2000 Electrical Troubleshooting Manual - Wedophones.com ...

More documents

Recommendations

Info

Pin Assignments Pin Type Signal Description/Function Connection 9 Not used 10 A EKP Activate relay Fuel pump relay 11 A OELD Oil pressure signal Instrument cluster 12 Not used 13 Not used 14 Not used 15 Not used 16 Not used 17 A TD Crankshaft RPM speed signal (TD) Electronic immobilizer control module (EWS III)/Thermal oil level sensor (TOENS) control module 18 Not used 19 Not used 20 Not used 21 A A-OELN Oil level signal Thermal oil level sensor (TOENS) control module 22 E DFAHR Speed signal right rear ABS/ASC/DSC control module 23 E KUPP Clutch signal Clutch switch 24 E KL 54 ON Brake signal Brake light switch 25 Not used 26 E 15A26 Terminal 15 Fuse 26 27 E MFL Cruise control signal Cruise control interface 28 E S_BLTS Brake signal Brake light switch 29 A S_KOREL Activate relay Compressor control relay 30 A LDPV Activate valve Leakage diagnosis pump 31 Not used 32 E/A TXDII TXD diagnosis data link Data link connector 33 E EWSDME Drive-away protection signal (code) Electronic immobilizer control module (EWS III) 34 E LDPS Leakage signal Leakage diagnosis pump 35 M 31 Ground Cruise control interface 36 E/A CAN+ CAN bus high Instrument cluster, ABS/ASC/DSC control module E = Input, A = Output, M = Ground
Pin Assignments Pin Type Signal Description/Function Connection 37 E/A CAN– CAN bus low Instrument cluster, ABS/ASC/DSC control module 38 Not used 39 Not used 40 Not used X60005 Pin Type Signal Description/Function Connection 1 A P_ZSZ3 Ignition coil signal Cyl. 3 ignition coil 2 A P_ZSZ2 Ignition coil signal Cyl. 2 ignition coil 3 A P_ZSZ1 Ignition coil signal Cyl. 1 ignition coil 4 Not used 5 M 31L Ground Ground point 6 M A_ZSR Ground Ground point 7 A P_ZSZ6 Ignition coil signal Cyl. 6 ignition coil 8 A P_ZSZ5 Ignition coil signal Cyl. 5 ignition coil 9 A P_ZSZ4 Ignition coil signal Cyl. 4 ignition coil E = Input, A = Output, M = Ground
Page 2 and 3:
BMW NA ELECTRICAL TROUBLESHOOTING M
Page 4 and 5:
INDEX CAMSHAFT POSITION SENSOR 2 (O
Page 6 and 7:
INDEX HIGH RANGE SPEAKER, LEFT REAR
Page 8 and 9:
INDEX RIGHT MID-HIGH RANGE SPEAKER,
Page 10 and 11:
0110.0 INTRODUCTION Schematics The
Page 12 and 13:
0140.0 SYMBOLS BATTERY FUSE DETAIL
Page 14 and 15:
SYMBOLS 30 86 87 85 30 86 87 87 85
Page 16 and 17:
0670.0 POWER DISTRIBUTION CHART FRO
Page 18 and 19:
POWER DISTRIBUTION CHART RELAY PAN
Page 20 and 21:
1290.0 2460.2 3234.0 0670.1 FUSE CH
Page 22 and 23:
FUSE CHART FUSES 1 TO 29 6575.2 ANT
Page 24 and 25:
FUSE CHART FUSES 30 TO 205 6169.0 W
Page 26 and 27:
0670.2 POWER DISTRIBUTION Z3 VERSIO
Page 28 and 29:
POWER DISTRIBUTION Z3 VERSIONS F10
Page 30 and 31:
POWER DISTRIBUTION F106 50A Z3 VERS
Page 32 and 33:
POWER DISTRIBUTION M VERSIONS 0670
Page 34 and 35:
POWER DISTRIBUTION 3 0 3 2 1 2 1 15
Page 36 and 37:
0670.3 FUSE DETAILS FUSES 1, 2, 3,
Page 38 and 39:
FUSE DETAILS FUSES 9 AND 10 F9 20A
Page 40 and 41:
FUSE DETAILS FUSES 14, 15, 16, AND
Page 42 and 43:
FUSE DETAILS FUSE 23 F23 5A P90 FR
Page 44 and 45:
FUSE DETAILS FUSE 26 F26 10A P90 F
Page 46 and 47:
FUSE DETAILS FUSE 31 F31 5A P90 FR
Page 48 and 49:
FUSE DETAILS FUSES 36, 37, 38, AND
Page 50 and 51: .5 VI/ WS 3 X1143 .5 VI/ WS 3 X1313
Page 52 and 53: FUSE DETAILS FUSES 48, 49, AND 201
Page 54 and 55: FUSE DETAILS FUSES 203, 204, AND 20
Page 56 and 57: 1 .75 BR GROUND DISTRIBUTION GROUND
Page 58 and 59: GROUND DISTRIBUTION 5 2.5 BR GROUN
Page 60 and 61: GROUND DISTRIBUTION Z3 VERSIONS 28
Page 62 and 63: GROUND DISTRIBUTION GROUND X9633 M
Page 64 and 65: GROUND DISTRIBUTION Z3 VERSIONS GRO
Page 66 and 67: 2 .5 BR GROUND DISTRIBUTION GROUND
Page 68 and 69: GROUND DISTRIBUTION GROUND X13006 Z
Page 70 and 71: 1 BR TELEPHONE CONNECTOR 2 X400 .5
Page 72 and 73: 0670.5 DATA LINK BLOCK DIAGRAM BOA
Page 74 and 75: DATA LINK Z3 VERSIONS DATA LINK CO
Page 76 and 77: DATA LINK M VERSIONS TXD AND RXD D
Page 78 and 79: DATA LINK M VERSIONS DATA LINK CONN
Page 80 and 81: 1210.17 ENGINE CONTROL SYSTEM MS41.
Page 82 and 83: Pin Assignments Pin Type Descriptio
Page 84 and 85: Pin Assignments Pin Type Descriptio
Page 86 and 87: 1 RT/WS 3 .5 WS/ GE 53 1210.17-00 E
Page 88 and 89: GROUND DISTRIBUTION 0670.4 X6454 1
Page 90 and 91: ENGINE CONTROL SYSTEM MS41.1 (6-CYL
Page 96 and 97: Pin Assignments A = X60001 B = X600
Page 98 and 99: Pin Assignments Pin Type Signal Des
Page 108 and 109: 2 1 ENGINE CONTROL SYSTEM MS42.1 (6
Page 112 and 113: 6 ENGINE CONTROL SYSTEM MS42.1 (6-C
Page 114 and 115: CHARGING SYSTEM Z3 VERSIONS POWER
Page 116 and 117: 2.5 SW/GE 2.5 SW/GE X6510 50 X6810
Page 118 and 119: 2.5 SW/GE 1 X6011 2.5 SW X6510 50
Page 120 and 121: 2460.2 ELECTRONIC TRANSMISSION CONT
Page 122 and 123: Pin Assignments Pin Type Descripti
Page 124 and 125: ELECTRONIC TRANSMISSION CONTROL (EG
Page 130 and 131: Pin Assignments X74 Pin Type Descr
Page 132 and 133: .35 BR/SW 6 31 7 34 SUPPLEMENTAL RE
Page 134 and 135: SUPPLEMENTAL RESTRAINT SYSTEM (AIR
Page 136 and 137: 3450.1 SLIP CONTROL (ABS/ASC) 10/99
Page 138 and 139: Pin Assignments X1175 Pin Type Des
Page 140 and 141: Pin Assignments Pin Type Descripti
Page 142 and 143: SLIP CONTROL (ABS/ASC) M VERSIONS P
Page 144 and 145: SLIP CONTROL (ABS/ASC) M VERSIONS P
Page 146 and 147: SLIP CONTROL (ABS/ASC) M VERSIONS A
Page 148 and 149: SLIP CONTROL (ABS/ASC) Z3 VERSIONS
Page 150 and 151:
3452.1 DYNAMIC STABILITY CONTROL (D
