TP39114202 2008 C30 S40 V50 C70 Wiring Diagram.pdf

matthewsvolvosite.com

TP39114202 2008 C30 S40 V50 C70 Wiring Diagram.pdf

VOLVO C30, S40, V50 & C70

WIRING DIAGRAM 2008

TP 39114202


Warning!

Vehicles with SRS (Airbag)/SIPS bag/

IC (Inflatable Curtain)

Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC

in order to avoid:

1. Personal injuries when performing repair work.

2. Damage or malfunction of the SRS/SIPS bag/IC system.

Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may

affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo

workshop.

In case of doubt, consult the SRS and SIPS bag/IC service manual.

Is the vehicle equipped with SRS/SIPS bag/IC

Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering

wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the

dashboard above the glove compartment. SRS vehicles from 1993 and onward also have

explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and

onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with

IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).

General recommendations

• Be especially careful when working on or around SRS, SIPS, and IC components.

• Make sure that no wires are pinched, frayed, or pierced.

• Never install accessories by the sensors.

• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done

in accordance with the methods in the SRS section of VIDA.

• Certain components of the aforementioned systems must be grounded while working. Read

the appropriate sections in VIDA.

• Install no accessories in the areas between the A and B posts, the B and C posts, and the C

and D posts.

Test terminal

Data link connector in the passenger compartment.

Changes introduced up to and including April 2007

Any changes made to the vehicles after this date are not included in the

manual. If necessary refer to service bulletins.

Volvo models are sold in versions adapted for different markets. These

adaptations depend on factors such as legal requirements, taxation, and

market demands.

This manual may therefore include illustrations and text that do not apply to

the vehicles in your country.

Order number: 39114202

Replaces previous publication 39114201 of Electronic Wiring Diagram

(EWD) TP 39118001. Can also be found on Electronic Wiring Diagram

(EWD) TP 39120002

We retain the right to make modifications.

© Volvo Car Corporation


Table of Contents 1:3

Vehicles with SRS (Airbag)/SIPS bag/

IC (Inflatable Curtain)..................................................... 2

Abbreviations................................................................. 7

How to use the wiring diagrams 1:2............................... 8

Electrical distribution 1:2.............................................. 10

Fuses

Engine compartment distribution box F1-F10............... 12

Engine compartment distribution box F11-F18............. 13

Engine compartment distribution box F20-F31............. 14

Engine compartment distribution box F32-F34............. 15

Engine compartment distribution box F35-FH1 ............ 16

Central Electronic Module (CEM) F43-F48................... 17

Central Electronic Module (CEM) F49-F61................... 18

Central Electronic Module (CEM) F62-F69................... 19

Central Electronic Module (CEM) F73-F85................... 20

Central Electronic Module (CEM) F86.......................... 21

Battery PF1-PF2........................................................... 22

Fuses in holder ............................................................. 23

Relays

Ignition switch and relays............................................. 24

Engine compartment distribution box R2-R14............. 25

Central Electronic Module (CEM) R15-R18................. 26

Central Electronic Module (CEM) R1 - R11B .............. 27

Other relays ................................................................. 28

Ground connections

Overview...................................................................... 29

31/3 - 31/10 cont.......................................................... 30

31/10 - 31/12 ............................................................... 31

31/52 - 31/66 ............................................................... 32

31/67 - 31/88 ............................................................... 33

31/89 - 31/115 ............................................................. 34

31/116 - Ground connections in chassis...................... 35

Control modules

Overview of locations................................................... 36

Overview of designations............................................. 37

Central Electronic Module (CEM) 1:2 ........................ 38

Data communication Low speed CAN 1:2 ................. 40

Data communication, High speed CAN ..................... 42

Data communication MOST ...................................... 43

Data communication, LIN 1:2 .................................... 44

Start Control Module (SCU) ....................................... 46

Accessory Electronic Module (AEM) ......................... 47

Group 23 Fuel system

Engine management system 4-cyl. 1.6l 1:2................. 48

Engine management system, 4-cyl. 1.8l & 2.0l 1:2...... 50

Engine management system, 5-cyl. 1:2....................... 52

Engine management system, 5-cyl. Turbo 1:2 ............ 54

Engine management system Diesel 4-cyl. 1.6l 1:2...... 56

Engine management system Diesel, 4-cyl. 2.0l 1:2..... 58

Engine management system Diesel, 5-cyl. 2.4l 1:3..... 60

Emission control 4-cyl 1.6l ........................................... 63

Emission control 4-cyl 1.8l & 2.0l................................. 64

Emission control 5-cyl.................................................. 65

Emission control, 5-cyl Turbo....................................... 66

Group 26 Cooling system

Cooling fan................................................................... 67

Group 27 Engine controls

Cruise control, 4-cyl ......................................................68

Cruise control, 5-cyl ......................................................69

Group 32 Alternator and voltage regulator

Power supply, 4-cyl...................................................... 70

Power supply, 5-cyl...................................................... 71

Group 33 Starting system

Starting system 4-cyl.................................................... 72

Starting system 5-cyl.................................................... 73

Group 35 Lighting

High and low beam ...................................................... 74

Active headlight, Bi-Xenon S40/V50............................ 75

Bi-Xenon C30/C70....................................................... 76

Running/Parking lights, Tail lights, S40/V50................ 77

Running/Parking lights, Tail lights (Bi-Xenon)

S40/V50 ...................................................................... 78

Running/Parking lights, Tail lights C30/C70 ................ 79

Running/Parking lights, Tail lights (Bi-Xenon)

C30/C70....................................................................... 80

Brake lights S40/V50 ................................................... 81

Brake lights C30/C70................................................... 82

Reversing lights S40/V50............................................. 83

Reversing lights C30/C70 ............................................ 84

Fog lights S40/V50 ...................................................... 85

Fog lights C30/C70 ...................................................... 86

Fog lights LHD Japan S40/V50.................................... 87

Fog lights LHD Japan C30/C70 ................................... 88

Follow-me-home lighting.............................................. 89

Interior lighting C30/S40/V50 1:2................................. 90

Interior lighting C70 1:2................................................ 92

Instrument and control illumination .............................. 94

Auxiliary lights.............................................................. 95

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 3


Table of Contents 2:3

Group 36 Additional electrical equipment

Direction indicators and hazard warning flashers

S40/V50 ...................................................................... 96

Direction indicators and hazard warning flashers

(Bi-Xenon) S40/V50 .................................................... 97

Direction indicators and hazard warning flashers

C30/C70 ...................................................................... 98

Direction indicators and hazard warning flashers

(Bi-Xenon) C30/C70 ................................................... 99

Windshield wiper/washer........................................... 100

Headlight washer....................................................... 101

Rear window wiper/washer C30/V50......................... 102

Rain sensor................................................................ 103

Keyless vehicle C30/S40/V50 1:2.............................. 104

Keyless vehicle C70 1:2 ............................................ 106

Rear parking assistance ............................................ 108

Front parking assistance............................................ 109

Immobilizer/Steering column lock module (SCL) ...... 110

Horn ...................................................................... 111

Anti-theft alarm C30................................................... 112

Anti-theft alarm S40/V50............................................ 113

Anti-theft alarm C70................................................... 114

Alcolock ..................................................................... 115

Accessory Electronic Module (AEM) ......................... 116

Group 37 Wiring and fuses

12V outlet C30/S40/V50 ............................................ 117

12V outlet C70........................................................... 118

Diagnostics system.................................................... 119

Tow hitch cable harness, 4-pin S40/V50 ................... 120

Tow hitch cable harness, 4-pin C30/C70................... 121

Tow hitch cable harness, 7-pin S40/V50 ................... 122

Tow hitch cable harness, 7-pin C30/C70................... 123

Tow hitch cable harness, 13-pin S40/V50/C70.......... 124

Tow hitch cable harness, 13-pin C30 ........................ 125

USB unit (AUU).......................................................... 126

Group 38 Instruments

Driver information module.......................................... 127

Seat belt reminder S40/V50....................................... 128

Seat belt reminder C30/C70 ...................................... 129

Group 39 Other

Audio C30/S40/V50 ................................................... 130

Audio C70.................................................................. 131

Audio High Performance/Premium Sound

C30/S40/V50 1:2 ....................................................... 132

Audio High Performance/Premium Sound C70 1:2 ... 134

Cellular phone 1:2...................................................... 136

Multimedia & Traffic information ................................ 138

Satellite radio ............................................................. 139

Handsfree Universal, Audio ....................................... 140

Handsfree Universal, Audio High Performance/

Premium Sound ......................................................... 141

Handsfree Max with Adapter...................................... 142

Handsfree Max .......................................................... 143

Subwoofer.................................................................. 144

Navigation system, portable....................................... 145

Group 43 Transmission

Automatic transmission AW55-51.............................. 146

Transmission M66...................................................... 147

Differential Electronic Module (DEM), S40/V50......... 148

Group 59 Brake system

Brake control system & STC...................................... 149

Brake control system & DSTC ................................... 150

Group 64 Steering

Electronic power steering........................................... 151

Group 83 Doors and openings

Central locking, front doors C30/S40/V50.................. 152

Central locking, rear doors S40/V50.......................... 153

Central locking system C70 ....................................... 154

Central locking, trunk lid/tailgateC30 ......................... 155

Central locking, trunk lid/tailgateS40/V50 .................. 156

Central locking, trunk lid/tailgate C70 ........................ 157

Central locking, storage compartment C70................ 158

Child safety lock S40/V50.......................................... 159

Central locking, fuel filler flap..................................... 160

Signal receiver, central locking C30/S40/V50............ 161

Signal receiver, central locking C70........................... 162

Power windows, front doors C30/S40/V50 ................ 163

Power windows, front doors C70 ............................... 164

Power windows, rear doors S40/V50......................... 165

Power sunroof C30/S40/V50 ..................................... 166

Power roof C70.......................................................... 167

Group 84 Exterior decorative elements, etc.

Power door mirrors C30/S40/V50.............................. 168

Power door mirrors C70............................................. 169

Heated door mirrors................................................... 170

Heated rear window................................................... 171

Blind Spot Information System................................... 172

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 4


Table of Contents 3:3

Group 85 Interior equipment

Power driver’s seat with memory function,

LHD S40/V50 ............................................................ 173

Power driver’s seat with memory function,

RHD S40/V50 .......................................................... 174

Power driver’s seat with memory function,

LHD C30/C70 ............................................................ 175

Power driver’s seat with memory function,

RHD C30/C70............................................................ 176

Power passenger seat with memory function,

LHD C30/C70 ............................................................ 177

Power passenger seat with memory function,

RHD C30/C70............................................................ 178

Power driver’s seat LHD S40/V50 ............................. 179

Power driver’s seat RHD S40/V50............................. 180

Power passenger seat LHD S40/V50........................ 181

Power passenger seat RHD S40/V50 ....................... 182

Heated seats.............................................................. 183

Group 87 Climate control system

Climate control system 4-cyl, Gasoline 1:2................ 184

Climate control system Diesel 1.6l & 2.0l 1:2 ............ 186

Climate control system, 5-cyl. 1:2.............................. 188

Climate control system PTC element ...................... 190

Parking heater, auxiliary heater................................. 191

Relay, electric engine heater ..................................... 192

Electric engine heater Flexifuel.................................. 193

Group 88 Internal equipment

Supplemental Restraint System (SRS)

C30/S40/V50 1:2 ....................................................... 194

Supplemental Restraint System (SRS) C70 1:2........ 196

Auto-dimming rearview mirror.................................... 198

Connectors .............................................. 199

Branching points......................................241

Cable harness routing in vehicle

Engine harness, gasoline 4-cyl 1.6 ........................... 252

Engine harness, gasoline 4-cyl 1.8 ........................... 252

Engine harness, gasoline 5-cyl................................... 253

Engine harness, Gasoline 5-cyl Turbo........................ 253

Engine harness, Diesel 1.6l ........................................254

Engine harness, Diesel 2.0l ........................................254

Engine harness, Diesel 2.4l ........................................255

Engine compartment harness, 4-cyl. ..........................256

Engine compartment harness, 5-cyl. ..........................256

Dashboard harness, LHD ...........................................257

Dashboard harness, RHD...........................................257

Floor harness, C30 LHD .............................................258

Floor harness, C30 RHD.............................................259

Floor harness, S40 LHD .............................................260

Floor harness, S40 RHD.............................................261

Floor harness, V50 LHD .............................................262

Floor harness, V50 RHD.............................................263

Floor harness, C70 LHD .............................................264

Floor harness, C70 RHD.............................................265

Roof harness, C30......................................................266

Roof harness, S40 ......................................................266

Roof harness, V50 ......................................................267

Roof harness, C70......................................................267

Tunnel harness, C30/S40/V50....................................268

Tunnel harness, C70 ..................................................268

Driver’s door harness, C30 .........................................269

Passenger door harness, C30 ....................................269

Driver's door harness, S40/V50 ..................................270

Passenger door harness, S40/V50.............................270

Driver’s door harness, C70 .........................................271

Passenger door harness addition, C70.......................271

Passenger door harness, C70 ....................................272

Passenger door harness addition, C70.......................272

Rear right door harness, S40/V50 ..............................273

Left rear door harness, S40/V50.................................273

Rear side panel harness, left C70...............................274

Harness, rear side panel, right C70 ............................274

trunk lid/tailgate harness, C30 ....................................275

Trunk lid/tailgate harness, S40 ...................................275

trunk lid/tailgate harness, V50.....................................276

Trunk lid/tailgate harness, C70 ...................................276

Component illustrations ..........................277

Index 1:2 ....................................................333

List of components 1:6 ............................335

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 5


TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 6


Explanations

Abbreviations

Groups

Group 23

Group 26

Group 27

Group 32

Group 33

Group 35

Group 36

Group 37

Group 38

Group 39

Group 43

Group 59

Group 64

Group 83

Group 84

Group 85

Group 87

Group 88

= Fuel system

= Cooling system

= Engine controls

= Alternator and voltage regulator

= Starting system

= Lighting

= Additional electrical equipment

= Wiring and fuses

= Instruments

= Other

= Transmission

= Brake system

= Steering

= Doors and openings

= Exterior decorative elements, etc.

= Interior equipment

= Climate control system

= Internal equipment

Ignition switch symbols

X

= Accessories (audio position)

S

= Powered upon insertion of key

15 = Contact remains connected during

start

15l = Contact is broken while starting

30 = Constant power from the battery

50 = Start

Countries/Markets

A

= Austria

AUS = Australia

B

= Belgium

CDN = Canada

CH = Switzerland

D = Germany

DK = Denmark

E

= Spain

EU/OS = Markets outside USA and Canada

FIN = Finland

GB = Great Britain

ISR = Israel

J

= Japan

KOR = Korea

N = Norway

NL = Netherlands

S

= Sweden

USA = United States of America

WEU = Western Europe

Other

AUTO

AWD

CAN

D

DPY

ECC

ETA

EXT. X

GDL

HISPEED

IR

LIN

LHD

LOSPEED

MAN

MEMORY

MMS

PETROL

RHD

SCR

SRS

T

W/O

2WD

4CYL, I4

5CYL, I5

Colors

BK, SB

BN

BU, BL

GN

GY, GR

LGN

OG, OR

PK, P

RD, R

VT, VO

WH, W

YE, Y

= Automatic transmission

= All wheel drive

= CAN communication

= Diesel

= Display

= Electronic climate control system

= Engine throttle body

= Extended X-feed

= Gas discharge lamp

= High speed data bus

= Infrared sensor

= LIN communication

= Left-hand drive

= Low speed data bus

= Manual transmission

= Memory driver’s seat

= Mass Movement Sensor

= Gasoline

= Right-hand drive

= Screened

= Airbag

= Turbocharged engine

= Without

= Two-wheel drive

= 4-cylinder engine

= 5-cylinder engine

= Black

= Brown

= Blue

= Green

= Gray

= Light Green

= Orange

= Pink

= Red

= Violet

= White

= Yellow

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 7


How to use the wiring diagrams 1:2

The descriptions below apply in general

to all wiring diagram manuals, although

not all sections are necessarily contained

in this manual.

A. Component designation

Every component has a component designation that

consists of two parts.

The first part is a type number that describes the

type of component in question, e.g. 3/xx.

The second part of the designation is a serial number,

e.g. x/2.

Together, this constitutes a component designation,

e.g. 3/2.

At the end of the manual is a list of components,

where, with the help of the component designation,

you can read off the name of the component,

e.g. 3/2 = light switch.

List of type numbers

The list shows which type of component that respective

type numbers refer to, e.g. 3/x = switch,

6/x = electric motor, etc.

1 Battery

2 Relay

3 Switch

4 Control module

5 Driver information module

6 Electric motor

7 Sensor

8 Actuator

9 Heating element

10 Light

11 Fuse

15 Electrical distribution rail/box

16 Audio

17 Service/diagnostics

18 Contact reel

19 Meter

20 Ignition component/shunt

27 Optics

31 Ground connection

63 Branching point

64 Connector

B. Branching points

The wiring diagrams contain numbered junction

points, e.g. 63/352.

This manual contains a section with a list of branching

points. This list shows all the components that

are connected to each branching point.

The location of the branching points is shown in the

"Cable harness routing in vehicle" section.

C. Connectors

Connectors provide a bridge between two cable harnesses

and are described in the "Connectors" section.

D. Electrical distribution

Operation of the fuses and relays is shown in the

"Electrical distribution" section.

E. Data communication

Today’s cars contain CAN and MOST networks that

transfer information. Connections to these networks

are not shown in their entirety in the respective wiring

diagram. Complete information on CAN and

MOST communication is found in the section

"Control modules".

F. Abbreviations

A number of different abbreviations are used in the

manual. These are explained in the section

"Abbreviations".

G. Component location

There is a section at the end of the manual in which

the appearance and location of components is

described in numerical order.

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 8


How to use the wiring diagrams 2:2

A E C F B D

4/28 AUTO

30+

TCM

3/156

64/90 64/111

3/155

15/31

GSM

33

2

A:7 WH-RD RD

WH-RD

A:2

CAN

LIN

GN-YE

A:6

A:8

64/90

GN-YE

10

D:14

D:15

F:16

F:14

E:14

4/56

CEM

CAN

LIN

1

2

F79

C:45

2/80

R2

LIN

E:22

E:21

RD-BU

RD-YE

1

2

F4

1

2

F18

Explanation of symbols

= System voltage

= Ground connection via wiring

= Ground connection in

component/chassis

= Screened wire

= Junction point

= Twisted cable

= Electrical connection

= Variant

MAN

S40

GN-BK

GN-BK

63/211

S40

GN-BK

= CAN communication

3/10 1

2

BK MAN

10/18

10/55

A:3 A:2 C:2 C:3 C:1

TURN

STOP

TAIL

FOG

BACK

UP

GN-BK

A:4 C:4

V50

V50

GN-BK V50

10/48

C:3

V50

C:1

BACK

UP

C:4 A:2 A:3

FOG

TAIL

STOP

C:2 A:4

10/17

TURN

= CAN high data signal

(CAN H)

= CAN low data signal (CAN L)

= LIN communication

BK

63/53

10/18

C:3 A:3 A:2 C:1

10/55

C:2

TAIL

STOP

TURN

FOG BACK

BK

BK

10/48

10/17

C:4 C:3 A:4 A:1 C:1

TAIL

STOP

BACK FOG

TURN

LIN

= LIN communication

= DIN cable, coaxial cable, etc.

UP

UP

GND GND2

GND2 GND

C:4 A:4

A:2 C:2

S40

S40

= Data communication

BK

BK

CAN

= CAN communication

31/52

31/11 31/12

= MOST communication

= MOST communication

= Connection with distribution

box

= Further connection to...

