Issue of Consent to Establish / NOC

AGENDA FOR THE 104 th 

MEETING OF 

PUDUCHERRY POLLUTION 

CONTROL COMMITTEE 

19-03 

03-2010

AGENDA ITEM – I 

ISSUE OF NOC / 

CONSENT TO ESTABLISH

Case No. 1: Issue of Consent to Establish / NOC to M/s. 

Raak Nursing and Paramedical College, Muthupillai 

Palayam Road, G.N.Palayam, Villianur, Puducherry for 

establishing nursing & Paramedical college. 

1. Project : Nursing and Paramedical College 

2. Water : 

a. Source : Public supply 

b. Requirement (LPD) : 2,500 

3. Waste water generation (LPD): 2000 

4. Investment : Rs.55.00 lakhs 

5. Power : 75 HP 

6. Category : Orange

7. Site Suitability : It is proposed in a vacant land. The site 

description is given below: 

North 

: Sulthanpet – G.N. Palayam Road 

South 

: Vacant land 

East & West : Houses (200 feet away) 

8. Environmental Aspects: 

i. There will be wastewater generation of about 2000 LPD from 

sanitary usage. The waste water shall be treated in STP and 

used for gardening. 

ii. There is no significant air emission in this proposal. 

iii. Solid waste in the form of garbage and trash will be genrated. 

This shall be disposed with municipal solid wastes. 

9. In view of the above we may consider issuing Consent to Establish 

with the following conditions: 

i. The water consumption shall be 2,500 and it shall be drawn from bore 

well authorized by State Ground Water Authority.

ii. The wastewater discharge shall not exceed 2000 LPD and it shall be 

treated in STP and used for gardening. 

iii. The Power requirement of the project shall be 75 HP. Prior approval 

shall be obtained from this Department before installation of any DG 

Set. 

iv. The solid waste generated shall be properly segregated and 

collected in separate ‘bins’, green bins for biodegradable waste, 

white bins for recyclable waste and black bins for non-recyclable 

waste as per Municipal Solid Waste (Management & Handling) 

Rules, 2000 and handed over to Municipality. 

v. The provisions of Noise Pollution (Regulation & Control) Rules, 2000 

shall be strictly complied and the Ambient Air Quality standards with 

respect to Noise should not exceed 50 dB (A) during daytime and 40 

dB (A) during nighttime.

Case No. 2: Issue of Consent to Establish / NOC to M/s. Sri 

Saptha Pulverisers, Puducherry for manufacturing 

Grinding of White Clay Stone – 5TPD 

1. Location : R. S.No.158/5, Ramanathapuram 

R.V., Villianur Commune, Puducherry. 

2. Raw material : White Clay Stone – 5 TPD, 

Coconut Shell 

3. Product & Capacity : Grinding of White Clay Stone – 5TPD 

4. Water Req. (LPD) : Source: Public 

Domestic & Sanitary : 1000 

5. Power : 124 HP 

6. Size : Small 

7. Category : Orange 

8. Investment : Rs.9 Lakhs

9. Process : Raw material -> Impact Pulverizing -> White 

Clay Powder -> Packing -> Dispatch 

10. Site Suitability : The proposed site is surrounded by vacant 

and dry agricultural lad. No residential set up is present nearer to 

the site. 

11. Remarks : The process will produce dust and noise while 

pulverizing the white clay. The following measures have to be 

provided to mitigate the dust and noise. 

i. Entire operation shall be carried out in closed premises 

ii. Packing of pulverized white clay shall be automatic. 

iii. Green belt consisting of taller and dense foliage plant like 

Casuarinas, Polyethina and Acacias sp. shall be 

developed around the premises of the unit. 

iv. Bag filter shall be provided as air pollution control device. 

v. Glass windows and rubber bush should be provided to the 

machineries to control the noise.

Case No. 3: Issue of Consent to Establish / NOC to M/s. Sri 

Iswarya Industries, Villianur Commune, Puducherry for 

manufacturing Reprocessed Plastic Granules-407.75 MTA 

1. Location : R.S.No.2, Plot No.147, 148 & 149, 2nd Cross, 

Vazhudavur Road, Kirumampet, 

Villianur Commune, Puducherry. 

2. Raw material : Raw Plastic waste – 930 Kgs./day 

3. Product & Capacity : Reprocessed Plastic Granules-407.75 MTA 


Cooling / boiler : 100 


Gardening : 20 

Total : 250 

5. Power : 104 HP 

6. Size : Small


8. Investment : Rs.10.00 lakhs 

9. Process : Plastic waste -> Sorting -> Grinding 

-> Mixing -> Melting -> Dieing -> Cooling -> Cutting -> Packing -> 

Despatch. 

