chevrolet municipal vehicles technical manual - Adamson Industries

More documents

Recommendations

Info

wIrINg DIagram – tahoE PPv aND 5w4 | 25 wIRING PROVISIONS FOR 12-VOLT BATTERY POwER SUPPLY Your vehicle is equipped with wiring provisions for a 12-volt battery power supply. Refer to the following information when adding electrical system. The wiring harness is located below the instrument panel near the center of the vehicle. The following information describes the breaker and relay location and provides a wiring diagram to aid in connecting customer equipment. The 12-volt battery power is supplied through two underhood mega fuses, one 125-amp and one 60-amp. This underhood power is fed to the breaker/relay center via a harness that passes through the driver side front of the dash, and routed across the instrument pane to a position forward of the glove box. The breaker/relay center is mounted to the instrument panel structure forward of the glove box. The center includes a plastic bracket, two relays, two 30-amp breakers and three 50-amp mega circuit breakers. Two 30-amp breakers supply power from the underhood 60-amp mega fuse through the contacts of the control relays to a 12-gauge (3.0 mm2) blunt cut wires. These two blunt cut leads are part of wire coiled under the instrument panel near the center of the vehicle. Each relay is operated by a 0.5 mm2 blunt cut, light or dark blue control lead includes in a 3-foot (91 cm) loop of wire under the instrument panel. Three 50-amp mega circuit breakers, protected by three fusible links, supply power directly from the underhood 125-amp mega fuse through three, 10-gauge (5.0 mm2 ) wires. Two of the wires are routed through the body harness to a split buss junction block to the left rear of the cargo area and secured near the jack and tools. This 3-foot (91 cm) of coiled wires can be accessed by removing the cup holder on the top of the trim panel. The third 10-gauge (5.0 mm2 ) wire is a blunt cut lead, which is part of the 3-foot (91 cm) loop of wire coiled under the instrument panel near the center of the vehicle. Note: Wiring diagrams for these options are shown in the Police Package owner’s <strong>manual</strong> supplement (shipped in glove box). An 8-gauge (8 mm2 ) ground lead is also provided and it is located under the front passenger sill plate. It can be accessed by removing the sill plate and pulling the loop of wire at the front of the plate, the lead is 3-feet (91 cm) long. Blunt cut ignition control power and signal circuits are also included in the wire coiled under the instrument panel near the center of the vehicle. They include: • A yellow, 20-gauge (0.5 mm2 ) circuit, HOT in ACCESSORY, RUN or RAP (Retained Accessory Power)* • Pink, 20-gauge (0.5 mm 2 ) circuit, HOT in START/RUN (7-amp maximum load) • A yellow/black, 20-gauge (0.5 mm 2 ) transmission park signal. This circuit provides switched power when the transmission is in P (Park) and the engine is running. The circuit is at 0-volts when the transmission is in any other position, i.e., R (Reverse), N (Neutral), D (Drive) or M (Manual 6-1). Note that the circuit is also at 12-volts with the transmission in P (Park) and the ignition is OFF. To avoid the possibility of undesired parasitic electrical load with the ignition is OFF it is suggested that the Park/ Signal circuit be isolated by routing it through the normally open contacts of a customer furnished ignition controlled relay.* • A dark green/white, 20-gauge (0.5 mm 2 ) Vehicle Speed Signal (VSS) provides 4,000 pulses per mile. The breaker and relay center is located behind and above the instrument panel storage compartment. Remove contents from the storage tray. Using the tab at the back of the compartment drop the tray down gently toward the floor. You will find the breaker/relay center above the right rear corner of the storage compartment. The bracket is attached to the instrument panel structure with two screws. It will hang from the hinge. * These two circuits share a 15-amp fuse. (10-amp combined maximum load) REVISIONS MARKED IN BLUE 1/24/2011 2011 Chevrolet Municipal Vehicles Technical Manual
