Power equipment for your service vehicle - Zip's Truck Equipment

Power equipment for your service vehicleGoodall ManufacturingGoodall Mfg. is proud to be an American manufacturer, building quality products in the U.S. for nearly 70 years.Our corporate office and manufacturing center is in Eden Prairie, MN, with distribution covering all of North America.From sales to technical support,we’re there when you need us.Your phone calls will be answered bya live person each time you call.Our Internal Engineering and CADDevelopment staff respond to customerrequests and conduct ongoing researchand development to make sure thatGoodall continues to offer new andinnovative products.Lean manufacturing allows us to havethe product available when you need it.From an inventory of components throughfinished goods, we’re prepared to giveyou just the product you need.Goodall has 70 years of industry andmanufacturing experience so we canguarantee quality in all our products.Cellular manufacturing allows us to quicklyrespond to changing customer needs.Each unit is tested to exacting standardsprior to shipping, ensuring reliable,trouble-free operation.Our shipping department and distributionnetwork can respond to mostorders within 24 hours.4 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleGoodall Power CentersGoodallPower CentersGoodall Power Centers are all-in-one products designed to meet the needs of today’s mobile servicemechanics. Units are engineered to reduce the amount of space necessary to fit inside most servicevehicles, by 50% in many cases.Our selection of models match the on-demand power requirements of government, municipalities,vehicle/equipment fleet maintenance, light to heavy-duty service and repair, the equipment rentalindustry, and many other service vehicle applications.The GPC 2000 Series and 3000 Series are integrated with a DC Welder, AC Generator and AirCompressor. The GPC 5000 Series adds a Jump Starter to round out your service truck needs.Please call Goodall today at 800-328-7730 to discuss your specific requirements.(See page 12 for specification chart)DC Welding Air Compressor AC Power Jump Starting800-328-7730 www.goodallmfg.com5

Power equipment for your service vehicleFeatures02-000 GPC 2000GoodallPower CentersDC Welding• CC stick• 25 ft. 1/0 gauge welding cables includedAC power• Synchronous, brushless AC generator• Limited AC output while weldingAir Power• CFM rated at 100 PSI, 150 PSI max.• Air gauge on control panels monitorsair tank pressureAir tank required (not included)Control Panel• Control panel mounted to unit is standard• Plug and play feature of control panelfor easy remote mounting.Requires extension harness fordistances beyond 12"Available Options950-085 6 ft. Control Panel Harness950-086 12 ft. Control Panel Harness950-154 18 ft. Control Panel HarnessHarness does not apply to 2500.Call for 2500 harness requirements.350-087 50 ft. Welding Cable UpgradeACCESSORIES61-130 30 gallon Vertical Mount Air Tank61-131 30 gallon Horizontal Mount Air Tank50-443 12 gallon Horizontal Mount Air TankAir tank required (not included)InstallationGoodall Power Centers provide for acompact and clean installation. Installationtime is reduced and simplified with theseeasy bolt-in packages, compared to theinstallation of separate components.• Center point lift includedIDEAL APPLICATIONS• Vehicle/equipment fleet maintenance• Light- to medium-duty service repair• Building and plant maintenance• Municipality and government service25"25"53.5"02-050 GPC 205002-500 GPC 2500 Hydraulically Powered25"53.5"IMT pic48"20"20"LIGHT TO MEDIUM DUTYWelder – DC Stick 40 - 240 amp - 200 amp 60% duty cycleGenerator – 4000 watt continuous, 60 Hz (while not welding)One 120 volt, 20 amp duplex outletOne 120 volt, 30 amp twist lock outletOne 240 volt, 20 amp twist lock outletAir Compressor – 2 stage 18 CFM @ 100 PSI, 150 PSI max.Engine – Electric start, air cooled Briggs & Stratton OHV V-TwinDimensions – Unit with fuel tank: 20"W x 53.5"D x 25"HControl box: 18"W x 5"D x 12"HBottom of unit to bottom to control box: 12"Weight – 600 lbs.Includes 8 gallon side mount fuel tank (removable)MEDIUM TO HEAVY DUTYWelder – DC Stick 40 - 250 amp - 225 amp 60% duty cycleGenerator – 5000 watt continuous 60 Hz (while not welding)One 120 volt, 20 amp duplex outletOne 120 volt, 30 amp twist lock outletOne 240 volt, 20 amp twist lock outletAir Compressor – 2 stage 24 CFM @ 100 PSI, 150 PSI max.Engine – Electric start, air cooled Kohler Command OHV V-TwinDimensions – Unit with fuel tank: 20"W x 53.5"D x 25"HControl box: 18"W x 5"D x 12"HBottom of unit to bottom to control box: 12"Weight – 625 lbs.Includes 8 gallon fuel tank (removeable)MEDIUM TO HEAVY DUTY2000 and 2050 control panel box is removable for remote mounting(optional harness required for distances beyond 12")142320"Welder – DC Stick 40 - 250 amp - 225 amp 60% duty cycleGenerator – 5000 watt continuous 60 Hz (while not welding)One 120 volt, 20 amp duplex outlet,One 120 volt, 30 amp twist lockOne 240 volt, 20 amp twist lock outletAir Compressor – 2 stage 24 CFM @ 100 PSI, 150 PSI max.Weight – 545 lbs.Dimensions – 20"W x 48"D x 25"HControl box: 18"W x 5"D x 12"HHydraulic requirements10 GPM @ 2500 PSI - 15 GPM @ 3000 PSI Tandem Pump35 gallon (minimum) hydraulic tank recommendedRequires two ¾" pressure lines (min.); 1" return line (min.)Standard remote mount control panel1. AC powerElectrical breakers, electrical outlets, volt meter2. Engine controls3. Air tank pressure gauge4. Welding controlsWelder settings, welder connections,welding polarity chart800-328-7730 www.goodallmfg.com7