10. Site Suitability : It is proposed in Kurumampet 

identified industrial area. 

11. Remarks : The process will not produce any 

discharge as no washing of old plastic materials is proposed. It will 

produce dust emission while grinding the materials. Inbuilt dust 

collector need to be provided.

Case No. 4: Issue of Consent to Establish / NOC to M/s. A - 

One Power Laundry, Puducherry for Power Laundry 

(Washing & Ironing Clothes) 

1. Location : R. S.No.287/5, Old.No.90, New No.29, 

Villianur Main Road, Odiampet, 

Villianur Commune, Puducherry. 

2. Raw material : Clothes 

3. Product & Capacity : Power Laundry (Washing & Ironing Clothes) 

4. Water Req. (LPD) : Source: Borewell 

Wash : 5000 


6. Size : Micro 


8. Investment : Rs.9 Lakhs 

9. Process : It involves washing clothes. 

10. Site Suitability : It is proposed in kombakkam road. 

11. Remarks : The process will generate 5000 LPD of wash 

wastes. It is proposed to discharge it into the adjacent canal. No 

sufficient space is available to provide treatment plant.

Case No. 5: Issue of Consent to Establish / NOC to M/s. Tri 

Sun Formulations for manufacturing Paracetamol – 300 

Kgs./day and Amoxicillin – 50 kgs./day 

1. Location : No.159 160, JK Nagar, Kariyamanikkam, 

Nettapakkam Commune, Puducherry. 

2. Raw material : Amoxicillin, Dicloxycilline, Cloxycilline, 

Paracetamol, Aceclofenac, Vitamins, etc. 

3. Product & Capacity : Paracetamol – 300 Kgs./day 

Amoxicillin – 50 kgs./day 

4. Water Req. (LPD) : Source: Ground water 





8. Investment : Rs.3.35 lakhs. 

9. Process : Raw materials -> Drying -> Mixing - 

> Granulation -> Dried Granules -> Grinding -> Compressing -> 

Packing. 

10. Site Suitability : It is proposed in developing 

residential area. Currently no house is present. 

11. Remarks : The process will produce dust 

emission while handling the raw materials. Centralized dust collector 

with necessary hood and ducts arrangement need to be provided. 

The process will not produce any effluent. It may produce 

wash water. It need to be solar evaporated.

Case No. 6: Issue of consent to establish / NOC to 

M/s. Innovative & Innovators (P) Ltd, Sooramangalam, 

Nettapakkam Commune, Puducherry for manufacturing 

Shaving foams, Room Fresheners, Pesticides sprays, 

Veterinary sprays, Chalk for Cockroaches as additional 

products. 

1. Products : Shaving foams, Room Fresheners, 

Pesticides sprays, Veterinary sprays, 

Chalk for Cockroaches 

2. Raw Materials : Soap liquid, perfume, kerosene, 

Chalk powder, pralathrin, etc., 

3. Process : 

For Aerosol products: 

L.P.G Cylinders loading -> Removal of Mercaptan through molecular 

sieves -> Moisture removal through steel column -> filling soap liquid for 

foam, room freshener perfume, pesticide liquid, deodorized kerosene in 

cans -> gas filling in aerosol containers -> leak checking -> final product

For Automobile cleaning products: 

Detergent liquid blending -> pumping -> filling -> packing in master 

cartons 

For chalk for cockroaches: 

Poured in plastic moulds -> sun dried -> plastic sleeved -> packed in 

carton boxes 

For liquid vaporizer: 

Blending of deodorized kerosene and pralathrin and perfume -> 

Filtration -> Filling in 35 and 45 ML plastic bottles -> thermo stick 

inserted in plug through hand crimp machine -> capped with plastic 

cap -> Finished Product 

Remarks: The process will not produce emission (or) discharge. It is 

located in residential area.