26 | wIrINg DIagram – tahoE PPv aND 5w4 wIRING DIAGRAM FOR 12-VOLT BATTERY POwER SUPPLY AND AUXILIARY BATTERY POwER JUNcTION BLOcK * Zero volts out of PARK, engine running; HOT in PARK with ignition OFF. * Note: Wiring diagrams for these options are shown in the Police Package owner’s <strong>manual</strong> supplement (shipped in glove box). 2011 Chevrolet Municipal Vehicles Technical Manual REVISIONS MARKED IN BLUE 1/24/2011
Page 1 and 2:
2011 CHEVROLET MUNICIPAL VEHICLES T
Page 4 and 5:
Law ENforcEmENt ProDuct couNcIL DIs
Page 6:
Terry Scissons Royal Canadian Mount
Page 9 and 10:
8 | DIstrIct saLEs maNagErs commErc
Page 12 and 13:
caPrIcE PoLIcE PackagE vEhIcLE PPv
Page 14 and 15:
caPrIcE PoLIcE PackagE PPv - 9c1 |
Page 16 and 17:
caPrIcE DEtEctIvE PoLIcE PackagE vE
Page 18 and 19:
caPrIcE DEtEctIvE PoLIcE PackagE -
Page 20 and 21:
caPrIcE PoLIcE PackagE 9c1 aND 9c3
Page 22 and 23:
caPrIcE 9c1 aND 9c3 sPEcIaL fEaturE
Page 24 and 25:
caPrIcE 9c1 aND 9c3 sPEcIaL EquIPmE
Page 26 and 27:
caPrIcE 9c1 aND 9c3 sPEcIaL EquIPmE
Page 28 and 29:
can specialty vehicle equipment (e.
Page 30 and 31:
caPrIcE PoLIcE PackagE aIr bags | 1
Page 32 and 33:
C D E C D E 880 mm (26.7 in.) 880 m
Page 34 and 35:
MODULE Radio 9 9 700. WH 0.3 Radio
Page 36 and 37:
LF_RAD_RTN LF_RAD_OUT RF_RAD_RTN RF
Page 38 and 39:
a. Always maintain a safe following
Page 40:
NotEs | 29 REVISIONS MARKED IN BLUE
Page 43 and 44:
2 | ImPaLa PoLIcE PackagE - 9c1 thi
Page 45 and 46:
4 | ImPaLa PoLIcE PackagE - 9c1 POW
Page 47 and 48:
6 | ImPaLa uNDErcovEr PoLIcE Packag
Page 49 and 50:
8 | ImPaLa uNDErcovEr PoLIcE Packag
Page 51 and 52:
10 | ImPaLa 9c1 aND 9c3 PoLIcE Pack
Page 53 and 54: 12 | sPEcIaL PaINt avaILabLE wIth 9
Page 55 and 56: 14 | ImPaLa 9c1 aND 9c3 PaINt schEm
Page 57 and 58: 16 | ImPaLa 9c1 aND 9c3 PaINt schEm
Page 59 and 60: 18 | ImPaLa 9c1 aND 9c3 sPEcIaL Equ
Page 65 and 66: 24 | aIr bags faq can the installat
Page 67 and 68: 26 | aIr bag DImENsIoNs - ImPaLa 9c
Page 69 and 70: 28 | wIrINg DIagram - ImPaLa 9c1 aN
Page 75 and 76: 34 | aNtI-Lock brakINg systEm faq G
Page 77 and 78: Date: April 1, 2010 To: Whom it may
Page 80 and 81: UpDAtES for 2011 new features • S
Page 82 and 83: tahoE 2wD PoLIcE PackagE PPv | 3 EX
Page 84 and 85: AVAILABLE EXTERIOR COLORS GHA Mocha
Page 86 and 87: tahoE 2wD PoLIcE PackagE PPv - oPtI
Page 88 and 89: UpDAtES for 2011 new features • (
Page 90 and 91: tahoE 4wD sPEcIaL sErvIcE - 5w4 | 1
Page 92 and 93: AVAILABLE EXTERIOR COLORS GHA Mocha
Page 94 and 95: tahoE 4wD sPEcIaL sErvIcE 5w4 - sPE
Page 96 and 97: tahoE PPv aND 5w4 sPEcIaL EquIPmENt
Page 98 and 99: tahoE PPv aND 5w4 sPEcIaL EquIPmENt
Page 100 and 101: can the installation of push bumper
Page 102 and 103: aIr bag DImENsIoNs - tahoE PPv aND
Page 106 and 107: wIrINg DIagram - tahoE PPv aND 5w4
Page 112 and 113: GM offers Anti-Lock Brake Systems a
Page 114: Date: April 1, 2010 To: Whom it may
Page 117 and 118: 2 | tahoE hybrID muNIcIPaL PackagE
Page 123 and 124: 8 | aIr bags faq can specialty vehi
Page 125 and 126: 10 | aIr bag DImENsIoNs - tahoE hyb
Page 127 and 128: 12 | aIr bag DImENsIoNs - tahoE hyb
Page 129 and 130: 14 | aNtI-Lock brakINg systEm a. Al
Page 132 and 133: UpDAtES for 2011 EXPrEss traNsPort
Page 134 and 135: POWERTRAIN EXPrEss traNsPort vaN -
Page 136 and 137: EXPrEss traNsPort vaN - 1Ls aND 2Ls
Page 138 and 139: can specialty vehicle equipment (e.
Page 140 and 141: aIr bag DImENsIoNs - EXPrEss traNsP
Page 142 and 143: GM offers Anti-Lock Brake Systems a
Page 144: NotEs | 13 2011 Chevrolet Municipal
Page 147 and 148: 2 | suburbaN commErcIaL fLEEt - 1fL
Page 155 and 156:
10 | aIr bags faq can specialty veh
Page 157 and 158:
12 | aIr bags toP viEW oF inStRuMEn
Page 159 and 160:
14 | aIr bags hEaD CuRtain anD FRon
Page 161 and 162:
16 | aNtI-Lock brakINg systEm a. Al
Page 164 and 165:
sILvEraDo 2500hD crEw cab 4wD work
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
can the installation of push bumper
Page 178 and 179:
SiDE viEW oF DRivER SiDE aiR baG DE
Page 180 and 181:
GM offers Anti-Lock Brake Systems a
Page 182:
For Information 1-800-FLEET-OP (353
show all

chevrolet municipal vehicles technical manual - Adamson Industries

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?