chevrolet municipal vehicles technical manual - Adamson Industries

EXTERIOR FEATURES
aSSiSt StEPS Black, mounted between front and rear wheels
DEFoGGER Electric, rear window
DooR hanDLES Black
suburbaN commErcIaL fLEEt - 1fL | 3
DooR LoCkS Power programmable with lockout protection, door lock cylinder no longer available on passenger front door and rear liftgate
FaSCia, FRont Color – keyed (Black when special paint is ordered)
FaSCia, REaR Color – keyed (Black when special paint is ordered)
hEaDLaMPS Dual halogen composite with automatic exterior lamp control and flash-to-pass feature
kEyLESS EntRy Includes two transmitters
kEyS Single two-sided, random code, for ignition and drivers door only
LuGGaGE RaCk Roof mounted Black side rails (center rails and luggage rack delete are available)
MiRRoRS Outside heated power-adjustable, manual-folding, Black
REaR LiFtGatE Liftgate/liftglass, with rear window washer and wiper (power liftgate not available)
RECovERy hookS Two front, chrome
WinDShiELD WiPERS Intermittent wet-arm with flat blade and pulse washers
cHASSIS FEATURES
aLtERnatoR 145-amp on 3/4 ton 160-amp on 1/2 ton models and with VYU Snow Plow Prep Package on 4-wheel drive
3/4 ton models; not available on 2-wheel drive 3/4 ton models
battERy Heavy-duty 600 cca, maintenance-free, rundown protection and retained accessory power
bRakES 4-wheel antilock, 4-wheel disc, vac power 1/2 ton models only; 4-wheel antilock, 4-wheel disc with hydro boost
3/4 ton models only
EnGinE See engine, transmission and axle chart on page 4
FRaME Modular with hydro formed frame rails
FuEL tank CaPaCity 31 gallon (117.3 liters) on 1/2 ton models and 39 gallon (148 liters) on 3/4 ton models
oiL CooLERS Auxiliary transmission oil cooler, heavy-duty air-to-oil (requires 3.42 axle ratio on 1/2 ton models) standard with 3/4 ton models
StabiLitRak Vehicle stability control system with proactive roll avoidance
StEERinG Power, rack and pinion
SuSPEnSion, FRont Coil-over-shock with stabilizer bar 1/2 ton models only; independent with torsion bar 3/4 ton only
SuSPEnSion, REaR Multi-link with coil springs 1/2 ton model only; multi-stage leaf springs 3/4 ton models only
tiRES See tire and wheel chart on page 5
tiRE PRESSuRE MonitoR CHECK TIRE PRESSURE will show on Driver Information Center (no sensor in spare tire)
tiRE, SPaRE See tire chart on page 5
tiRE, SPaRE CaRRiER Lockable outside, winch-type mounted under frame at rear
tRaiLERinG EQuiPMEnt Heavy-duty includes trailering hitch platform, 7-wire harness with independent fused trailering circuits mated to a 7-way sealed
connector and VR4 2-inch trailering receiver
tRanSFER CaSE Active single-speed, electronic autotrac with rotary controls, does not include Neutral (N). Cannot be dinghy towed, requires GU4 3.08
rear axle. Not available on 2WD models, 3/4 ton models or with K5L heavy-duty trailering package (2-speed transfer case is available)
tRanSMiSSion 6-speed automatic, see engine, transmission and axle chart on page 4
WhEELS See wheel and tire chart on page 5
REVISIONS MARKED IN BLUE 1/5/2011 2011 Chevrolet Municipal Vehicles Technical Manual