Case No. 7: M/s. Alam Alloys, R.S.No. 122/4 – A, Surakudi 

Village, Thirunallar Commune, Karaikal – Modification in Air 

Pollution Control Systems 

The proposal for modification in Air Pollution Control Systems was 

discussed in the 102nd Meeting of PPCC held on 20.01.2010. The 

project agency was directed to carry out air quality monitoring with and 

without scrubber and then approach this authority. The decision of the 

Meeting was intimated vide Letter No. PPCC/APCS- 

MOD/KKL/SCI/2010/133 dated 10.02.2010. Accordingly, the project 

agency have completed the said air quality monitoring with and without 

scrubber through M/s. Richardson & Cruddas Ltd., (A Govt. of India 

Undertaking) and submitted the result. The result reveals that the 

concentration of Suspended Particulate Matter was found to be less 

when assessed without scrubber compared to the presence of 

scrubber. The concentration of Sulphur-di-Oxide and Oxides of 

Nitrogen are more or less on par with or without scrubber.

Hence, it is requested by the project agency to operate the Air 

Pollution Control Systems with Heat Exchanger and three chambered 

bag filter arrangements (210 bags in each chamber totaling to 630 

bags) for effective performance of the systems without any choking 

problem.

Case No. 8: M/s. Hotel Mano Residency, No. 16, P.K. Salai, Karaikal 

Municipality, Karaikal – Issue of Consent to Establish / NOC 

1. Name of the proposal : M/s. Hotel Mano Residency 

2. Location : No. 16, P.K. Salai, Karaikal Municipality, 

Karaikal. 

3. Raw materials / day : Hotel Project (Foods and Beverages) 

4. Product & Capacity : Hotel with Lodging and Restaurant 

5. Covered under : Water Act 

(Air/Water/EP Act) 

6. Water 

a) Source : Public supply + Purchase + Borewell 

(Existing) 

b) Requirement in Lts. / day : 9000 

i) Industrial : 2000 (Process and Wash) 

ii) Sanitary : 7000

7. Status 

i) Size : Small 

ii) Category 

: Orange 

iii) Investment : Rs. 4,00,00,000/- 

8. Power : 120 H.P. 

9. Process : Hotel Project with Lodging and 

Restaurant facilities. 

10. Air emission : The unit uses LPG cylinders as fuel 

for cooking purpose. Since LPG is used as fuel for cooking purpose, 

air emission will be less. Exhaust fan with duct air vent for kitchen is 

installed. 125 KVA capacity D.G. Set with acoustic noise proof control 

system is installed as standby in case of power failure. 

11. Effluent generation : The wash water generation from 

kitchen and domestic waste water generation are drained thro’ 

municipal drainage.

12. Solid waste generation : Solid waste generation in the form 

of kitchen wastes is composted and other wastes are handed over to 

Municipality. 

13. Area availability : 1998 Sq. M. 

14. Remarks : It is an existing hotel. The unit has 

obtained licenses from Foods and Drugs Administration, Fire 

Station, Karaikal Planning Authority, Commercial Taxes Department, 

Karaikal Municipality, Electricity Department, State Ground Water 

Unit and Soil Conservation and is registered with the Registrar of 

firms. Incorporating necessary conditions we may consider issue of 

NOC.

Case No. 9: M/s. Karaikal Port Pvt. Ltd., Keezhavanjore, T.R. 

Pattinam Commune, Karaikal, Nagore Post – Issue of NOC 

for Desalination (R.O) Plant and Issue of NOC for 8 MW power 

supply for Phase – II. 

1. Name of the proposal : M/s. Karaikal Port Pvt. Ltd., 

2. Location : Keezhavanjore, T.R. Pattinam 

Commune, Karaikal. 

3. Product & Capacity : General Cargo and Coal for Phase - I 

4. Status : i) Size : Large 

ii) Category 

5. Power 

i) Available : 4 MW (Phase – I) 

ii) Required 

: 8 MW (Phase – II) 

: Red 

6. Desalination (R.O.) Plant : Capacity – 600 KLD 

(i) Use 

: For domestic purpose within the port 

(ii) Average Water Intake : 1500 KLD 

(iii) Average Water Discharge: 900 KLD

(iv) Point of Discharge : Sea and location to be finalized based on 

model studies being carried out by 

M/s. Indomer Coastal Hydraulics, Chennai. 

7. Remarks : M/s. Karaikal Port Pvt. Ltd., is an 

existing Port located at Keezhavanjore, T.R. Pattinam Commune, 

Karaikal. It is a large-scale, red category Port involved in handling of 

handling of General Cargo and Coal at Phase - I. The unit is running 

with valid Air and Water Consent Order (To Operate). The proposed 

Desalination plant though falls within the port boundary is under the 

purview of CRZ Notification, 1991 and hence clearance from PCZMA is 

required for Desalination Plant. In the first instance, the project 

proponent has requested NOC from PPCC for further clearances. The 

unit has obtained Environmental and CRZ clearance for expansion of 

Karaikal Port (Phase – II) from Ministry of Environment and Forests, 

Government of India wherein the power requirement is also indicated.