10/17-18

G

1

1

= Connector between cable

harnesses

= Connector connected in

component

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 9


TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 10

Electrical distribution 1:2

Overview

EF

C

1

F36

F34

F35

F33

F32

3

2

5

5

3

1 2

3

5

1 2

F10

F17

F14

BK-WH

GN-BU

2/32

R14

R13

2/35

R10

2/82

F12

F13

F9

RD-OG

RD

RD-OG

RD-GN

RD-OG

RD-OG

A

15/31

6/25

50

31

M

ACM

30

B:1

6/26

B+

31

G

B:1

A:1

RD

RD

12V

BK

31/3

1/1

BK

31/4

PF2

PF1

RD

RD-OG

40

14

39

64/90=15/31A

64/91

8/84:1

7/51:6

64/90=15/31A

11

4

BK-RD

GY

64/90=15/31A

41

12

21

BK-BU

GN-BU

GN-BU

GN-YE

GN-OG

GN-YE

GN-BU

GN-YE

BK-YE

WH-BU

BK-RD

B

I4

I5

Diesel

Diesel

BK-RD

GN-BU

2

1

1

2

35

63/13

GN-YE

GN-YE

GN-YE

5 cyl

I4 Diesel

D

64/90=

15/31A

31

64/90

9

GN-BU

GN-BU

GN-BU

GN-BU

GN-BU

64/113

6

GN-BU

6

B:11 B:29

B:17

B:33

ECM

4/46.1-3

CAN

LIN

5CYL

R12

2/14

F6 2

1

5

3

1

2

16


TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 11

Electrical distribution 2:2

Overview

RD-WH

RD-BK

RD-GN

RD-OG

RD-BU

RD-OG

RD-BU

2

1

3

5

3

1

5

2

3

1

5

2

2

5

3

1

CAN

CEM

4/56

LIN

BK-YE

G:11

C

G:18

E:29

E:9

E:30

3/1

30

15

X

5

50 S

B:7

A:42

A:15

A:30

A:17

B:5

B:2

B:1

B:3

GY-BK

RD-GN

YE

GN-WH

64/111

5

G:9

E:22

E:23

E:20

E:21

RD-YE

RD-BU

RD-WH

RD-OG

RD

RD

BK-BU

2/182

R9

2/34

R4

2/22

R11

R2

2/17

F20

F26

F3

F30

F31

F2

F16

F23

F4

F18

F27

F29

F11

F8

F7

F1

F5

F21

F28

F22

F15

A

RD-OG

E

BK-WH

F

GN-BU

15/31

WH-BK

R5

F24

BK-RD

13

64/90=15/31A

RD

WH-BK

BK BK BK

GN-WH

OG-BU

23

64/90=15/31A

64/90=15/31A

RD

RD-WH

RD-WH

S40/V50

C70

RD

13

17

64/90=15/31A

BK-YE

18

GN-YE

BK-RD

B

64/861

1

RD

D

GN-BU

16/10

63/121

63/231

63/120

16/11

GN-WH 10/5:1

10/6:1

GN-YE

6/104:1

3

5

1 2

2/142

64/113

7

31/114

I4

I5


Fuses

Engine compartment distribution box F1-F10

F19

F30 F24 F21 F20 F22

F8

F7

F1

F31

F25

F32

F33

F34

F35

F36

F29

F17

F18

F15 F13 F11 F9

F16 F14 F12 F10

F2

F3

F4

F5

F6

F28 F27 F26 F23

15/31 Engine compartment distribution box

No. Fuse function via A

F1 4/71 Cooling fan control module - 50

F2 6/71 Electrical Power Steering Module (EPS) - 80

F3 2/193 Relay, comfort functions

-

60

4/56 Central Electronic Module (CEM)

2/193

F45 Fuse in the Central Electronic Module (CEM)

2/193

F48-F49 Fuses in the Central Electronic Module (CEM)

2/193

F60-F61 Fuses in the Central Electronic Module (CEM)

2/193

F62-F63 Fuses in the Central Electronic Module (CEM)

-

F68-F69 Fuses in the Central Electronic Module (CEM)

2/193

F80 Fuse in the Central Electronic Module (CEM)

2/193

F84-F85 Fuses in the Central Electronic Module (CEM)

-

F4 2/63 Relay, high beam

4/56 Central Electronic Module (CEM)

F55 Fuses in the Central Electronic Module (CEM)

F58-F59 Fuses in the Central Electronic Module (CEM)

F74 Fuses in the Central Electronic Module (CEM)

F77 Fuses in the Central Electronic Module (CEM)

F5 9/41 PTC-element - 80

F6 4/109 Glow plug control module (GCU), 5-cyl. Diesel - 70

20/23-26 Glow plug, 4-cyl. Diesel 2/14 60

F7 4/16 Brake Control Module (BCM), pump - 30

F8 4/16 Brake Control Module (BCM), valves - 20

F9 2/32 Main relay, engine management system

F32-F36 Fuses in the engine compartment distribution box

F10 4/31 Fan control module - 40

continues

-

-

-

2/63

-

-

-

2/32

60

30

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 12


Fuses

Engine compartment distribution box F11-F18

F19

F30 F24 F21 F20 F22

F8

F7

F1

F31

F25

F32

F33

F34

F35

F36

F29

F17

F18

F15 F13 F11 F9

F16 F14 F12 F10

F2

F3

F4

F5

F6

F28 F27 F26 F23

15/31 Engine compartment distribution box

No. Fuse function via A

F11 2/182 Relay, headlight washer motor

4/59 Convertible Roof Module (CRM), C70

6/104 Pump, high pressure headlight washer

F12 2/82 Relay, heated rear window

9/2 Heated rear window

-

-

2/182

-

2/82, 16/141

F13 6/25 Starter motor 2/35 30

F14 4/110 Trailer Module (TRM) - 40

F15 4/59 Convertible Roof Module (CRM), C70 30

F16 2/159 Infotainment relay, S40/V50/C30

-

30

16/105 Audio module (AUD), S40/V50/C30

-

F22 Fuse, engine compartment distribution box, S40/V50/C30

-

F43 Fuse in the Central Electronic Module (CEM), S40/V50/C30

-

F64 Fuse in the Central Electronic Module (CEM), S40/V50/C30

-

F65-F67 Fuses in the Central Electronic Module (CEM), S40/V50/C30

2/159

F16 2/159 Infotainment relay, C70

16/105 Audio module (AUD), C70

F22 Fuse, engine compartment distribution box, C70

F43 Fuse in the Central Electronic Module (CEM), C70

F64 Fuse in the Central Electronic Module (CEM), C70

F65-F67 Fuses in the Central Electronic Module (CEM), C70

-

-

-

-

-

2/159

F17 6/1 Wiper Motor Module (WMM) - 30

F18 2/80 Relay, reversing light

2/89 Relay, interior lighting

4/56 Central Electronic Module (CEM)

F46-F47 Fuses in the Central Electronic Module (CEM)

F56-F57 Fuses in the Central Electronic Module (CEM)

F79 Fuse in the Central Electronic Module (CEM)

F81-F83 Fuses in the Central Electronic Module (CEM)

F86 Fuse in the Central Electronic Module (CEM)

continues

-

-

-

2/89

-

2/80

-

2/89

20

30

40

40

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 13


Fuses

Engine compartment distribution box F20-F31

F19

F30 F24 F21 F20 F22

F8

F7

F1

F31

F25

F32

F33

F34

F35

F36

F29

F17

F18

F15 F13 F11 F9

F16 F14 F12 F10

F2

F3

F4

F5

F6

F28 F27 F26 F23

15/31 Engine compartment distribution box

No. Fuse function via A

F20 2/17 Relay, horn

16/10 Horn 1

16/11 Horn 2

F21 4/7 Combustion Preheater Module (CPM) - 20

F22 16/79 Subwoofer Module (SUB) - 25

F23 4/28 Transmission Control Module (TCM)

4/46 Engine Control Module (ECM), 5-cyl.

F24 9/32 PTC-resistor, crankcase ventilation, 5-cyl. Diesel

9/38 Heated fuel filter, 5-cyl. Diesel

F26 2/35 Relay, starter motor

3/1 Start Control Module (SCU)

4/56 Central Electronic Module (CEM)

11K/1 Fuse in holder

11K/2 Fuse in holder

F44 Fuse in the Central Electronic Module (CEM)

F51-F54 Fuses in the Central Electronic Module (CEM)

F73 Fuse in the Central Electronic Module (CEM)

-

2/17

2/17

-

-

2/142

2/142

F27 8/3 Electromagnetic clutch, climate control system 2/22 10

F29 2/34 Relay, front fog lights

10/5 Fog light, front left

10/6 Fog light, front right

F30 4/46 Engine Control Module (ECM), 2.0l Diesel, 1.6l Gasoline - 3

F31 6/26 Alternator, 4-cyl. - 10

continues

3/1

-

3/1

3/1

-

3/1

3/1

3/1

-

2/34

2/34

15

10

20

15

15

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 14


Fuses

Engine compartment distribution box F32-F34

F19

F30 F24 F21 F20 F22

F8

F7

F1

F31

F25

F32

F33

F34

F35

F36

F29

F17

F18

F15 F13 F11 F9

F16 F14 F12 F10

F2

F3

F4

F5

F6

F28 F27 F26 F23

15/31 Engine compartment distribution box

No. Fuse function via A

F32 2/14 Relay, glow plug system

6/143 Regulator motor, Turbo

7/15 Front heated oxygen sensor, 4-cyl.

7/17 Mass air flow sensor (MAF), 5-cyl. Diesel

7/82 Rear heated oxygen sensor, 4-cyl.

8/6-8/10 Injection valves, 5-cyl.

8/121 Coolant valve, 2.0l Diesel

8/122 Bypass valve, intercooler, 1.6l Diesel

F33 4/46 Engine control module (ECM), 5-cyl. Diesel

6/114 Vacuum pump, 5-cyl.

7/15 Front heated oxygen sensor, 5-cyl.

7/82 Rear heated oxygen sensor, 5-cyl. Turbo

7/186 Heated oxygen sensor, rear, 5-cyl. without Turbo

7/187 Heated oxygen sensor, center 5-cyl. without Turbo

8/84 Switch, vacuum pump

9/32 PTC-resistor, crankcase ventilation, 2.0l. Diesel

9/38 Heated fuel filter, 4-cyl. Diesel

F34 4/109 Glow plug control module (GCU), 5-cyl. Diesel

8/6-8/9 Injection valves, 1.6l.

8/77 Fuel volume control valve, 2.0l Diesel

8/111 Fuel flow control valve, 1.6l Diesel

8/113 Bypass valve, EGR cooling

8/119 Pressure monitor, climate control system, 5-cyl.

8/120 EGR valve, 5-cyl. Diesel

8/133 Control valve fuel pressure

20/3 -20/7 Spark plug and ignition coil

20/17 Transformer, ignition coils, 1.6l

continues

-

-

-

-

-

-

-

-

-

8/84

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

10

20

10

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 15


Fuses

Engine compartment distribution box F35-FH1

F19

F30 F24 F21 F20 F22

F8

F7

F1

F31

F25

F32

F33

F34

F35

F36

F29

F17

F18

F15 F13 F11 F9

F16 F14 F12 F10

F2

F3

F4

F5

F6

F28 F27 F26 F23

15/31 Engine compartment distribution box

No. Fuse function via A

F35 2/22 Relay, climate control system

4/46 Engine control module (ECM), 5-cyl. Diesel

6/67 Fuel leakage control pump, 5-cyl.

6/99 EGR motor, 1.6l Diesel, 1.8l Gasoline

7/17 Mass air flow sensor (MAF), 5-cyl. Gasoline, 4-cyl. Diesel

7/192 Water detection sensor, 4-cyl. Diesel

8/6-8/9 Injection valves, 1.8l.

8/18 EVAP valve, Gasoline

8/19 Solenoid, variable valve timing, intake, 5-cyl. Gasoline

8/28 Turbocharger control valve, 2.5l Turbo

8/45 Vacuum valve, variable intake manifold, 1.8l

8/65 Pressure switch, power steering, 1.6l

8/77 Fuel volume control valve, 2.0l Diesel

8/81 Solenoid, variable valve timing, exhaust, 2.5l Turbo

8/82 Solenoid, variable turbo geometry, 4-cyl. Diesel

8/114 Valve, air/fuel mixing, 1.8l

8/132 Control valve, intake, 2.0l Diesel

9/32 PTC-resistor, crankcase ventilation 5-cyl. Gasoline

F36 4/46 Engine Control Module (ECM)

7/15 Front heated oxygen sensor, 5-cyl. Diesel

7/51 Accelerator pedal sensor

FH1 10/65 Auxiliary light, front right

10/69 Auxiliary light, front left

-

-

2/22

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

2/64

2/64

15

10

20

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 16


Fuses

Central Electronic Module (CEM) F43-F48

F43

F37

F42

F65

F64

F86

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F43 4/124 Accessory USB unit (AUU)

16/1 Integrated Audio Module (IAM)

16/46 RTI Display

16/60 Phone Module (PHM)

16/93 Control module, cellular phone handsfree

16/108 Multimedia Module (MMM)

17/42 USB-port

F44 4/46 Engine Control Module (ECM), 5-cyl.

4/9 Supplemental Restraint System Module (SRS)

F45 9/1 Front 12V outlet

9/25 Rear 12V outlet

F46 3/111 Switch unit, lights

5/1 Driver Information Module (DIM)

10/1 Lamp housing, front left

10/2 Lamp housing, front right

10/29 Glove compartment lighting

10/97 Courtesy lighting, left

10/102 Courtesy lighting, right

Alcolock

F47 10/22 Ceiling light

10/150 Rear reading light

10/114 Vanity mirror lighting, left, not C70

10/115 Vanity mirror lighting, right

F48 2/16 Relay, rear window wiper

2/92 Relay, windshield washer motor

2/93 Relay, rear window washer motor

6/2 Washer pump

6/32 Rear window wiper motor

continues

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

2/92

2/16

15

10

15

5

5

15

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 17


Fuses

Central Electronic Module (CEM) F49-F61

F43

F37

F42

F65

F64

F86

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F49 4/9 Supplemental Restraint System Module (SRS)

7/93 Occupant Weight Sensor (OWS), USA/CDN

F51 2/142 Fuel filter preheater relay

4/82 Differential Electronic Module (DEM)

9/41 PTC-element

F52 4/16 Brake Control Module (BCM)

4/28 Transmission Control Module (TCM)

F53 6/71 Electrical Power Steering Module (EPS) - 10

F54 4/46 Engine Control Module (ECM), 5-cyl.

- 10

4/86 Parking Assistance Module (PAM)

4/112 Gas Discharge Lamp Module (GDL), master, left

4/113 Gas Discharge Lamp Module (GDL), slave, right

4/114 Headlamp Control Module (HCM)

F55 4/93 Keyless Vehicle Module (KVM) - 20

F56 4/119 Remote Keyless Entry (RKE)/Remote Receiver Module (RRX)

- 10

16/35 Siren Control Module (SCM)

F57 3/9 Contact brake light

17/13 Data link connector

F58 2/64 Relay, auxiliary lights (accessory)

4/113 Gas Discharge Lamp Module (GDL), slave, right

10/2 Lamp housing, front right

F59 4/112 Gas Discharge Lamp Module (GDL), master, left

10/1 Lamp housing, front left

F60 9/12 Seat Heating Module (SHM), driver’s side - 15

F61 9/13 Seat Heating Module (SHM), passenger side - 15

continues

-

-

-

-

-

-

-

-

-

3/60

-

-

-

-

10

10

5

15

7.5

7.5

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 18


Fuses

Central Electronic Module (CEM) F62-F69

F43

F37

F42

F65

F64

F86

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F62 4/33 Sunroof control module - 20

F63 3/129 Rear Right Door Module (RDM) - 20

F64 10/245 Lock indicator, left door, C70

10/246 Lock indicator, right door, C70

16/145 Remote Digital Audio Receiver (RDAR)

F65 2/157 Relay, subwoofer control module

7/182 Remote control IR sensor, RTI

16/46 RTI Display

16/93 Control module, cellular phone handsfree

16/105 Audio Module (AUD)

16/150 AM/FM antenna and amplifier, right rear fender, C70

16/150 Window antenna amplifier, left, C30

F66 3/112 Climate Control Module (CCM)

16/1 Integrated Audio Module (IAM)

16/1.2 Infotainment Control Module (ICM)

F68 3/254 Steering Wheel Module (SWM) - 5

F69 3/112 Climate Control Module (CCM)

3/286 BLIS switch

3/286 PAS switch

6/48 Damper Motor Module (DMM), recirculation

6/95 Damper Motor Module (DMM), temperature, left side

6/96 Damper Motor Module (DMM), temperature, right side

6/102 Damper Motor Module (DMM), defroster

6/103 Damper Motor Module (DMM), floor/ventilation

7/149 Rain Sensor Module (RSM)

7/159 Air Quality Sensor (AQS)

continues

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

-

5

5

10

5

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 19


Fuses

Central Electronic Module (CEM) F73-F85

F43

F37

F42

F65

F64

F86

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F73 3/117 Switch unit, ceiling light

3/217 Belt buckle contact, rear left

3/218 Belt buckle contact, center rear

3/219 Belt buckle contact, rear right

4/33 Sunroof control module

8/48 Auto-dimming rearview mirror

10/22 Ceiling light

F74 4/83 Fuel pump control module, Gasoline

6/33 Fuel pump

F77 4/78 Accessory Electronic Module (AEM)

17/19 12V outlet, cargo compartment

17/39 13-pin outlet, tow hitch cable harness

F79 8/48 Auto-dimming rearview mirror

10/48 Reversing light, right

10/55 Reversing light, left

-

-

-

-

-

-

-

2/23

2/23, 26/5

F81 3/128 Rear left Door Module (LDM) - 20

F82 3/127 Passenger Door Module (PDM) - 25

F83 3/126 Driver Door Module (DDM) - 25

F84 3/27 Switch unit, power passenger seat

4/54 Power Seat Module (PSM)

F85 3/26 Switch unit, power driver’s seat

4/52 Power Seat Module (PSM)

continues

-

-

-

2/80

-

-

-

-

5

15

15

5

25

- 25

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 20


Fuses

Central Electronic Module (CEM) F86

F43

F37

F42

F65

F64

F86

4/56 Central Electronic Module (CEM)

No. Fuse function via A

F86 3/26 Switch unit, power driver’s seat

3/27 Switch unit, power passenger seat

3/268 Load assistance switch

4/52 Power Seat Module (PSM)

4/54 Power Seat Module (PSM)

10/24 Cargo compartment lighting

10/25 Ceiling light, cargo compartment

10/26 Reading light, rear left

10/27 Reading light, rear right

10/114 Vanity mirror lighting, left, C70

26/5 DC/AC converter, fuel tank

-

-

-

-

-

-

-

-

-

-

2/23

5

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 21


Fuses

Battery PF1-PF2

PF1

PF2

1/1 Battery

No. Fuse function via A

PF1 6/25 Starter motor

6/26 Alternator

PF2 F1-F14 Fuses in the engine compartment distribution box

F16-F18 Fuses in the engine compartment distribution box

F20-F21 Fuses in the engine compartment distribution box

F23-F24 Fuses in the engine compartment distribution box

F26-F27 Fuses in the engine compartment distribution box

F29-F31 Fuses in the engine compartment distribution box

-

-

-

-

-

-

-

-

150

150

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 22


Fuses

Fuses in holder

11K/1-2

11K Fuses in holder

No. Fuse function via A

1 Alcolock - 5

2 Alcolock - 5

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 23


Relays

Ignition switch and relays

A

3

1

B

Position

Terminal

4

8

30

S

X

15

50

Key Out

0

I

II

X

X X

X X X

X X X X

III X X X X

Relays, general

The diagram indicates two or three different designations for the relay’s position. This

is described below.

A B C

2

1(86)

1

3(30)

A = Corresponds to the position on the back

of the relay box (wiring side)

B = Corresponds to the position on the relay.

C = An old designation that may be found on

the relay

2(85)

4

5(87)

3

4(87a)

5

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 24


Relays

Engine compartment distribution box R2-R14

R9

R6

R12

R10

R7

R3

R1

R14

R13

R11

R8

R5

R4

R2

15/31 Engine compartment distribution box

Pos Relay function

R2 2/17 Relay, horn

R4 2/34 Relay, front fog lights

R5 2/142 Fuel filter preheater relay

R9 2/182 Relay, headlight washer motor

R10 2/82 Relay, heated rear window

R11 2/22 Relay, climate control system

R12 2/14 Relay, glow plug system

R13 2/35 Relay, starter motor

R14 2/32 Main relay, engine management system

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 25


Relays

Central Electronic Module (CEM) R15-R18

R18

R15

4/56 Central Electronic Module (CEM)

Pos Relay function

R15 2/23 Fuel pump relay, Gasoline

R18 2/193 Relay, comfort functions

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 26


Relays - soldered

Central Electronic Module (CEM) R1 - R11B

4/56 Central Electronic Module (CEM)

Pos Relay function

R1 2/89 Relay, interior lighting

R2 2/80 Relay, reversing light

R7A 2/92 Relay, windshield washer motor

R7B 2/93 Relay, rear window washer motor

R8 2/63 Relay, high beam

R11A 2/16 Relay, rear window wiper

R11B 2/159 Relay, infotainment

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 27


Relays

Other relays

Relays accessories

Pos

Relay function

Dashboard 2/64 Relay, auxiliary lights (accessory)

Cargo

compartment

2/157 Relay, subwoofer control module

Front

member

2/192 Relay, electric engine heater

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 28


Ground connections

Overview

31/80

31/102

31/4

31/89

31/88

31/119

31/3

31/112

31/114

31/110

31/52

31/83

31/84

31/6

31/10

31/115

31/116

31/66

31/67

31/117

31/11

31/107 31/12

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 29


Ground connections

31/3 - 31/10 cont.

