operation, maintenance and monitoring plan ... - Ithaca-SHIP.org!

More documents

Recommendations

Info

6 Acronyms AMSL bgs CSM DO DPE EPT GAC gpm HDPE Hg hp IRM LAH LSH LSHH LSL LSLL NYSDEC OD O&M OM&M ORP PLC QA/QC scfm SOP SPDES SRP/AA SVE TCE VOC above mean sea level below ground surface conceptual site model dissolved oxygen dual-phase extraction Emerson Power Transmission granular activated carbon gallons per minute high density poly ethylene mercury horsepower Interim Remedial Measure level alarm high level switch high level switch high high level switch low level switch low low New York State Department of Environmental Conservation outer-diameter operation and maintenance Operation, Maintenance and Monitoring oxidation-reduction potential process logic control quality assurance/quality control standard cubic feet per minute standard operating procedure State Pollution Discharge Elimination System Supplemental Remedial Program/Alternatives Analysis soil vapor extraction trichloroethene volatile organic compounds 19
Figures
Page 1 and 2: OPERATION, MAINTENANCE AND MONITORI
Page 3 and 4: Contents 3.3.1 Groundwater Sampling
Page 5 and 6: contamination was the subject of th
Page 7 and 8: This system was shut down on August
Page 9 and 10: • Allen-Bradley MicroLogix progra
Page 11 and 12: sump and SVE air/water separator. T
Page 13 and 14: • Check the satellite drum (perso
Page 15 and 16: 3 Groundwater Monitoring Plan 3.1 P
Page 17 and 18: zone. Additionally, groundwater ele
Page 19 and 20: • water level data and drawdown i
Page 21: 5 References Environmental Strategi
Page 32: Appendix A - As-Built Drawings
Page 40 and 41: Well ID (a) Top of Casing Elevation
Page 42 and 43: MID-ATLANTIC ENVIRONMENTAL EQUIPMEN
Page 44 and 45: Start-up Procedures 1 Engineering D
Page 46 and 47: INSTALLATION & START UP PROCEDURES
Page 52 and 53: SHIP LOOSE FOR INSTALLATION ON SITE
Page 54: scale bar, each block is 12" long *
Page 64 and 65: Page 1 of 3 COMPONENT LIST PROJECT
Page 66 and 67: Page 3 of 3 63 2 GOULDS NPE, 1ST1F5
Page 68 and 69: 38 1 LEGEND PLATE TALL, 30 MM, RED/
Page 70 and 71: Section 2 SVE
Page 72 and 73:
Page 2 Clean water can be injected
Page 74 and 75:
Page 4 2. Install packing (42) befo
Page 76 and 77:
Page 6 PARTS LIST — 331, 332, 333
Page 78 and 79:
Page 8 REPAIR/CONVERSION KIT NUMBER
Page 80 and 81:
2 Sutorbilt Legend Series Setting t
Page 82 and 83:
4 Legendary Design Features 1 High-
Page 84 and 85:
6 The Sutorbilt Legend Design Flex-
Page 86 and 87:
8 Sutorbilt Legend Pressure Perform
Page 88 and 89:
10 Sutorbilt Legend Dimensional Dat
Page 90:
Protect your Sutorbilt investment w
Page 93 and 94:
Product Overview The new 841 PLUS
Page 95 and 96:
Summary 841 PLUS ® Motor Stock Mot
Page 97 and 98:
U.S. ELECTRICAL MOTORS 1800 S P E E
Page 99 and 100:
Installation, Operation & Maintenan
Page 101 and 102:
INSTALLATION / MOUNTING Mount unit
Page 103 and 104:
Do not force control wheel beyond s
Page 105 and 106:
FOR SERVICE CALL: NEAREST U.S.E.M.
Page 109 and 110:
Shaft Coupler Body S-Flex Shaft Cou
Page 111 and 112:
Shaft Coupler Insert Shaft Coupling
Page 113 and 114:
REMEDIATION DRAIN OUT 2" ALUM. FNPT
Page 115 and 116:
View Datasheet http://www.solbergmf
Page 117 and 118:
Section 3 Air Compressor Air Stripp
Page 119 and 120:
K13 - 3/4" NPT, Brass Body, Univers
Page 121 and 122:
Parts Module Code: 0 Switch,Level,M
Page 123 and 124:
Air Stripper Module Code: 6400 6400
Page 125 and 126:
Miscellaneous Part Part: As per det
Page 127 and 128:
Building, Trailer or Skid Module Co
Page 129 and 130:
Parts Listing per Maintenance Code
Page 131 and 132:
Maintenance Schedule 50561 Ithaca,