Power equipment for your service vehicleThe GPC 5000 series is our 4-in-1 package including jump startingControl box can be remotely mountedPOWER CENTER 2000The Power Center 5000 incorporates a reliable 12/24 voltGoodall jump starting system with a welder, AC generatorand air compressor, providing a 4-in-1 service package.These compact units provide the same functionality asmultiple components but use less space.Easily bolted into the bed of a pickup or service body, theGPC 5000 series puts four services in one package, savingup to 50% space and weight over individual components andfulfilling the on-demand power requirements of today’s mobileservice mechanics.WELDERPerfect for general repair welding and light fabricationAC GENERATORRun power tools (i.e. saws, drills, grinders,lights, sanders, etc.)AIR COMPRESSORRun air tools (i.e. impact wrenches up to 1" forintermittent use, ratchets, grinders, nailers, etc.)or fill tiresJUMP STARTERPower to jump start 12/24 volt vehicles and equipment10 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleFeatures05-000 GPC 5000GoodallPower CentersDC Welding• CC stick• 25 ft. 1/0 gauge welding cables includedAC power• Synchronous, brushless generator• Limited AC output while weldingAir Power• CFM rated at 100 PSI, 150 PSI max.• Air gauge on control panels monitorsair tank pressureAir tank required (not included)Jump StARTING• Voltage regulator with reverse polarityprotection controls output voltage to asafe level for today’s electronics• Surge protection with Antizap providessafer boosting• Polarity and low battery LED indicatorsconfirm proper connections• 12 volt nominal, 700 amp• 24 volt nominal, 400 amp• 30 ft., 1/0 ga. welding cable allowsfor flexibility and ease of use• 1000 amp clamps allow maximumamperage outputControl Panel• Control panel mounted to unit is standard• Plug and play feature of control panelfor easy remote mountingRequires extension harness fordistances beyond 12"(see options)Available Options950-087 6 ft. Control Panel Harness950-088 12 ft. Control Panel Harness950-153 18 ft. Control Panel Harness250-022L 13 Gallon Rear Mount Fuel TankUpgrade (factory installed) fromstandard 6 gallon side mount350-087 50 ft. Welding Cable Upgrade450-044 50 ft. Boosting Cable Upgrade550-056 30 CFM Air Compressor UpgradeACCESSORIES61-130 30 gallon Vertical Mount Air Tank61-131 30 gallon Horizontal Mount Air Tank50-443 12 gallon Horizontal Mount Air TankAir tank required (not included)InstallationGoodall Power Centers provide for acompact and clean installation. Installationtime is reduced and simplified with theseeasy bolt-in packages, compared to theinstallation of separate components.• Center point lift included25"50"MEDIUM TO HEAVY DUTYWelder – DC Stick 40 - 250 amp - 225 amp 60% duty cycleGenerator – 5000 watt continuous 60 Hz (while not welding)One 120 volt, 20 amp duplex outletOne 120 volt, 30 amp twist lock outletOne 240 volt, 20 amp twist lock outletAir Compressor – Single stage, 23 CFM @ 100 PSI, 150 PSI max.Jump Staring – 12 volt nominal, 700 amp, 24 volt nominal, 400 ampEngine – Electric start, air cooled Kohler Command OHV V-TwinDimensions – Unit with fuel tank: 38"W x 50"D x 25"HControl box: 18"W x 5"D x 12"HBottom of unit to bottom of control box: 10"Weight – 850 lbs.Includes 6 gallon side mount fuel tank (removable)Optional 13 gallon back mount fuel tank changesoverall dimensions to: 42"W x 46"D x 26"HControl panel box is removable for remote mounting(optional harness required for distances beyond 12")1 2 34 538"1. AC powerElectrical breaker, electrical outlets2. Air tank pressure gauge3. Engine controls4. Welding controlsWelder settings, welder connections,welding polarity chart5. Jump starting controlsAmp & voltmeter, 12/24 volt selectorswitch, jump starter connector plug800-328-7730 www.goodallmfg.com11