Case No.10: Issue of Consent to Establish / NOC to 

M/s. White Field Minerals Pondy, Korkadu for carrying seiving 

activity as additional activity in order to improve the quality 

of the pulverizing materials. 

It is pulverizing of China Clay, Dolamite, Calcite and soap stone and 

supplying to M/s. Hindustan Lever Ltd. Consent to Establish was 

issued on 20.6.2006 and Consent to Operate was issued on 

23.2.2009. 

Process of the unit is Minerals -> Drying -> Pulverising -> 

Packing. It is proposes to carry out ‘Seiving’ activity as additional 

activity in order to improve the quality of the pulverizing materials. 

Seiving activity will produce dust. Hence centralized 

‘Dedusting’ arrangement with necessary ducts system need to be 

provided.

Case No. 11: Issue of NOC to establish M/s. Fab Express, 

R.S.No.4/1, Vazhudavor Road, Kurumampet, Villianur 

Commune, Puducherry - Reg. 

1. Location : R. S.No.4/1, Vazhudavor Road, 

Kurumampet, Puducherry. 

2. Raw material : Clothes, Detergent Powder 

3. Product & Capacity : Power Laundry 

(Washing & Ironing Clothes) 

4. Water Req. (LPD) : Source: Private & Public 

Process : 3000 

Wash : 250 



Total : 4000 




8. Investment : Rs.2.25 Lakhs 

9. Process : It involves washing clothes. 

10. Site Suitability : It is proposed at Kurumbapet identified 

industrial area. No residential set up is present nearer to the site. 

11. Remarks : The process will generate wash water and propose to 

discharge in the public drain. It is estimated approximately 1800 LPD 

of wash water will be generated. Phosphate and Sulphate are the two 

ingredients generally present in washing plant. 5 mg/l and 2 mg/l are 

the maximum permissible standards for discharging the effluent. 

Hence the unit need to provide ETP systems consisting of collection 

tank and settling tank. 

This proposal was placed before the 103rd meeting of PPCC 

held on 19.2.2010. The Committee directed the project agency to 

submit details about the source of dirty linen, quantity and nature of 

washing materials going to be used and the method of treatment of 

waste water.

Accordingly, the project agency has provided the following details: 

Source of dirty linen 

Quantity 

Details of washing materials 

Mode of disposal of wash water 

: Hotels 

: 15,000 pieces 

: Detergent powder 

: Gardening after treatment

Case No.12 : Issue of Consent to Establish to M/s. Mother 

Supreme for establishing a Power Laundry unit 

Details of the proposed unit: 

i) Location : R.S. No. 176/5, ECR Road, Saram, 

Oulgaret Municipality, Puducherry. 

ii) Product & Capacity : 

Power Laundry – 105 kg/day 

iii) Raw Materials : Liquid Detergents 

iv) Water 

a. Source : Public Supply 

b. Requirement (LPD) 

Industrial Consumption 

Domestic Consumption 

c. Effluent Discharge ( LPD) 

Industrial 

Domestic 

: 750 LPD 

:300 LPD 

: 450 LPD 

: 250 LPD

v) Size : Micro Enterprise 

vi) Category : Orange 

vii) Investment : Rs. 10.5 Lakhs 

viii) Power : 10 HP 

ix) Process 

: Stained Fabric -> Washing with Detergents in 

Washing Machine -> Hydro Extractor -> Drier -> Ironing the Fabric -> 

Delivering the Fabric to the Customer 

x) Site Suitability : The unit is proposed in an existing building 

facing ECR Main Road on North and surrounded by residential–cumcommercial 

establishments on east and west and Shankar Vidyalaya 

School Ground on South. Covered U-Drain is available in the front of 

the building.

xi) Environmental Aspects : 

Waste Water: The unit generates about 450 LPD of wastewater from 

washing. The project proponent has proposed to discharge it into public 

sewer (Covered U Drain) present in front of the building. 

Air: There is no significant impact due to air emission in this proposal. 

Solid Waste: There is no significant impact due to solid waste 

generation in this proposal. 