Page 152 and 153:
Pin Assignments Pin Type Signal Des
Page 154 and 155:
DYNAMIC STABILITY CONTROL (DSC III)
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
5116.0 POWER MIRRORS OUTSIDE MIRROR
Page 162 and 163:
POWER MIRRORS ELECTROCHROME REAR VI
Page 164 and 165:
ZKE CENTRAL LOCKING (ZV) INPUT DETA
Page 166 and 167:
.5 WS/SW .5 WS/GN 14 .35 WS/SW .35
Page 168 and 169:
.35 WS/GN X1236 .35 WS/SW .35 WS/GN
Page 170 and 171:
.35 SW/WS 4 ZKE POWER WINDOWS (FH)
Page 172 and 173:
5200.0 POWER SEATS DRIVER’S SEAT
Page 174 and 175:
2 BR POWER SEATS SPORT SEATS DRIVER
Page 176 and 177:
5203.0 HEATED SEATS 8 X9454 TEST F4
Page 178 and 179:
5410.5 POWER TILT SUNROOF 5 GROUND
Page 180 and 181:
58g LIGHT SWITCH DETAILS 6300.0 .5
Page 182 and 183:
Pin Assignments F = X10182 G = X132
Page 184 and 185:
Pin Assignments Pin Type Descriptio
Page 186 and 187:
CENTRAL BODY ELECTRONICS (ZKE IV) 6
Page 188 and 189:
6133.0 HORN P90 F8 FRONT POWER 15A
Page 190 and 191:
10 .5 BL/RT/GE 1 N12w ANTI-THEFT CO
Page 192 and 193:
10 .5 BL/RT/GE 1 N12w A104 A6000 AN
Page 194 and 195:
WIPER/WASHER MODULE (WWM) HIGH 28 X
Page 196 and 197:
6167.1 HEADLIGHT WASHER (SRA) 6 14
Page 198 and 199:
6211.0 INSTRUMENT CLUSTER 10/99 621
Page 200 and 201:
Pin Assignments X17 Pin Type Descri
Page 202 and 203:
INSTRUMENT CLUSTER INDICATORS A35y
Page 204 and 205:
11 R INSTRUMENT CLUSTER INDICATORS
Page 206 and 207:
TEMPERATURE GAUGE INSTRUMENT CLUSTE
Page 208 and 209:
INSTRUMENT CLUSTER CONSOLE INSTRUME
Page 210 and 211:
INSTRUMENT CLUSTER Z3 VERSIONS IND
Page 212 and 213:
6213.1 ANALOG CLOCK Z3 ROADSTER 2
Page 214 and 215:
6300.0 LIGHT SWITCH DETAILS P90 FR
Page 216 and 217:
LIGHT SWITCH DETAILS .5 GR/RT .5 GR
Page 218 and 219:
6312.0 HEADLIGHTS/FOG LIGHTS 9 5 F2
Page 220 and 221:
HEADLIGHTS/FOG LIGHTS 9 5 F23 5A 6
Page 222 and 223:
6313.0 TURN/HAZARD LIGHTS 4 1 BL/GN
Page 224 and 225:
TURN/HAZARD LIGHTS .5 BL/GN 2 X389
Page 226 and 227:
6314.0 PARK/TAIL/UNDERHOOD LIGHTS 2
Page 228 and 229:
PARK/TAIL/UNDERHOOD LIGHTS 6 8 2 .7
Page 230 and 231:
6320.0 LICENSE PLATE/LUGGAGE COMPAR
Page 232 and 233:
LICENSE PLATE/LUGGAGE COMPARTMENT L
Page 234 and 235:
6322.0 BACK UP LIGHTS F26 10A 12 X
Page 236 and 237:
BRAKE LIGHTS M VERSIONS X1215 .5 B
Page 238 and 239:
6332.0 INTERIOR ACCESSORIES F37 10A
Page 240 and 241:
CANADA LATE PRODUCTION .5 GN/RT .5
Page 242 and 243:
6424.0 REAR WINDOW DEFOGGER M COUPE
Page 244 and 245:
6450.6 INTEGRATED HEATING- AND CLIM
Page 246 and 247:
Pin Assignments (Z3 Versions) X1834
Page 248 and 249:
INTEGRATED HEATING- AND CLIMATE CON
Page 250 and 251:
Page 252 and 253:
Page 254 and 255:
Page 256 and 257:
2 6510.1 RADIO/HIFI FUSE DETAILS 06
Page 258 and 259:
.5 BL MRH+ 12 RADIO/HIFI 13 .5 BR 1
Page 260 and 261:
2 RADIO/HIFI FUSE DETAILS 0670.3 1
Page 262 and 263:
RADIO/HIFI ROADSTER WITH HIFI MRH+
Page 264 and 265:
RADIO/HIFI MRH+ MRH- MLH+ MLH- 13 2
Page 266 and 267:
RADIO/HIFI 7 .23 VI 8 6 .23 GN 1 1
Page 268 and 269:
6571.0 CRUISE CONTROL (TEMPOMAT) 32
Page 270 and 271:
CRUISE CONTROL (TEMPOMAT) 5 3 12 .3
Page 272 and 273:
6575.2 ANTI-THEFT SYSTEM (ALPINE) 3
Page 274 and 275:
6581.3 BOARD COMPUTER (BC - LOW) 1
Page 276 and 277:
COMPONENT LOCATION CHART COMP. DESC
Page 278 and 279:
Page 280 and 281:
Page 282 and 283:
Page 284 and 285:
Page 286 and 287:
Page 288 and 289:
Page 290 and 291:
Page 292 and 293:
Page 294 and 295:
Page 296 and 297:
Page 298 and 299:
Page 300 and 301:
Page 302 and 303:
Page 304 and 305:
Page 306 and 307:
Page 308 and 309:
Page 310 and 311:
Page 312 and 313:
7100.0 COMPONENT LOCATION VIEWS EL
Page 314 and 315:
COMPONENT LOCATION VIEWS M6510 S
Page 316 and 317:
COMPONENT LOCATION VIEWS X165 G
Page 318 and 319:
COMPONENT LOCATION VIEWS X13032
Page 320 and 321:
COMPONENT LOCATION VIEWS K25 RIG
Page 322 and 323:
COMPONENT LOCATION VIEWS K920 DR
Page 324 and 325:
COMPONENT LOCATION VIEWS X114 X1
Page 326 and 327:
COMPONENT LOCATION VIEWS S8511
Page 328 and 329:
COMPONENT LOCATION VIEWS G14 LE
Page 330 and 331:
Page 332 and 333:
COMPONENT LOCATION VIEWS A2w I
Page 334 and 335:
COMPONENT LOCATION VIEWS A12 SU
Page 336 and 337:
COMPONENT LOCATION VIEWS X279 X74
Page 338 and 339:
Page 340 and 341:
COMPONENT LOCATION VIEWS S408 I
Page 342 and 343:
COMPONENT LOCATION VIEWS B9508
Page 344 and 345:
COMPONENT LOCATION VIEWS B6231 O
Page 346 and 347:
COMPONENT LOCATION VIEWS Y6120
Page 348 and 349:
COMPONENT LOCATION VIEWS G12 DR
Page 350 and 351:
COMPONENT LOCATION VIEWS H34 HIGH
Page 352 and 353:
COMPONENT LOCATION VIEWS M17 L
Page 354 and 355:
COMPONENT LOCATION VIEWS P900 AU
Page 356 and 357:
COMPONENT LOCATION VIEWS B6236
Page 358 and 359:
COMPONENT LOCATION VIEWS B6240 K
Page 360 and 361:
COMPONENT LOCATION VIEWS P98 FU
Page 362 and 363:
COMPONENT LOCATION VIEWS A1900
Page 364 and 365:
SPLICE LOCATION VIEWS SPLICE HARNES
Page 366 and 367:
X184 X185 X203 X223 X245 X246 X276
Page 368 and 369:
SPLICE LOCATION VIEWS ENGINE HARNES
Page 370 and 371:
8500.0 CONNECTOR VIEWS FIG. 1 F
Page 372 and 373:
CONNECTOR VIEWS FIG. 1 FIG. 2 FI
Page 374 and 375:
CONNECTOR VIEWS FIG. 1 FIG.
Page 376 and 377:
CONNECTOR VIEWS FIG. 1 FIG. 2 FIG.
Page 378 and 379:
CONNECTOR VIEWS FIG. 1 FIG. 2
Page 380 and 381:
CONNECTOR VIEWS FIG. 1 FIG. 2 FIG.
Page 382:
CONNECTOR VIEWS FIG. 1
show all

2000 Electrical Troubleshooting Manual - Wedophones.com ...

Create successful ePaper yourself

Delete template?

Save as template?