Power equipment for your service vehicleGPC Comparison ChartWelding Air AC Jump Starting PowerModel Amperage (DC) CFM Wattage Amperage Source02-000 200 18 4000 NA Gas Engine02-050 225 24 5000 NA Gas Engine02-500 225 24 5000 NA Hydraulic03-000 270 DC / 250 CV 30 10000 NA Gas Engine05-000 225 23* 5000 700 Gas EngineCommon ElectrodesElectrode Polarity description6010 DCEP Deep penetrating, good for dirty, rusty or painted metals6011 DCEN Deep penetrating, good for dirty, rusty or painted metals6013 DCEN or DCEP Medium penetrating, superior bead appearance7018 DCEN or DCEP Low hydrogen, superior quality, medium penetratingKeep in oven at 250-450°FDCEN = Straight PolarityDCEP = Reverse PolaritySUGGESTED RANGES ARE APPROXIMATEElectrode Size Amperage Range Plate Thickness1/16" 20-40 0-3/16"3/32" 40-125 0-1/4"1/8" 75-185 1/8+"5/32" 105-250 1/4+"3/16" 140-305 3/8+"* 30 CFM availableAVERAGE WATTAGE REQUIREMENT GUIDEstarting Wattage Requirementsrunning Wattage Requirements(AMPS X VOLTS = WATTS) (approximate) (approximate)Sump pump, 1/2 HP 2150 1050Air compressor, 1 HP 4500 1600Bench grinder, 8" 2500 1400Hand drill, 1/2" 900 600High-pressure washer, 1 HP 3600 1200Circular saw, heavy duty, 7-1/4" 2300 1400Table Saw, 10" 4500 1800Drills, 1/2" 5.4 amps 900 600Industrial motors, 1/2 HP, split phase 2600 600Industrial motors,1-1/2 HP, capacitor start capacitor run 4200 1600Fan, 1/2 HP 3500 1100Milk cooler 1800 1100Portable heater (kerosene, diesel fuel) 150,000 BTU 1000 625Battery charger, 60 amp with 250 amp boost 1500/5750 1500/5750Electric welder, 200 amp AC 9000 9000Air compressors, 1 HP 4500 160012 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleGoodall Start•Alls ®All Start•All ® models provide continuousregulated power for jump startingStart•AllsA state-of-the-art voltage regulator with reverse polarity protection is standard on all models.This regulation controls output voltage to a safe level for today’s electronics.We offer 24 different Start•All ® models ranging from 300 to 1000 amp output. Models areavailable in 12 volt or a 12/24 volt combination. For your additional service requirements,models are available with integrated air compressors and/or AC generators.To choose the correct Start•All ® model for your application, please reference the selectionguide on page 31 or call 800-328-7730 to discuss your specific requirements.Jump StartingAC PowerAir Compressor800-328-7730 www.goodallmfg.com13

Power equipment for your service vehicleEconomical and reliable boost starting ideally suitedfor moderate climates and/or occasional jump starting14 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleJump Starting 12 Volt 300 AmpFeaturesStart•Alls11-708 Start•All ® 15GENERAL• Voltage regulator with reverse polarityprotection controls output voltage to asafe level for today’s electronics• Surge protection with Antizap providessafer boosting• Polarity and low battery LED indicatorsconfirm proper connections• Single DC boosting switch for easyoperationThe 11-708 is the perfect choice for car and light duty truckstarting. This unit will do what the larger units do, however, forlarger vehicles, cables must be connected to the vehicle for alonger period of time.Amp meterEngine – Recoil start with electric assist Kohler OHVgasoline with 1.6 gallon fuel tankDimensions – 25"W x 24"D x 19"HShipping Weight – 200 lbs.25"24"19"OUTPUT• 12 volt nominal, 300 ampCABLES AND CLAMPS• 30 ft., 2 ga. welding cable allowsflexibility and ease of use• 500 amp clamps allow maximumamperage output11-602 Start•All ®The 11-602 provides the same jump starting power asthe 11-708 and adds an air compressor, making it a goodchoice for those who need to run small air tools or fill tires.Volt and amp meter to monitor boosting outputAir Compressor – Single stage 8 CFM @ 100 PSI,150 PSI max.*Engine – Electric start, air cooled Briggs & StrattonOHV gasoline engine with 2 gallon fuel tank23"24"Dimensions – 27"W x 23"D x 24"H27"Shipping Weight – 350 lbs.* Air tank required for compressor (not included)See page 33 for our selection of air tanks800-328-7730 www.goodallmfg.com15

Power equipment for your service vehicleMid-range Start•Alls are ideal for small fleets,in-town trucks, rental and agricultural equipment16 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleJump Starting 12 Volt 450 Ampfeatures 11-605 Start•All ®Start•AllsGENERAL• Voltage regulator with reverse polarityprotection controls output voltage to asafe level for today’s electronics• Surge protection with Antizap providessafer boosting• Polarity and low battery LED indicatorsconfirm proper connections• Volt and amp meter to monitor boostingoutput• Single DC boosting switch for easyoperationThe 11-605 is ideal for starting in-town trucks, schoolbuses and agricultural equipment. These mid-rangeunits, with less power output than the 11-610, offercomparable features at a lower price.Dimensions – 27"W x 23"D x 24"HShipping Weight – 315 lbs.11-606 Start•All ®23"27"24"OUTPUT• 12 volt nominal, 450 ampThe 11-606 combines the 11-605 starting capabilities with theconvenience of an AC generator, supplying power to run powertools and lights to illuminate your work site.AC Generator – 2000 watt, 1 duplex 120 volt, 20 amp outletCABLES AND CLAMPS• 30 ft., 1/0 ga. welding cable allowsflexibility and ease of use• 1000 amp full-power clamps allow higheramperage flowDimensions – 27"W x 23"D x 24"HShipping Weight – 350 lbs.23"27"24"ENGINE11-607 Start•All ®• Electric start, air cooled Briggs & StrattonVanguard OHV gasoline engine with 2gallon fuel tankThis 2-in-1 unit packages the power of a Start•All with an aircompressor suitable to handle many mobile service requirements.Air Compressor – Single stage, 13 CFM @ 100 PSI, 150 PSI max.*Dimensions – 31"W x 25"D x 26"HShipping Weight – 420 lbs.26"* Air tank required for compressor (not included)See page 33 for our selection of air tanks25"31"11-608 Start•All ®The 11-608 is a compact 3-in-1 Start•All combining the jump startingcapabilities of an 11-605 with an AC generator and an air compressor.Ideal for the mobile service mechanic, providing a single source solutionfor multiple power applications.AC Generator – 2000 watt, 1 duplex 120 volt, 20 amp outletAir Compressor – Single stage, 13 CFM @ 100 PSI, 150 PSI max.*Dimensions – 31"W x 25"D x 26"H26"Shipping Weight – 450 lbs.25"* Air tank required for compressor (not included)See page 33 for our selection of air tanks31"800-328-7730 www.goodallmfg.com17

