Kymco Super 9 (SH10DA) servicemanual - Scootergrisen

More documents

Recommendations

Info

9. A.C. GENERATOR A.C. GENERATOR INSTALLATION Install the A.C. generator stator and pulser coil wire clamp onto the right crankcase, and then install the pulser coil. Connect the A.C. generator wire connector. Clean the taper hole in the flywheel off any burrs and dirt. Install the woodruff key in the crankshaft keyway. Install the flywheel onto the crankshaft with the flywheel groove aligned with the crankshaft woodruff key. Hold the flywheel with the universal holder and install the flywheel flange nut. Torque: 34.3~39.2N-m Start the engine and check the ignition timing. (3-7) Install other removed parts in the reserve order of removal. 9-5 SUPER 9 50 A.C. Generator Wire Connector Universal Holder Woodruff Key
10. CRANKCASE/CRANKSHAFT 10 SUPER 9 50 __________________________________________________________________________________ __________________________________________________________________________________ __________________________________________________________________________________ __________________________________________________________________________________ __________________________________________________________________________________ CRANKCASE/CRANKSHAFT __________________________________________________________________________________ SERVICE INFORMATION ................................................................ 10-1 TROUBLESHOOTING ....................................................................... 10-1 CRANKCASE SEPARATION............................................................ 10-2 CRANKSHAFT REMOVAL............................................................... 10-2 CRANKSHAFT INSPECTION ........................................................... 10-3 CRANKSHAFT INSTALLATION ..................................................... 10-4 CRANKCASE ASSEMBLY................................................................ 10-6 10-0 10
Page 2 and 3:
1. GENERAL INFORMATION 1 SUPER 9 50
Page 6 and 7:
1. GENERAL INFORMATION SERVICE PREC
Page 8 and 9:
1. GENERAL INFORMATION If the fuse
Page 10 and 11:
1. GENERAL INFORMATION After clamp
Page 12:
1. GENERAL INFORMATION After routi
Page 17 and 18:
1. GENERAL INFORMATION SPECIAL TOOL
Page 19 and 20:
1. GENERAL INFORMATION 1-17 Front S
Page 21 and 22:
1. GENERAL INFORMATION Reserve Cap
Page 23:
1. GENERAL INFORMATION Wire Harness
Page 27 and 28:
1. GENERAL INFORMATION ENGINE STOPS
Page 29 and 30:
1. GENERAL INFORMATION ENGINE LACKS
Page 33 and 34:
1. GENERAL INFORMATION POOR SUSPENS
Page 35 and 36:
1. GENERAL INFORMATION FUEL GAUGE 1
Page 37 and 38:
2. EXHAUST MUFFLER/FRAME COVERS 2 S
Page 39 and 40:
2. EXHAUST MUFFLER/FRAME COVERS FRA
Page 41 and 42:
2. EXHAUST MUFFLER/FRAME COVERS LEG
Page 43 and 44:
2. EXHAUST MUFFLER/FRAME COVERS BOT
Page 45:
3. INSPECTION/ADJUSTMENT 3 SUPER 9
Page 60 and 61: 4. LUBRICATION SYSTEM 4 SUPER 9 50
Page 66 and 67: 5. ENGINE REMOVAL/INSTALLATION 5 SU
Page 69: 5. ENGINE REMOVAL/INSTALLATION Remo
Page 72: 6. CYLINDER HEAD/CYLINDER/PISTON SE
Page 82 and 83: 7. KICK STARTER/DRIVE PULLEY/ CLUTC
Page 87: 7. KICK STARTER/DRIVE PULLEY/ CLUTC
Page 91: 7. KICK STARTER/DRIVE PULLEY/ CLUTC
Page 99 and 100: 8. FINAL REDUCTION 8 SUPER 9 50 ___
Page 101: 8. FINAL REDUCTION FINAL REDUCTION
Page 104 and 105: 8. FINAL REDUCTION Drive new bearin
Page 107 and 108: 9. A.C. GENERATOR 9 SUPER 9 50 ____
Page 114: 10. CRANKCASE/CRANKSHAFT SERVICE IN
Page 124 and 125: 11. COOLING SYSTEM RADIATOR RADIATO
Page 126 and 127: 11. COOLING SYSTEM RADIATOR BRACKET
Page 130: 11. COOLING SYSTEM WATER PUMP BEARI
Page 136 and 137: 12. CARBURETOR 12 SUPER 9 50 ______
Page 138 and 139: 12. CARBURETOR THROTTLE VALVE DIS-
Page 140 and 141: 12. CARBURETOR Install the throttle
Page 142 and 143: 12. CARBURETOR Connect the auto bys
Page 148 and 149: 13. STEERING HANDLEBAR/FRONT WHEEL/
Page 169 and 170:
14. REAR BRAKE/REAR FORK/REAR WHEEL
Page 172 and 173:
Page 176 and 177:
Page 178 and 179:
Page 181 and 182:
15. ELECTRICAL EQUIPMENT SUPER 9 50
Page 186:
15. ELECTRICAL EQUIPMENT IGNITION S
Page 191:
15. ELECTRICAL EQUIPMENT STARTER RE
Page 194:
16. INSTRUMENT/SWITCHES/LIGHTS SERV
Page 203:
17. EVAPORATIVE/EXHAUST EMISSION CO
show all

Kymco Super 9 (SH10DA) servicemanual - Scootergrisen

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?