31/3 Left MacPherson strut tower

1/1 Battery

31/4 Engine

1/1 Battery

31/6 A-post, driver’s side

3/111 Switch unit, lights

4/93 Keyless Vehicle Module (KVM), RHD

4/102 Steering Column Lock Module (SCL)

10/1 Lamp housing, front left

10/2 Lamp housing, front right

17/13 Data link connector

Alcolock

31/10 A-post, passenger side

2/16 Relay, rear window wiper

2/23 Relay, fuel pump

2/63 Relay, high beam

2/64 Relay, auxiliary lights (accessory)

2/89 Relay, interior lighting

2/92 Relay, windshield washer motor

2/93 Relay, rear window washer motor

2/159 Relay, infotainment

2/193 Relay, comfort functions

3/25 Switch, power roof/sunroof

3/112 Climate Control Module (CCM)

3/117 Switch unit, ceiling light

3/156 Gear Selector Module (GSM)

3/173 Switch, trunk lid/tailgate private lock

3/286 BLIS or PAS switch

4/33 Sunroof control module

4/56 Central Electronic Module (CEM)

6/2 Washer pump

6/48 Damper Motor Module (DMM), recirculation

6/95 Damper Motor Module (DMM), temperature, left side

6/96 Damper Motor Module (DMM), temperature, right side

6/102 Damper Motor Module (DMM), defroster

6/103 Damper Motor Module (DMM), floor/ventilation

6/117 Interior temperature sensor

7/122 Mass Movement Sensor Module (MMS), front

7/149 Rain Sensor Module (RSM)

7/159 Air Quality Sensor (AQS)

8/48 Auto-dimming rearview mirror

8/134 Solenoid, reverse interlock, manual

continues

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 30


Ground connections

31/10 - 31/12

31/10 A-post, passenger side

9/1 Front 12V outlet

9/25 Rear 12V outlet

10/22 Ceiling light

10/29 Glove compartment lighting

10/114 Vanity mirror lighting, left, S40/V50/C30

10/115 Vanity mirror lighting, right

10/150 Rear reading light

16/1 Integrated Audio Module (IAM)

16/45 Portable navigation system

16/93 Control module, cellular phone handsfree

31/11 Rear left side

3/35 Switch, handle, trunk lid/tailgate, C30

3/78 Lock unit, trunk lid/tailgate

4/78 Accessory Electronic Module (AEM), C70

4/86 Parking Assistance Module (PAM)

4/110 Trailer Module (TRM), C30

6/32 Rear window wiper motor, C30

7/101 Glass breakage sensor, C30

9/2 Heated rear window, C30

10/3 License plate lighting, C30

10/18 Lamp housing, rear left

16/79 Subwoofer Module (SUB)

16/105 Audio Module (AUD)

16/145 Remote Digital Audio Receiver (RDAR), S40/V50

17/19 12V outlet, cargo compartment, C70

31/12 Rear right side

4/59 Convertible Roof Module (CRM)

4/78 Accessory Electronic Module (AEM), S40/V50

4/86 Parking Assistance Module (PAM)

4/110 Trailer Module (TRM)

6/37 Lock motor, fuel filler flap

10/17 Lamp housing, rear right

10/19 Auxiliary brake light, C30

16/145 Remote Digital Audio Receiver (RDAR), C30/C70

17/19 12V outlet, cargo compartment, S40/V50

17/37 4-pin outlet, tow hitch cable harness

17/38 7-pin outlet, tow hitch cable harness

17/39 13-pin outlet, tow hitch cable harness

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 31


Ground connections

31/52 - 31/66

31/52 Left MacPherson strut tower

3/10 Reversing light contact

4/28 Transmission Control Module (TCM)

4/46 Engine Control Module (ECM)

7/24 Front knock sensor, Gasoline

7/192 Water detection sensor, Diesel

8/3 Electromagnetic clutch, climate control system

9/32 PTC resistor, crankcase ventilation

9/38 Heated fuel filter, Diesel

10/65 Auxiliary light, front right

10/69 Auxiliary light, front left

31/66 Left B-post

3/26 Switch unit, power driver’s seat, LHD

3/27 Switch unit, power passenger seat, RHD

3/35 Switch, handle, trunk lid/tailgate

3/76 Lock unit, rear left door

3/78 Lock unit, trunk lid/tailgate

3/85 Power window switch, rear left door

3/128 Rear left Door Module (LDM)

3/275 Lock contact, left rear door

3/287 Rear seat entry switch, left

4/52 Power Seat Module (PSM), LHD

4/54 Power Seat Module (PSM)

4/93 Keyless Vehicle Module (KVM), RHD

6/32 Rear window wiper motor, V50/C30

6/35 Fuel pump, auxiliary heater

8/51 Igniter, side airbag, driver’s side, LHD

8/52 Igniter, side airbag, passenger side, RHD

8/92 Lap belt tensioner, driver, LHD

9/2 Heated rear window, C70

9/12 Seat Heating Module (SHM), driver’s side, LHD

9/13 Seat Heating Module (SHM), passenger side, RHD

10/3 License plate lighting, S40/V50/C70

10/19 Auxiliary brake light, V50/C70

10/26 Reading light, rear left

10/114 Vanity mirror lighting, left, C70, LHD

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 32


Ground connections

31/67 - 31/88

31/67 Right B-post

3/26 Switch unit, power driver’s seat, RHD

3/27 Switch unit, power passenger seat, LHD

3/77 Lock unit, rear right door

3/86 Power window switch, rear right door

3/129 Rear Right Door Module (RDM)

3/276 Lock contact, right rear door

3/288 Rear seat entry switch, right

4/52 Power Seat Module (PSM), RHD

4/54 Power Seat Module (PSM)

4/82 Differential Electronic Module (DEM), S40/V50

4/93 Keyless Vehicle Module (KVM), LHD

7/93 Occupant Weight Sensor (OWS), USA/CDN

7/158 Mass movement sensor rear

8/51 Igniter, side airbag, driver’s side, RHD

8/52 Igniter, side airbag, passenger side, LHD

8/92 Driver’s lap belt tensioner, RHD

9/12 Seat Heating Module (SHM), driver’s side, RHD

9/13 Seat Heating Module (SHM), passenger side, LHD

10/27 Reading light, rear right

10/114 Vanity mirror lighting, left, C70, RHD

16/105 Audio module (AUD), C30

31/80 Left MacPherson strut tower

4/16 Brake Control Module (BCM), valves

31/83 A-post, driver’s side

3/1 Ignition switch

3/6 Switch, hazard warning flashers

3/254 Steering Wheel Module (SWM)

5/1 Driver Information Module (DIM)

17/13 Data link connector

31/84 A-post, passenger side

4/56 Central Electronic Module (CEM)

7/51 Accelerator pedal sensor

7/149 Rain Sensor Module (RSM)

8/31 Airbag igniter, passenger side

8/32 Igniter, airbag stage 2, passenger side

16/1 Integrated Audio Module (IAM)

16/1.2 Infotainment Control Module (ICM)

16/46 RTI Display

16/60 Phone Module (PHM)

16/108 Multimedia Module (MMM)

31/88 Engine

9/32 PTC resistor, crankcase ventilation

20/3 Spark plug and ignition coil

20/4 Spark plug and ignition coil

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 33


Ground connections

31/89 - 31/115

31/89 Engine

20/5 Spark plug and ignition coil

20/6 Spark plug and ignition coil

20/7 Spark plug and ignition coil

31/102 Front member

2/192 Relay, electric engine heater

31/107 trunk lid/tailgate(V50)

16/16 Window antenna amplifier

31/117 Ground connection, roof, V50

31/110 Right MacPherson strut tower

3/271 Contact, immobilizer, clutch pedal

4/7 Combustion Preheater Module (CPM)

4/113 Control module, gas discharge lamp, slave, right

6/1 Wiper Motor Module (WMM)

6/28 Motor, passenger compartment fan

6/104 Pump, high pressure headlight washer

7/4 Brake fluid level sensor

7/5 Washer fluid level sensor

8/119 Pressure monitor, climate control system

8/127 Pressure switch, climate control system, Diesel

10/2 Lamp housing, front right

10/6 Fog light, front right

31/112 Right MacPherson strut tower

9/41 PTC element, Diesel

31/114 Left MacPherson strut tower

3/62 Hood alarm contact

4/71 Cooling fan control module

4/112 Gas Discharge Lamp Module (GDL), master

4/114 Headlamp Control Module (HCM)

6/71 Electrical Power Steering Module (EPS)

6/114 Vacuum pump, Gasoline

10/1 Lamp housing, front left

10/5 Fog light, front left

16/10 Horn 1

16/11 Horn 2

16/35 Siren Control Module (SCM)

31/115 Left A-post

3/126 Driver Door Module (DDM), LHD

3/127 Passenger Door Module (PDM), RHD

4/83 Fuel pump control module, RHD

4/111 Additive Dosing Module (ADM), RHD

6/33 Fuel pump, RHD

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 34


Ground connections

31/116 - Ground connections in chassis

31/116 Right A-post

3/126 Driver Door Module (DDM), RHD

3/127 Passenger Door Module (PDM), LHD

4/83 Fuel pump control module, LHD, Gasoline

4/111 Additive Dosing Module (ADM), LHD

6/33 Fuel pump

31/117 Roof

31/107 Ground connection, trunk lid/tailgate (V50)

31/119 Left MacPherson strut tower

4/16 Brake Control Module (BCM)

Grounded directly to chassis

3/4 Switch unit, cruise control (SWS)

3/37 Contact horn

3/47 Parking brake contact

4/9 Supplemental Restraint System Module (SRS)

4/56 Central Electronic Module (CEM)

6/25 Starter motor

6/26 Alternator

7/6 Oil pressure monitor

8/3 Electromagnetic clutch, climate control system

8/33 Igniter, belt tensioner, driver’s side

8/34 Igniter, belt tensioner, passenger side

8/55 Igniter, rear left belt tensioner

8/56 Igniter, rear right belt tensioner

8/66 Igniter, left inflatable curtain

8/67 Igniter, right inflatable curtain

8/128 Driver’s belt force limiter

8/129 Passenger belt force limiter

16/16 Window antenna amplifier

16/67 Antenna amplifier, bumper, C70

16/141 Interference filter, rear window, left

16/142 Interference filter, rear window, right

16/150 AM/FM antenna and amplifier, right rear fender, C70

16/150 Window antenna amplifier, left, C30

18/4 Contact reel

20/22-25 Glow plug

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 35


DIM RRX

LCM

SWM

RKE

DDM

RSM BCM

AQS

DMM

HCM

ECM

GDL

TCM

WMM

SCM

ACM

GDL

CPM

EPS

MMM

CEM

SCU

RCM

PDM

AEM

TRM

RDM

GSM OWS SHM

CCM

BSC

ICM

SCL

PHM

IAM

Control modules

Overview of locations

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 36

PSM

KVM

SHM

LDM

SRS

AUD

ADM

SUB

DEM

PAM

CRM


Control modules

Overview of designations

Unit

Designation

ACM 6/26 Alternator Control Module (ACM)

ADM 4/111 Additive Dosing Module (ADM)

AEM 4/78 Accessory Electronic Module (AEM)

AQS 7/159 Air Quality Sensor (AQS)

AUD 16/105 Audio Module (AUD)

BCM 4/16 Brake Control Module (BCM)

BSC 7/164 Body Sensor Cluster Stability Sensor (BSC)

CCM 3/112 Climate Control Module (CCM)

CEM 4/56 Central Electronic Module (CEM)

CPM 4/7 Combustion Preheater Module (CPM)

DDM 3/126 Driver Door Module (DDM)

DEM 4/82 Differential Electronic Module (DEM)

DIM 5/1 Driver Information Module (DIM)

DMM 6/48 Damper Motor Module (DMM), recirculation

6/95 Damper Motor Module (DMM), temperature, left side

6/96 Damper Motor Module (DMM), temperature, right side

6/102 Damper Motor Module (DMM), defroster

6/103 Damper Motor Module (DMM), floor/ventilation

ECM 4/46 Engine Control Module (ECM)

EPS 6/71 Electrical Power Steering Module (EPS)

GDL 4/112 Gas Discharge Lamp Module (GDL), master, left

4/113 Gas Discharge Lamp Module (GDL), slave, right

GPS 16/139 Global Positioning System Module (GPS)

GSM 3/156 Gear Selector Module (GSM)

HCM 4/114 Headlamp Control Module (HCM)

IAM 16/1 Integrated Audio Module (IAM)

ICM 16/1.2 Infotainment Control Module (ICM)

KVM 4/93 Keyless Vehicle Module (KVM)

LCM 4/126 Left Camera Module (LCM)

LDM 3/128 Rear left Door Module (LDM)

MMM 16/108 Multimedia Module (MMM)

OWS 7/93 Occupant Weight Sensor (OWS)

PAM 4/86 Parking Assistance Module (PAM)

PDM 3/127 Passenger Door Module (PDM)

PHM 16/60 Phone Module (PHM)

PSM 4/52 Power Seat Module (PSM)

4/54 Power Seat Module (PSM)

RCM 4/127 Right Camera Module (RCM)

RDM 3/129 Rear Right Door Module (RDM)

RKE 4/119 Signal receiver, keyless vehicle (RKE)

RRX 4/119 Remote Receiver Module (RRX)

RSM 7/149 Rain Sensor Module (RSM)

SCL 4/102 Steering Column Lock Module (SCL)

SCM 16/35 Siren Control Module (SCM)

SCU 3/1 Start Control Module (SCU)

SHM 9/12 Seat Heating Module (SHM), driver’s side

9/13 Seat Heating Module (SHM), passenger side

SRS 4/9 Supplemental Restraint System Module (SRS)

SUB 16/79 Subwoofer Module (SUB)

SWM 3/254 Steering Wheel Module (SWM)

TCM 4/28 Transmission Control Module (TCM)

TRM 4/110 Trailer Module (TRM)

WMM 6/1 Wiper Motor Module (WMM)

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 37


TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 38

B:12

B:11

A:32

G:18

G:9

H:22

H:1

D:3

C:4

C:3

A:25

G:2

C:14

B:6

C:6

B:3

H:6

A:41

E:37

E:25

C:2

H:21

E:10

C:12

C:13

B:5

C:7

D:5

B:14

A:1

B:10

E:13

E:39

E:38

D:4

C:9

H:23

B:17

G:26

G:3

C:10

A:40

H:2

F:27

B:1

G:1

A:35

A:33

E:9

E:40

C:26

G:11

C:8

C:45

H:5

C:20

A:7

A:38

C:11

D:7

D:9

D:12

C:38

E:29

C:39

A:3

E:1

E:2

E:3

A:10

F:12

B:26

A:34

B:27

F:20

F:21

F:18

F:19

G:21

H:25

G:12

G:23

A:15

F:28

F:31

B:21

B:22

B:23

G:27

B:19

B:2

B:4

F:7

F:5

G:28

F:24

A:37

F:22

B:28

B:7

B:30

G:19

A:42

E:14

E:41

H:18

H:20

H:19

B:18

B:32

F:1

F:3

F:2

F:13

F:17

B:31

B:29

A:39

A:17

F44

F52

F53

F54

F51

F47

F86

F46

B

C A

F79

2/89

R1

2/80

R2

4/56

15+

CEM

CAN

LIN

Control modules

Central Electronic Module (CEM) 1:2


Control modules

Central Electronic Module (CEM) 2:2

C

A

B

4/56

BK 63/25

BK

BK 63/12

BK

B:16

B:15

F:16

F:14

B:8

B:9

G:15

G:14

F:30

F:15

B:24

B:25

A:16

C:18

H:4

H:8

H:24

G:16

G:32

C:34

C:33

E:30

C:22

A:23

C:28

C:43

C:42

C:37

A:43

C:46

A:44

H:7

A:45

E:12

A:28

D:10

A:14

E:8

C:21

E:27

E:11

D:8

G:30

C:41

C:27

A:21

A:29

C:40

C:17

E:28

C:16

A:8

E:36

A:18

C:25

C:31

C:24

A:4

A:9

C:44

C:30

F59

F58

F55

F66

F65

F67

F73

F77

F45

F60

F61

F49

F80

F69

F68

R11B

2/159

2/193

R18

2/23

R15

CEM

2/16

R11A

2

3

CAN

LIN

4

5 1

1 2

5

3

4

C:29

D:14

C:23

A:19

H:3 C:32

F56

F83

F82

F57

F43

F64

F85

F84

F62

F48

2/93

R7B

2/92

R7A

2/63

R8

F81

F63

B:13

H:17

G:31

G:7

G:22

G:6

G:13

G:24

C:1

F:9

F:25

G:29

E:22

E:20

F74 E:23

A:30 X+

E:21 30+ (1)

E:18 30+ (5)

30+ (2)

30+ (3)

30+ (4)