Power equipment for your service vehicleGoodall’s most powerful gasoline-engine driven12 volt only series is perfect for starting any 12 volt vehiclePower to start heavy-duty vehicles • Performance you can rely on • Power to start vehicle after vehicle18 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleJump Starting 12 Volt 700 AmpFeatures 11-610 Start•All ®Start•AllsGENERAL• Voltage regulator with reverse polarityprotection controls output voltage to asafe level for today’s electronics• Surge protection with Antizap providessafer boosting• Polarity and low battery LED indicatorsconfirm proper connections• Volt and amp meter to monitor boostingoutput• Single DC boosting switch for easyoperationThe 11-610 has the output necessary for starting heavy-dutyvehicles and equipment. Performance you can rely on—startafter start, year after year—and power that will crank enginesin cold weather climates vehicle after vehicle. Powerful 12 voltjump starting in a compact size.Dimensions – 28"W x 23"D x 26"HShipping Weight – 350 lbs.23"28"26"VOLTAGE• 12 volt nominal, 700 amp11-611 Start•All ®CABLES AND CLAMPS• 30 ft., 1/0 ga. welding cable allowsflexibility and ease of use• 1000 amp full-power clamps allow higheramperage flowThe 11-611 combines the 11-610 starting capabilities withthe convenience of an AC generator, supplying the power torun power tools and lights to illuminate your work site.AC Generator – 2000 watt, 1 duplex 120 volt,20 amp outletDimensions – 31"W x 25"D x 29"H29"ENGINEShipping Weight – 450 lbs.• Electric start, air cooled Briggs & StrattonVanguard OHV V-Twin gasoline enginewith 2-1/4 gallon fuel tank25"31"11-612 Start•All ®The 11-612 couples the 11-610 with an air compressor.This 2-in-1 unit packages the power of a Start•All withan air compressor suitable to handle many mobile servicerequirements.Air Compressor – Single stage, 13 CFM @ 100 PSI,150 PSI max.*Dimensions – 31"W x 25"D x 29"H29"Shipping Weight – 465 lbs.* Air tank required for compressor (not included)See page 33 for our selection of air tanks25"31"800-328-7730 www.goodallmfg.com19

Power equipment for your service vehicle12 and 24 volt starting power for off-road construction equipment,transit buses and any 12 volt application20 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleJump Starting 12/24 Volt 700 AmpFEATURES 11-620 Start•All ®Start•AllsGENERAL• Voltage regulator with reverse polarityprotection controls output voltage to asafe level for today’s electronics• Surge protection with Antizap providessafer boosting• Polarity and low battery LED indicatorsconfirm proper connections• Volt and amp meter to monitor boostingoutput• Single DC boosting switch for easyoperationOUTPUT• 12 volt nominal, 700 amp• 24 volt nominal, 400 ampCABLES AND CLAMPS• 30 ft., 1/0 ga. welding cable allowsflexibility and ease of use• 1000 amp full-power clamps allow higheramperage flowENGINE• Electric start, air cooled Briggs & StrattonVanguard OHV V-Twin gasoline enginewith 2-1/4 gallon fuel tankThe 11-620 has the output necessary for starting heavydutyvehicles and equipment. Performance you can relyon—start after start, year after year—and power that willcrank engines in cold weather climates vehicle after vehicle.Powerful 12/24 volt jump starting in a compact size.26"Dimensions – 28"W x 23"D x 26"HShipping Weight – 350 lbs.23"28"11-621 Start•All ®The 11-621 combines the 11-620 starting capabilities withthe convenience of an AC generator, supplying the powerto run power tools and lights to illuminate your work site.AC Generator – 2000 watt, 1 duplex 120 volt, 20 amp outletDimensions – 31"W x 25"D x 29"H29"Shipping Weight – 430 lbs.25"31"11-622 Start•All ®The 11-622 couples the 11-620 with an air compressor.This 2-in-1 unit packages the power of a Start•All withan air compressor suitable to handle many mobile servicerequirements.Air Compressor – Single stage, 13 CFM @ 100 PSI,150 PSI max.*Dimensions – 31"W x 25"D x 29"H29"Shipping Weight – 450 lbs.* Air tank required for compressor (not included)See page 33 for our selection of air tanks25"31"800-328-7730 www.goodallmfg.com21

Power equipment for your service vehicleMilitary specific jump starting with NATO plugSpecifically designed units for militaryapplications. These units have a NATO pluginstalled on them for 24 volt jump starting.This plug is polarity protected and live onlyin 24 volt mode. These units retain all otherfeatures and benefits of the 11-620 seriesof Start•Alls.NATO plug22 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleMilitary Jump Starting with NATO Plug 12/24 Volt 700 AmpFeatures 11-625M Start•All ®Start•AllsGENERAL• Voltage regulator with reverse polarityprotection controls output voltage to asafe level for today’s electronics• Surge protection with Antizap providessafer boosting• Polarity and low battery LED indicatorsconfirm proper connections• Volt and amp meter to monitor boostingoutput• Single DC boosting switch for easyoperationThe 11-625M integrates a 24 volt NATO plug for militaryapplications. In a compact combination 12/24 volt unit, ithas the output necessary for starting heavy-duty militaryvehicles and equipment. Performance you can rely on—start after start, year after year—and power that will crankengines in cold weather climates vehicle after vehicle.Dimensions – 28"W x 23"D x 26"HShipping Weight – 350 lbs.24 volt NATO plug23"28"26.5"OUTPUT• 12 volt nominal, 700 amp• 24 volt nominal, 400 amp11-626M Start•All ®CABLES AND CLAMPS• 30 ft., 1/0 ga. welding cable allowsflexibility and ease of use• 1000 amp full-power clamps allow higheramperage flowENGINE• Electric start, air cooled Briggs & StrattonVanguard OHV V-Twin gasoline enginewith 2-1/4 gallon fuel tankThe 11-626M combines the 11-625M starting capabilitieswith the convenience of an AC generator, supplying power torun power tools and lights to illuminate your work site.AC Generator – 2000 watt1 duplex 120 volt, 20 amp outletDimensions – 31"W x 25"D x 29"HShipping Weight – 430 lbs.24 volt NATO plug25"31"29"11-627M Start•All ®The 11-627M adds an air compressor to the 11-625MStart•All. This 2-in-1 unit packages the power of aStart•All with an air compressor suitable to handle manymobile service requirements.Air Compressor – Single stage, 13 CFM @ 100 PSI,150 PSI max.*Dimensions – 31"W x 25"D x 29"H29"Shipping Weight – 450 lbs.24 volt NATO plug* Air tank required for compressor (not included)See page 33 for our selection of air tanks25"31"800-328-7730 www.goodallmfg.com23

