Team Massachusetts Solar Decathlon 2011 Project Manual

More documents

Recommendations

Info

August 11, 2011 Revisions The Project Manual has been updated from the previous issue. Revisions include: • Interconnection Application Form - Changed • One-Line Electrical Schematic - Changed • Calculations of Service / Feeder Net Computed Load and Neutral Load (NCE 220) - Changed • Plan View of Lot Showing House, Decks, Ramps, Tour Path and Service Point - Changed • Elevation View Showing Terminal Box with Service Point, meter and Service Equipment - Changed • 01 54 00 – Construction Aids – Changed • 01 74 19 – Construction Waste Management and Disposal – Added • 05 14 13 – Architecturally Exposed Structural Aluminum - Changed • 05 50 00 – Metal Fabrications - Changed • 06 05 23 – Wood, Plastic and Composite Fasteners - Changed • 06 10 00 – Rough Carpentry - Changed • 06 82 00 – Glass-Fiber Reinforced Plastic - Added • 07 13 13 – Bituminous Sheet Waterproofing - Removed • 07 91 00 - Prefromed Joint Seals - changed • 09 91 23 – Interior Paint - Changed • 11 31 00 – Residential Appliances - Changed • 12 21 13.23 – Horizontal Louver Blinds - Removed • 21 13 13 – Wet-Pipe Sprinkler Systems - Changed • 22 07 19 – Plumbing Piping Insulation - Removed • 22 11 16 – Domestic Water Piping - Changed • 22 12 19 – Facility Potable Water Storage Tanks - Changed • 22 13 53 – Facility Septic Tanks - Added • 22 33 30.16 – Residential, Storage Electric Domestic Water Heaters - Changed • 22 33 30.26 – Residential, Collector-to-Tank, Heat-Exchanger-Coil, Solar-Electric Domestic Water Heaters - Changed • 23 21 13 – Hydronic Pumps - Removed • 23 31 13.16 – Round and Flat-Oval Spiral Ducts - Changed • 23 33 13 – Dampers - Changed • 23 37 13 – Diffusers, Registers and Grilles - Changed • 23 72 00 – Air-to-Air Energy Recovery Equipment - Changed • 23 81 26 – Split-System Air Conditioners - Changed • 23 84 16 – Dehumidifiers - Changed • 26 05 19 – Low-Voltage Electrical Power Conductors and Cables - Changed • 26 05 26 – Grounding and Bonding for Electrical Systems - Changed • 26 05 33 – Raceway and Boxes for Electrical Systems - Changed • 26 24 16 – Panelboards - Changed • 26 27 00 – Low-Voltage Distribution Equipment - Changed • 26 27 13 – Electricity Metering - Changed • 26 31 00 – Photovoltaic Collectors - Changed • 26 51 00 – Interior Lighting – Changed • 26 56 00 – Exterior Lighting – Changed • 27 05 13 – Communications Services - Removed • 27 21 00 – Data Communications Network Equipment - Changed • 27 21 33 – Data Communications Wireless Access Points - Changed • 27 22 26 – Data Communications Laptops - Changed 2011 US DOE Solar Decathlon Team Massachusetts Published 08/11/11 8
• 27 24 13 – Printers - Removed • 27 26 16 – Database Development - Removed • 27 26 19 – Application Development - Removed • 28 31 00 – Fire Detection and Alarm - Removed • 28 31 46 – Smoke Detection Sensors - Added • 28 31 49 – Carbon-Monoxide Detection Sensors - Added Rules Compliance Checklist RULE DESCRIPTION LOCATION DESCRIPTION Drawing # Project Manual Page # Drawing(s) showing the assembly and disassembly sequences and the movement of heavy machinery on the Rule 4-2 Construction Equipment competition site O-101,102 Rule 4-2 Construction Equipment Specifications for heavy machinery O-101,102 01 54 00 - 1 Rule 4-3 Ground Penetration Drawing(s) showing the locations and depths of all ground penetrations on the competition site S-101 Rule 4-4 Impact on the Turf Drawing(s) showing the location, contact area, and soil-bearing pressure of every component resting directly on the turf S-101 Rule 4-5 Generators Specifications for generators O-101,102 01 54 00 - 1 Rule 4-6 Spill Containment Drawing(s) showing the locations of all equipment, containers, and pipes that will contain liquids