (TB-50, TB-100) servicemanual - Scootergrisen

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?