31/10

31/84

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 39


Control modules

Data communication Low speed CAN 1:2

GY-RD

BU-RD

C30/C70

C30/C70

64/31

12

WH

11

GN

4/54

PSM

B:4

B:3

CAN

3/126

DDM

CAN

A:12

A:3

BU-RD

GY-RD

64/41

2

1

BU-RD

GY-RD

63/220

GY-RD

BU-RD

63/221

64/30

12

11

WH

4/52

PSM

B:4

4/9

7/93

4/86

SRS

CAN

OWS

CAN

PAM

CAN

4/110

TRM

CAN

A:56 GY-RD

A:53

BU-RD

A:52

A:51

1

10

A:14

A:7

B:1

B:2

GN

WH

GY-RD

BU-RD

WH

GN

GY-BK

BU-YE

64/31

9

10

1 2

WH GY-RD

63/421

GY-RD

BU-RD

GN BU-RD

1 2

GY-RD

GY-RD

63/228

BU-RD

64/322

63/422

63/232

4X/110B

WH

GN

A:4

A:3

4/78

AEM

CAN

S40/V50/C70

GY-RD

GY-RD

BU-RD

BU-RD

BU-RD

63/229

63/233

GY-RD

BU-RD

C70

C70

GY-RD

BU-RD

BU-RD

GY-RD

64/245

1

C70

3

GY-RD

BU-RD

64/43

1

2

GN

GY-RD

BU-RD

B:3

CAN

4/93

B:4 KVM

B:3

CAN

4/59

F:1 CRM

F:9

CAN

3/127

PDM

A:3

A:12

CAN

16/60

PHM

4/56

F:30 F:15

4

7

#

1

2 3

5 6

8 9

0

A:12

1A:1

GY-OG B:24

BU-BK B:25

B:8 GY-BK

B:9

BU-YE

4/7

CPM

A

B

CAN

G:16

GY-RD

A:4

G:32

BU-RD

A:5

CAN

17/13

3

CEM

CAN

11

CAN

BU-RD

B:15

GY-RD

B:16

LIN

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 40


Control modules

Data communication, Low speed CAN 2:2

5/1

DIM

BU-WH

GY-VT

9

10

CAN

16/1.2

ICM

A:10

A:9

3/112

CCM

A:7 GY-RD

10

C°/F°

CAN

A:8

BU-WH

8

11

9

CAN

A

B

GY-BK

BU-YE

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 41


Control modules

Data communication, High speed CAN

4/46.1

ECM

GY-RD

B:57

4/28

TCM

A:8

GY-RD

B:57

4/46.2

ECM

BU-RD

64/90

15

1

GY-RD

BU-RD

B:44

B:58

B:45

CAN

5 CYL

2,4 L

AW 55-51

CAN

A:6

BU-RD

64/90

GY-RD

15

BU-RD

1

B:44

B:54

B:41

CAN

5 CYL

2,5 L T

GY-RD

BU-RD

64/90

15

1

GY-RD

BU-RD

B:22

B:23

B:49

B:50

4/46.3

ECM

CAN

5 CYL

2,4 L D

4/16

BCM

CAN

7/164

BSC

CAN

DSTC

11

15

25

29

2

1

BU

GY

64/113

GY

BU

GY-RD

BU-RD

17 18

63/222

63/226

GY-RD

BU-RD

63/223 63/227

BU-RD

GY-RD

GY-RD

BU-RD

S40/V50

S40/V50

64/90

GY-RD

15

BU-RD

1

64/90

15

1

4/114

HCM

A:3

A:2

CAN

S40/V50

GY-RD

BU-RD

GY-RD B:31

BU-RD B:19

4/46.7

ECM

CAN

4 CYL

1,6 L

A:4A

A:3A

4/46.4

ECM

CAN

4 CYL

2,0 L D

4/46.5

ECM

63/216

BU-RD

A:2

6/71

EPS

GY-RD

BU-RD

A:4A

A:3A

CAN

17/13

CAN

6

63/215

GY-RD

A:3

CAN

4 CYL

1,6 L D

14

64/90

15

4/46.6

ECM

1

GY-RD

A:A4

GY-RD

BU-RD

GY-RD

BU-RD

BU-RD

A:B4

CAN

GY-RD

BU-RD

4/56

CEM

CAN

G:15

G:14

F:14

F:16

W/O AWD

W/O AWD

2WD

BU-RD

GY-RD

BU-RD

GY-RD

GY-RD

BU-RD

64/112

4

5

64/51

6

2

BU-RD

GY -RD

BU-RD

GY-RD

C:8

C:9

6

7

3/254

SWM

CAN

4/111

ADM

CAN

4 CYL

1,8 L

B:12

B:11

64/50

BU-RD

3

GDL/AWD GY-RD

4

2 WD &GDL

BU-RD

GY-RD

64/50

BU-RD

6

GY-RD

5

BU-RD

63/225

BU-RD

AWD

S40/V50/C70

BU-RD

A:7

4/82

DEM

63/224

GY-RD

GY-RD

S40/V50/C70

GY-RD

A:8

CAN

S40/V50/C70

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 42


Control modules

Data communication MOST

16/1

IAM

16/1.2

ICM

CAN

B:2

O

OG

B:1

CAN

B:1

B:2

16/60

PHM

D:2

O

C:1

C:2

16/108

MMM

O

O

O

O

OG

O

OG

OG

OG

OG

O

O

CAN

C70

1 2

4 5

7 8

# 0

3

6

9

D:1

OG

O

OG

16/105

AUD

D:1

D:2

OG

O

OG

2 1 64/97

16/79

SUB

C:1

OG

O

O

OG

64/978

1

2

C:2

O

16/105

AUD

D:2

O

OG

16/145

RDAR

D:1

O

OG

C:2

C:1

16/105

AUD

D:2

OG

OG

O

O

16/79

SUB

C:2

O

OG

OG

O

OG

OG

64/972

2

1

D:1

C:1

O

16/145

RDAR

2

1

O

OG

O O

OG

OG

64/978

2

1

16/105

AUD

D:2

O

OG

D:1 OG

O

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 43


Control modules

Data communication, LIN 1:2

4/28

TCM

I5

AW55-51

64/90

A:7 RD

33

RD

64/111

3/156

2

RD

2 GSM

LIN

LIN

4/113

GDL

ECU SLAVE

4/112

GDL

ECU MASTER

3/1

SCU

LIN

A:11 A:11

LIN

A:12

16/35

2 SCM

LIN

A:2

WH-RD

LIN

WH-GN

6/1 LHD

WMM

1

WH-BK

6/1 RHD

WMM

4

WH-RD

4/56

G:1

CEM B:17

G:26

LIN

LIN

BUS

2

WH-GN

63/339

WH-GN

4/102

SCL

4

LIN

LIN

LIN

WH-GN

LIN

BUS

3

WH-GN

7/149

RSM

3

WH-GN

63/14

WH-GN

G:3

H:23

LIN

BUS

9

F:27

C:32

H:3

WH-GN

WH

S40/V50/C30

2

4/119

RKE/

RRX

LIN

LIN

4/119

8/48

RKE/

RRX

WH

C70

3

LIN

SIGNAL

POWER

LIN

GND

2

WH-GN

LIN

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 44


Control modules

Data communication, LIN 2:2

9/12

9/13

SHM

SHM

6/48 RHD

6/95

6/103

3/286

DMM

LIN

LIN

LIN

2

YE

3 A:2

A:2

WH

BU

BU

LIN

7/159 RHD

ECC

AQS

2 YE

4

64/25G 4 64/30

4 64/31

WH RHD

RHD WH-GN

WH LHD

LHD WH-GN

LIN

7

6

64/112

3/112

CCM

6/48 LHD

6/96

6/102

DMM

2

VT

WH

64/545

3

WH-GN

6

WH

WH-GN

WH

WH-GN

12

7

C°/F°

LIN

LIN

16/1.2

ICM

A:2 WH-BU

3/254

SWM

C:5

7/159 LHD

ECC

AQS

2 VT

LIN

4/46.1

ECM

LIN

LIN

6/26

ACM

A:1

WH-RD

WH-RD

A:88

LIN

5 CYL

2,4 L

4/46.2

A:46 ECM

4/126

LCM

LIN

LIN

5 CYL

2,5 L T

4/127

RCM

LIN

3/126

DDM

LIN

3/81

WINDOW

CONTROL

SWITCH

LIN

S40/V50

3/128 LHD

3/129 RHD

LDM/RDM

LIN

A:13

WH-RD

4

GN-WH

C30

6

B:4

GN-WH

GN-WH

5 64/333

C30

S40/V50/C70

63/26 64/41

64/43

WH-RD

BK

4 4

WH-RD

BK

64/45 LHD

64/47 RHD

1

BK

S40/V50

BK

WH-RD

4/46.3

ECM

A:88

64/47 LHD

64/45 RHD

1

LIN

5 CYL

2,4 L D

C70

BK

S40/V50

BK

BK

64/35

C30

GN-WH

5

GN-WH

GN-WH

B:4

A:13

6

LIN

3/127

PDM

LIN

3/129 LHD

3/128 RHD

LDM/RDM

LIN

S40/V50/C70

S40/V50/C70

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 45


Control modules

Start Control Module (SCU)

INHIBIT

KEY IN

RD

3/1 B:7

SCU

30

3 2 1 0 F26

3

2

1

0

PATS

MODULE

305

IMMOBILIZER SUPPLY

S

POWER

B1

LIN

RD-GN

B:8

B2

B4

50

RD-BK

15

B:6

GROUND

B:5

RD-BK

A:3

BK-YE

A:1

WH-GN

A:2

GY-BK B:2

GN-WH B:3

YE B:1

X

63/5

RD-GN

63/88

WH-GN

4

4/102

SCL

63/339

RD-GN

WH-GN

LIN

4/56

B:13

A:15

B:17

A:42

A:17

A:30

1

1

1

1

1

CEM

1

F44

F52

F53

F54

F51

F73

2

2

2

2

2

2

BK

LIN

A:10 E:3 E:2 E:1 A:3 C:39 E:29 C:38 A:16 C:18 H:4

31/83

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 46


Control modules

Accessory Electronic Module (AEM)