Power equipment for your service vehicleHydraulically powered, 12 and 12/24 volt jump startingGoodall’s hydraulically powered Start•All ® unitsfree you from the maintenance of a gasolineengine. Perfect for mounting on trucks equippedwith either an under-the-hood or PTO hydraulicpump. Can be mounted in locations where anengine powered Start•All would not be practical.24 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleJump Starting 12/24 Volt Hydraulicfeatures 11-802 Start•All ®Start•AllsGENERAL• Voltage regulator with reverse polarityprotection controls output voltage to asafe level for today’s electronics• Surge protection with Antizap providessafer boosting• Polarity and low battery LED indicatorsconfirm proper connections• Volt and amp meter to monitor boostingoutput• Single DC boosting switch for easyoperationCABLES AND CLAMPS• 30 ft., 1/0 ga. welding cable allowsflexibility and ease of use• 1000 amp full-power clamps allow higheramperage flowACCESSORIESStud kit for additional remote plug andjump starting outlet locations71-556 Stud KitThe 11-802 is a 12 volt only, hydraulically powered jump starting unit. The 11-802 has the output necessary for startingheavy duty vehicles and equipment. Performance you can rely on—start after start, year after year—and power that willcrank engines in cold weather climates vehicle after vehicle. Powerful jump starting in a compact size.Output – 12 volt nominal, 700 ampHydraulic requirements – 15 GPM @ 2500 PSI35 gallon (min.) hydraulic tankrecommendedRequires ¾" pressure hose (min.);1" return hose (min.)Dimensions – 36"W x 18"D x 12"HShipping Weight – 250 lbs.11-807 Start•All ®The 11-807 is a 12/24 volt hydraulically powered jump starting unit. The 11-807 has the output necessary forstarting heavy-duty vehicles and equipment. Performance you can rely on—start after start, year after year—andpower that will crank engines in cold weather climates vehicle after vehicle. Powerful jump starting in a compactsize, for those requiring a combination of 12/24 volt jump starting.Output – 12 volt nominal, 700 amp24 volt nominal, 400 ampHydraulic requirements – 15 GPM @ 2500 PSI35 gallon (min.) hydraulic tankrecommendedRequires ¾" pressure hose (min.);1" return hose (min.)18"36"12"12"Dimensions – 36"W x 18"D x 12"HShipping Weight – 250 lbs.18"36"Bumper box with plug12-296 12 ft., 1/0 ga. Welding Cable12-297 12 ft., 2/0 ga. Welding Cable11-811 Start•All ®Goodall’s most powerful Start•All, the 11-811 is a 12/24 volt hydraulically powered jump starting unit. The 11-811has the output necessary for starting heavy-duty vehicles and equipment. Performance you can rely on—start afterstart, year after year—and power that will crank engines in cold weather climates vehicle after vehicle. Powerfuljump starting in a compact size, for those requiring a combination of 12/24 volt jump starting.Hydraulic ports (right side)Output – 12 volt nominal, 1000 amp24 volt nominal, 600 ampHydraulic requirements: – 25 GPM @ 2500 PSI35 gallon (min.) hydraulic tankrecommendedRequires ¾" pressure hose (min.);1" return hose (min.)Dimensions – 48"W x 20"D x 12"H20"48"12"Shipping Weight – 400 lbs.800-328-7730 www.goodallmfg.com25

