*TM 10-7310-281-13&P - JATONKAM35s HOME ON THE WEB

TM 10-7310-281-13&P
TABLE OF CONTENTS
Page No.
WP Sequence No.
Figure 20. Battery Pack Identification Plate ...................................... 0005-27
Operation Under Unusual Conditions ..................................................................................... WP 0006
Chapter 3 – Operator Troubleshooting Procedures
Malfunction Symptom Index ................................................................................................... WP 0007
Table 1. Malfunction Symptom Index ................................................. 0007-1
Troubleshooting Procedures MBU Controller Error Codes .................................................... WP 0008
Table 1. Controller Error Codes ........................................................... 0008-1
Troubleshooting Procedures Burner Will Not Start or Shuts Down During Operation ............ WP 0009
Troubleshooting Procedures Burner Will Not Refuel .............................................................. WP 0010
Troubleshooting Procedures Burner Runs Poorly but Does Not Shut Down ......................... WP 0011
Chapter 4 – Operator Maintenance Instructions
Preventive Maintenance Checks and Services (PMCS) Introduction ..................................... WP 0012
Preventive Maintenance Checks and Services (PMCS) ........................................................ WP 0013
Table 1. Preventive Maintenance Checks and Services for MBU ...... 0013-2
Figure 1. MBU “Before Operation” PMCS .......................................... 0013-2
Figure 2. Power Converter “Before Operation” PMCS ....................... 0013-3
Figure 3. Battery Pack “Before Operation” PMCS .............................. 0013-4
Figure 4. System Cables “Before Operation” PMCS .......................... 0013-5
Figure 5. Fuel Can Adapter and Fuel Hose
“Before Operation” PMCS .................................................... 0013-6
Figure 6. MBU and Battery Pack “During Operation” PMCS .............. 0013-7
Figure 7. MBU “After Operation” PMCS ............................................. 0013-8
Figure 8. Battery Pack “After Operation” PMCS ................................. 0013-9
Table 2. PMCS Mandatory Replacement Parts..……………………...0013-10
MBU Service ........................................................................................................................... WP 0014
Figure 1. Drain the Fuel Tank ............................................................. 0014-2
Cable Clips Inspect, Replace ................................................................................................. WP 0015
Figure 1. Inspect Chassis Mounted Cable Clips and Hose Clamps ... 0015-2
Figure 2. Replace Chassis Mounted Cable Clips and Hose Clamps .. 0015-3
Electrical Connector Assembly Inspect .................................................................................. WP 0016
Figure 1. Inspect the Electrical Connector Assembly ........................ 0016-1
Figure 2. Inspect the Electrical Connector Assembly ........................ 0016-2
Controller Assembly Inspect, Calibrate, Replace ................................................................... WP 0017
Figure 1. Inspect the Controller Assembly .......................................... 0017-3
iv