A:1

A:3

B:26

B:50

A:2

A:4

B:1

B:25

Pos Function Type

A:1 Electrical distribution Ground

A:2 Electrical distribution Feed

A:3 CAN communication Input/output signals

A:4 CAN communication Input/output signals

B:1 Remote start Feed

B:2 Remote start Ground

B:3 Remote start Input signal

B:4 Electric engine heater Ground

B:5 Electric engine heater Steering, alternating

current feed

B:11 Handsfree, mute of audio Input signal

B:15 Alarm signal Output signal

B:16 Alarm signal Output signal

B:33 Alarm signal Output signal

B:34 Alarm signal Output signal

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 47


Group 23 Fuel system

Engine management system 4-Cyl. 1.6l 1:2

15/31

30+

1

F9

2

BK-BU

64/90

21

BK-BU

A

4/46.7

RD-OG

RD-OG

2/32

R14

1

3

1 1 1

F36

2

F32

2

F34

2

5

2

1

F35

2

GN-WH

63/99

8/6

GN-WH

8/7

GN-YE

8/8

GN-BU

8/9

GN-RD

2

1

2

1

2

1

2

1

BK-WH

BK-YE

BK-BU

BK-OG

A:27

A:13

A:28

A:12

ECM

CAN

4CYL

1,6 L

GN-BU

41

GN-BU

GN-BU

12 14

64/90

6/120

ETA

1

2

3

4

5

6

WH-BU

YE-BU

WH-BU

BN

YE

WH-RD

B:41

B:42

A:21

A:6

A:22

A:48

WH

BN

B:36

B:13

7/16

1

2

GN-RD

GN-WH

8/65

2 1

BN-WH

B:29

63/52

20/3

20/6

20/4

20/5

20/17

3

2

1

BK-GN

A:3

BK-OG A:1

GN-RD

1

BK-OG

B:35

7/6

P

63/SH8

BK

63/74

SCR

BK

A:16

7/24

1

2

YE

BK

A:32

A:31

7/165

P

1

2

3

4

BN-GN

WH-VT

YE-GN

WH-GN

A:20

A:52

B:3

B:17

GN-OG

GN-YE

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 48

B

C


Group 23 Fuel system

Engine management system, 4-Cyl. 1.6l 2:2

15/31

30+

1

1

1

1

A

BK-BU

F30

2

F26

2

F4

2

F18

2

4/46.7

ECM

A:8

RD RD

5

64/111

4/56

RD-BU

E:22

1

RD-YE

E:21

1

B:7

3/1 30

5

CEM

F74

2

F57

2

CAN

50 S

B:2

X 15

GY-BK

A:42

2/23

R15

2

5

4

A:28

4CYL

1,6 L

B:9 RD

64/90

13

RD

A:40 GN-WH

8

GN-WH

B:21 GN-BU

GN-BU

37

GY 5 7/51

A:47 GY

28

1

2

3

4

6

YE

WH

BN

E:40

E:10

G:22

G:31

G:7

CAN

LIN

1 3

B:31

B:19

A:5 BK-YE

A:42 BK-YE

B:40 BK-YE

B:7 BK-YE

B:8

63/53

GN-YE

BK-YE

BK

63/12

BK

BK-YE

7

64/111

6/33

GN-WH

64/51 7 8

1 4 2

M

C:16

GN-WH

BK-OG

E:41 E:28

OG-WH

3/9 2

1

OG

BK-OG LHD

RHD

BK-OG

BK BK

63/25

5 6

I4 PETROL

2WD

B

C

GN-OG

31/84

31/52

31/116

31/115

31/10

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 49


Group 23 Fuel system

Engine management system, 4-cyl. 1.8l & 2.0l 1:2

RD-OG

RD-OG

30+

15/31

F9

1

2

2/32

R14

1

3

5

2

BK-BU

63/99

64/90

21

GN-WH

GN-YE

GN-BU

GN-RD

GN-OG

8/6

8/7

8/8

8/9

8/114

BK-BU

1

2

1

2

1

2

1

2

2

1

BK-WH

BK-YE

BK-BU

BK-OG

BK-RD

4/46.6

A:D1

A:D2

A:E1

A:E2

C:D2

A

ECM

CAN

1

F36

2

1

F32

2

1

F34

2

1

F35

2

1

F33

2

GN-BU

63/54

GN-YE

7/6 1

8/45

2

1

BK-YE

BK-OG

C:D1

A:D4

4CYL

1,8 L

P

GN-BU

41

GN-BU

GN-BU

12 14

64/90

GN-BU

7/16

1

2

BN

GN-BK

7/165

4

3

63/67

WH

BN

WH-VT

A:C3

C:E1

A:A2

2

1

WH-GN

YE-GN

A:B1

B:A2

63/74 63/US02

BK

GN-RD

SCR

7/24

1

2

SCR

YE

BK

A:E4

A:E3

20/3

2

3 1

GN-YE

WH

A:H1

20/4

3

2

1

GN-BU

WH-RD

A:H4

20/5

2

3 1

GN-RD

63/95

WH-BU

A:H2

20/6

2

3 1

GN-BK

WH-GN

A:H3

6/120

ETA

1

2

3

4

5

6

GN-RD

BK-OG

WH-BU

BN-BU

WH-BU

YE-BU

GN-OG

GN-OG

GN-YE

BK-BU

C:H3

C:H4

C:G1

C:F1

C:E4

C:F3

A

B

C

D

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 50


Group 23 Fuel system

Engine management system, 4-cyl. 1.8l & 2.0l 2:2

A

4/46.6

B:G1

BK-BU

15/31

30+

1

F26

2

1

F4

2

1

F18

2

ECM

CAN

4CYL

1,8 L

A

B

C

D

B:E3

B:G2

B:D2

B:L2

B:C2

B:B2

B:F2

C:C4

B:F1

C:E2

C:A4

A:A4

A:B4

C:H1 BK-YE

B:M4 BK-YE

A:G1 BK-YE

B:L4 BK-YE

B:M3

B:M2

GN-WH

GN-BU

GY

BK-RD

WH-RD

BK-YE

BK-OG

YE-RD

WH-VT

GY

BU

GN-OG

GN-OG

GN-YE

BK-BU

64/90

8

37

28

4

34

17

5

29

19

6/26

A:1 ACM

A:2

63/53

LIN

GN-WH

GN -BU

GY

5

RD RD

5

B:7

3/1 30

7/51

50 S

BK

B:2

1

2

3

4

6

64/111

5

31/52

X 15

GY-BK

GN-YE

YE

WH

BN

BK-YE

7

BK-YE

BK

A:42

E:40

E:10

G:22

G:31

G:7

31/84

64/111

63/12

GN-WH

4/56

CEM

CAN

LIN

BK

64/51

26/5

FlexiFuel

2/23

R15

3/9 2

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 51

GN-WH

RD

RD

2

1

C:16

7 8

BK

BK

64/54 4 3

GN-OG

M

1

5

1

6/33

1.8l/

2.0l M

5

DC/AC

RD-BU

1

2

5

3

E:22

F74

E:41

6/33

Flexi

fuel

4

BK-OG

RD-YE

OG

OG-WH

LHD

BK-OG

31/116

E:21

1

2

F57

E:28

1

A:28

RHD

BK-OG

31/115

63/25

BK BK

31/10


Group 23 Fuel system

Engine management system, 5-cyl. 1:2

30+

15/31

1

F9

2

BK-BU

7/156

P

64/90

21

1

2

3

4

BN-BU

WH-GN

YE-BU

WH-BU

BK-BU

A:5

A:71

A:13

A:94

4/46.1

A

RD-OG

RD-OG

1

2/32

R14

1

3

1 1

2

5

1

1

63/98

GN-YE

GN-YE

GN-YE

GN-YE

GN-YE

8/6

8/7

8/8

8/9

8/10

2

1

2

1

2

1

2

1

2

1

BK-WH

BU

BK-GN

BK-BU

BK

A:84

A:83

A:82

A:81

A:80

ECM

CAN

F33

2

F36

2

F34

2

F35

2

F32

2

7/16

7/81

P

1

2

1

2

3

YE-VT

BN-WH

BN

BK

GY

A:67

A:22

A:69

A:4

A:16

5CYL

2,4 L

8/84

P

63/13

6/114

63/121

GN-YE

GN-YE

1

2

BK BK

GN-RD

1

2

GN-BU

GN-BU

GN-BU

GN-BU

GN-YE

41 12 14 39 64/90

63/54

GN-YE

GN-BU

GN-WH

9/32

2

BK-WH

1

7/17

20/3

BK

20/4

BK

31/88

20/5

BK

31/89

7/6

1

20/6

BK

20/7

BK

P

MAF

3

1

2

3

4

5

GN-BU

4 GN-BU

2

3 1

4

2

1

4

2

3 1

4

2

3 1

4

2

3 1

GN-BU

GN-BU

GN-BU

GN-BU

6/120

GY

BN-BU

WH-RD

BN-BU

BK-GN

ETA

7/24 1

2

1

7/25

2

YE-RD

YE-RD

63/103

YE-RD

YE-RD

YE-RD

1

2

3

4

5

6

WH-BK

BN-YE

WH-RD

BN-RD

WH

WH-RD

63/97 YE-RD A:12

WH-BK A:60

GN-RD

BK-OG

YE

BN-BU

WH-BU

YE-BU

WH-BU

WH-GN

A:23

A:70

A:93

A:3

A:91

A:46

A:20

A:62

A:21

A:58

A:59

A:34

A:35

A:75

A:74

A:24

A:72

A:15

A:96

63/120

BK

7/166

1

QLT 2

3

WH A:40

BN A:10

YE A:14

31/114

GN-BU

GN-YE

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 52

B

C


Group 23 Fuel system

Engine management system, 5-cyl. 2:2

A

4/46.1

BK-BU

15/31

1

1

30+

1

1

F23

F26

F4

F18

B:16

2

2

2

2

ECM

RD RD

5

64/111

4/56

GN-WH

RD-BU

1

E:22

RD-YE

E:21 A:17

1

1

RD

B:7

3/1 30

5

CEM

2

F74

2

F57

2

F54

CAN

50 S X 15

B:2 B:3

GY-BK

A:42

2/23

R15

2

5

4

A:28

5CYL

2,4 L

B:54

B:41

B:14

B:26

RD

GN-WH

GN-YE

GY

64/90

23

GN-WH

8

GN-YE

37

GY 5 7/51

28

1

2

3

4

6

BK-YE

7

E:40

E:10

YE G:22

WH G:31

BN G:7

64/111

CAN

LIN

C:16

1 3

E:41

OG-WH

3/9 2

E:28 E:1

B:30 GN-YE

13

GN-YE

B:20 WH-BK

24

WH-BK

64/113

7

WH-BK

A:58

A:45

A:57

A:44

B:1 BK-YE

B:2 BK-YE

B:3 BK-YE 63/53

B:4 GN-BU

B:6 GN-BU

63/65

BK

GN-YE

BK

BK-YE

63/12

GN-OG

1

6/33 M

BK-RD

GN-OG

GN-WH

WH-BK

GN-WH

BK-OG

BK-OG

WH-BK

14 7 8

4 5

1

OG

64/51

1 2 3 64/956

C30

1 2 3

4/83

GN-WH

GN-OG

BK-RD

BK-OG

63/33

4 5 64/956

C30

BK-RD

1 4

1

6/33 M

BK-RD

BK-OG LHD

RHD

BK-OG

BK BK

63/25

5

6

5 6

B

C

GN-BU

31/52

31/84

I5 PLASTIC

AWD 2WD

I5 PZEV

METAL TANK

31/116

31/115

31/10

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 53


Group 23 Fuel system

Engine management system, 5-cyl. Turbo 1:2

RD-OG

RD-OG

30+

15/31

1

F9

2

2/32

R14

1 2

3 5

1 1 1 1 1

F33 F36 F34 F35 F32

2 2 2 2 2

BK-BU

7/156

P

GN-BU

63/98

64/90

21

1

2

3

4

8/28

8/6

GN-YE

8/7

GN-YE

8/8

GN-YE

8/9

GN-YE

8/10

GN-YE

2

1

2

1

2

1

2

1

2

1

2

1

BK-BU

BN-BU

GN-RD

YE-BU

WH-BU

BN-YE

BK-WH

BK-YE

BK-GN

BK-BU

BK-OG

A

A:15 4/46.2

A:41

A:44

A:89

A:51

A:1

A:25

A:3

A:2

A:26

ECM

CAN

63/13

GN-YE

GN-BU

7/165

7/16

P

1

2

3

4

1

2

BN

A:38

WH-GN

A:87

GY

A:43

BK-GN A:86

BN-WH

WH-VT

A:42

A:12

41 40

12 14 39 64/90

GN-YE

GN-BU

63/54

GN-BU

7/17

2

MAF

3

4

5

BN-BU

WH-RD

BN-RD

A:61

A:18

A:63

8/84

P

1

2

7/6

P

1

BK-GN

7/24

1

2

3

4

WH-BK

BN-YE

BN-RD

WH-RD

A:9

A:7

A:55

A:79

A:31

6/114

63/121

BK BK

GN-RD

31/88

31/89

20/3

BK

20/4

BK

20/5

BK

20/6

BK

20/7

BK

4

2

3 1

3

4

2

1

4

2

3 1

4

2

3 1

4

2

3 1

GN-BU

GN-BU

GN-BU

GN-BU

GN-BU

GN-NU

7/25

63/103

1

2

WH

WH-RD

BN-RD

WH-RD

WH-BK

WH-BU

WH-GN

A:77

A:53

A:81

A:57

A:34

A:82

A:58

63/120

6/120

ETA

M

1

2

3

4

5

6

GN-RD

BK-OG

WH-BU

BN-BU

WH-BU

YE-BU

A:75

A:14

A:19

A:74

A:88

A:65

BK

GN-BU

GN-BU

GN-YE

5CYL

2,5 L T

GN-YE

9/32

2 1 GN-WH

1

2

BK-WH

7/166

1

QLT 2

3

WH A:10

BN A:85

YE A:20

31/114

GN-BU

GN-YE

B

C

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 54


Group 23 Fuel system

Engine management system, 5-cyl. Turbo 2:2

A

4/46.2

BK-BU

15/31

30+

B:27

1

F23

1

F26

1

F4

1

F18

2

2

2

2

ECM

CAN

5CYL

2,5 L T

B:16

B:30

B:14

B:15

B:21

B:2

B:4

B:6

GN-WH

GN-YE

GN-YE

B:17 GN-BU

B:26 GY

B:54

B:41

B:57

B:44

B:3

B:5

RD

BK-YE

BK-YE

BK-YE

GN-BU

GN-BU

WH-BK

63/65

64/90

23

8

37

13

9

28

24

63/53

RD

RD RD

5

6

64/111

4/56

3/1 B:7

30

5

50 S X 15

B:2

GY-BK A:42

GN-WH

E:40

GN-YE

E:10

GY 5 7/51

1 YE G:22

2 WH G:31

3 BN G:7

4

7 64/111

64/113

WH-BK

7

BK-YE

63/12

BK-YE

GN-OG

1

BK-RD

CEM

CAN

LIN

4/83

WH-BK WH-BK WH-BK

14

2/23

R15

1 2 3

GN-OG

GN-OG

GN-WH GN-WH GN-WH

4

4

1

7

BK-RD

C:16

5

RD-BU

E:22

1

F74

2

2 5 4

1 3

BK-OG BK-OG

BK-OG

1 2 3

5

8

64/956

C30

BK-RD

E:41

3/9

64/51

OG

63/33

64/956

C30

1 4

RD-YE

OG-WH

BK-RD

E:21

1

F57

2

E:28

2

1

LHD

BK-OG

A:28

RHD

BK-OG

BK BK

63/25

GN-YE

BK

BK

6/33

M

6/33

M

5 6

5

B

C

GN-BU

31/84

31/52

I5 PLASTIC

AWD 2WD

I5 PZEV

METAL TANK

31/116 31/115

31/10

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 55


Group 23 Fuel system

Engine management system Diesel 4-cyl. 1.6l 1:2

15/31

RD

30+

RD-OG

RD-OG

BK-BU

64/90

21

BK-BU

B:E1

4/46.5

1

1

F6

F9

2/14

R12 3

5

2

1

1

1

2

1

2

1

1

2/32

R14

3

5

1

2

8/6

8/7

2

1

2

1

BK-WH

GN-WH

BK-YE

GN-YE

C:G3

C:H1

C:G4

C:G2

F32

2

F36

2

F33

2

F34

2

F35

2

8/8 2 BK-BU C:H4

1 GN-BU C:H2

8/9 2 BK-OG C:H3

1 GN-RD C:G1

ECM

GN-OG

7/86

8/82

1

2

2

WH-VT

BN-WH

BK-BU

B:F1

B:L4

C:E1

CAN

9/38

GN-RD

GN-RD

63/53

BK

1

2

BK-RD

GN-YE

GN-YE

GN-BK

GN-BU

6 39 41

12 14 64/90

BK-OG

GN-BU

GN-YE

GN-BU

GN-BU

63/54

GN-BU

GN-RD

7/17

GN-RD

3

MAF

7/192

1

2

8/111

2 1

M

4

2

5

3

7/191

7/16

7/6 2

P

1

2

1

2

7/71 1

P 2

3

1

7/154 1

2

BK-BU

WH-BU

WH-RD

WH-BU

BN-BU

WH

BN

YE-GN

BN-GN

WH-GN

WH-BU

BK-YE

BK-GN

WH-BU

BN-BU

B:E2

B:C3

B:A2

B:H3

C:C2

B:F2

B:H1

B:E4

B:D4

B:K2

C:A2

B:M4

A:E3

B:H2

C:F1

4CYL

1,6 L D

GN-BU

BK-YE

WH-BU

64/90

2

16

7/25

1

2

3

BK-YE

WH-BU

YE-RD

WH-RD

BN-RD

C:F2

C:A4

B:F3

B:B1

B:C1

GN-OG

GN-OG

64/91

1

7/174

P

3

1

2

YE-VT

WH-VT

BN-WH

B:M2

A:G1

B:G4

B:K1

C:F3

RD

63/124

7/162

P

1

2

3

WH-GN

BN-GN

YE-GN

B:G3

B:C4

B:B4

BK

GN-OG

GN-OG

GN-OG

GN-OG

7/21

P

1

2

3

8/120

YE-VT

63/41

YE-VT YE-RD

WH-VT

BN-WH

B:F4

B:D1

B:A1

GN-OG

4 3

2 1

1

GN-OG

1

GN-OG

1

GN-OG

1

64/600

20/23 20/24 20/25 20/26

M

4

5

1

2

3

WH-GN

BN-GN

YE-GN

BK-GN

GN-BK

C:D4

C:D3

B:A4

B:D2

B:C2

31/52

2

2

2

2

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 56

A

B

C


M

Group 23 Fuel system

Engine management system Diesel, 4-cyl. 1.6l 2:2

4/46.5

15/31

1

30+

1

F26

2

F4

2

F18

2

ECM

RD RD

5

64/111

4/56

RD-BU

RD-YE

E:22 E:21

1 1

B:7

3/1 30

5

CEM

F74

2

2

F57

CAN

4CYL

1,6 L D

C:B3

A:A2

A:C3

A:B3

B:K4

C:A4

50 S X 15

B:2

GY-BK A:42

64/90

WH-GN

7

WH-GN

G:30

GN-WH

8

GN-WH

E:40

GN-BU

GN-BU

E:10

37

GY

GY

5 7/51

28

1 YE G:22

BK-YE

2 WH G:31

2

3 BN G:7

WH-BU

16

4

6

CAN

LIN

2/23

R15

2 5 4

1 3

A:28

E:41

C:16

E:28

A:A4

A:A3

OG-WH

3/9 2

BK

6/99

BK-YE

7

64/111

OG

1

63/25

C:D1

B:K3

B:L1

BN-RD

63/42 BN-RD

WH-RD

YE-RD

BK-BU

5

6

1

4

3

BK-YE

GN-WH

BK

B:J2

B:F4

B:M1

YE-RD

63/41

BN-GN

WH-GN

WH-GN

BK-GN

8/122

5

6

1

3

4

M

GN-YE

BK

64/51

7

8

GN-WH

BK-OG

A:G4

A:H4

A:H1

BK-YE

BK-YE

BK-YE

63/53

4/111

ADM

1

8

BK-OG

BK-OG

BK

6

CAN

7

9

GN-OG

RHD

LHD

A

B

C

GN-BK

GN-BU

4 3

6/33

10 BK-RD

31/52 31/84

31/115 31/116 31/10

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 57

1

M

2


Group 23 Fuel system

Engine management system Diesel, 4-cyl. 2.0l 1:2

15/31

RD

30+

RD-OG

RD-OG

BK-BU

64/90

21

BK-BU

4/46.4

B:H3

2/14

R12

3

5

1

2

1

F32

1

F36

1

2

F6

1

F33

1

2

1

F9

F34

1

F35

2/32

R14

3

5

1

2

7/172

8/132

1

2

3

2

1

YE-VT

WH-VT

BN-WH

GN-BK

C:E3

C:C1

C:D4

B:M3

8/6 2

1

GN-WH

BK-WH

C:M3

C:L3

8/7 2

1

GN-YE

BK-YE

C:M2

C:L1

ECM

CAN

2

2

2

2

2

8/8 2 GN-BU C:M4

1 BK-BU C:L2

BK-RD

WH-BU

BK-YE

GN-OG

GN-YE

GN-YE

GN-BU

GN-RD

GN-BU

GN-BU

GN-BU

63/54

GN-BK

8/9 2 GN-RD C:M1

1 BK-OG C:L4

8/82 2 BK-BU

1

GN-BU

B:M1

4CYL

2,0 L D

64/91

1

16

2

39 41 6 12 14

63/86A

RD

GN-WH

GN-RD

GN-RD

9/32 1

1

9/38

2

2

64/90

GN-RD

7/17

3

BK-OG

MAF

GN-BU

GN-BU

GN-RD

7/192

1

3

2

2

4

5

8/133 2

1

8/77 2

1

8/121 2

WH-BU

WH-BU

BN-BU

BU-WH

BK-BU

BK-BU

BK-GN

C:H2

B:C1

B:G2

C:H3

B:L4

B:M4

B:L3

GN-BK

1

7/6 2

BK-GN

C:F3

7/154 1

2

BK

P

WH-BU

BN-BU

C:A3

C:J1

BK-WH

BK-YE

WH-BU

B:E1

B:D4

RD

63/124

7/16 1

2

WH

BN

C:A2

C:G1

7/71

1

P 2

3

YE-GN

BN-GN

WH-GN

C:E2

C:D1

C:B1

GN-OG

GN-OG

4 3

2 1

1

2

GN-OG

GN-OG

1

2

GN-OG

GN-OG

1

2

GN-OG

GN-OG

1

2

64/600

20/23 20/24 20/25 20/26

BK

BK

63/53 63/53A

7/25

7/77 1

2

3

2

1

YE-RD

WH-RD

BN-RD

WH-VT

BN-WH

BK-YE

BK-YE

BK-YE

BK-YE

BK-YE

BK-YE

C:F4

C:B4

C:F1

B:A2

B:G3

A:G4

A:H4

B:K2

C:H4

C:J4

C:K4

GN-OG

31/52

A

B

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 58


Group 23 Fuel system

Engine management system Diesel, 4-cyl. 2.0l 2:2

4/46.4

15/31

1

1

30+

1

F30

F26

F4

F18

2

2

2

2

ECM

CAN

RD

RD RD

5

B:7

3/1 30

64/111

5

4/56

CEM

RD-BU

F74

2

RD-YE

E:21

1

F57

2

4CYL

2,0 L D

B:G4

A:E2

A:E4

A:C3

A:F3

A:A4

A:A3

B:E4

B:D1

B:C4

C:B2

C:B3

C:A4

B:A3

B:H2

B:B4

B:J2

B:C2

B:B2

B:D3

B:E2

B:D2

B:C3

B:L2

B:M2

50 S

B:2

X 15

64/90

GY-BK A:42

RD

13

WH-GN

7

WH-GN

G:30

GN-WH

8

GN-WH

E:40

GN-BU

GN-BU

E:10

37

GY

GY 5 7/51

28

1 YE G:22

2 WH G:31

3 BN G:7

4

WH-RD

BN-RD

WH-BU

BN-BU

YE-VT

WH-VT

BN-WH

YE-GN

WH-GN

BN-GN

BK-GN

GN-BK

BN-YE

YE-BK

WH-BK

WH-GN

BN-GN

YE-GN

6

1

3

4

7/193

1

2

3

7/162

1

2 P

3

7/190

1

2

7/191

1

2

7/174

3

1 P

2

8/120

5

M

6

GN-YE

BK-YE

BK-YE

BK

7

64/111

63/12

4/111

ADM

CAN

LIN

GN-WH

C:16

64/51 7 8

1

8

6

2/23

R15

GN-WH

BK-OG

A:28

2 5 4

1 3

E:41 E:28

OG-WH

3/9 2

1

OG

BK-OG

BK-OG

RHD

LHD

63/25

BK BK

CAN

7

9

GN-OG

C:K2

C:K3

C:J3

GN-YE

GN-YE

GN-YE

63/65

6/33

4

3

1

M

2

A

GN-OG

10

BK-RD

B

31/84

31/115 31/116 31/10

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 59


Group 23 Fuel system

Engine management system Diesel, 5-cyl. 2.4l 1:3

15/31

30+

1

F6

1

F9

BK-BU

64/90

21

BK-BU

A

RD

RD-OG

1

2

F33

1

2

1 1

F35 F34 F36

2 2

1

F32

2

8/6 1 GN-YE

2 BK-WH

8/7

1 GN-YE

2 BU

8/8

1 GN-YE

2 BK-GN

8/9

1 GN-YE

2 BK-BU

1 GN-YE

8/10

2 BK

7/25 1

2

7/190

1

2

BN-RD

WH-RD

WH-RD

BN-RD

7/191 1

WH-BU

2

BN-BU

7/16

1

2

BN-WH

WH-VT

4/46.3

A:1

A:50

A:25

A:75 ECM

A:3

A:74

A:2

A:73

A:26

A:49

A:77

A:53

A:84

A:62

A:58

A:8

A:60

A:56

CAN

LIN

5CYL

2,4 L D

GN-RD

GN-BU

GN-BK

GN-BU

GN-YE

GN-BU

GN-YE

7/17 MAF 4

3

2

1

GN-BU

BN-RD

WH-RD

BN-BU

A:86

A:59

A:29

RD

40

14

12

41

39 64/90

GN-BU

BK-YE A:48

GN-YE 7/15

3

2

6

BN

GY

A:57

A:31

4

1

WH-BK A:80

5

WH A:6

63/54

YE-GN 35

GN-BU A:32

WH-BU

16

WH-BU A:90

2

BK-YE A:37

AUTO

64/90

8/113

1

2

GN-BK

BK-GN

AUTO

A:92

8/120

1

2

3

WH-GN

BK-GN

GN-BU

A:66

A:71

6

YE-GN

A:28

4/109

GLOW PLUG

DRIVER

N

RELAY BOX

DRIVER

N

DRIVER

N

DRIVER

N

11 10 9

DRIVER

N

7

6/143

M

1

2

3

4

GN-OG

BK-RD A:9

YE-BK A:21

PUISSANCE

MOS

PUISSANCE

MOS

PUISSANCE

MOS

PUISSANCE

MOS

PUISSANCE

MOS

6

GLOW P5 GLOW P4 GLOW P3 GLOW P2 GLOW P1

5

4

3

2

1

GN-YE

GN-RD

GN-BU

GN-WH

GN-OG

38 27

26 25

24 64/90

7/162

7/165

1

P 2

3

1

P

2

4

3

BN-GN A:64

WH-GN A:65

YE-GN A:19

GY A:87

WH-GN A:85

BK-GN A:82

BN A:15

WH-RD

WH-RD

WH-RD

WH-RD

WH-RD

RD-OG

2

2

2/32

R14

1 2

3 5

1

1

1

1

1

20/22 20/23 20/24 20/25 20/26

2

2

2

2

2

GN-YE

GN-BU

GN-OG

B

C

D

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 60


Group 23 Fuel system

Engine management system Diesel, 5-cyl. 2.4l 2:3

15/31

30+

1

1

1

1

A

BK-BU

F26

2

F4

2

2/142 R5

1

3

F24

2

2

F18

4/46.3

2

5

ECM

B:42

RD

64/111

5

RD

WH-BK

RD-YE

CAN

7

3/1 30

5

BK

63/121

LIN

50 S X 15

B:2 B:3

15I

GN-WH

RD-BU

4/56

A:17

E:29

E:22

E:21

5CYL

2,4 L D

1

1

1

GN-WH

CEM

2

F51

F74

2

F57

2

B:48 GN-WH

B:38 GN-YE

64/90

8

37

GN-WH

GN-YE

A:42

E:40

E:10

CAN

LIN

2/23

R15

2 5 4

1 3

A:28

RD

WH-BK

BK

63/25

B:4

63/120

BK

BK

9/32

1

2

GN-WH

G:7

G:31

G:22

C:16

E:41 E:28

OG-WH

3/9 2

64/90 13

7

64/113

B:2

B:6

BK-YE

BK-YE

BK-YE

63/53

BK-WH

9/32

1

2

GN-WH

63/85

OG

RD

1

31/52

BK-WH

BN

WH

YE

GN-WH

64/51

14

GN-OG

7

WH-BK

GN-RD

BK

B:23

B:22

7/51

8

9/38

1

2

B:47

B:1

B:3

B:5

GY

GN-BU

GN-BU

64/90

28

63/65

GY

5

6

BK-YE 4

7 64/111

3

2

1

6/33 1

M

5 6

BK

B

C

D

GN-OG

GN-YE

GN-BU

BK-YE

63/12

BK

BK-OG RHD

BK-OG LHD

BK-OG

RD-BK

BK

63/33

BK

31/84

31/115

31/116 31/114 31/10

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 61


Group 23 Fuel system

Engine management system Diesel, 5-cyl. 2.4l 3:3

4/46.3

7/154

1

2

WH-BU

BN-BU

A:61

A:78

ECM

7/174 3

P 1

2

WH-VT

BN-WH

YE-VT

A:44

A:63

A:41

CAN

LIN

7/173

1

2

3

BN-WH

WH-VT

YE-RD

A:10

A:33

A:7

5CYL

2,4 L D

8/98 1

2

YE-RD

BN-RD

A:23

A:93

7/166

1

QLT 2

3

WH A:34

BN A:36

YE A:42

6/118

1 BK

2

GN-OG

3

WH-BK

4

YE-BK

5

BN-YE

A:4

A:5

A:81

A:40

A:52

6/120

ETA

1

4

2

3

GN-RD

BN-BU

BK-OG

WH-BU

A:24

A:72

A:67

A:18

6

YE-BU

A:11

8/111

M

1

2

YE A:47

BN A:94

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 62


BK-BU

Group 23 Fuel system

Emission control 4-cyl 1.6l

15/31

30+

F9

1

2

RD-OG

RD-OG

2/32

R14

1

2

3

5

1

1

F32

F35

2

2

GN-YE

GN-BU

64/90 39 32 14 21

4/46.7

GN-YE

GN-RD

GN-RD

ECM

A:8

BK-BU

8/18

1

CAN

2

BK-OG

B:16

4CYL

1,6 L

A:41

7/15

A:30

O

2

2

1

4

3

BK-OG

WH-BU

BN-BU

B:6

A:49

B:2

B:38

B:27

WH-VT

BN-WH

7/163

1

2

B:37

B:26

WH-RD

BN-RD

7/25

1

2

7/82

O 2

2

1

4

3

BK-YE

WH

BN

B:39

A:38

B:14

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 63


Group 23 Fuel system

Emission control 4-cyl 1.8l & 2.0l

15/31

30+

F9

1

2

RD-OG

RD-OG

2/32

R14

1

2

BK-BU

3

5

1

1

2

F32

2

F35

BK-OG

BK-GN

P1

P3

6/99

P2

M

GN-YE

GN-BU

BK-RD

BK-WH

P4

P6

P5

64/90 39 32 14

21

GN-BK

GN-RD

GN-BU

4/46.6

BK-BU

63/54

GN-RD

ECM

B:G1

C:B1

8/18

2

1

BK-OG

B:H1

CAN

C:B2

C:C1

BN-RD

4CYL

1,8 L

C:C2

GN-RD

7/15

O

2

1

2

3

4

BK-GN

BN-BU

WH-BU

B:C1

B:E1

GN-YE

63/63

C:D4 7/172

WH-VT

2

C:A1

BN-WH

1

7/82

O 2

1

2

4

3

BK-GN

WH-GN

BN-RD

BN

B:M1

B:D1

B:E2

A:B3

A:B2

WH-RD

BN-RD

7/25

2

1

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 64


Group 23 Fuel system

Emission control 5-cyl

15/31

30+

F9

1

2

RD-OG

RD-OG

2/32

R14

1

2

BK-BU

3

5

1

1

F33

2

F35

2

2/22:1

R11

GN-BU

64/113

13

11

10

GN-YE

GN-BU

12

GN-YE

63/13

GN-BU

WH-VT

YE-VT

BK-WH

BK-WH

YE-VT

WH-VT

64/51

GN-BU

64/90 40 14

21 26

27

25 11 9

10 12

63/54

GN-BU

GN-BU

8/18

4/46.1

BK-BU

WH-VT

WH-VT

GN-BU

2 6/67 4

GN-YE

1

2

GN-BU

8/19

1

BK-OG

A:53

ECM

B:16

B:23

3

M

1

2

BK-OG

A:78

CAN

B:46 YE-VT

YE-VT

BK-WH

5CYL

2,4 L

W/O T

B:33 BN-WH

63/61

7/15

GN-YE

B:58

B:45

O

2

1

2

3

4

BU

WH

BK-YE

A:76

A:48

A:47

B:57

B:44

7/186

GN-YE

A:17

A:19

YE-BK

BN-RD

7/172

1

2

O 2

1

2

4

3

BN-RD

WH-RD

63/94

BN-BU BN-BU

BN-BU

A:49

A:68

A:11

A:63

A:39

A:64

A:43

WH-VT

YE-RD

WH-BK

BN

3

7/173

1

3

2

7/187

GN-YE

O 2

1

2

4

3

BN-RD

WH-RD

BK

A:50

A:95

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 65


Group 23 Fuel system

Emission control, 5-cyl Turbo

15/31

30+

F9

1

2

RD-OG

RD-OG

2/32

R14

1

2

3

5

1

1

F33 F35

2

63/13

GN-YE

2

2/22:1

GN-BU

GN-BU

WH-VT

YE-VT

BK-WH

64/113

GN-BU

13

WH-VT

11

YE-VT

10

BK-WH

12

GN-YE

GN-YE

GN-BU

BK-BU

WH-VT

64/90 35 40 14

21 26

27

25 64/51 11 9 10 12

GN-YE

GN-YE

GN-BU

GN-BU

8/81

1

4/46.2

ECM

B:27

BK-BU

WH-VT

WH-VT

GN-BU

2 6/67 4

2

BK-WH

A:96

B:45

63/54

GN-BU

8/19

CAN

3

M

1

1

2

BK-RD

A:72

YE-VT

BK-WH

GN-BU

8/18

1

5CYL

2,5 L T

B:46 YE-VT

2

BK-OG

A:50

B:23

BN-WH

B:54

7/15

B:41

O 2

4

3

5

1

2

6

BK-YE

GN-YE

BU

WH

GY

WH

A:73

A:91

A:67

A:92

A:68

B:57

B:44

A:16

YE-RD

7/172

1

7/82

A:36

BN-WH

2

O 2

2

1

4

3

BN-RD

GN-YE

WH-RD

BN-RD

A:49

A:90

A:95

A:83

A:17

A:37

WH-VT

YE-BK

BN-YE

3

7/173

1

2

A:59

WH-BK

3

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 66


Group 26 Cooling system

Cooling fan

30+

15/31

1

F1

2

WH-RD

A:10

4/46.7

ECM

4CYL

1,6 L

CAN

OG-BU

WH-RD

4/46.6

ECM

4CYL

1,8 L

B:C2

CAN

4/71

1

4

WH

64/90

34

WH-RD

WH-RD

W/O T

T

B:7

B:8

4/46.1

4/46.2

ECM

5CYL

CAN

+

-

2

6/29

GN-YE

1

BK

WH-RD

A:58

4/46.3

ECM

5CYL

2,4 L D

CAN

2

BK

WH-RD

A:B2

4/46.5

ECM

4CYL

1,6 L D

63/120

CAN

4/46.4

BK

WH-RD

A:B2

ECM

4CYL

2,0 L D

CAN

31/114

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 67


Group 27 Engine controls

Cruise control, 4-cyl

15/31

30+

1

1

F9

F18

RD-OG

RD-OG

1

2

2/32

R14

2

2

E:21

GN-VT

GN-BU

GN-YE

3 5

F35

2 F36 1

2 1

4/28 AUTO

TCM

64/90

64/111

A:7 RD

33

RD 2 RD

2

3/156

GSM

RD-WH

4/56

1

F57

E:28

2

RD-YE

E:21

2/193:3

CAN

LIN

A:8

A:6

LIN

3/9 2

1

1

3/39 2

MAN 3

OG

GN-YE

BN

E:41

G:21

G:24

CEM

CAN

LIN

F68

2

3/254

SWM

A:45 OG-BK C:1

BK-WH C:4

D:1

D:3

D:4

F:5

F:6

F:3

18/4

B:3

B:2

B:5

A:1

A:2

A:3

63/30

3/4

SWS

G:15

G:14

CAN

F:16

F:14

63/5

5/1

DIM

9

10

6

7/51

4

BK BK-YE BK-YE

7

1

2

3

5

64/90

64/111

63/12

GY

YE

WH

BN

28

6/120 1.6L

ETA

M

6/120 1.8L

ETA

G:22

G:31

G:7

1

2

3

4

5

6

2

3

4

M 5

6

1

BK

WH-BU

YE-BU

WH-BU

BN

YE

WH-RD

GN-RD

BK-OG

WH-BU

BN-BU

31/83

GY 1.6L

A:47

GY 1.8L

B:D2

GY 2.0L D

A:F3

GY 1.6L D

A:B3

B:41

B:42

A:21

A:6

A:22

A:48

B:22

B:10

B:37

B:38

4/46.4-7

ECM

CAN

4CYL

B:E:1 BK-BU 1,6L.D

B:H3 BK-BU 2,0L.D

A:35 BK-BU

B:31

B:19

A:41

A:30

A:A3

A:A4

1.8L

A:8 BK-BU 1.6L

CAN

1.6L

1.8L

64/90

21

Diesel (1,6/2,0L)