Power equipment for your service vehicle900 series Start•All ® with air compressor for road service vehiclesThe 11-900 series Start•All ® units are designed to mount on the bed of a pickup truckor between the side packs on a service vehicleJump StartingAC PowerAir Compressor26 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleJump Starting-Industrial Combination Unitsfeatures 11-920 Start•All ®Start•AllsGENERAL• Voltage regulator with reverse polarityprotection controls output voltage to asafe level for today’s electronics• Surge protection with Antizap providessafer boosting• Polarity and low battery LED indicatorsconfirm proper connections• Volt and amp meter to monitor boostingoutput• Single DC boosting switch for easyoperationThe 11-920 is Goodall’s industrial 12 volt jump startingunit. If you need solid, dependable and efficient 12 voltjump starting, this is your unit. Designed for easymounting on your service vehicle.Output – 12 volt nominal, 700 ampAir Compressor – Single stage, 23 CFM @ 100 PSI150 PSI max.*Dimensions – 30"W x 40.5"D x 21"HShipping Weight – 475 lbs.* Air tank required for compressor (not included)See page 33 for our selection of air tanks41.5"30"21"CABLES AND CLAMPS• 30 ft., 1/0 ga. welding cable allowsflexibility and ease of use• 1000 amp full-power clamps allow higheramperage flowAir Power• CFM rated at 100 PSI, 150 PSI max.Air tank required (not included)11-923 Start•All ®The 11-923 is Goodall’s industrial 12/24 volt jump startingunit. Specifically suited for those who need 24 volt startingcapabilities.Output – 12 volt nominal, 700 amp24 volt nominal, 400 ampAir Compressor – Single stage, 23 CFM @ 100 PSI150 PSI max.*21"ENGINE• Electric start, air cooled Kohler OHVV-Twin gasoline engine.Fuel tank required (not included)Dimensions – 30"W x 40.5"D x 21"HShipping Weight – 475 lbs.* Air tank required for compressor (not included)See page 33 for our selection of air tanks41.5"30"Available Options61-130 30 gallon Vertical Mount Air Tank61-131 30 gallon Horizontal Mount Air Tank50-443 12 gallon Horizontal Mount Air Tank61-180 8 gallon Fuel TankControl box detailaccessoriesStud kit for additional remote plug andjump starting outlet locations71-554 Stud KitBumper box with plug12-296 12 ft., 1/0 ga. Welding Cable12-297 12 ft., 2/0 ga. Welding Cable800-328-7730 www.goodallmfg.com27

Power equipment for your service vehicleInstallation Guidelines for 920 AC, 921, 922 and 923 ACSpecifically designed to mount in a service body, the models on page 30 have a control panel whichis designed for mounting in the first compartment on the curb side. This control panel has all thegauges and controls, along with the oil filter and drain, for convenient operation and maintenance.These units require the installer to fabricate an enclosure. This enclosure must be built to allow forproper air flow and heat dissipation.All 11-900 series installations must be approved by the factory prior to ordering to assure proper:• air flow• heat dissipationCall Goodall at 800-328-7730• weather resistancePicture shows typical installation (may be shown with optional equipment)28 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleInstallation Guidelines for 920 AC, 921, 922 and 923 ACStart•AllsIllustration depicts typical installation shown with sides and covers (not included)The control panel is located on thecurb side of the service vehicle forconvenience and safety.Panel includes:• Oil pressure gauge (921 & 922 only)• AC volt meter (920AC & 923AC only)• Air pressure gauge• Hour meter• Volt meter• Amp meter• DC boosting switch• Air compressor switch• Remote oil filter• Engine oil drain hose7"19.75"Standard remote AC control panel forthe 11-920 AC and 11-923 AC includes:• AC volt meter• Circuit breakers• One 120 volt, 20 amp duplex outlet• One 120 volt, 30 amp twist lock outlet• One 240 volt, 20 amp twist lock outlet• Dimensions: 10.5"W x 4"D x 18"H10.5"18"All 11-900 series installations must be approved by the factory prior to ordering to assure proper:• air flow• heat dissipationCall Goodall at 800-328-7730• weather resistance800-328-7730 www.goodallmfg.com29