Page 133 and 134:
Troubleshooting Chart Symptom Poten
Page 135 and 136:
Excessive Discharge pressure built
Page 137 and 138:
Stripper is not cleaning contaminan
Page 139 and 140:
Bag Filter Vessel is operating over
Page 141 and 142:
Transmitter is sending over 20 mill
Page 143 and 144:
Ref: 9820.00 Sheet: 106 Industrial
Page 145:
Ref: 9820.00 Sheet: 108 Industrial
Page 148 and 149:
Reliable, Clean, Dry Air. Ingersoll
Page 150 and 151:
Ingersoll Rand Industrial Technolog
Page 152 and 153:
OPERATING AND SAFETY PRECAUTIONS
Page 154:
Product Overview e-LINE ® motors a
Page 157 and 158:
Microcontroller Repeat Accuracy +/-
Page 159 and 160:
3 Phase Voltage Monitor PLMU Univer
Page 163 and 164:
Weekly Timer H5L 1/4 DIN Size Timer
Page 165 and 166:
H5L H5L Dimensions Unit: mm (inch)
Page 167 and 168:
H5L H5L Operation ■ NOMENCLATURE
Page 169 and 170:
H5L H5L ■ DELETING ON/OFF PROGRAM
Page 171 and 172:
H5L H5L First Circuit Operation Set
Page 173 and 174:
H5L H5L Second Circuit Day-of-the-W
Page 175 and 176:
H5L H5L NOTE: DIMENSIONS ARE SHOWN
Page 177 and 178:
2 © 2001-2002 Schneider Electric A
Page 179 and 180:
Manual Motor Starters, Controllers,
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
90° 90° 90° 90° Manual Motor St
Page 211 and 212:
Page 213 and 214:
Page 215 and 216:
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
Page 227 and 228:
Page 229 and 230:
= Manual Motor Starters, Controller
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
Square D Company 8001 Highway 64 Ea
Page 237 and 238:
78 © 2001-2002 Schneider Electric
Page 239 and 240:
TeSys D-Line Contactors, and Starte
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
TeSys D-Line Contactors and Starter
Page 279 and 280:
MEASURED LIMITING VOLTAGE PERFORMAN
Page 281 and 282:
w w w.apc.com 1 Connect Battery Bac
Page 283 and 284:
MicroLogix 1100 Programmable Contro
Page 285 and 286:
Table of Contents Preface Who Shoul
Page 287 and 288:
Table of Contents iii Connecting th
Page 289 and 290:
Table of Contents v Disposing . . .
Page 291 and 292:
Preface Read this preface to famili
Page 293 and 294:
Chapter 1 Hardware Overview Hardwar
Page 295 and 296:
Hardware Overview 1-3 1762 Expansio
Page 297 and 298:
Hardware Overview 1-5 Programming P
Page 299 and 300:
Chapter 2 Installing Your Controlle
Page 301 and 302:
Installing Your Controller 2-3 ATTE
Page 303 and 304:
Installing Your Controller 2-5 Safe
Page 305 and 306:
Installing Your Controller 2-7 depe
Page 307 and 308:
Installing Your Controller 2-9 Mast
Page 309 and 310:
Installing Your Controller 2-11 Sch
Page 311 and 312:
Installing Your Controller 2-13 Ins
Page 313 and 314:
Installing Your Controller 2-15 Con
Page 315 and 316:
Installing Your Controller 2-17 Mou
Page 317 and 318:
Installing Your Controller 2-19 4.
Page 319 and 320:
Installing Your Controller 2-21 Use
Page 321 and 322:
Installing Your Controller 2-23 WAR
Page 323 and 324:
Chapter 3 Wiring Your Controller Th
Page 325 and 326:
Wiring Your Controller 3-3 Screw-ca
Page 327 and 328:
Wiring Your Controller 3-5 Recommen
Page 329 and 330:
Wiring Your Controller 3-7 Wiring D
Page 331 and 332:
Wiring Your Controller 3-9 Table 3.
Page 333 and 334:
Wiring Your Controller 3-11 Figure
Page 335 and 336:
Wiring Your Controller 3-13 • The
Page 337 and 338:
Wiring Your Controller 3-15 Expansi
Page 339 and 340:
Page 341 and 342:
Page 343 and 344:
Wiring Your Controller 3-21 1762-IF
Page 345 and 346:
Page 347 and 348:
Wiring Your Controller 3-25 1762-OF
Page 349 and 350:
Chapter 4 Communication Connections
Page 351 and 352:
Communication Connections 4-3 show
Page 353 and 354:
Communication Connections 4-5 If th
Page 355 and 356:
Communication Connections 4-7 Conne
Page 357 and 358:
Communication Connections 4-9 Using
Page 359 and 360:
Communication Connections 4-11 Conn
Page 361 and 362:
TERM A B COM SHLD CHS GND TX TX TX
Page 363 and 364:
Page 365 and 366:
Communication Connections 4-17 exce
Page 367 and 368:
Communication Connections 4-19 End-
Page 369 and 370:
Communication Connections 4-21 1761
Page 371 and 372:
Communication Connections 4-23 1761
Page 373 and 374:
Communication Connections 4-25 Powe
Page 375 and 376:
Communication Connections 4-27 Conn
Page 377 and 378:
Communication Connections 4-29 When
Page 379 and 380:
Chapter 5 Using the LCD This chapte
Page 381 and 382:
Using the LCD 5-3 Startup Screen Th
Page 383 and 384:
Using the LCD 5-5 Table 5.2 Main Me
Page 385 and 386:
Using the LCD 5-7 Selecting Between
Page 387 and 388:
Using the LCD 5-9 I/O Status The Mi
Page 389 and 390:
Using the LCD 5-11 2. Then, press t
Page 391 and 392:
Using the LCD 5-13 Monitoring a Bit
Page 393 and 394:
Using the LCD 5-15 5. We will chang
Page 395 and 396:
Using the LCD 5-17 12. Hold down th
Page 397 and 398:
Using the LCD 5-19 IMPORTANT Althou
Page 399 and 400:
Using the LCD 5-21 3. If Integer is
Page 401 and 402:
Using the LCD 5-23 You can identify
Page 403 and 404:
Using the LCD 5-25 Using the Mode S
Page 405 and 406:
Using the LCD 5-27 • How to forci
Page 407 and 408:
Using the LCD 5-29 screen, refer to
Page 409 and 410:
Using the LCD 5-31 Configuring Adva
Page 411 and 412:
Using the LCD 5-33 3. Select KeyIn
Page 413 and 414:
Using the LCD 5-35 3. If ENET Cfg i
Page 415 and 416:
Page 417 and 418:
Using the LCD 5-39 Viewing System I
Page 419 and 420:
Page 421 and 422:
Chapter 6 Using Real-Time Clock and
Page 423 and 424:
Using Real-Time Clock and Memory Mo
Page 425 and 426:
Using Real-Time Clock and Memory Mo
Page 427 and 428:
Chapter 7 Online Editing The online
Page 429 and 430:
Online Editing 7-3 • Accept Rung
Page 431 and 432:
Online Editing 7-5 Directions and C
Page 433 and 434:
Online Editing 7-7 ATTENTION PTO an
Page 435 and 436:
Online Editing 7-9 Edit Functions i
Page 437 and 438:
Appendix A Specifications Controlle
Page 439 and 440:
Specifications A-3 Table A.2 Digita
Page 441 and 442:
Specifications A-5 Table A.5 BBB FE
Page 443 and 444:
Specifications A-7 Table A.11 Worki
Page 445 and 446:
Specifications A-9 Table A.14 Input
Page 447 and 448:
Specifications A-11 Table A.15 Outp
Page 449 and 450:
Specifications A-13 Table A.18 Modu
Page 451 and 452:
Specifications A-15 Table A.20 Gene
Page 453 and 454:
Specifications A-17 Table A.22 Inpu
Page 455 and 456:
Specifications A-19 (1) (2) Table A
Page 457 and 458:
Specifications A-21 Table A.26 Outp
Page 459 and 460:
Appendix B Replacement Parts This c
Page 461 and 462:
Replacement Parts B-3 Battery Handl
Page 463 and 464:
Replacement Parts B-5 Disposing ATT
Page 465 and 466:
Appendix C Troubleshooting Your Sys
Page 467 and 468:
Troubleshooting Your System C-3 I/O
Page 469 and 470:
Troubleshooting Your System C-5 Con
Page 471 and 472:
Troubleshooting Your System C-7 Cri
Page 473 and 474:
Troubleshooting Your System C-9 Err
Page 475 and 476:
Appendix D Using Control Flash to U
Page 477 and 478:
Using Control Flash to Upgrade Your
Page 479 and 480:
Appendix E Connecting to Networks v
Page 481 and 482:
Connecting to Networks via RS-232/R
Page 483 and 484:
Page 485 and 486:
Page 487 and 488:
Page 489 and 490:
Page 491 and 492:
Page 493 and 494:
Page 495 and 496:
Appendix F Connecting to Networks v
Page 497 and 498:
Connecting to Networks via Ethernet
Page 499 and 500:
Page 501 and 502:
Page 503 and 504:
Page 505 and 506:
Page 507 and 508:
Appendix G System Loading and Heat
Page 509 and 510:
System Loading and Heat Dissipation
Page 511 and 512:
System Loading and Heat Dissipation
Page 513 and 514:
Glossary The following terms are us
Page 515 and 516:
Glossary 3 embedded I/O Embedded I/
Page 517 and 518:
Glossary 5 LED (Light Emitting Diod
Page 519 and 520:
Glossary 7 switch should be less th
Page 521 and 522:
Glossary 9 run mode This is an exec
Page 523 and 524:
Index Numerics 1762-24AWA wiring di
Page 525 and 526:
Index 3 1762-OX6I wiring diagram 3-
Page 527 and 528:
Index 5 status G-9 surge suppressor
Page 530 and 531:
Rockwell Automation Support Rockwel
Page 533 and 534:
Installation Instructions MicroLogi
Page 535 and 536:
Page 537 and 538:
Page 539 and 540:
Page 541 and 542:
Page 543 and 544:
Page 545 and 546:
Page 547 and 548:
Page 549 and 550:
Page 551 and 552:
Page 553 and 554:
Page 555 and 556:
Page 557 and 558:
Page 559 and 560:
Page 561 and 562:
Page 563 and 564:
Page 565 and 566:
Page 567 and 568:
180.0 mm (7.087 in.) 165.8 mm (6.52
Page 569 and 570:
VAC L1 1766-L32AWA 1766-L32AWA COM
Page 571 and 572:
VAC L1 1766-L32BWA 1766-L32BWA COM
Page 573 and 574:
1766-L32BXBA +24 VDC VDC NUET VAC D
Page 575 and 576:
Rockwell Automation Support Rockwel
Page 577 and 578:
GRUNDFOS INSTRUCTIONS SQ, SQE Insta
Page 579 and 580:
SQ, SQE Installation and operating
Page 581 and 582:
2.4 Motor cooling requirements To e
Page 583 and 584:
5. Cable sizing Single-phase 60 Hz
Page 585 and 586:
10. Installing the pump 10.1 Instal
Page 587 and 588:
13. Assembly of pump and motor To a
Page 589 and 590:
14.1 Instruments not allowed Note:
Page 591 and 592:
Pump models Pump type Accessories P
Page 594 and 595:
Being responsible is our foundation
Page 596 and 597:
MODEL ORDERING CHART Accuracy Range
Page 598 and 599:
4. Electrical Connections Wire Leng
Page 600 and 601:
Installation 1.0 Location Select a
Page 602 and 603:
4-Wire Connection (1-5 or 2-10 VDC
Page 604 and 605:
INSTALLATION 1. Select a location t
Page 606 and 607:
2.1 Panel Installation 1. The panel
Page 608 and 609:
3.3 Open Collector Output The Open
Page 610 and 611:
Calibrate Menu Display (Factory set
Page 612 and 613:
Troubleshooting Display Condition P
Page 614 and 615:
: ERDCO Engineering Corporation ,v
Page 616 and 617:
Switches & signal output g Armor-Fl
Page 618 and 619:
Meter rangeability v Liquid applica
Page 620 and 621:
A Full Range of Product Features Un
Page 622 and 623:
NPE Close Coupled Pump Major Compon
Page 624 and 625:
Performance Curves - 60 Hz, 3500 RP
Page 626 and 627:
Performance Curves - 60 Hz, 3500 RP
Page 628 and 629:
1/2 HP Performance Curves - 60 Hz,
Page 630 and 631:
NPE Close Coupled - Dimensions, Wei
Page 632 and 633:
NPE Frame Mounted - Dimensions, Wei
Page 634 and 635:
ITT Commercial Water Typical Applic
Page 636 and 637:
USFilter Material Safety Data Sheet
Page 638 and 639:
ACTIVATED CARBON, AquaCarb Series,
Page 640 and 641:
ACTIVATED CARBON, AquaCarb Series,
Page 642 and 643:
Section 7 WARRANTY
Page 644 and 645:
the instrument or equipment is abus
Page 646 and 647:
(c) Should Seller initiate any lega
Page 648 and 649:
AMERICAN FAN COMPANY TERMS OF SALE
Page 650 and 651:
16. Provisions requiring notice: An
Page 652 and 653:
Monthly Maintenance Schedule/Checkl
Page 654 and 655:
Oil/Water Separator-Monthly Mainten
Page 656 and 657:
Quarterly Maintenance Schedule/Chec
Page 658 and 659:
Standard Operating Procedure - 3b G
Page 660 and 661:
14. If a well is purged to dryness
Page 662:
collecting the rinsate in the appro
show all

operation, maintenance and monitoring plan ... - Ithaca-SHIP.org!

Create successful ePaper yourself

Delete template?

Save as template?