Remarks: 

The earlier proposal of this Project Proponent to establish a Power 

Laundry unit at a developing residential area in Navarkulam was 

rejected in the 101st meeting of PPCC held on 16.12.2009 as the 

committee observed that disposal of the waste water from the unit 

would be a problem in the proposed site since proper drainage facilities 

are not available. Now the Project Proponent has submitted a fresh 

proposal in a new site where Covered U-Drain is available.

Case No. 13 : Issue of Consent to Establish / NOC to 

M/s. Amsam Industries for establishing a Perfume 

manufacturing unit: 


i) Location : Plot No. 27, II Cross Mariamman Nagar, 

Karaminaikuppam, Oulgaret Municipality, 

Puducherry 

ii) Product & Capacity : Eau De Cologne, After Shave Lotion 

(Not exceeding 1500 Litres of Spirit per Month) 

iii) Raw Materials 

: ENA Spirit – 1500 Ltrs / month, DM - Water, 

Perfumes & Colour 

iv) Water requirement : Source 

: Public 

Requirement : Industrial - 50 LPD ( for bottle washing) 

Domestic – 50 LPD 

v) Size : Micro

vi) Category 

vii) Power 

: Orange 

: Nil 

viii) Investment : Rs. 50,000/-. 

ix) Process 

: Mixing of raw materials manually in a vessel 

and filling in bottles. 

x) Site Suitability : The unit is proposed in the ground floor of a 

residential building with road on west and surrounded by residential 

establishments on other three sides. This is a developed residential 

area. 

xi) Environmental Aspects: The process will produce odour. Alcohol is 

used as raw material which has potential for fire hazard.

Case No.14 : Issue of Consent to Establish / NOC to 

M/s. Bhimarao Cleaning Products for establishing a 

cleaning Products and Agarbathi manufacturing unit: 


i. Location : No. 37, Water Tank Street, Bahour Pet, Bahour, 

Puducherry 

ii. Product : Phenoyl – 10 LPD 

Soap Oil – 5 LPD 

Agarbathies -3 Kg/day 

Cleaning Powder – 10 Kg/day 

Washing powder – 5 kg/day 

Liquid Blue – 5 LPD 

iii. Raw Material: Soft Soap, Oleic acid, Acid Slurry, washing soda, 

Sodium phosphate. Sodium carbonate, perfumes, 

coloring agents.

iv. Water 


Requirement (KLD) 

Sanitary : 25 LPD 

v. Waste water generation (KLD): 

Sanitary : 25 LPD 

vi. Power 

vii. Process 

: Nil 

: Manual mixing of various raw materials in 

containers. 

viii. Site Suitability : This site is surrounded by thatched huts on 

all sides. It is in rural area 

ix. Environmental Aspects: 

This is a tiny industry and the products are of very less quantity. 

Only vessel and hand wash water of about 25 LPD is envisaged. 

This could be discharged into an impervious solar evaporation 

pond.

Case No. 15 : Issue of Consent to Establish / NOC to Magna 

Mission Biotek (India) Pvt. Ltd. for establishing Polypeptide-K 

Ingredient manufacturing unit: 


i) Location : No. A-20, Rural Industrial Estate, 

Kattukuppam, Manapet, Bahour Commune, 

Puducherry 

ii) Product & Capacity : Polypeptide- 

K Ingredient – 2 kgs/day or 624 kgs/annum. 

iii) Raw Materials 

: Bitter Gourd Seed – 50 kgs/day, 

iv) Water 

a. Source : Borewell 


Industrial Consumption: 

Process: : 500 LPD 

Washing : 200 LPD 

Domestic Consumption: 200 LPD 

Garden : 100 LPD 

Total : 1000 LPD

c. Effluent Discharge (LPD) 

Industrial : 200 LPD 

Domestic : 160 LPD 

v) Size : Small 

vi) Category 

vii) Investment 

viii) Power 

: Orange 

: Rs. 65.79 Lakhs 

: 35 HP 

ix) Process : 

Bitter Gourd Seeds -> De-hulling -> washing -> drying -> particle size 

reduction -> de-oiling -> washing -> vacuum drying -> De-oiled Seed 

Powder -> Extraction -> Phase Separation -> Precipitation and 

Crystallization -> Purification / washing -> filtration -> drying -> 

sterilization -> Polypeptide-K Ingredient 

Polypeptide-K Ingredient is used in the manufacture of Herbal 

Medicines for Diabetics.

x) Site Suitability: 

The unit is proposed in a vacant industrial building in Rural Industrial 

Estate at Kattukuppam. It is surrounded by road on east and north 

and industrial buildings on south and west. 

xi) Environmental Aspects: 

Waste water: The unit generates about 200 LPD of waste water from 

washing of Bitter Gourd Seeds and about 50 LPD wash water from 

process vessel washing. This water is proposed to be used for 

gardening. 

