2008 Carryall 295 SE and XRT 1550 SE Illustrated Parts ... - Mobilicab

More documents

Recommendations

Info

INDEX temperature indicator light, coolant 6-17 tester, continuity 14-5 tether 1-57 thermometer, battery 14-3 thermostat 13-11 thread-forming grease fitting 5-15 throttle shaft, carburetor 9-11 throttle valve 9-11 thrust button 12-7 thrust plate 12-7 tie rod end 5-5 tie wrap 1-51, 4-11, 4-15, 5-5, 9-15, 9-17, 12-3 tilt bed 1-49 tilt bed frame 1-49 tilt latch hand grip 1-49, 1-53 tire 2-3 tire assembly, black 2-3 tire, mud 2-3 tool accelerator pedal adjustment 14-3 belt tensioning, starter/generator 14-11 brake adjustment 14-3 brake cable release 14-3 brake pedal adjustment 14-3 brake pedal tension 14-3 cam installation 14-3 carburetor float level 14-7 charger bezel 14-3 clutch alignment 14-5 cT-wrench 14-5 drive clutch fixed sheave 14-5 drive clutch holder 14-5 drive clutch spider removal 14-5 driven clutch spring compression base 14-5 driven clutch spring compression collar 14-5 driven clutch spring compression nut 14-5 governor shaft installation 14-7 puller, special use 14-9 steering column bearing press 14-9 steering column retaining ring 14-9 steering wheel puller 14-9 transaxle axle seal 14-9 transaxle pinion seal 14-9 transmission 14-9 valve guide driver 14-9 valve seat cutter 14-5 tool kit, clutch 14-5 torque converter 11-11 torque roller 11-9, 11-13 touch-up paint 14-7 track, prop rod 1-47 transaxle axle seal tool 14-9 transaxle housing 12-23 transaxle pinion seal tool 14-9 transmission cable bracket 7-3 transmission chain 12-13, 12-25 transmission fork 12-13, 12-25 transmission tool 14-9 transmission, diesel, parallel shaft 12-25 transmission, gasoline, parallel shaft 12-13 tube axle 12-23 breather 7-13 carburetor air vent 9-3, 9-7 crankcase vent 9-13 fuel pickup 9-9 ROPS support 1-43 tube bumper kit 1-3 tune-up kit 14-9 turn signal light 1-7 T-wrench tool 14-5 U upright 5-7 urethane bushing 1-49 V valve 9-23, 9-25 breather 7-13 exhaust 7-45 fuel pickup tube 9-5 inlet 7-45 seat 7-11 valve assembly, reed 8-15 valve clearance adjuster screw 14-9 valve guide driver tool 14-9 valve guide reamer 14-9 valve seat cutter 14-5, 14-11 valve seat cutter guide 14-11 valve seat cutter tool 14-5 valve seat t-wrench 14-11 valve spring 8-17 valve spring compressor 14-11 valve spring retainer 8-17 valve stem 2-3 valve, carburetor 9-11 valve, exhaust 8-17 valve, float 9-11 valve, intake 8-17 valve, throttle 9-11 vent barb 9-3, 9-7 vent, housing, upper 12-23 vent, transmission 12-13, 12-25 volt ohm meter 14-11 voltage regulator 8-7 W warning light, low oil 6-15, 6-17 water flange 13-11 water pump 13-13 wedge, bearing puller 14-3 weight clutch 11-9, 11-13 weldment press 14-5 ROPS base front 1-13 weldment, accelerator pedal 9-19, 9-21 weldment, accelerator pedal bracket 9-19, 9-21 weldment, actuator bracket 1-51 weldment, air cleaner support 9-23, 9-25 weldment, brake pedal 4-13 weldment, Forward/Reverse shifter 12-3 weldment, Forward/Reverse