WH-BU

B:25

31/84

GN-BU

8/77

2.0L D

2

1

YE-BU

BK-BU

B:26

B:M4

B:M4

BK-YE

8/111

1.6L D

2 1

M

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 68


Group 27 Engine controls

Cruise control, 5-cyl

15/31

30+

1

1

F9

F18

RD-OG

RD-OG

1

2

2/32

R14

2

2

E:21

GN-VT

GN-YE

3 5

F36

2 1

4/28 AUTO

TCM

64/90

64/111

A:7 RD

33

RD 2 RD

2

3/156

GSM

RD-WH

4/56

1

F57

E:28 2

RD-YE

E:21

2/193:3

CAN

LIN

A:8

A:6

LIN

3/9 2

1

MAN

7/123

1

OG

1 YE

2 WH

3 BN

E:41

G:12

G:23

G:21

G:15

CEM

CAN

LIN

F68

2

3/254

SWM

A:45 OG-BK C:1

BK-WH C:4

D:1

D:3

D:4

F:5

F:6

F:3

18/4

B:3

B:2

B:5

A:1

A:2

A:3

63/30

3/4

SWS

G:14

F:16

CAN

F:14

63/5

5/1

DIM

9

G:22

G:31

G:7

10

7/51

6

4

BK BK-YE BK-YE

31/84

7

1

2

3

5

64/111

63/12

YE

WH

BN

GY

64/90

28

6/120

ETA

M

6/120

ETA

8/111

2.4L D

1

2

3

4

5

6

M 5

6

M

5CYL W/O T

5CYL W/O T

5CYL W/O T

5CYL W/O T

5CYL W/O T

5CYL W/O T

BK

31/83

YE

YE-BU

4/46.1-3

ECM

B:42 BK-BU I5D

GY B:26

T

GY B:26

B:27 BK-BU

GY B:47 B:16 BK-BU W/O T

GN-RD

BK-OG

BN-BU

WH-BU

A:75

A:74

A:24

A:72

A:15

A:96

1 5CYL T

GN-RD A:75

2 5CYL T

BK-OG A:14

3 5CYL T

WH-BU A:19

4 5CYL T

BN-BU A:74

1

2

5CYL T

5CYL T

W/O T

T

I5D

WH-BU

YE-BU

A:88

A:65

YE A:47

BN A:94

CAN

5CYL

B:58

B:45

B:54

B:41

B:22

B:23

64/90

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 69

CAN

Turbo

Diesel

21


Group 32 Alternator and voltage regulator

Power supply, 4-cyl

31/4

31/3

BK

BK

1/1

12V

- +

PF1

1 2

6/25

A:1

RD

B:1

RD

2

PF2

1

RD

M

15/31

F31

1

2

RD

20 64/90

4/46.7

6/26

B:1

B+

ECM

ACM

A:7

RD

A:33

CAN

LIN

1.6 L

VOLT. REG.

4/46.6

ECM

C:A4

A:3

A:1 A:2

C:E2

CAN

BU

1.8 L

GY

BU

GY

4/46.4

ECM

BU

GY

A:A1

B:H4

CAN

2,0 L D

4/46.5

ECM

BU

GY

C:B1

B:A3

CAN

1,6 L D

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 70


Group 32 Alternator and voltage regulator

Power supply, 5-cyl

31/4

31/3

BK

BK

1/1

12V

- +

PF1

1 2

RD

6/25

A:1

B:1

RD

M

6/26

B:1

B+

ACM

LIN

VOLT. REG.

A:1

4/46.1

ECM

WH-RD

A:88

CAN

2,4 L

4/46.2

ECM

WH-RD

A:46

CAN

2,5 L T

4/46.3

ECM

WH-RD A:88

CAN

2,4 L D

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 71


Group 33 Starting system

Starting system 4-cyl

15/31

64/120

1

1

1

R13

2/35

1

3

GY

6/25 A:1 B:1

RD

6/26 B:1

F26

F13

2

2

2

5

M

RD-GN

RD

RD

RD

GY

BK-RD

64/90

4 11

2

1

PF1

2

1

PF2

RD

B:7

3/1 30

5 64/111

5

BK-RD

BK-RD

BK-RD

GY

4/46.4

ECM

2,0 L D

A:1D

CAN

1/1

12V

GY-BK

50 S

B:2

X

15

4/46.7

ECM

1,6 L

B:30

CAN

4/56

A:42

E:9

4/46.5

ECM

1,6 L D

CEM

BK-RD

C:1A

CAN

BK

BK

CAN

G:21

GN-YE

3/39 2

4/46.6

ECM

1,8 L

BK-RD

B:L2

G:24

3

CAN

BN

31/4

31/3

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 72


Group 33 Starting system

Starting system 5-cyl

1

F13

1

F26

15/31

2

2

RD

RD-GN

64/90

GY 11 GY

2/35 R13

3(30) 1(86)

5(87) 2(85)

RD

5 64/111

B:7 3/1

30

5

50 S X 15

B:2 B:3

GN-BU

BK-RD

64/90

31

4

GN-BU

BK-RD

B:11

B:8

4/46.1

ECM

B:15

1

64/120

RD

B:1 6/26

B+

ACM

G

31

6

9

13

GN-BU

GN-YE

B:17

B:30

2,4 L

CAN

GY-WH

GY

A:1 6/25 B:1

LIN

BN

GN-WH

GN-BU

GY-BK

20

BN

GN-BU

BK-RD

B:11

B:9

4/46.2

ECM

AUTO

BN

GN-BU

B:17

2,5 L T

B:13

GN-YE

B:15

CAN

M

RD

4/56

A:17

E:9

A:42

GY-WH

4/46.3

RD

CEM

GN-BU

B:33

ECM

AUTO

2

1

PF2

2

1

PF1

1

F44

BK-RD

GN-BU

GN-YE

B:44

B:29

B:41

2,4 L D

CAN

B:34

1/1

12V

2

CAN

LIN

4/28

A:5

A:10

TCM

BK

BK

CAN

A:9

BK-YE

63/53

BK

G:21

BN

MAN

7/123 3

GY-WH

AUTO

G:23

WH

2

G:12

YE

1

MAN

WH-RD

3/271

1

14 64/113

GN-YE

4

64/111

GN-YE

GN-YE

2 1

63/108

BK

MAN

2

WH-RD

4/93

KVM

E:3

BK BK

63/109

CAN

31/4 31/3

31/110

31/52

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 73


Group 35 Lighting

High and low beam

30+

5/1

DIM

10

9

3/254

SWM

15/31

1

F4

1

F18

3/111

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

2

2

CAN

WH-VT

CAN

C:7

RD-BU

RD-YE

SUPPLY

OG-BK

14

POS 0

0 1 2

POS 1

POS 2

6

BK-GN

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

10 13

FF IND.

REOST LEV

11

4/56

B:31

E:22

E:21

A:40

B:2

A:28

4

5

2/63

R8

1

CEM

E:37

3

2

2/89

R1

1

5 4

B:8

CAN

B:9

2

3

1 1

F59

F58

LIN

F46

1

2

2

2

E:11

E:27

E:25 A:38

63/139

64/111

BK

10/1

12

10/70

10/68

4

10/2

12

10/66

10/64

4

+

+

6/38 M

6/39

-

L

LOW HIGH PARK TURN

BK

M

-

63/25

BU

BK

BK

L

LOW HIGH PARK TURN

BK

63/120 63/108

BK

BK

6 9 3 10

6

9

3

10

GN-OG

GN-VT

GN-BK

BK

GN-WH

63/6

63/121 63/109

BK

BK

BK

OG

GN-YE

ILLUM

GND

BU

OG

BK

OG

OG

18

GN-YE

C70

OG S40/V50/C30

S40/V50/C30

C70

BU

BK

8

9 64/111

31/10

31/114

31/6

31/110

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 74


Group 35 Lighting

Active headlight, Bi-Xenon S40/V50

3/254

30+

SWM

15/31

1

1

1

2

F4

F18

2

F26

2

3/111

LIGHTS ON

FF = FRONT FOG

CAN

RD

RF = REAR FOG

C:7

WH-VT

RD-BU

4/56 B:31

E:22

RD-YE

RD

5 64/111

B:7 3/1

30

5

50 S X 15

B:3

E:21

GN-WH

A:17

0 1 2 3

SUPPLY

POS 0

POS 1

POS 2

ABL

FRONT FOG

14 6 5 4

OG-BK

BK-GN

BK-BU

OG-GN

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

BK

11

B:8

B:9

CEM

A:40

B:2

B:4

B:4

E:37

CAN

2/63

R8

LIN

63/6

1

1 1

F59

F58

F54

2

2 2

BK

BK

BK

E:27 E:11 E:1

10/1 5 10 4 10/2

4

10 5

Gnd Gnd

Ignitor Gnd Gnd

Ignitor

Lin

12

M

LEVELING

Supply

6

Low

Beam

ECU

Lit5

Actuator

BiLitronic

9 3

High

Beam

Sidemarker

E:25

GN-BK

GN-VT

PARK

TURN

GN-YE

63/91G

63/121 4/114

F:3

63/109

C:3 WH-BK

WH-RD C:2

HCM

LIN

63/120

63/108

BK

BK

TURN

PARK

Sidemarker

GN-OG

GN-BK

High

Beam

3

Actuator

BiLitronic

ECU

Lit5

M

LEVELING

BK

BK

BK

Low

Beam Supply Lin

9 6 12

GN-YE

GN-YE

BK

BK

F:2

CAN

A:3

A:2

BK

BK

5/1

E:2

D:2

D:3

E:3

DIM

10

9

WH

BN

YE

WH

CAN

7/121 1

4

5

BN

WH

YE

64/113

27

19

20

BN

WH

YE

64/50

7

8

9

BN

WH

YE

1

4

5

7/120

31/114

31/110

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 75

31/6


Group 35 Lighting

Bi-Xenon C30/C70

3/254

30+

SWM

15/31

1

1

1

2

F4

F18

2

F26

2

3/111

LIGHTS ON

FF = FRONT FOG

CAN

RD

RF = REAR FOG

C:7

WH-VT

RD-BU

4/56 B:31

E:22

RD-YE

RD

5 64/111

B:7 3/1

30

5

50 S X 15

B:3

E:21

GN-WH

A:17

14 6 5

OG-BK

BK-GN

BK-BU

0 1 2

SUPPLY

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

11

B:8

CEM

A:40

B:2

B:4

B:9

2/63

R8

E:37

A:28

GN-BK

BK

G:26

CAN

E:25

LIN

1

1 1

F59

F58

F54

WH-RD

GN-VT

GN-BK

GN-BK

7/121 1

4

E:27

10/1 9

TURN

PARK

GN-BK

63/92

5

A:5

A:9

A:12

BN

WH

YE

AUX.

MAIN

4/112

WH

A:1

HIGH BEAM

ACTUATOR

ELEC.

BALLAST

BK

3 6 12 11 2 8

BN

GY-RD

BN-RD

B:1

B:6

LOW

HI DRTL

GDL

MASTER

LIN

A:4 A:3 A:2

YE

WH

WH-RD

WH-GN

WH-BU

B:5

B:3

B:4

27

19

20

64/113

M

LEVELING

2

5 4 10

BN

WH

GN-YE

B:2

B:7

B:8

BN

WH

YE

A:10

A:11

A:6

BK

BK

2 2

E:11 E:1

GN-YE

63/121 63/109

WH-BK

63/91G

64/50

7

BN 1

7/120

8

WH 4

9

YE 5

GN-OG

GN-YE

BK

BK

GN-OG

BK

63/120 63/108

BK

BK

10/2 9

TURN

PARK

GN-OG

63/93

A:5

A:10

A:11

A:6

AUX.

MAIN

4/113

HIGH BEAM

ACTUATOR

ELEC.

BALLAST

M

LEVELING

3 6 12 11 2 8 5 4 10

GY-RD

BN-RD

B:1

B:6

5/1

LOW

HI DRTL

WH-RD

WH-GN

WH-BU

B:5

B:3

B:4

GDL

SLAVE

DIM

CAN

LIN

9

BN

WH

GN-YE

B:2

B:7

B:8

10

A:9

63/25

BK

BK

BK BK

63/6

31/114 31/110

31/10 31/6

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 76


Group 35 Lighting

Running/Parking lights, Tail lights, S40/V50

30+

15/31

1

F4

1

F18

3/111

2

2

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

RD-BU

RD-YE

SUPPLY

POS 0

0 1 2

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

4/56

E:22

E:21

14 5 11

CEM

A:40

B:4

OG-BK

BK-BU

G:14

G:15

E:13

G:2

F:16

F:14

CAN

10/11

10/1 4 10/2 4

+

+

10/12

BK

BK

LIN

M

LOW HIGH PARK

M

TURN

-

L

LOW HIGH PARK TURN

-

L

BK

C:13

C:14

C:12

OG-BU

7

7

64/48

BK OG-BK

5

S40

S40

OG-GN

OG

OG-WH

10/18

S40

10/51

10/52

C:2

10/44

10/45

C:1

S40

10/17

63/109

63/121

TURN

STOP

BACK

FOG

TAIL

TAIL FOG BACK

STOP

TURN

10/3 1 2

V50

3

OG-WH

V50

OG

GND

GND2

C:3

GND2

C:4

GND

BK BK BK BK

63/196

1 64/48

TAIL

63/172

A:1

A:3

OG-WH

STOP

BK-WH

10/51

10/52

10/18

TAIL TURN FOG BACK

C:4

C:3

BK

V50

V50

V50

10/17

BACK

BK

FOG

S40

10/44

10/45

TURN

C:1 A:2

TAIL

V50

BK

OG

STOP

C:6 A:4

BK V50

BK

TAIL

S40

BK

63/108

BK

BK

63/120

BK

63/6

BK

31/66

31/11

31/12

31/110

31/114

31/6

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 77


Group 35 Lighting

Running/Parking lights, Tail lights (Bi-Xenon) S40/V50

30+

15/31

1

F4

1

F18

3/111

2

2

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

RD-BU

RD-YE

SUPPLY

POS 0

0 1 2

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

4/56

E:22

E:21

14 5 11

CEM

G:14

A:40

OG-BK

G:15

B:4

BK-BU

F:16

CAN

E:13

F:14

G:2

LIN

10/1

10/11

10/12

4 10/2

4

BK

BK

BK

Gnd

Gnd

Ignitor

Ignitor

Gnd

Gnd

64/48

C:13

OG-BK OG-BK

5

C:14

C:12

Lin

S40

S40

M

LEVELING

Supply

Low

Beam

ECU

Lit5

OG-BU

OG-GN

OG

OG-WH

Actuator

BiLitronic

High

Beam

10/18

Sidemarker

7

S40

PARK

TURN

TURN

10/51

10/52

PARK

C:2

7

Sidemarker

10/44

10/45

High

Beam

C:1

Actuator

BiLitronic

S40

ECU

Lit5

Low

Beam

M

LEVELING

Supply Lin

10/17

63/109

63/121

10/3 1 2

TURN

STOP

BACK

FOG

TAIL

TAIL FOG BACK

STOP

TURN

V50

3

OG-WH

V50

OG

GND

GND2

C:3

GND2

C:4

GND

64/48

BK BK BK BK

1

63/196

TAIL

63/172

A:1

A:3

OG-WH

STOP

BK-WH

10/51

10/52

10/18

TAIL TURN FOG BACK

C:4

C:3

BK

V50

V50

V50

10/17

BACK

BK

FOG

S40

10/44

10/45

TURN

C:1 A:2

TAIL

V50

BK

OG

STOP

C:6 A:4

BK V50

BK

TAIL

S40

BK

63/108

BK

BK

63/120

BK

63/6

BK

31/66

31/11

31/12

31/110

31/114

31/6

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 78


Group 35 Lighting

Running/Parking lights, Tail lights C30/C70

30+

15/31

1

2

F4

1

2

F18

3/111

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

4/56

RD-BU

E:22

RD-YE

E:21

SUPPLY

0 1 2

14 5 11

CEM

A:40

B:4

OG-BK

BK-BU

E:13

G:14

G:15

F:16

CAN

G:2

10/11

10/1 4

10/2 4

F:14

LIN

M

+

10/12

+

TURN PARK

HIGH LOW

L

-

M

LOW

-

L

HIGH

PARK

TURN

BK

BK

C:13

C:14

C:12

OG-BU

OG-GN

7

7

BK

C70

C30

OG

OG-BK

64/233 6

1 64/791

63/11

OG-WH

10/18

10/51

10/52

FOG

OG-WH

C:2 C:3

TAIL1 TAIL2

TURN

STOP

BACK

10/17

BACK

STOP

TURN

10/44

OG

10/45

C:3 C:1

TAIL2 TAIL1 FOG

63/109

63/121

10/3

3

1 210/3 A:1 B:1

OG

OG-WH

C70

GND2

C:1

GND

GND

GND2

C:2

C70

BK

BK

10/19:5

BK

10/18

10/51

10/52

10/17

10/44

10/45

7 64/233

2

C1:1

OG-BU

C3:3

C4:4

GY-OG

C2:3

C70

C30

BK BK

63/172

C30

C1:4

BK-WH C30

C3:2 C4:1

BK C70

BK C30

BU-GY

C70

BK

C2:2

C30

63/108

BK

63/120

BK

63/6

BK

63/174

63/175

BK

BK

FOG

POSITION

REVERSE

POSITION

TURN

REVERSE

POSITION

TURN

BK

FOG

POSITION

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

OG-BK OG-BK

RD-BK

BK-YE

BK-GN BU-BK

A:2 B:2

63/11G

64/791

BK-BU

31/66

31/11

31/11

31/12

31/12

31/110

31/114

31/6

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 79


Group 35 Lighting

Running/Parking lights, Tail lights (Bi-Xenon) C30/C70

15/31

30+

1

2

F4

1

2

F18

3/111

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

4/56

RD-BU

E:22

RD-YE

E:21

SUPPLY

0 1 2

14 5 11

CEM

A:40

B:4

OG-BK

BK-BU

E:13

G:14

G:15

G:2

10/11

10/11

10/12

F:16

F:14

CAN

LIN

10/1 9

PARK

TURN

AUX.

MAIN

HIGH BEAM

ACTUATOR

LOW

HI DRTL

ELEC.

BALLAST

M

LEVELING

10/2 9

PARK

TURN

AUX.

MAIN

HIGH BEAM

ACTUATOR

LOW

HI DRTL

ELEC.