Air: There is no significant impact due to air emission in this proposal. 

Solid Waste: There is no significant impact due to solid waste 

generation in this proposal.


M/s. Pondicherry Nitrous Oxide, for establishing Nitrous 

Oxide Gas manufacturing unit 


i) Location : A-19, Rural Industrial Estate, 

Kattukuppam, Puducherry 

ii) Product & Capacity : Nitrous Oxide 

Gas – 384 Cu.m./day or 115200 Cu.m/Year 

iii) Raw Materials : Ammonium Nitrate – 1500 kg/day, 

Caustic Solution 200 Ltrs, 

Dilute Sulphuric Acid Solution – 100 Ltrs. 

iv) Water 



Industrial Consumption : 

Process: : 500 LPD 

Cooling : 400 LPD 

Domestic Consumption : 300 LPD

c. Effluent Discharge ( LPD) 

Industrial 

: Nil 

Domestic 

: 250 LPD 

v) Size : Small 

vi) Category 

vii) Investment 

viii) Power 

: Orange 

: Rs. 50 Lakhs 

: 80 HP 

ix) Process : 

Nitrogen dioxide (N2O) is produced by heating Ammonium Nitrate 

(NH4NO3) to a temperature of 250 deg. C. -> Production of Nitrogen 

Oxide along with steam and traces of Ammonia, Nitric Acid and other 

Oxides of Nitrogen such as NO and NO2. Purification in series of 

caustic and acid scrubbing towers -> gas collection –> Compression - 

> Drier -> -> liquefied by chilling -> Cylinder filling.

x) Site Suitability: 

The unit is proposed in a vacant industrial building in Rural Industrial 

Estate at Kattukuppam. It is surrounded by road on east, industrial 

buildings on north and west and vacant land on south. 

xi) Environmental Aspects: 

Slightly acidic waste water will be generated in the process which is 

proposed to be recycled back to the process after treatment. There 

is no air emission or hazardous waste from the process. 

Ammonium Nitrate is the major raw material for this unit. Though 

Ammonium Nitrate is freely available in market and used as 

fertilizers, it is also being used in the preparation of explosives. 

Ammonium Nitrate can cause explosion in contact with heat, 

combustible materials, organic materials or metals. Hence the unit 

has to take proper precautions during storage and handling of 

Ammonium Nitrate. 

Nitrous Oxide Gas produced in the unit finds major use as anesthesia 

during surgery. The product has to be carefully handled since any 

accidental leakage may affect the health of the recipients.

Remarks: Though the unit is not having high pollution potential 

under normal operations, it involves use of hazardous raw materials 

which could cause explosion if not handled properly and the product 

itself could cause hazard during accidental leakages. The proposal 

requires clearance from Explosives Department for Filling and Storage 

of cylinders and Hydraulic Testing of Cylinders. Clearance of Food and 

Drug Authority is also required.

Case No. 17 : Issue of Consent to Establish / NOC to 

M/s Nandhu Clinic, Elaikara Street, Karaikal. 

1. Location : No.18/A, Elaikara Street, Karaikal 

2. Bed strength : 5 

3. Water Requirement (LPD) 

Source : Public Supply & Ground water. 

Hospital Consumption : 550 LPD 

4. Effluent Discharge (LPD) 

Hospital : 440 LPD 

5. Category : Red 

6. Investment : Rs.4.5 lakhs. 

7. Power : 19 KVA. 

8. DG set, if any : 15 KVA installed

9. Site Suitability : The proposed site is 

surrounded by road followed by residence on North, 

residential area on South and east and Godown on western 

side. This site falls under Mixed area. 

10. Environmental Aspects 

Water: The unit will generate about 440 LPD of hospital waste 

water and domestic waste water and it is proposed to 

discharge into the public drain after proper disinfection and 

treatment. 

Air: There will be no significant air pollution as there is no 

emission from the unit.

Solid Waste: There shall be generation of general solid waste 

and generation of Bio-Medical waste from the proposal. The 

general waste will be disposed through the concerned 

Municipality. The unit will dispose Bio-Medical waste as per 

Rules. The unit has applied in Form-I to obtain authorization 

under Bio-Medical Waste (Management & Handling) Rules, 

1998. 