at any point during the event P- 101,102,103,104 22 05 00 - 1 22 11 16 - 1 22 12 19 - 1 22 33 30.16 - 1 22 33 30.26 - 3 23 21 13 - 2 Rule 4-6 Rule 4-7 Rule 4-7 Rule 5-2 Spill Containment Lot Conditions Lot Conditions Solar Envelope Dimensions Specifications for all equipment, containers, and pipes that will contain fluids at any point during the event Calculations showing that the structural design remains compliant even if 18 in. (45.7 cm) of vertical elevation change exists Drawing(s) showing shimming methods and materials to be used if 18 in. (45.7 cm) of vertical elevation change exists on the lot S-101 Drawing(s) showing the location of all house and site components relative to the solar envelope P- 101,102,103,104 G-201,202 G-201,202 01 54 00 -1 2011 US DOE Solar Decathlon Team Massachusetts Published 08/11/11 9
Page 1 and 2: Project Manual U.S. DEPARTMENT OF E
Page 3 and 4: 2.1. PHPP as Design Tool ..........
Page 5 and 6: 22 33 30.26 Residential, Collector-
Page 7: May 5, 2011 Revisions The Project M
Page 11 and 12: Rule 8-5 Village Grid Specification
Page 13 and 14: Load Summary The structural design
Page 15 and 16: 2011 US DOE Solar Decathlon Team Ma
Page 59 and 60:
2011 US DOE Solar Decathlon Team Ma
Page 61 and 62:
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
Detailed Water Budget Function Even
Page 81 and 82:
Summary of Reconfigurable Features
Page 83 and 84:
One-Line Electrical Schematic O PV
Page 85 and 86:
NEUTRAL LOAD CALCULATIONS Value Uni
Page 87 and 88:
Elevation view showing the terminal
Page 89 and 90:
8.1. Philosophy ...................
Page 91 and 92:
Figure 2.1: Screen Shot of PHPP Ver
Page 93 and 94:
2.3. PHPP Results for Boston Great
Page 95 and 96:
4.1. Sizing the System The first st
Page 97 and 98:
4.2. The SunDrum Collector Finally,
Page 99 and 100:
5.4. Electrical Load Figure 5.1: Ef
Page 101 and 102:
Figure 6.1: Interactions between th
Page 103 and 104:
Doors - Includes schedule of door s
Page 105 and 106:
4 Scheduled Electrical Draw 3 [kW]
Page 107 and 108:
100 Indoor Relative Humidity 80 RH
Page 109 and 110:
5 Net Energy Consumed 0 -5 -10 kWh
Page 111 and 112:
The dashboard makes understanding e
Page 113 and 114:
Division 09 - Finishes 09 29 00 Gyp
Page 115 and 116:
Divisions 31 - Earthwork 31 05 00 S
Page 117 and 118:
1.04 PROJECT MEETINGS A. Arrange fo
Page 119 and 120:
E. Install materials in proper rela
Page 121 and 122:
2. Compliance with All Codes Regard
Page 123 and 124:
B. Geotextile fabric must be wrappe
Page 125 and 126:
2. 16’ long sections and 7’ sec
Page 127 and 128:
C. Apply bituminous paint to concea
Page 129 and 130:
A. Manufacturer: Simpson Strong-Tie
Page 131 and 132:
SECTION 06 10 00 ROUGH CARPENTRY PA
Page 133 and 134:
C. Provide preservative-treated mat
Page 135 and 136:
2.02 EXTERIOR SHEATHING A. Exterior
Page 137 and 138:
SECTION 06 20 00 Finish Carpentry P
Page 139 and 140:
SECTION 06 46 00 WOOD TRIM PART 1 -
Page 141 and 142:
SECTION 06 82 00 GLASS-FIBER REINFO
Page 143 and 144:
B. Roof, Floor and Walls: 3,000 squ
Page 145 and 146:
C. Ridge Cap PART 3 - EXECUTION END
Page 147 and 148:
SECTION 07 71 23 MANUFACTURED GUTTE
Page 149 and 150:
DIVISION 8 - OPENINGS SECTION 08 14
Page 151 and 152:
SECTION 08 52 00 WOOD WINDOWS PART
Page 153 and 154:
SECTION 08 61 00 ROOF WINDOWS PART
Page 155 and 156:
A. CertainTeed Gypsum, Inc.; 4300 W
Page 157 and 158:
A. Color to match tile color 2.03 T
Page 159 and 160:
3.01 Installation A. Comply with fl
Page 161 and 162:
C. Clean and prepare surfaces in an
Page 163 and 164:
DIVISION 10 - SPECIALTIES SECTION 1
Page 165 and 166:
2.03 SHOWER CURTAIN A. Water Resist
Page 167 and 168:
2.03 PLYWOOD A. Finish Grade B. Bir
Page 169 and 170:
SECTION 10 71 13.13 EXTERIOR SHUTTE
Page 171 and 172:
3. Size: 18.5 cubic feet 4. Specifi
Page 173 and 174:
DIVISION 12 - FURNISHING SECTION 12
Page 175 and 176:
SECTION 12 36 00 COUNTERTOPS PART 1
Page 177 and 178:
C. Multi-use Chairs: These chairs a
Page 179 and 180:
SECTION 12 58 36 NIGHTSTANDS PART 1
Page 181 and 182:
2. 3/4 inch, Quantity: 10 foot 3. 1
Page 183 and 184:
DIVISION 22 - PLUMBING SECTION 22 0
Page 185 and 186:
3.03 INSPECTING A. Inspect all pipe
Page 187 and 188:
SECTION 22 12 19 FACILITY POTABLE W
Page 189 and 190:
SECTION 22 13 16 SANITARY WASTE PIP
Page 191 and 192:
SECTION 22 13 53 FACILITY SEPTIC TA
Page 193 and 194:
C. Equipment: 1. State Water Heater
Page 195 and 196:
SunDrum panels. This fluid is pumpe
Page 197 and 198:
DIVISION 23 - HEATING, VENTILATING
Page 199 and 200:
a. 45 degree adjustable elbow; 8”
Page 201 and 202:
PART 2 - PRODUCTS 2.01 MANUFACTURER
Page 203 and 204:
d. Matching diameter galvanized mou
Page 205 and 206:
SECTION 23 72 00 AIR TO AIR ENERGY
Page 207 and 208:
SECTION 23 81 26 SPLIT SYSTEM AIR C
Page 209 and 210:
B. Be sure to install the unit leve
Page 211 and 212:
7. Refrigerant: R-410A 8. Filter: s
Page 213 and 214:
C. Belden 2.02 MATERIALS A. Southwi
Page 215 and 216:
B. Clean conductor surfaces before
Page 217 and 218:
I. To view these products’ techni
Page 219 and 220:
PART 2 - PRODUCTS 2.01 MANUFACTURER
Page 221 and 222:
SECTION 26 27 00 LOW-VOLTAGE DISTRI
Page 223 and 224:
SECTION 26 27 13 ELECTRICITY METERI
Page 225 and 226:
SECTION 26 28 16 ENCLOSED SWITCHES
Page 227 and 228:
SECTION 26 31 00 PHOTOVOLTAIC COLLE
Page 229 and 230:
3.02 SAFETY D. Note: SunPower modul
Page 231 and 232:
F. Philips 1. 3140-10-S-LSTA4-8420-
Page 233 and 234:
DIVISION 27 - COMMUNICATIONS SECTIO
Page 235 and 236:
SECTION 27 22 26 DATA COMMUNICATION
Page 237 and 238:
DIVISION 28 - ELECTRONIC SAFETY AND
Page 239 and 240:
SECTION 28 31 49 CARBON MONOXIDE DE
Page 241 and 242:
DIVISION 31 - EARTHWORK SECTION 31
Page 243 and 244:
PART 3 - EXECUTION 3.01 INSTALL A.
Page 245 and 246:
1. Product Data a. DC Specification
Page 247 and 248:
U.S. D.O.E. Solar Decathlon 2011 Pu
Page 249 and 250:
TO GO BACK, CLICK HERE U.S. D.O.E.
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Cooktop U.S. D.O.E. Solar Decathlon
Page 257 and 258:
Microwave/Convection Oven Combo Con
Page 259 and 260:
Range Hood TO GO BACK, CLICK HERE U
Page 261 and 262:
Page 263 and 264:
Television U.S. D.O.E. Solar Decath
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
TO GO BACK, CLICK HERE Fresh Water
Page 271 and 272:
Grey Water Storage Tank Husky 1000
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
SunDrum Solar Thermal Modules U.S.
Page 279 and 280:
Page 281 and 282:
Page 283 and 284:
Solar Thermal Expansion Tank U.S. D
Page 285 and 286:
Solar Hot Water 80 Gallon Tank U.S.
Page 287 and 288:
Page 289 and 290:
Page 291 and 292:
Page 293 and 294:
Page 295 and 296:
Page 297 and 298:
Page 299 and 300:
Page 301 and 302:
Page 303 and 304:
WEEB Bonding Jumper TO GO BACK, CLI
Page 305 and 306:
Page 307 and 308:
Page 309 and 310:
Page 311 and 312:
Page 313 and 314:
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
Leviton Switches TO GO BACK, CLICK
Page 321 and 322:
Landis & Gyr Meter Socket U.S. D.O.
Page 323 and 324:
Page 325 and 326:
Page 327 and 328:
Page 329 and 330:
Page 331 and 332:
Combiner Boxes U.S. D.O.E. Solar De
Page 333 and 334:
Page 335 and 336:
Division 27 - Communications U.S. D
Page 337 and 338:
Page 339 and 340:
Page 341 and 342:
Solrenview U.S. D.O.E. Solar Decath
Page 343 and 344:
Page 345 and 346:
Laptop HP Pavilion dv7t series Proc
Page 347 and 348:
Smoke Detector U.S. D.O.E. Solar De
Page 349 and 350:
Carbon Monoxide Detector U.S. D.O.E
Page 351 and 352:
Division 48 - Electrical Power Gene
show all

Team Massachusetts Solar Decathlon 2011 Project Manual

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?