BALLAST

M

LEVELING

C70

C:13

C30

C:14

C:12

7

OG-BU

OG-GN

OG

7

BK

BK

64/233

OG-BK

6

1 64/791

63/11

OG-WH

10/18

10/51

10/52

FOG

OG-WH

C:2 C:3

TAIL1 TAIL2

TURN

STOP

BACK

10/17

BACK

STOP

TURN

10/44

OG

10/45

C:3 C:1

TAIL2 TAIL1 FOG

63/109

63/121

10/3

3

1 210/3 A:1 B:1

OG

OG-WH

C70

GND2

C:1

GND

GND

GND2

C:2

C70

BK

BK

BK

10/19:5

BK

10/18

7 64/233 2 64/791

C1:1

OG-BU

C70

10/51

10/52

C3:3

10/17

10/44

10/45

C4:4

GY-OG

C30

C2:3

BK BK

63/172

C30

C1:4

BK-WH C30

C3:2 C4:1

BK C70

BK C30

BU-GY

C70

BK

C2:2

C30

BK 63/108

BK 63/120

63/6

BK

63/174

63/175

BK

BK

FOG

POSITION

REVERSE

POSITION

TURN

REVERSE

POSITION

BK

TURN

FOG

POSITION

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

OG-BK OG-BK

RD-BK

BK-YE

BK-GN BU-BK

A:2 B:2

63/11G

BK-BU

31/66

31/11

31/11

31/12

31/12

31/110

31/114

31/6

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 80


Group 35 Lighting

Brake lights S40/V50

30+

15/31

1

1

F4

F18

2

2

RD-BU

RD-YE

4/56

E:22

E:21

1

G:14

CEM

2

F57

E:28

OG-WH

3/9

2

64/90

8

ECM

G:15

F:16

F:14

CAN

LIN

E:41

OG

1

E:40 GN-WH

64/48

V50 OG-YE

2

OG-YE

C:7

S40

D:5

OG-YE

1 10/19

C:3

C:4

A:28

D:12

16/142

S40

OG

V50

OG

BK

BK

63/211

BK

BK

BK

S40

63/212

5

V50

BK

63/196

BK

63/25

BK

1

64/48

OG-BK

S40

OG-BK

V50

10/50

10/18 A:4

10/43

A:3 10/17

BK

TAIL

STOP

V50

V50

STOP

TAIL

A:3

A:4

V50

V50

63/172

10/18

10/50

A:4

BK-WH

BK

10/17

10/43

A:3

TURN

STOP BACK FOG TAIL

TAIL FOG BACK

STOP

TURN

GND

A:3

GND2

S40

S40

GND2

GND

A:4

BK

BK

BK

31/11 31/12

31/10

31/66

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 81


Group 35 Lighting

Brake lights C30/C70

30+

15/31

1

1

F4

F18

2

2

4/56

E:22

E:21

1

D:14

CEM

2

F57

E:28

OG-WH

3/9

2

D:15

F:16

F:14

CAN

E:41 1

OG

E:40 GN-WH

C:7

64/233

C70

3

2

BN

1 10/19

C:3

BK

C:4

BK

63/28

5

2 C30

10/3:3

1

7

64/233

63/172

BK

BK

BK

BK

BK

RD-BU

RD-YE

64/90

8

ECM

LIN

OG-YE

OG-YE

64/48A

C30

OG

C70

C30

OG

C30

C70

OG-BK

10/50

10/43

WH

C70

C30

C5:1

C6:1

STOP

STOP

64/48A

10/18

BK-WH

C5:2

C6:2

10/17

BK

C1:4 BK-BU

C3:2 C4:1

BU-GY C2:2

BK-WH

10/50

10/43

BK

10/18 A:1

10/17

A:2

FOG

TAIL1

TAIL2

TURN

STOP BACK

BACK

STOP

TURN

TAIL2 TAIL1 FOG

63/174

GND2

GND

GND

A:2 A:1

GND2

63/175

BK

BK

REVERSE

POSITION

TURN

FOG

POSITION

C30

C30

C30

C30

FOG

POSITION

REVERSE

POSITION

TURN

C70

C70

31/11

31/11 31/12

31/12

31/66

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 82


Group 35 Lighting

Reversing lights S40/V50

30+

4/28 AUTO

A:7

TCM

AW55-51

RD

64/90

33

64/111

RD

2

RD

3/156

2 GSM

15/31

1

1

LIN

F4

F18

2

2

CAN

A:6

LIN

A:8

4/56

E:22

RD-BU

E:21

RD-YE

CEM

2/80

R2

G:14

G:15

F:16

1

F:14

CAN

F79

2

GN-YE

GN-WH

GN-WH

64/90

GN-BU

10

E:14

LIN

GN-WH

C:45

MAN M56/M66 5-Cyl

MAN IB5 4-Cyl Petrol

MAN M56 4-Cyl 2,0L D

GN-BK

MAN

MAN MTX 75/MMT6 4-Cyl D

S40

GN-BK

10/55

GN-BK V50

GN-BK

10/48

2 3 2 2

3/10

10/18

C:1 C:3

10/17

TAIL TURN FOG BACK BACK FOG TURN TAIL

1

C:4

V50

V50

C:6

BK

GN-BK

63/53

10/52

10/48

10/18

A:1

A:2

10/17

TURN

STOP

BACK

V50

V50

FOG

TAIL

BK

TAIL FOG BACK

STOP

TURN

GND

BK

BK

BK

BK

BK

A:3

GND2

S40

S40

GND2

GND

A:4

31/52

31/11 31/12

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 83


Group 35 Lighting

Reversing lights C30/C70

30+

4/28 AUTO

64/90 64/111

A:7

TCM

AW 55-51 RD RD

33

2

RD

3/156

2 GSM

15/31

1

1

LIN

F4

F18

2

2

CAN

A:6

LIN

A:8

4/56

E:22

RD-BU

E:21

RD-YE

G:14

G:15

CEM

2/80

R2

F:16

1

F:14

CAN

F79

2

MAN IB5 4-Cyl Petrol GN-WH

MAN MTX75/MMT6 4-Cyl D

GN-WH

3

2

MAN

MAN M56/M66 5-Cyl

BK

GN-YE

2

3/10

1

64/90

GN-BU

10

E:14

10/18

C30

FOG

POSITION

LIN

C1:4

BK-BU

C3:2

TURN

10/18

POSITION

BK-WH

10/55

C3:1

GN-BK

10/55

A:3

GN-BK

GN-BK

C:45

GN-BK

10/48 10/48

REVERSE

C2:1

A:4

C4:1

POSITION

BK

BU-GY

10/17

10/17

C2:2

C30

63/53

C30

FOG

TAIL1

TAIL2

TURN

BK

BK

BK

STOP

BACK

BACK

STOP

TURN

TAIL2 TAIL1 FOG

C30

C70

GND2

GND

GND

GND2

A:2 A:1

C70

63/175

BK

TURN

POSITION

FOG

63/174

BK

REVERSE

31/52

31/11

31/11 31/12

31/12

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 84


Group 35 Lighting

Fog lights S40/V50

30+

RD-GN

RD-OG

RD-OG

5/1

15/31

DIM

1

1 1

F18

F4

F29

10

2

2 2

2/34

R4

1

3

9

CAN

2

5

GN-WH

10/5

1 GN-WH

1

10/6

4/56

2

2

CEM

3 1 7

8

11

CAN

BK

LIN

LHD

RD-YE

RD-BU

BK-YE

E:21

E:22

G:9

3/111

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

0 1 2

A:32 GN-BU

B:23

BK-YE

BK

B:22

B:6

BK-YE

GN-OG

BK

C:6

GN-YE

GN-YE

RHD

SUPPLY

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

GN-YE

GN-YE

GN-YE

63/109

63/121

10/18

10/53

C:6

10/17

10/46

C:4

TAIL TURN FOG BACK

BACK

FOG

TURN

TAIL

63/6

BK

C:4

V50

V50

C:6

BK

LHD

S40

RHD

S40

BK

BK

63/108

63/120

10/18

10/53

V50

V50

10/46

C:4 C:3

10/17

BK

BK

TURN

STOP

BACK

FOG

TAIL

TAIL FOG BACK

STOP

TURN

BK

GND

S40

GND2

C:3

GND2

C:4

GND

S40

S40

BK

BK

S40

31/114

31/11 31/12

31/6

31/110

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 85


Group 35 Lighting

Fog lights C30/C70

30+

RD-GN

RD-OG

RD-OG

5/1

15/31

DIM

1

1 1

F18

F4

F29

10

2

2 2

2/34

R4

1

3

9

CAN

2

5

RD-YE

RD-BU

BK-YE

GN-WH

10/5

1 GN-WH

1

10/6

4/56

E:21

E:22

G:9

3/111

2

LIGHTS ON

FF = FRONT FOG

2

RF=REARFOG

CEM

0 1 2

SUPPLY

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

3 1 7

8

11

CAN

A:32 GN-BU

B:23

BK-YE

BK

BK

LIN

B:22

B:6

BK-YE

GN-OG

BK

C:6

C70

BK

GN-YE

RHD

RHD

C70

C30

63/121

10/18

10/53

GN-YE

C30

LHD

LHD BK

10/17

10/46

63/109

C1:2

C2:1

FOG

POSITION

REVERSE

POSITION

TURN

REVERSE

POSITION

TURN

POSITION

FOG

63/6

BK

C30

C1:4 C3:2

BK-BU

C4:1

BU-GY

C2:2

C30

GN-YE

BK

10/53

C:4

FOG TAIL1

TAIL2

TURN

10/18

STOP BACK

10/17

BACK

STOP

TURN

10/46

C:4

TAIL2 TAIL1 FOG

63/108

63/120

C30

C30

BK

BK BK-WH

C70

63/174

BK

GND2

C:1

GND

BK BK

63/175

GND

GND2

BK

C:2

C70

BK

BK

31/114

31/11 31/11

31/12

31/12

31/6 31/110

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 86


Group 35 Lighting

Fog lights LHD Japan S40/V50

30+

RD-GN

RD-OG

RD-OG

5/1

15/31

DIM

1

1 1

10

F18

F4

F29

9

2

2 2

2/34

R4

1

3

CAN

2

5

RD-YE

RD-BU

BK-YE

GN-WH

10/5

1 GN-WH

1

10/6

4/56

E:21

E:22

G:9

3/111

2

LIGHTS ON

FF = FRONT FOG

2

RF = REAR FOG

CEM

0 1 2

SUPPLY

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

3 1 7

PWR

FF IND.

REOST LEV

ILLUM

GND

8 11

CAN

A:32 GN-BU

B:23

BK-YE

BK

BK

LIN

B:22

B:6

BK-YE

GN-OG

BK

C:6

GN-YE

63/121

GN-YE

1

10X/18C

GN-YE

V50

63/109

10/18

10/46

C:1

10/17

63/6

TURN

STOP

TAIL

FOG

BACK

BACK

UP

FOG

TAIL

STOP

TURN

V50

C:4

C:2

V50

V50

V50

BK

UP

BK

BK

BK

10X/18C 4

S40

GN-YE

63/108

63/120

10/18

S40

10X/18C 4 2 10X/17C

10/46

C:3 10/17

BK

BK

TURN

STOP

BACK

FOG

TAIL

TAIL FOG BACK

STOP

TURN

BK

GND

S40

GND

GND2

C:3

GND2

C:4

GND2

GND

GND

S40

BK

BK

BK

3 4

BK

10X/18C

10X/17C

31/114

31/11 31/12

31/6

31/110

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 87


Group 35 Lighting

Fog lights LHD Japan C30/C70

30+

RD-GN

RD-OG

RD-OG

5/1

15/31

DIM

1

1 1

10

F18

F4

F29

9

2

2 2

2/34

R4

1

3

CAN

2

5

RD-YE

RD-BU

BK-YE

GN-WH

10/5

1 GN-WH

1

10/6

4/56

E:21

E:22

G:9

3/111

2

LIGHTS ON

FF = FRONT FOG

2

RF = REAR FOG

CEM

0 1 2

CAN

SUPPLY

POS 0

POS 1

POS 2

A:32 GN-BU

B:23

BK-YE

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

3 1 7

PWR

FF IND.

8

REOST LEV

ILLUM

GND

11

BK

BK

LIN

B:22

B:6

BK-YE

GN-OG

BK

C:6

BK

GN-YE

2

GN-YE

63/121

10/18

FOG

POSITION

TURN

POSITION

REVERSE

10/17

REVERSE

POSITION

10X/18C1

TURN

POSITION

10/46

FOG

C2:1

4

10X/18C

63/109

C1:4 C3:2

C4:1

C2:2

63/6

BK

C30

BK-BU

OG-GY

C30

GN-YE

BK

4 10X/18C1

BK-BU

BU-GY

2 10X/17C2

10/46

63/120

C30

10/18

FOG

TAIL1

TAIL2

TURN

STOP

BACK

C30

10/17

BACK

STOP

TURN

C:4

TAIL2 TAIL1 FOG

63/108

BK

BK BK-WH

C70

63/174

BK

BK

GND2 GND

C:1

1 10X/18C

BK BK

63/175

GND

GND2

C:2

BK

BK

C70

2 10X/17C

BK

BK

31/114

31/11

31/11

31/12

31/12

31/6

31/110

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 88


Group 35 Lighting

Follow-me-home lighting

30+

15/31

1

F18

2

4/56

RD-YE

E:21

1

1

F83

F82

2

C:31 C:24

2

64/41

21

64/43

21

BK

BK

BK

BK

3/126

A:18 3/127 A:18

DDM

PDM

A:3

B:14 BN-OG

A:3

BK-BU

A:12 A:12

B:14

BK-BU

BK-BU

CAN

A:9

B:12

BK

BK

C30

S40/V50/C70

S40/V50/C70

C30

CAN

A:9

B:12

BK

BK

C30

S40/V50/C70

S40/V50/C70

C30

64/333 6 12 64/333

64/35 6

12 64/35

BK BK

20

6/62

My

M x

64/41

M F

MEM

X MEM

Y

BK

BK

20

6/63

My

10/148 10/149

M x

64/43

M F

MEM

X MEM

Y

31/115 LHD

31/116 RHD

31/116 LHD

31/115 RHD

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 89


Group 35 Lighting

Interior lighting C30/S40/V50 1:2

30+

15/31

1

F18

2

1

2

F26

1

F4

2

RD-YE

RD

5

64/111

RD

RD-BU

B:7

3/1 30

5

50 S

X 15

B:1

BK

10/25

4 2

V50

OG-BU

64/48

13

OG-BU

V50

4/56

E:21

YE

2/89

R1

A:30 E:22

A

3/78

M

4

3

2

BK

BK

BK

63/196

BK

6

8

1

BK-BU

BK-BU

BK-RD

BK-RD

C30

S40

S40/V50

C30

10/24

4 2

OG-BU

S40

C30

63/173

OG-BU

OG-BU

F:24

C:20

1 1

F86

2

F47

2

1

2

F46

F73

1

2

CEM

D:7

BK

BK

A:38

CAN

C30

BK

C30

63/174

S40/V50

OG

63/139

OG

OG

10/97

1 2

10/102

1 2

BK

BK

A:25

LIN

BK

10/115

63/172

OG

2 1

10/29

OG

BK-BU

63/10

OG

D:3

H:4

1 3

10/22

A:3

A:4

A:5

A:1

BK-YE

D:12

A:28

10/114

3 2 1 21 21

1On

2Off

3 Ctsy

MAP READING

10/150

C30

2

3/117

A:2

4

1 3

BK-YE

10/150 S40/V50

2

3

1

C30

BK

63/211

BK

BK

S40/V50

BK

OG-YE

OG-YE

BK

OG-YE

OG-YE

OG-YE

OG-YE

63/213

BK

BK

BK

31/11 31/66

63/25

31/10

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 90


Group 35 Lighting

Interior lighting C30/S40/V50 2:2

64/41

21

BK

A:18

3/126 DDM

4/56

A

CEM

1

2

F82

1

2

F83

C:31 BK

C:24

BK

21 64/43

BK

3 64/41

BN-OG

CAN

A:11 A:9 64/41

BK

20

S40/V50 64/45

BK-OG

2

3/100 4 3/76

4

AJAR

A:2

A:3

12

2 1

LOCK

FEEDBACK

DLOCK

UNLOCK

CLOCK

BK

BK

M M M

CHILD

LOCK

CLOCK

UNLOCK

DLOCK

LOCK

FEEDBACK

1 2

2 1

F:21

F:19

F:20

F:18

63/198

BK

BK-BU

BK

S40/V50

S40/V50

63/193

BK

BK

64/43

2

64/47

64/45

10

A:18 3/127

PDM

3/110

BK

12

2 1

4

BK

3/77

4

BK

CAN

A:3

A:12

8

S40/V50

A:9

A:11

BN-WH

63/195

BK

63/192

BK

63/172

20

64/43

10

64/47

BK

BK

BK

BK

BK

63/171

BK

AJAR

CAN

BK

1 LHD

8 RHD

BK

1

LIN

3

12 2 1

M

M

M

CLOCK

UNLOCK

DLOCK

LOCK

FEEDBACK

AJAR

1 RHD

8 LHD

AJAR

LOCK

FEEDBACK

DLOCK

UNLOCK

CLOCK

CHILD

LOCK

BK

31/116 LHD

LHD 31/115

31/115 RHD 31/67

31/66 RHD 31/116

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 91


Group 35 Lighting

Interior lighting C70 1:2

63/171

BK

30+

BK-YE

BK

10/114

AM

BK RHD

BK LHD

63/212

BK-YE

BK

63/172

64/80 5 4 3 64/80A 3 4 5

BK-YE

BK-OG

RD-OG

RD-BK

RD-BK

RD-OG

BK-OG

3 2

3

1 2 10/27

10/26

2 1

2 1

15/31

1 1

F18 F26

2 2

RD

5 64/111

RD-BU

1

F4

2

3

64/10B

2 1

2 1

OG-BU

3/268

2 1 2 1 2 1

64/250

6

1

3

OG-YE

OG-BU

OG-YE

1

OG-YE

RD-YE

RD

B:7

3/1 30

5

50 S X 15

B:1

YE

OUT

3/78

5

BK

4

3

7

BK

1

5

IND

GND

64/250

BK

64/250

2

BK

BK

BK

10/24

4 2

10/24

4 2

BK

BK

64/250 1

BK

63/173

F:24

4/56

E:21

2/89

R1

A:30 E:22

CEM

A

M

BK

2

OG-BU

C:20

1 1

F86

2

F47

2

1

BK

BK

OG

63/139

OG

OG

10/97

1 2

10/102

1 2

OG

2

F46

F73

1

2

D:7

A:38

CAN

BK

BK

A:25

LIN

10/115

2 1

10/29

BK

BK-YE

1 3

12 14 2

BK-BU

OG

OG

63/10

OG

D:3

H:4

D:12

3/117

A:28

3

2

1

1On

2Off

3 Ctsy

10/22

1

9

63/211

BK

OG-YE

OG-YE

OG-YE

63/213

BK

BK

BK

31/67 31/66

31/11

63/25

31/10

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 92


Group 35 Lighting

Interior lighting C70 2:2

64/41

21

BK

A:18

3/126 DDM

4/56

A

CEM

1

2

F82

1

2

F83

C:31

C:24

BK

A:2

A:3

CAN

A:11 A:9 64/41

BK

20

BN-OG

BK

3/100 4

BK

63/198

12

2 1

BK

21 64/43

3 64/41

AJAR

LOCK

FEEDBACK

DLOCK

UNLOCK

CLOCK

F:19

BK

F:18

BK

BK

64/43

A:18 3/127

PDM

3/110

BK

12

2 1

4

CAN

A:3

A:12

A:9

A:11

BK

20

64/43

BK

1 LHD

8 RHD

BK

CAN

LIN

3

CLOCK

UNLOCK

DLOCK

LOCK

FEEDBACK

AJAR

1 RHD

8 LHD

BK

BK

BN-WH

63/195

31/116 LHD

LHD 31/115

31/115 RHD RHD 31/116

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 93


OG-BU

Group 35 Lighting

Instrument and control illumination

30+

15/31

5/1

1

2

F4

1

2

F18

DIM

10

9

OG

3

CAN

RD-BU

RD-YE

3/126

DDM

A:3

A:3

3/127

PDM

A:12

A:12

4/56

E:22

E:21

CAN

A:13

A:13

CAN

CEM

2/89

R1

LIN

3/128

LDM

LIN

3/129

RDM

F:15

F:30

B:8

B:9

CAN

LIN

1

2

F46

3/111

LIN

6

6

LIN

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

D:4

A:1

B:21

A:38

0 1 2

OG-BU

SUPPLY

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

9 12 11

BK-RD

OG-BU

64/10B 64/70

5

OG-BU C70

1

C70

64/25G

2

BK

BK BK

63/6

63/25

BK

HEADLLEV

PWR

13

FF IND.