We may Consider issue of Consent to Establish with the 

following conditions: 

i. The Bio-Medical waste shall be collected, stored and 

disposed as per the provisions of the Bio-Medical Waste 

(Management & Handling) Rules, 1998. 

ii. The waste water shall be discharged only after proper 

treatment and disinfection.

Case No. 18 : Issue of Authorisation to M/s Nandhu 

Clinic, Elaikara Street, Karaikal, under Bio-Medical Waste 

(Management & Handling) Rules, 1998 as amended from 

time to time 

The salient features of the hospital is detailed below: 

Category 

of waste 

C-1 

C-2 

C-3 

C-4 

C-5 

Quantity of waste 

(Kgs/ Month) 

0.3 

-- 

-- 

0.5 

0.25 

Method of treatment \ disposal 

Handed over to municipality 

-- 

-- 

-- 

--

C-6 

C-7 

C-8 

C-9 

C-10 

0.5 

0.5 

5 lits 

-- 

1000 lits 

-- 

-- 

Discharged into drain 

-- 

-do- 

The hospital is having one needle cutter. At present they are 

disposing the Bio-Medical waste through the Municipality. In future 

the hospital can utilize the Common facility established at 

Thanjavur by M/s Medi Care systems, Seggipatti, Thanjavur, for 

final disposal of the Bio-Medical Waste.

Case No.19 : Issue of NOC to M/s. Deepak Cables India (P) 

Ltd., Thiruvandarkoil for power enhancement from 1970 HP 

to 2856 HP 

This is a Medium-scale, Orange category unit. The Air Consent of 

the unit is valid till 30.09.2010. The unit has proposed for power 

enhancement from 1970 HP to 2856 HP. The salient features of the 

proposal are given below: 

Location 

Products 

& 

Capacity 

Existing Unit 

R.S. No. 129/1, 2,3 Whirlpool Road, 

Thiruvandarkovil, Pondicherry- 

Aluminium Conductors – 8000 

Kms/Annum,Aluminium Conductors 

(7 Strands)-7000 Kms/Annum, 

Aluminium Wire Rods – 15000 

MTA,G.S.S Earthwire – 6000 

Kms/Annum 

Expansion Proposal 

Same Location 

Aluminium Conductors – 

8000 Kms / 

Annum,Aluminium 

Conductors 

(7 Strands)-7000 Kms / 

Annum, Aluminium Wire 

Rods – 15000 MTA,G.S.S 

Earthwire – 6000 

Kms/Annum

Size 

Category 

& 

Medium Scale ; 

Orange Category 

Medium Scale ; 

Orange Category 

Power 

Requirement 

1970 HP 

2856 HP 

[Additional of 886 HP] 

Solid waste 

Aluminum scraps is reused in 

the process. 

Aluminum scraps is reused in 

the process. 

Process details: 

Aluminum Ingot + Scraps -> Rerolling –Wire -> Winding -> Inspection 

-> Finished product 

Remarks: 

The requirement for power enhancement is for installation of additional 

machineries for quality improvement and increasing of conductor 

size. 

There will be no enhancement in the sanctioned production capacity. 

Waste Water: There will be no effluent generation from the process. 

Air Pollution Control Systems Attached: Wet Scrubber and Dust 

Collector 

Solid Waste Generation: Aluminium Scrap generated from process is 

recycled back as raw material.


M/s. Indyva, Mannadipet Commune, Puducherry for 

manufacturing Spirulina (Aqua product) – 10,800 Kgs./Year 

1. Location : R.S.No.24/12, T.V.Malai Road, Sellipet, 

Mannadipet Commune, Puducherry. 

2. Raw material : Urea – 5 Kgs./day ; 

Potassium – 5 Kgs./day 

Sodium Chloride – 5 Kgs./day 

3. Product & Capacity : Spirulina (Aqua product) – 10,800 Kgs./Year 

4. Water Req. (LPD) : Supply: Borewell 

Process : 2000 

Wash : 100 



Total : 2200





9. Process : Raw materials -> Mixing with water to 

be filled in the tub height of 15 cm -> After 15 days, the grown spirulina 

collected -> Filtering -> Drying -> Grinding -> Packing. 

10. Site Suitability : The site is located in the Sellipet village. In 

front of the site is Sellipet road, to the left side of the unit is 

Sankarabarani river, all the other sides are vacant agricultural land. 

11. Remarks : The process will not produce any emission. 

This is a SCP (Single Cell Protein) obtained from the algae cultivation. 