Power equipment for your service vehicleJump Starting 12/24 Volt 700 Amp11-922 Start•All ®ffeaturesThe 11-922 Start•All is an industrial grade unit, designedto integrate into a service body. The control panel remotemounts into the side pack compartment.Output – 12 volt nominal, 700 ampAir Compressor – Single stage 23 CFM @ 100 PSI,150 PSI max.*Dimensions – 30"W x 40.5"D x 21"HShipping Weight – 475 lbs.* Air tank required for compressor (not included)40.5"21"GENERAL• Voltage regulator with reverse polarityprotection controls output voltage to asafe level for today’s electronics• Surge protection with Antizap providessafer boosting• Polarity and low battery LED indicatorsconfirm proper connections30"• Volt and amp meter to monitor boosting11-921 Start•All ®output• Single DC boosting switch for easyoperation11-921 Start•All is an industrial grade unit with both 12 and 24 jumpstarting capabilities, designed to integrate into a service body. Thecontrol panel remote mounts into the side pack compartment.Output – 12 volt nominal, 700 amp24 volt nominal, 400 ampAir Compressor – Single stage 23 CFM @ 100 PSI,150 PSI max.*Dimensions – 30"W x 40.5"D x 21"H21"CABLES AND CLAMPS• 30 ft., 1/0 ga. welding cable allowsflexibility and ease of use• 1000 amp full-power clamps allow higheramperage flowShipping Weight – 475 lbs.* Air tank required for compressor (not included)40.5"Air Power30"• CFM rated at 100 psi, 150 psi max.11-920AC Start•All ®The 11-920AC Start•All is an industrial grade unit with the addition ofan AC generator, designed to integrate into a service body. The controlpanel remote mounts into the side pack compartment.Output – 12 volt nominal, 700 ampAir Compressor – Single stage 23 CFM @ 100 PSI,150 PSI max.*AC Power – 120 volt, 6000 watt peak5000 watt continuousDimensions – 31"W x 40.5"D x 21"HShipping Weight – 575 lbs.* Air tank required for compressor (not included)Standard remote AC panelENGINEAir tank required (not included)• Electric start, air cooled Kohler OHVV-Twin gasoline engine.Fuel tank required (not included)ACCESSORIES61-130 30 gallon Vertical Mount Air Tank61-131 30 gallon Horizontal Mount Air Tank50-443 12 gallon Horizontal Mount Air Tank61-180 8 gallon Fuel Tank11-923AC Start•All ®Stud kit for additional remote plug andjump starting outlet locationsThe 11-920AC Start•All is an industrial grade unit, with both 12 and 24 jump starting capabilitiesand the addition of an AC generator, designed to integrate into a service body.The control panel remote mounts into the side pack compartment.Output – 12 volt nominal, 700 amp24 volt nominal, 400 ampAir Compressor – Single stage 23 CFM @ 100 PSI,150 PSI max.*AC Power – 120 volt, 6000 watt peak5000 watt continuousDimensions – 31"W x 40.5"D x 21"HShipping Weight – 575 lbs.71-554 Stud KitBumper box with plug12-296 12 ft., 1/0 ga. Welding Cable12-297 12 ft., 2/0 ga. Welding Cable* Air tank required for compressor (not included)Standard remote AC panel30 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleStart•All ® Selection Guide12 Volt Starting Units 12/24 Volt Starting UnitsStart•AllsHeavy-duty car, Car, pick-up, Starting any 12 volt Starting any 12 volt Starting any 12 voltlight-duty truck in-town truck, up to and including up to and including up to and includingand school bus and semi-tractors and semi-tractors. semi-tractors.equipment starting semi-tractor starting agricultural equipment Starting 24 volt Starting 24 voltin moderate in cold weather transit, military and transit, military andclimates climates off-road equipment off-road equipment12 volt amp output 300 amps 450 amps 700 amps 700 amps 1000 amps24 volt amp output NA NA NA 400 amps 600 ampsSELECTED MODELS SELECTED MODELS SELECTED MODELS SELECTED MODELS SELECTED MODELSJump startingonly11-70811-60511-61011-80211-62011-625M11-80711-811Jump startingand 8 CFM air11-602Jump startingand 13 CFM air11-60711-61211-62211-627MJump startingand 23 CFM air11-92011-92211-92111-923Jump startingand 2000 watt AC11-60611-61111-62111-626MJump startingand 13 CFM airand 2000 watt AC11-608Jump startingand 23 CFM airand 6000 watt AC11-920AC11-923ACQuestions to consider when calling for assistance in selecting selecting a Start•All ® unit:1. What is the voltage of the vehicles you will be starting? (12, 24 or both 12 and 24)2. How many batteries are on the vehicles you will be starting? (1, 2, 3 or 4)3. What is you climate? (How many days are below 0º F and 32º F?)4. How many vehicles per day do you jump start? (average and worst case)5. Do you require the capability to jump start several vehicles in a short period of time?6. What type of vehicle do you plan on mounting the Start•All to? (pick-up, open bed, service body)7. Do you need AC power? If so, what wattage requirements do you have?8. Do you need air power? If so, how much air do you require and what type of air tools will you be using?Call Goodall at 800-328-7730 or e-mail info@goodallmfg.com for help with your selection.800-328-7730 www.goodallmfg.com31

Power equipment for your service vehicleGPC and Start•All ® Accessories61-740 Tow Cart 61-744 Cable Storage Rack• 3 10" solid rubber wheels, frontswivels for easy maneuvering• Dimensions: 29"W x 33-1/2"L• Fits Start•All models: 605, 610,620, 611, 621, 708• For easy storage of Start•All cables• Attaches to service vehicles70-556 Hitch Tongue 1-7/8" receiverCanvas Covers61-185 Fuel Pump Safety Kit61-739 For 11-708 model61-741 For 11-712, 11-716and 11-718 models61-742 For 11-605, 11-606,11-610 and 11-620models61-743 For 11-607, 11-608,11-611, 11-612,11-621 and 11-622models• Option to be used with any ofthe 11-900 series Start•All units• Will shut down fuel pump whenStart•All engine is not runningBumper Box with PlugFor additional remote plug and jump startingoutlet locationsFor service trucks. Stainless steel.12 ft. of cable. Comes with 71-402 plug.71-554 For 600 & 900 series Start•Alls71-556 For 800 series Start•Alls12-296 12 ft., 1/0 ga.12-297 12 ft., 2/0 ga.32 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleGPC and Start•All ® Accessories61-180 Remote Mount Fuel Tank250-022 Fuel Tank• 7.8 gallon capacity• 13 gallon capacity• 23"L x 10"W x 10"D• 43"L x 7"D x 22"H• Cap includes easy-to-readgauge• For use with 11-900 seriesStart•AllsAccessories250-023 Fuel Tank250-021 Fuel Tank• 6 gallon capacity• 29"L x 22"W x 3"D• 8 gallon capacity• 20"L x 19"W x 6"D61-130 / 61-131 30 Gallon Air Tank50-443 12 Gallon Air Tank• ASME certified• Vertical or horizontal mount• 61-130 Vertical mount• 61-131 Horizontal mount• 19" x 41"• For use with 11-900 and 11-600series Start•Alls and GPC units• Horizontal mount• ASME certified• 14" x 26"• For use with 11-900 and 11-600series Start•Alls and GPC unitsWelding CablesPlug-Ended Cable Sets350-056 50 ft., welding cable 70-444 50’ 1/0 ga. with red plug800-328-7730 www.goodallmfg.com33

Power equipment for your service vehicleBoost•All ® – 12 and 12/24 volt Portable Jump StartingThe portable Boost•All ® provides fast, powerfulboost to any vehicle. This unit is ideal forparking lot jump starting. Typical applicationsinclude parking garages, car lots, schools,farms, salvage yards, marinas, rental locations,and small fleets.34 www.goodallmfg.com 800-328-7730

