PRECOR - National Gym Supply, Inc

Accessing the Diagnostic Software
for the 95X series Treadmill
The treadmill's diagnostic software consists of the following modes:
• Display Test
• Keyboard Test
• Heart Rate Test
• Lift Test
CIRCUIT BREAKER MOUNT
2@ P5T44275-102
2@
• Belt Speed Test
• Belt Power Test
• Circuit Breaker Test
Procedure
1. Plug the power cord into the wall outlet, then turn on the treadmill
with the circuit breaker.
2. The keys on the display are hypothetically numbered 1 to 7 from left
to right. The STOP is key number 4 and is located directly below the
QUICK START key. The QUICK START key is not part of the numbering
sequence. Note: The numeric keys may also be used for the all keys in
the access sequence except for the RESET key.
3. With the PRECOR banner scrolling, press keys RESET-5-1-7-6-5-7-6-1
sequentially.
4. Watch the electronic display as the display test progresses. This test
illuminates all of the LEDs on the display. If all of the LEDs do not
illuminate, replace the upper PCB.
5. Press the STOP or ENTER key to proceed to the keyboard test.
FUSES
1.00 Amp, 250 Vac
3) P5T11075-102
2.00 Amp, 250 Vac
3! P5T11075-105
Precor 954/956
Belts, Decks, and Deck Parts c
b P6T36355-126 Run Belt, OEM, Self-lube, v. 3, 4 $ 384.78
c P5T36355-128 Running Belt, OEM, v. 1, 2 only 479.60
c P5T48402-102 Waxless Tread Deck, v. 1, 2 302.28
d P5T59048-101 Spring Kit, w/ Lube, 954–6 118.00
e P5T48402-102 OEM Deck, V1, 2 302.28
f P5T59085-101 OEM Deck Assembly, V3, 4 335.72
g TM062 Superwear Deck, V1, 2 188.00
h TM055 Superwear Deck, V3, 4 183.00
i TM033DX Durabelt-X ® , Pre-Waxed, 95X v. 1, 2 210.00
j TM034DX Durabelt-X ® , Pre-Waxed, 95X v. 3, 4 227.00
1)cP5T43018-101 Deck Spring 956, each 20.36
c P5T43019-101 Washer for Bed Spring 1.50
c PR6T33873-102 Stud, Bed Spring, 960 20.72
c TM001 NGS Deck Lube, 2 oz. (1 application) 12.00
c TM002 NGS Deck Lube, 1 lb. (8 applications) 68.00
Frame Partsc
1! P5T39188-102 Hood 954–956, v. 1,2 88.00
1@ P5T39192-102 End Cap, Right Rear 95X 17.50
1# P5T39192-101 End Cap, Left Rear 95X 17.50
1$ P5T44268-102 Deck Trim, 954 & 956 72.70
Console Electronics c
1% P5T50998-102 Stop Button Retro Kit 95X, v. 1, 2 only 56.10
1^ P5T44395-511 Faceplate, C954 224.50
1& P5T44394-511 Faceplate, 956 v. 1-3 577.16
c
P5T39024-505 PCA, Display Precor C954 370.50
OEM DECK
f P5T59085-101, V3, 4
e P5T48402-102, V1, 2
DECK
h TM055, V3, 4
g TM062, V1, 2
Electronics and Elevation Partsc
1* P5T59049-101 Lower Electronics $ 727.56
1( P5RE02 Lower PCA, Repair, All 185.00
2) P5T45674-136 Power Cord, 125v, 954/956, v. 1, 2 64.20
2! P5T45672-136 Power Cord, 240v, 954-6, v. 1, 2 61.63
c P5T39006-502 Display PCB, v. 1, 2, 3 404.14
c P5RE03 Display PCB, Repair 120.00
2@ P5T44275-102 Circuit Breaker Mount 10.34
2# PR6T10435-101 Breaker Switch, 110V 75.80
2$ PR6T10738-102 Breaker Switch, 250V 98.34
2% PRE06 Lift Actuator, Repair 115.00
2^ P5T39207-111 Lift Actuator, 120V, v. 1, 2 305.36
2& P6T59088-101 Lift Actuator, 120V, v. 3, 4 222.10
Drive Systemc
c ST005 Drive Belt 17.16
2& P5T59070-105 Drive Motor, v. 3, 4 537.30
2* P5T59089-101 Drive Motor, 120v, v. 1, 2 935.56
2( MRE05 Drive Motor, Repair 196.00
3) P5T11075-102 Fuse, 1.00 Amp, 250V, Slow, Radial 3.20
3! P5T11075-105 Fuse, 2.00 Amp, 250V, Slow, Radial 3.08
3@ P5T20002-113 Motor Brush, 95xi only 66.00
3# P5T39128-104 Drive Roller, 956, v. 1, 2 680.00
3$ P5T44214-104 Drive Roller, v. 3, 4 313.62
3% P5T44212-104 Take-Up Roller, v. 3, 4 300.52
3^ P5T39123-105 Take-Up Roller, v. 1, 2 only 332.64
3& P5T44236-101 GFX Cushion 63.26
DURABELT-X ®
i TM033DX, 95X v. 1, 2
j TM034DX, 95X v. 3, 4
GFX CUSHION
3& P5T44236-101
PRECOR 954/956 V. 1, 2
Circuit Breakers
2# PR6T10435-101, 120V
2$ PR6T10738-102, 240V
2# 2$
WWW.GYMPART.COM 1-800-GYMPART (1-800-496-7278) PARTS RESOURCE BOOK 2009 105