shifter bracket 12-3 weldment, front dash dash weldment 1-13 weldment, lever, lost motion 9-21 weldment, receiver 5-15 weldment, shaft shift 12-17, 12-29 weldment, tilt bed frame 1-49 wheel 2-3 wheel, steering 1-39, 5-3 wire assembly 6-19, 6-21, 8-13, 9-5, 9-9 wire harness 1-5, 1-7, 6-5, 6-9, 8-7 wire harness, bed lift 1-51 wrap, tie 1-51, 4-11, 4-15, 5-5, 9-15, 9-17, 12-3 wrench, spanner 14-9 Y yoke, gear 14-7 yoke, support (steering) 5-5 Page i-16 2008 Carryall 295 SE and XRT 1550 SE Gasoline and Diesel Vehicles Illustrated Parts List
Page 1:
2008 Carryall 295 SE and XRT 1550 S
Page 4 and 5:
NOTE: This illustrated parts list r
Page 6 and 7:
CONTENTS SECTION 4 - BRAKE SYSTEMS
Page 8 and 9:
CONTENTS Cables - Kawasaki Gasoline
Page 11 and 12:
BODY AND TRIM 1 G E D
Page 13 and 14:
ITEM PART NO. DESCRIPTION 1 2 3 4 B
Page 15 and 16:
ITEM PART NO. DESCRIPTION 1 2 3 4 F
Page 17 and 18:
Page 19 and 20:
ITEM PART NO. DESCRIPTION 1 2 3 4 C
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
ITEM PART NO. DESCRIPTION 1 2 3 4 P
Page 27 and 28:
ITEM PART NO. DESCRIPTION 1 2 3 4 S
Page 29 and 30:
ITEM PART NO. DESCRIPTION 1 2 3 4 D
Page 31 and 32:
ITEM PART NO. DESCRIPTION 1 2 3 4 G
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
ITEM PART NO. DESCRIPTION QTY 1 2 3
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
ITEM PART NO. DESCRIPTION 1 2 3 4 R
Page 55 and 56:
Page 57 and 58:
ITEM PART NO. DESCRIPTION 1 2 3 4 L
Page 59 and 60:
ITEM PART NO. DESCRIPTION 1 2 3 4 T
Page 61 and 62:
ITEM PART NO. DESCRIPTION 1 2 3 4 E
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
WHEELS AND TIRES 2 G E D
Page 71 and 72:
ITEM PART NO. DESCRIPTION 1 2 3 4 W
Page 73 and 74:
DECALS 3 G E D
Page 75 and 76:
SAFETY DECALS - CA 295 SE AND XRT 1
Page 77 and 78:
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
BRAKE SYSTEMS 4 G E D
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
ITEM PART NO. DESCRIPTION 1 2 3 4 M
Page 91 and 92:
ITEM PART NO. DESCRIPTION MASTER CY
Page 93 and 94:
ITEM PART NO. DESCRIPTION 1 2 3 4 H
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
STEERING AND SUSPENSION 5 G E D
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
ELECTRICAL SYSTEM 6 G E D
Page 123 and 124:
6 G E D 000662-001 2008 Carryall 29
Page 125 and 126:
Page 127 and 128:
6 G E D 000662-002 2008 Carryall 29
Page 129 and 130:
Page 131 and 132:
ELECTRICAL COMPONENT BOX, GASOLINE
Page 133 and 134:
ITEM PART NO. DESCRIPTION ELECTRICA
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
DIESEL ENGINE - CLOSED BREATHER 7 G
Page 145 and 146:
ITEM PART NO. DESCRIPTION 1 2 3 4 K
Page 147 and 148:
Page 149 and 150:
ITEM PART NO. DESCRIPTION 1 2 3 4 O
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
ITEM PART NO. DESCRIPTION 1 2 3 4 H
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
ITEM PART NO. DESCRIPTION 1 2 3 4 M
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
ITEM PART NO. DESCRIPTION 1 2 3 4 I
Page 173 and 174:
Page 175 and 176:
ITEM PART NO. DESCRIPTION 1 2 3 4 6
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
ITEM PART NO. DESCRIPTION 1 2 3 4 N
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
ITEM PART NO. DESCRIPTION 1 2 3 4 V
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
KAWASAKI FH680D GASOLINE ENGINE 8 G
Page 199 and 200:
ITEM PART NO. DESCRIPTION KAWASAKI
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
ITEM PART NO. DESCRIPTION 1 2 3 4 V
Page 215 and 216:
Page 217 and 218:
FUEL, INTAKE, AND GOVERNOR SYSTEM 9
Page 219 and 220:
ITEM PART NO. DESCRIPTION FUEL SYST
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
Page 227 and 228:
CARBURETOR ASSEMBLY, KAWASAKI GASOL
Page 229 and 230:
CARBURETOR INSTALLATION - KAWASAKI
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
ITEM PART NO. DESCRIPTION 1 2 3 4 A
Page 237 and 238:
ITEM PART NO. DESCRIPTION 1 2 3 4 A
Page 239 and 240:
Page 241 and 242:
INTAKE DUCT AND AIR BOX ASSEMBLY -
Page 243 and 244:
EXHAUST SYSTEM 10 G E D
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
CLUTCHES 11 G E D
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
ITEM PART NO. DESCRIPTION QTY 1 2 3
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
DRIVETRAIN COMPONENTS 12 G E D
Page 275 and 276:
Page 277 and 278:
Page 279 and 280:
ITEM PART NO. DESCRIPTION FRONT DIF
Page 281 and 282:
Page 283 and 284:
Page 285 and 286:
Page 287 and 288:
Page 289 and 290:
TRANSMISSION SHIFT SHAFT AND BELL C
Page 291 and 292:
TRANSMISSION SHIFT SHAFT AND BELL C
Page 293 and 294:
Page 295 and 296:
Page 297 and 298: ITEM PART NO. DESCRIPTION 1 2 3 4 T
Page 299 and 300: ITEM PART NO. DESCRIPTION TRANSMISS
Page 301 and 302: TRANSMISSION - DIESEL VEHICLES, SHI
Page 303 and 304: TRANSMISSION - DIESEL VEHICLES, SHI
Page 305 and 306: RADIATOR AND COOLANT SYSTEM (DIESEL
Page 307 and 308: ITEM PART NO. DESCRIPTION 1 2 3 4 R
Page 309 and 310: ITEM PART NO. DESCRIPTION 1 2 3 4 C
Page 311 and 312: ITEM PART NO. DESCRIPTION 1 2 3 4 C
Page 313 and 314: COOLING SYSTEM CLAMPS, HOSES, AND H
Page 315 and 316: ITEM PART NO. DESCRIPTION 1 2 3 4 W
Page 317 and 318: ITEM PART NO. DESCRIPTION 1 2 3 4 W
Page 319 and 320: ITEM PART NO. DESCRIPTION 1 2 3 4 B
Page 321 and 322: MAINTENANCE AND SERVICE TOOLS 14 G
Page 323 and 324: ITEM PART NO. DESCRIPTION 1 2 3 4 M
Page 325 and 326: ITEM PART NO. DESCRIPTION MAINTENAN
Page 331: ITEM PART NO. DESCRIPTION MAINTENAN
Page 334 and 335: INDEX 101871001 14-3 101879401 5-5
Page 336 and 337: INDEX 102604301 7-27 102604401 7-23
Page 338 and 339: INDEX 102729401 7-37 102729501 7-37
Page 340 and 341: INDEX 103218501 4-15 103218901 1-37
Page 342 and 343: INDEX boot, half shaft 5-9 bottle,
Page 344 and 345: INDEX FNR shifter cable 9-15, 9-17
Page 346 and 347: INDEX seat 1-35, 1-37 panel center
Page 352: Club Car, Inc. P.O. Box 204658 Augu
show all

2008 Carryall 295 SE and XRT 1550 SE Illustrated Parts ... - Mobilicab

Create successful ePaper yourself

Delete template?

Save as template?