BAR NONE - Truekleen

BAR NONE
Industrial Lotion Hand & Body Soap
DESCRIPTION
This soap-like product is a better cleaner and
kinder to the skin than soap. Instead of being
made from oils and caustics, as soaps have
been for thousands of years, Bar None is made
from modern synthetic surfactants derived
from pure coconut oil. All of the natural
glycerin of the coconut oil is retained and
lotionizers are added for maximum kindness
to the skin. Softness to the skin and better
cleaning are noticeable after every use, but
especially against greasy industrial soil and
especially in hard water areas.
BENEFITS
SOAPLESS: Has a similar appearance to
liquid soap, can be used through standard
soap dispensers, etc., but Bar None has none of the negatives of soap.
HARD WATER TOLERANT: There’s no curdling or loss of cleaning ability
when used with hard water.
BETTER AGAINST GREASY SOIL: The synthetic detergent base
outcleans soap against greasy, oily soil.
MORE NEUTRAL pH: Caustics used in making soap result in a higher pH
than required in Bar None.
ATTRACTIVE FRAGRANCE: Bar None will never develop that sour smell
that some soaps do with age.
HOW TO USE
Wet the hands, the hair or skin with water. Then add a
few drops of Bar None. Rub to a rich lather to clean.
Rinse off soil and “Bar None” with water.
USES
For washing one’s hands, hair and the complete body to
remove dirt, grime and greasy oily soil.
SPECIFICATIONS
APPEARANCE...........................Pearly orange/pink
NON-AQUEOUS......................................14% ± 0.5
ODOR...............................................Cherry/almond
SPECIFIC GRAVITY...........................1.030 ± 0.005
DENSITY.......................................8.60 ± 0.05 lb/gal
BOILING POINT.....................................Near 212°F
pH...............................................................9.0 ± 0.5
FLASH POINT...................................None to boiling
STABILITY..................................One year minimum
PRODUCT CODE..............................................IHC
TrueKleen Products is a division of The Bullen Companies, Folcroft, PA 19032
Phone 610-534-8900 • Fax 610-534-8912 • www.bullenonline.com

SECTION 2 - HAZARDOUS INGREDIENTS
MSDS PREPARED BY AND PRODUCT MANUFACTURED BY THE BULLEN COMPANIES
1640 DELMAR DRIVE, FOLCROFT, PA. 19032 • EMERGENCY PHONE 215/724-8100
MATERIAL SAFETY DATA SHEET
(Prepared According to 29 CFR 1910.1200)
SECTION 1 - PRODUCT IDENTIFICATION
Trade Name BAR NONE INDUSTRIAL LOTION HAND & BODY SOAP
Product Type Hand Soap
CHEMICAL NAME/COMMON NAME CAS NO. PERCENT(optional) TLV(Source)
Sodium Lauryl Sulfate 151-21-3
Signs and Symptoms of Overexposure(Chronic) None known
Medical Conditions
Aggravated by Overexposure None known Carcinogen/Suspect Carcinogen Ingredients NTP OSHA IARC
X
NONE
Do not get in eyes.
x x x
Other ingredients in this product are : Less than 1% by weight or less than 0.1% for carcinogens Not hazardous Declared to be Trade Secret
SECTION 3 - PHYSICAL DATA
Boiling point(°F.) Near 212 Specific Gravity(H2O=1.0) (± 0.005) 1.030
pH (± 0.5) 9.0
Vapor Pressure(mm Hg)
Unknown
Vapor Density(Air=1)
Unknown
Solubility in water x Complete Insoluble Emulsifiable (or Dispersible) Slight (or Partial)
Evaporation Rate(vs. H2O) Faster Slower About the Same
Appearance and Odor
Pearly Orange/pink Liquid, Cherry/almond Odor
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
Flash Point( T.C.C. ) °F. x None to Boiling Flammable Limits Upper
Lower
Unknown Unknown
Extinguishing Media CO2, dry chemical, foam, water spray.
Special Firefighting Procedures Do not enter confined fire-spaces without protective clothing and self-contained air supply.
Unusual Fire and Explosion Hazards None known.
SECTION 5 - REACTIVITY DATA
Stability Stable Incompatibility Strong oxidizers
Hazardous Decomposition Products Carbon monoxide and other unidentified organic gases may occur during incomplete combustion.
SECTION 6 - HEALTH HAZARDS
x
Primary Routes of Exposure Eye Skin Oral Inhalation Other
Signs
and Symptoms
of Overexposure
(Acute)
Eyes
Skin
Ingestion
Inhalation
Prolonged or repeated contact of concentrated product with eyes will cause irritation and reddening. May cause skin irritation with certain individuals. Ingestion of
this product may cause exposed person to vomit and may result in some diarrhea.
SECTION 7 - EMERGENCY AND FIRST AID PROCEDURES
Flush immediately with water for at least 15 minutes. If persistent irritation occurs, call a physician.
Not applicable
Drink large quantities of milk or water. Call a physician.
Not applicable
SECTION 8 - SPECIAL PROTECTION INFORMATION
Respiratory Protection Not needed under normal conditions of use.
Ventilation Requirements Local Exhaust x Mechanical Other
Protective Gloves Not required. Eye Protection Not required Other Protective Clothing Not required for normal use
SECTION 9 - SPILL OR LEAK PROCEDURES
Steps to be Taken
if Released or Spilled
Waste Disposal Methods
Precautions to be Taken
in Handling and Storage
Dilute with much water and flush to drain.
Dispose of in accordance with applicable Federal, State and Local ordinances.
SECTION 10 - STORAGE AND HANDLING INFORMATION
X
The health hazards given on this Material Safety Data Sheet apply to this product in its concentrated form(as supplied) and may differ significantly at use dilution.
The signs and symptoms of overexposure apply only to negligence in handling or misuse of the concentrated product and not to the routine exposure to the
product,if diluted, under conditions of ordinary use.
IHC
DATE PREPARED___________________
October 23, 2003
DATE PREPARED JANUARY 20, 2011