REOST LEV

ILLUM

GND

C70

OG

OG

63/139

1 3/25

OPEN ROOF

CLOSE ROOF

GND

4

BK C70

63/86B

C70

BK

C70

C70

31/10

31/6

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 94


Group 35 Lighting, Accessories

Auxiliary lights

15/31

30+

RD

1

2

F4

RD-BU

4/56

E:22

FH1

1

1 5 4

2/63

R8

2

2 3

CEM

1

2

F58

CAN

LIN

D:8

D:9

A:28

GN

3/60

1

2

2/64

1

30

2

86

BK

63/25

87

5

87

3

85

4

BK

RD

RD

RD

BK

1

1

2

BK

BK

2

10/69 10/65

BK

RD

GN-RD

31/52

31/10

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 95


Group 36 Additional electrical equipment

Direction indicators and hazard warning flashers S40/V50

30+

3/254

SWM

C:8

C:9

CAN

5/1

15/31

DIM

1 1

F18 F4

9

10

CAN

4/56

RD-YE

2

E:21

2

E:22

BK C:31 C:24 BK

RD-BU

3/126

A:3

A:12

BK

1

21 64/41

F83

1

64/43 21

F82

A:18

2 CEM

2

3/127

DDM

PDM A:3

A:12

BK

A:18

B:12

B:14 CAN

CAN

CAN

B:14

B:12

LIN

A:9

A:9

6/62

10/15

E:38

C:9

B:19

B:3

C:10 E:39

6/63

10/16

My

M x

M F

MEM

X MEM

Y

BK

BU-OG

BK-BU

BU

BK-OG

BU

BK-BU

BK-OG

BU-RD

3/6 3

0 1

1

BU-RD

BU-RD

BU

My

M x

M F

BK

MEM

X MEM

Y

10/1 4

-

5

10/2 4

-

M

LOW HIGH PARK TURN

+

L

10/13

M

LOW HIGH PARK TURN

+

L

10/14

BK

BK

V50

BK-OG

1 1

V50

BK

63/121

10/18

S40

A:2

10/17

S40

A:1

63/109

BK

10/54

TURN

STOP

BACK

FOG

TAIL

S40

63/5

S40

TAIL FOG BACK

STOP

TURN

10/47

BK

63/120

GND

A:3

GND2

GND2

GND

A:4

63/108

64/41 20

20 64/43

C:2

10/18

BK

BK

BK

10/17

C:2

BK

BK

10/54

TAIL TURN FOG BACK

V50

V50

BACK

FOG

TURN

TAIL

10/47

BK

BK

C:4

C:6

BK-WH

BK

LHD 31/115

RHD 31/116

31/114

31/11

31/83

31/12

31/110 LHD 31/116

RHD 31/115

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 96


Group 36 Additional electrical equipment

Direction indicators and hazard warning flashers (Bi-Xenon) S40/V50

C:8

C:9

3/254

SWM

CAN

30+

5/1

15/31

1 1

DIM

F18 F4

9

10

CAN

4/56

RD-YE

2

E:21

2

E:22

BK C:31 C:24 BK

RD-BU

3/126

A:3

A:12

BK

1

21 64/41

F83

1

64/43 21

F82

A:18

2 CEM

2

3/127

DDM

PDM

A:3

A:12

BK

A:18

B:12

B:14 CAN

CAN

CAN

B:14

B:12

LIN

A:9

A:9

6/62

10/15

E:38

C:9

B:19

B:3

C:10 E:39

6/63

10/16

My

M x

M F

MEM

X MEM

Y

BU-OG

BU

BU

BK-OG

BU-RD

3/6 3

0 1

1

BU-RD

BU-RD

BU

My

M x

M F

BK

MEM

X MEM

Y

4 10/13

10/14

4

5

BK-OG

BK

63/5

63/109

20

BK

BK

64/41 64/43

C:2 10/18

10/17 C:2

BK

BK

BK

BK

BK-BU

BK-OG

BK-BU

BK

10/1

Gnd

Gnd

Ignitor

Ignitor

Gnd

10/2

Gnd

Lin

M

LEVELING

Supply

Low

Beam

ECU

Lit5

Actuator

BiLitronic

High

Beam

V50

Sidemarker

PARK

TURN

1

TURN

1

PARK

Sidemarker

High

Beam

V50

Actuator

BiLitronic

ECU

Lit5

Low

Beam

M

LEVELING

Supply Lin

BK

S40

S40

63/121

A:2

TURN STOP

BACK

FOG

10/18

TAIL

10/17

TAIL FOG BACK

BK

STOP

TURN

A:1

S40

S40

20

V50

C:6

BK

10/54

10/47

BK

GND

GND2

GND2

GND

A:3

A:4

BK

10/54

TAIL TURN FOG BACK

V50

BACK

FOG

TURN

TAIL

10/47

C:4

BK-WH

BK

63/120

63/108

LHD 31/115

RHD 31/116

31/114

31/11

31/83

31/12

31/110

LHD 31/116

RHD 31/115

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 97


M

-

Group 36 Additional electrical equipment

Direction indicators and hazard warning flashers C30/C70

30+

3/254

SWM

C:8

C:9

CAN

5/1

15/31

DIM

1 1

F18 F4

9

10

CAN

4/56

RD-YE

2

E:21

2

E:22

BK C:31 C:24 BK

RD-BU

3/126

BK

1

21 64/41

F83

1

64/43 21

F82

A:18

2 CEM

2

3/127

BK

A:18

A:3

DDM

PDM

A:3

A:12

A:12

B:14

B:12

CAN

CAN

CAN

B:14

B:12

LIN

A:9

A:9

6/62

10/15

E:38

C:9

B:19

B:3

C:10 E:39

6/63

10/16

MEM

MEM

X Y

M F

My

M x

BU-OG

BU

BK

BK-OG

BU-RD

3/6 3

0 1

1

BK

BU-RD

BU

My

M x

M F

BK

MEM

X MEM

Y

10/1 4

5

10/2 4

-

10/13

TURN

PARK

20 64/43

BK

63/109

BK

BK

63/5

BK

BK-OG

BK-WH

HIGH LOW

L

+

M

LOW HIGH PARK TURN

+

L

10/14

BK

BK

BK

63/121

1 1

10/18

64/41 20

BK

BK

10/54

10/17

C3:4

C4:3

BK

BK

BK

FOG

POSITION

TURN

POSITION

REVERSE

REVERSE

POSITION

TURN

FOG

POSITION

C1:4

BK-BU

C3:2 C4:1

BU-GY C2:2

BK

63/120

10/18 A:4

10/17

A:3

63/108

FOG

TAIL1

BK

TAIL2

TURN

STOP

BACK

BACK

STOP

TURN

TAIL2 TAIL1 FOG

GND2

GND

GND

GND2

A:2 A:1

63/174 63/175

BK

BK

10/47

C30

C30

C70

C70

LHD 31/115 31/114

31/11

RHD 31/116

31/11 31/83 31/12 31/12 31/110 31/116 LHD

31/115 RHD

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 98


Group 36 Additional electrical equipment

Direction indicators and hazard warning flashers (Bi-Xenon) C30/C70

30+

3/254

SWM

C:8

C:9

CAN

5/1

15/31

DIM

1 1

F18 F4

9

10

CAN

4/56

RD-YE

2

E:21

2

E:22

BK C:31 C:24 BK

RD-BU

3/126

BK

1

21 64/41

F83

1

64/43 21

F82

A:18

2 CEM

2

3/127

BK

A:18

A:3

DDM

PDM

A:3

A:12

A:12

B:14

B:12

CAN

CAN

CAN

B:14

B:12

LIN

A:9

A:9

6/62

10/15

MEM

MEM

X Y

M F

My

M x

E:38

BU-OG

BU

BK

C:9

BK-OG

B:19

BU-RD

B:3

BK

C:10 E:39

BU-RD

BU

6/63

My

M x

M F

MEM

X MEM

Y

10/16

10/1 9

LEVELING

M

HIGH BEAM

AUX.

ACTUATOR

MAIN

ELEC.

LOW

BALLAST

HI DRTL

10/13

PARK

TURN

3/6

0 1

3

1

5

10/14

TURN

9

AUX.

MAIN

PARK

HIGH BEAM

ACTUATOR

LOW

HI DRTL

BK

10/2

ELEC. M

BALLAST LEVELING

BK

BK

10/18

10/54

1

BK-OG

10/17

1

10/47

BK

BK

63/121

FOG

POSITION

TURN

C3:4

POSITION

REVERSE

REVERSE

POSITION

TURN

C4:3

FOG

POSITION

63/109

BK

C1:4

BK-BU

C3:2 C4:1

BU-GY C2:2

C30

BK

C30

64/41 20

63/120

10/18 A:4

63/5

10/17

A:3

63/108

20 64/43

FOG

TAIL1

TAIL2

TURN

STOP BACK

BACK

STOP

TURN

TAIL2 TAIL1 FOG

BK

BK

BK BK-WH

BK

BK

GND2 GND

GND

GND2

C70

A:2 A:1 C70

63/174 63/175

BK

BK

BK

BK

BK

LHD 31/115

RHD 31/116

31/114

31/11

31/11

31/83 31/12 31/12 31/110 31/116 LHD

31/115 RHD

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 99


Group 36 Additional electrical equipment

Windshield wiper/washer

30+

15/31

1

1

1

2

F17

F26

2

F3

2

6/1 LHD

WMM

M

LIN

4

1

3

WH-GN

BK

WH-GN

63/108

WH-GN

WH-GN

BK

1

4

2

6/1 RHD

WMM

M

LIN

RD RD

5

64/111

B:7 3/1

30

5

50 S X 15

B:3

RD-OG

GN-WH

4/56

G:3

A:17

E:20

R18

2/193

4 5

1

CEM

3

2

2

1

BK

CAN

LIN

F:16 F:14

R7 A

2/92

2 5 4

1 3

F48

A:28

R7 B

2/93

2 5 4

1 3

F68

A:45

64/79V

YE-BK

4

Petrol 5cyl

6/2 2

E:12

E:8 WH-BK

1

Petrol 5cyl

63/25

63/5

OG-BK

BK-WH

3/254

C:1 SWM

C:8

C:9

C:4

CAN

BK

YE-BK

64/79V

WH-BK

1

WH-BK YE-BK

BK BK

31/110 31/10

31/83

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 100


Group 36 Additional electrical equipment

Headlight washer

30+

15/31

1

F11

2

RD-BK

RD-WH

1(86) 3(30) 2/182

R9

4/56

2(85)

5(87)

CEM

CAN

G:11

BK-RD

BK-GN

B:2

LIN

OG-BK

3/111

A:40

GN-YE

5cyl

GN-YE GN-YE

2

64/79V

LIGHTS ON

FF = FRONT FOG

RF = REAR FOG

Petrol

0 1 2

SUPPLY

POS 0

POS 1

POS 2

FRONT FOG

REAR FOG

FUELLID

RF IND.

HEADLLEV

PWR

FF IND.

REOST LEV

ILLUM

GND

14 6 11

6/104

1

2

5cyl

Petrol

BK BK

5

64/79V

BK BK

63/6

BK BK

63/108

31/6

31/110

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 101


Group 36 Additional electrical equipment

Rear window wiper/washer C30/V50

30+

15/31

1

F26

2

1

F3

2

RD RD

5

B:7

3/1 30

64/111

5

RD-OG

50 S

X

15

B:3

GN-WH

4/56

A:17

E:20

F:16

F:14

CEM

CAN

R7 A

2/92

2 5 4

1 3

R11 A

2/16

2 5 4

2

F48

R7 B

2/93

2 5 4

4

5

1 3

1

R18

2/193

64/79V

YE-BK

4

Petrol 5cyl

YE-BK

2

6/2

E:12

E:8

1

WH-BK Petrol 5cyl

64/79V

WH-BK

1

WH-BK YE-BK

1

LIN

1 3

3

2

1

F68

2

C:33

C:34

A:28

A:45

6/32

3

2

1

BK

BK

BK

BK

BK

V50

C30

V50

C30

BK

63/196

64/48

6

3

5

1

GN-BU

V50

BK

WH-RD

WH-RD

BK

63/172 63/174

BK

C30

BK

BK BK

63/25

63/5

BK

OG-BK

BK-WH

C:1

C:8

C:9

C:4

3/254

SWM

CAN

31/66 31/11 31/10

31/83

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 102


Group 36 Additional electrical equipment

Rain sensor

30+

15/31

1

1

F3

F26

2

2

3/254

SWM

5/1

DIM

5

RD

RD

64/111

C:8

10

3/1

B:7

30

5

C:9

9

50 S X

15

B:3

CAN

CAN

4/56 E:20

CEM

7/149

RSM

1

3

2

BK

C70

63/14

OG-BK

WH-GN

WH-GN

BK

H:7

H:23

D:10

1

F69

2

2/193

5

4

3

R18

1

2

CAN

LIN

63/214

G:3 A:28 A:14

BK

1 LHD

4 RHD

63/12

3 LHD

2 RHD

BK

WH-GN

RD-OG

GN-HW

A:17

LIN

6/1

WMM

LIN

BK

63/108

BK

BK

M

63/25

BK

31/110

31/10

31/84

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 103


Group 36 Additional electrical equipment

Keyless vehicle C30/S40/V50 1:2

15/31

30+

4/93

1

F26

2

1

F4

2

1

F18

2

3/1

KEY IN

INHIBIT

SCU

RD RD

64/111 5

30

B:7

RD-BU

RD-YE

4/56 E:22 E:21

1

F55

2

1

CEM

CAN

1

2

F56

H:6

H:3

D:10

OG-YE

WH

BK

63/214

BK

BK

W/O MMS & RAIN SENSOR

1

2

3

4/119

RKE/

RRX

POWER

GY-RD

BU-RD

B:3

B:4

KVM

CAN

3 2 1 0

PATS

MODULE

3

2

1

0

C:32

C:41

WH-BK

OG-WH

315

IMOBILIAIZER SUPPLY

305

POWER

B1

LIN

GROUND

B2

B4

50

15

A:15 C:26

AUTO

OG

B:5

B:6

RD-BK

A:3

BK BK-YE

A:1

63/5

X

D:14

C:5

E:14

64/112

RD-GN RD-GN

8

RD-GN

63/88

10/3

C30

BK

2

BK

S40/V50

BK

1

3/35

3

RD-GN

63/196

1 64/48

63/172

BK

BK

BK

63/171

3/271

V50

S40

C30

1

RHD

LHD

MAN

64/48

10

7

2

BK-WH

BK-WH

WH-RD

V50

S40

C30

64/113

14

BK-YE

BK-YE

BK-YE

WH-RD

D:15

E:18

C:4

E:3

2 1

C30

S40/V50

MAN

2

63/174

BK C30 BK

63/172

BK

BK S40/V50

BK

BK

BK BK BK

63/109

63/108

31/83 31/11 31/66 31/66 31/67 31/110

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 104


Group 36 Additional electrical equipment

Keyless vehicle C30/S40/V50 2:2

S40/V50/C30

4/93

E:2

BK

64/43 LHD

64/41 RHD

11

BK

1

3/274 LHD

3/273 RHD

2

BN-WH LHD

BN-OG RHD

LHD PASSENGER DOOR

RHD DRIVER DOOR

E:22

A:14

A:23

D:22

A:5

D:2

BK

WH

BK

BK

BK

BK

C30

C30

12

5

6

13

14

15

C30

C30

BK

WH

BK

BK

BK

BK

3

5 P1

4

P2

1

2

6

1

2

2

4

3

3/110 LHD

3/100 RHD

BN-WH LHD

BN-OG RHD

2 1

RELEASE

M

CLUTCH

UNLOCK

LOCK

BK

1

BN-WH LHD

BN-OG RHD

63/195 LHD

63/198 RHD

3/127 LHD

3/126 RHD

PDM

A:11

64/729A

CAN

11

KVM

CAN

E:5

E:20

A:14

A:23

D:21

B:3

C:1

E:19

E:21

A:15

A:3

D:9

B:4

D:1

BN-RD

BN-BU

WH-RD

GY-RD

BN-GN

BN

YE

BK

BK

WH

BK

BK

BK

BK

C30

C30

64/47

11

12

16

17

13

14

15

64/41 LHD

64/43 RHD

14

15

BK

BK

WH

BK

BK

BK

BK

BK

BK

1

3

4 P1

5

P2

1

2

6

1

2

2

4

3

3/77

BN-YE

BN-YE

2 1

RELEASE

M

2 1

RELEASE

M

CLUTCH

UNLOCK

LOCK

UNLOCK

LOCK

1

BK

REAR RIGHT DOOR

BN-OG LHD

BN-WH RHD

63/192

S40/V50

1

2

S40/V50/C30

3/273 LHD

LHD DRIVER DOOR

3/274 RHD BN-OG LHD RHD PASSENGER DOOR

11

BK

1

2

BN-WH RHD

BN-OG LHD

12

BK

3

6

BN-WH RHD

C30 WH

5 P1

5

3/100 LHD

63/198 LHD

C30 BK

4

6 P2

3/110 RHD

63/195 RHD

BK

13

BK

3

CLUTCH 4

1

2

2

3/276

BK

3/126 LHD

3/127 RHD

DDM

A:11

64/729A

CAN

11

64/47

BK

10

63/171

BK

31/67

S40/V50

E:17

E:4

A:15

A:3

E:15

B:2

C:2

BN-GN

BN-YE

WH-GN

GY-OG

BN-WH

BN-BU

YE-BU

64/45

11

12

16

17

13

14

15

BK

BK

WH

BK

BK

BK

BK

1

3

4 P1

5

P2

1 3/275

2

2

1

2

6

3

1

2

3/76

BN-GN

BN-GN

2 1

RELEASE

M

CLUTCH

UNLOCK

LOCK

4

1

2

BK BK

REAR LEFT DOOR

BK

63/193

64/45

10

63/172

BK

A:22

A:21

A:22

A:21

WH-BK

GY-BK

64/49

1

2

WH-BK

GY-BK

WH-BK

GY-BK

1

2

2

1

P1

P2

P1

P2

16/132

S40/V50

16/132

C30

31/66

B:14

B:15

B:14

B:17

WH-GN

2

GY-OG 1

WH-GN

GY-OG

P2

1 P1

2

P1

P2

16/133

S40

16/133

V50

A:2

A:18

WH-VT

GY-WH

1

2

P1

P2

16/134

A:1

A:17

WH

GY

2

1

P2

P1

16/135

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 105


Group 36 Additional electrical equipment

Keyless vehicle C70 1:2

15/31

30+

4/93

1

F26

2

1

F4

2

1

F18

2

3/1

KEY IN

INHIBIT

SCU

RD RD

64/111 5

30

B:7

RD-BU

RD-YE

4/56 E:22 E:21

1

F55

2

CEM

CAN

1

2

F56

H:6 OG-YE

H:3 WH

D:10 BK BK

63/214

8

3

6

4/119

RKE/

RRX

POWER

GY-RD

BU-RD

B:3

B:4

KVM

CAN

3 2 1 0

PATS

MODULE

3 1

2

0

C:32

C:41

WH-BK

OG-WH

315

IMOBILIAIZER SUPPLY

A:15 C:26

AUTO

OG

B:5

B:6

305

A:3

B1 POWER

A:1

B2 GROUND

RD-GN

50

15

RD-BK

X

D:14

C:5

LIN

B4

E:14

64/112

RD-GN RD-GN

8

RD-GN

63/88

D:15

64/233

5

BK-YE

63/277

BK-YE

E:18

BK-YE

10/3 1

RHD

BK-WH

63/5

3

63/171

LHD

BK-WH

C:4

MAN

WH-RD

64/113

14

WH-RD

E:3

BK

3/271

1

7 64/233

2 1

BK

BK

MAN

2

63/172

BK BK

63/109

BK

BK

63/108

31/83 31/66 31/67 31/110

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 106


Group 36 Additional electrical equipment

Keyless vehicle C70 2:2

4/93

E:2

BK

64/43 LHD

64/41 RHD

11

BK

1

3/274 LHD

3/273 RHD

2

BN-WH LHD

BN-OG RHD

LHD PASSENGER DOOR

RHD DRIVER DOOR

KVM

CAN

E:22

A:14

A:23

D:22

A:5

D:2

BK

WH

BK

BK

BK

BK

BN-WH LHD

12

BK

3

BN-OG RHD

WH

5 P1

5

3/110 LHD

BK

4

6 P2

3/100 RHD

63/195 LHD

63/198 RHD

BK

13

BK

2

CLUTCH 1

14

15

BK

BK

1

2

6

4

3

2 1

RELEASE

M

UNLOCK

LOCK

BN-WH LHD

BN-OG RHD

3/127 LHD

3/126 RHD

PDM

A:11

64/729A

CAN

11

E:19

BK

64/41 LHD

64/43 RHD

11

BK

1

1

2

6

3/273 LHD

3/274 RHD

2

BN-OG LHD

BN-WH RHD

1

2

RHD PASSENGER DOOR

LHD DRIVER DOOR

E:21

A:15

A:3

D:9

B:4

D:1

BK

WH

BK

BK

BK

BK

BN-OG LHD

12

BK

3

BN-WH RHD

WH

5 P1

5

3/100 LHD

63/198 LHD

BK

4

6 P2

3/110 RHD

63/195 RHD

BK

13

BK

3

CLUTCH 4

14

15

BK

BK

1

2

1

2

2 1

RELEASE

M

UNLOCK

LOCK

BN-OG LHD

BN-WH RHD

3/126 LHD

3/127 RHD

DDM

A:11

64/729A

CAN

11

A:22

A:21

WH-BK

GY-BK

64/49

1

2

WH-BK

GY-BK

1

2

P1

P2

16/132

B:14

B:15

WH-GN

GY-OG

1 P1

2

P2

16/133

A:2

A:18

WH-VT

GY-WH

2

1

P1

P2

16/134

A:1

A:17

WH

GY

2

1

P2

P1

16/135

TP 39114202 C30/S40 (04-)/V50/C70 (06-) 2008 107


Group 36 Additional electrical equipment