NewV Lac LM Gloss Lacquer 40UC9300 - Stehlin Hostag UK

Revision Date 17/03/11
Revision 2
Supersedes date 15/08/11
SAFETY DATA SHEET
NEWV LAC LM GLOSS LACQUER
SECTION 1: IDENTIFICATION OF THE SUBSTANCE/MIXTURE AND OF THE COMPANY/UNDERTAKING
1.1. Product identifier
Product name
Product No.
NEWV LAC LM GLOSS LACQUER
40UC9300
1.2. Relevant identified uses of the substance or mixture and uses advised against
Identified uses
UV Curing Varnish
1.3. Details of the supplier of the safety data sheet
Supplier
1.4. Emergency telephone number
SECTION 2: HAZARDS IDENTIFICATION
2.1. Classification of the substance or mixture
STEHLIN HOSTAG INK UK LTD
UNIT D4 LINKMEL CLOSE
QUEENS DRIVE INDUSTRIAL ESTATE
NOTTINGHAM
NG2 1NA
Tel : 0115 9860477
Fax : 0115 9862681
e-mail: sds@stehlin.co.uk
Classification (EC 1272/2008)
Classification (1999/45/EEC)
Physical and Chemical
Hazards
Human health
Environment
Xi;R36/38.
Not classified.
Skin Irrit. 2 - H315;Eye Irrit. 2 - H319
Not classified.
Human health
Irritating to eyes and skin. This material has been shown to be a severe skin irritant and an allergic sensitiser.
Physical and Chemical Hazards
Uncontrolable polymerisation of the product with generation of heat can occur if the product is stored at temperatures higher
than 60 degrees centigrade or if it is exposed to direct sunlight.
2.2. Label elements
Label In Accordance With (EC) No. 1272/2008
Signal Word
Hazard Statements
Precautionary Statements
Warning
H315
H319
P280
Causes skin irritation.
Causes serious eye irritation.
Wear protective gloves/protective clothing/eye protection/face
protection.
1 / 5

NEWV LAC LM GLOSS LACQUER
P305+351+338
IF IN EYES: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue rinsing.
P313
Get medical advice/attention.
Supplementary Precautionary Statements
P264
Wash … thoroughly after handling.
P302+352 IF ON SKIN: Wash with plenty of soap and water.
P321
Specific treatment (see … on this label).
P332+313 If skin irritation occurs: Get medical advice/attention.
P337
If eye irritation persists:
P362
Take off contaminated clothing and wash before reuse.
2.3. Other hazards
SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS
3.2. Mixtures
Acrylated Oligomer

Skin contact
NEWV LAC LM GLOSS LACQUER
Remove contaminated clothing and shoes. Wash skin thoroughly with mild soap and water. Seek medical advice.
Eye contact
In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
4.2. Most important symptoms and effects, both acute and delayed
4.3. Indication of any immediate medical attention and special treatment needed
SECTION 5: FIREFIGHTING MEASURES
5.1. Extinguishing media
Extinguishing media
Extinguish with foam, carbon dioxide, dry powder or water fog.
Unsuitable extinguishing media
Do not use water jet as an extinguisher, as this will spread the fire.
5.2. Special hazards arising from the substance or mixture
Hazardous combustion products
May polymerise.
5.3. Advice for firefighters
Special Fire Fighting Procedures
Keep away from heat, no naked lights. No smoking Use water only to cool containers until well after the fire is out.
Excercise caution when fighting any chemical fire.
Protective equipment for fire-figthers
Do not enter fire area without proper protective equipment, including respiratory protection
SECTION 6: ACCIDENTAL RELEASE MEASURES
6.1. Personal precautions, protective equipment and emergency procedures
Equip clean up crew with proper protection. Wear protective clothing as described in Section 8 of this safety data sheet.
6.2. Environmental precautions
Prevent entry into drains. Prevent from entering into soil, waterways and groundwater. Notify authorities if liquid enters
sewers or public waters
6.3. Methods and material for containment and cleaning up
Should be prevented from entering drains. Clean up any spills as soon as possible, using absorbent material to collect it.
Use suitable disposal containers.
6.4. Reference to other sections
SECTION 7: HANDLING AND STORAGE
7.1. Precautions for safe handling
Avoid all unnecessary exposure. Use splash goggles when eye contact due to splashing is possible. Handle in accordance
with good industrial hygiene and safety procedures. For even minor contact, immediately remove contaminated
clothing/wash skin thoroughly with mild sopa/water. Avoid all unnecessary exposure. Where contact with eye or skin is
likely, wear suitable protection. Provide local exhaust or general room ventilatin to minimize exposure to dust. Wash
hands and other exposed areas with mild soap and water before eating, drinking or smoking and when leaving work.
7.2. Conditions for safe storage, including any incompatibilities
Provide local exhaust or general room ventilation to mimimize dust and/or vapour concentrations. Keep at temperature no
exceeding 60 degrees C. Store in tightly closed original container in a dry, cool and well-ventilated place. Store away from:
Avoid all heat sources including direct sunglight. Keep away from oxidising agents, strongly alkaline and strongly acid
materials.
7.3. Specific end use(s)
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
8.1. Control parameters
8.2. Exposure controls
Engineering measures
Provide local exhaust or general room ventilation to minimise dust and/or vapour concentrations.
3 / 5

Respiratory equipment
NEWV LAC LM GLOSS LACQUER
No special respiratory protection equipment is recommended under normal conditions of use with adequate ventillation.
Hand protection
PVC or natural rubber gloves are not recommended. Use Nitrile or neoprene rubber gloves.
Eye protection
Wear splash-proof eye goggles to prevent any possibility of eye contact.
Hygiene measures
Use appropriate hand lotion to prevent defatting and cracking of skin. When using do not eat, drink or smoke.
Skin protection
Wear suitable protective clothing where prolonged contact is likely.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
9.1. Information on basic physical and chemical properties
Appearance
Colour
Odour
Solubility
Liquid
Initial boiling point and boiling range >100
Vapour pressure
Flash point (°C) >100
9.2. Other information
Colourless.
Characteristic.
Insoluble in water

NEWV LAC LM GLOSS LACQUER
SECTION 13: DISPOSAL CONSIDERATIONS
General information
Dispose of in a safe manner in accordance with local/national regulations.
13.1. Waste treatment methods
SECTION 14: TRANSPORT INFORMATION
General
Not classified according to transport regulations for dangerous goods.
14.1. UN number
14.2. UN proper shipping name
14.3. Transport hazard class(es)
14.4. Packing group
14.5. Environmental hazards
14.6. Special precautions for user
14.7. Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code
SECTION 15: REGULATORY INFORMATION
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
15.2. Chemical Safety Assessment
SECTION 16: OTHER INFORMATION
Revision Comments
Converted to GHS format
Issued By
Revision Date 17/03/11
Revision 2
Supersedes date 15/08/11
SDS No. 10874
Safety Data Sheet Status
B.A Hayden HSQE Manager
Approved.
Date issued: 17/02/12
Risk Phrases In Full
R36/38
R36
R43
Hazard Statements In Full
H319
H315
H317
Irritating to eyes and skin.
Irritating to eyes.
May cause sensitisation by skin contact.
Causes serious eye irritation.
Causes skin irritation.
May cause an allergic skin reaction.
Disclaimer
This information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in
any process. Such information is, to the best of the company's knowledge and belief, accurate and reliable as of the date indicated. However, no
warranty guarantee or representation is made to its accuracy, reliability or completeness. It is the user's responsibility to satisfy himself as to the
suitability of such information for his own particular use.
5 / 5