The waste water after the harvest of algae shall be treated and 

disposed for gardening.


M/s. K.M.V. Cattle Feeds Mannadipet Commune, 

Puducherry for manufacturing Cattle Feed – 900 TPA 

1. Location :R.S.No 136/9, Pondy Villupuram Main 

Road, Madagadipet Palayam, 

Mannadipet Commune, Puducherry. 

2. Raw material : Rice Bran, Ulundam Pottu, Waste Biscuit, 

Thuvaram Pottu or broken rice, Oil cake, Cotton 

Seed, Maize, Biscuit dough, Waste maida or 

Tapioca flour, Salt 

3. Product & Capacity : Cattle Feed – 900 TPA 

4. Water Req. (LPD) : Supply: Private 


5. Power : 100 HP 

6. Size : Small



9. Process : Raw materials -> Pulverizing -> Flouring -> 

Mixing -> Packing. 

10. Site Suitability : On the northern side is NH 45 (Pondy – 

Villupuram Road) and vacant land on the Eastern and Southern 

side, commercial complex on the Western side 

11. Remarks : During the pulverizing and grinding activity 

there will be noise and dust generation which can be mitigated by 

providing dust collector and carrying out all the activities in the 

closed environment with exhaust facilities.


M/s. Sunglow Pharmaceuticalss, Villianur Commune, 

Pondicherry for manufacturing Tablets Coated & 

Uncoated – 36 Millions/annum, Capsules – 3 

millions/annum, Dry Powders – 1200 Kgs/Annum 

1. Location : R.S. No.2, Plot.No.29-38, Opposite to 

Ponlait, Kurumbapet, Villianur Commune 

Panchayat, Puducherry 

2. Raw material : Paracetamol – 20 kgs./day 

Diclofenac – 1 Kg/Day 

Amlodipine – 1 Kg/Day 

Metformine Hcl – 25 Kgs/Day 

Amoxicillin – 10 kgs./day 

3. Product & Capacity : Tablets Coated & Uncoated – 36 

Millions/annum 

Capsules – 3 millions/annum 

Dry Powders – 1200 Kgs/Annum 

4. Water Req. (LPD) : Source: Borewell & Private

Process 

: 50 LPD [Water to be used from 

Private [D.M Water Suppliers]] 

Wash : 50 

Boiler : 50 

Domestic and Sanitary: 50 

Total : 200 




8. Investment : Rs.54 lakhs 

9. Process : For Tablets :- Raw Material -> Sifting-> Dry 

Blending -> Compression/Slugging -> Milling/Sifting -> Lubrication -> 

Q.C Check -> Compression -> Q.C Check -> Coating -> Q.C Check -> 

Blister Packing/Strip Packing/Alu packing -> Q.C Release -> Final 

Packing -> Stores -> Distribution.

For Capsules[Hard Gelatin]- Sifting -> Blending & Mixing -> 

Lubrication -> Q.C Analysis -> Encapsulation -> Polishing & Sorting -> 

Analysis -> Packing -> Q.C release -> Distribution. 

10. Site Suitability : It is proposed in Kurumbapet identified 

industrial area. No residential set up is present nearer to the site. 

11. Remarks : The process will produce dust emission while 

handling the raw materials. Centralized dust collector need to be 

provided. As no liquid formulation is proposed, it will not produce 

effluent. However wash water from vessels and floor will be generated 

to the extent of 1 KLD. Mechanical Evaporator need to be provided.


M/s. Sri Lakshmi Industries, Nettapakkam Commune, 

Pondicherry for manufacturing Detergent Cake – 500 

Kg/Day, Washing Powder – 300 Kg/Day 

1. Location : R.S. No.117/1, 115/1, Eripakkam Road, 

Kalmandapam, Nettapakkam Commune, 

Puducherry. 

2. Raw material : Soda ash, Acid slurry, Sodium 

3. Product & Capacity : Detergent Cake – 500 Kg/Day 

Washing Powder – 300 Kg/Day 


Sanitary : 500 


6. Size : Small


8. Investment : Rs.3 Lakh 

9. Process : Raw Materials -> Blending -> Plodding -> 

Cutting -> Packing 

10. Site Suitability :The site is located at Eripakkam road. M/s. 

MRF is located on the northern side, road on the Western side, 

vacant land on the Eastern and Southern side. 

11. Remarks: The process will produce dust emission while 

handling the raw materials

Issue of Consent to Establish / NOC

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?