Power equipment for your service vehiclePortable Boost•All ® – Battery PoweredFEATURES 13-023 Boost•All ®GENERAL• Fully automatic charger to keep batteryin ready-to-use condition (batteries notincluded)• Pneumatic tires allow easy movementto vehicle• Retractable plug and cord for charging• Space saving, small footprint• High density, scratch resistant,polyethylene caseCABLES AND CLAMPS• Heavy-duty 1000 amp clamps and qualitywelding cableBattery requirements• All models accommodate two Group 31batteries* Batteries not included with purchase ofunit (lead acid batteries recommended)12 volt only jump startingCables – 1/0 ga. 12 ft. welding cableDimensions – 18"L x 24"W x 42"HShipping Weight – 70 lbs.13-024 Boost•All ®12/24 volt jump startingCables – 1/0 ga. 12 ft. welding cableDimensions – 18"L x 24"W x 42"HShipping Weight – 77 lbs.Simple selector plug to choose 12 or 24 volt jump startingBoost•AllsTrailer Light Tester• For models 13-043 and 13-04413-043 Boost•All ®12 volt only jump starting with the added featureof an integrated trailer light testerCables – 1/0 ga. 12 ft. welding cableDimensions – 18"L x 24"W x 42"HShipping Weight – 75 lbs.• 7-position dial to test each circuitseparately• Amp meter to check current draw inlighting system• Circuit breaker• 4 pin flat adapter small trailers• 6 pin for heavy duty trailers• 7 pin for semi trailersTrailer light tester with multiple pin adapters13-044 Boost•All ®12/24 volt only jump starting with the added featureof an integrated trailer light tester.Cables – 1/0 ga. 12 ft. welding cableDimensions – 18"L x 24"W x 42"HShipping Weight – 75 lbs.Simple selector plug to choose 12 or 24 volt jump startingTrailer light tester with multiple pin adapters800-328-7730 www.goodallmfg.com35

Power equipment for your service vehicleSuper Boost•All ® – 12/24 volt mobile jump startingThe Super Boost•All ® provides a convenient andsafer access point for adding 12/24 volt jump startingcapabilities to any service vehicle. Terminals or cablesare provided for connecting to 2 or 4 auxiliary batteries.Charging of the auxiliary batteries is accomplished byconnecting to the service vehicle’s alternator. The useof a battery isolator (part no. 13-465) is required (soldseparately) in all installations. This eliminates anypossible feedback that may damage the servicevehicle’s electrical system. A volt meter is provided toread the voltage of the vehicle to be started as well asthe voltage of the auxiliary jump starting batteries.36 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleSuper Boost•All ®featuresSuper Boost•All ® Control BoxGENERAL• Requires 2 or 4 auxiliary batteries(not included)• Control box capable of connecting twoor four batteries• User-friendly controls and instructionsmounted for easy access• Surge/spike protected with Antizap• Polarity indicator for easy, correcthook-up• Volt meter allows operator to monitorsystem voltage before, during and afterjump starting• Auxiliary batteries are charged with theservice vehicles alternator. Requires theuse of a battery isolator.OUTPUT• Provides either 12 or 24 volt boostingcapacity• Easy plug selection to choose 12 or 24volt operationCABLES AND CLAMPS• 25 ft. booster cables with full power jawsand quick disconnect plug13-400 / 13-404 13-406 / 13-408SuperBoost•Alls13-465 200 Amp Battery IsolatorAllows the service vehicle’salternator to provide a chargeto the auxiliary batteries whileelectrically isolating the twosystems. An isolator protects theservice vehicle’s electrical systemand components while keepingthe auxiliary batteries isolated.Required for use with 13-400,13-404, 13-406 and 13-408.13-448 4 In-LineBattery Box13-400 Super Boost•All control boxwith 25 ft., 2 ga. welding cablewith 800 amp full-power jaws,clamps and connecting studs13-404 Super Boost•All control boxwith 25 ft., 1/0 ga. welding cablewith 1000 amp full power jaws,clamps and connecting studs13-442 2 In-LineBattery Box13-406 Super Boost•All control boxwith 25 ft., 2 ga. welding cablewith 800 amp full power jaws,clamps and 12 ft. connecting cables13-408 Super Boost•All control boxwith 25 ft., 1/0 ga. welding cablewith 1000 amp full power jaws,clamps and 12 ft. connecting cables13-444 4 SquareBattery Box60"L x 11"D x 16"H31"L x 10"D x 13.5"H 28"L x 24"D x 14"H800-328-7730 www.goodallmfg.com37

Power equipment for your service vehicleJump Starting Plug Kits38 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleStart•All ® Plug KitsMADE IN THEUSAStart•All ® Plug-to-Plug KitsStart•All ® Heavy Duty Plug-to-Socket Kit12-500 12-60012-375 20 ft. standard-duty kit, 4 ga. with blue plug 5 ft. battery to plug,15 ft. plug to 400 amp clamps with weather cap12-400 30 ft. standard-duty kit, 4 ga. with blue plug 5 ft. battery to plug,25 ft. plug to 400 amp clamps with weather cap12-475 20 ft. heavy-duty kit, 2 ga. with blue plug 5 ft. battery to plug,15 ft. plug to 500 amp clamps with weather cap12-500 30 ft. heavy-duty kit, 2 ga. with blue plug 5 ft. battery to plug,25 ft. plug to 500 amp clamps with weather cap12-600 30 ft. diesel equipment kit, 1/0 with red plug 5 ft. battery to plug,25 ft. plug to 800 amp clamps with weather cap12-608 30 ft. heavy-duty stainless steel bumper box kit with redpolarity-protected plug, weatherproof stainless steelbumper box with 5 ft. connector cable, and25 ft. 1/0 ga. duplex welding cable with 800 amp clampsPlug KitsClamp-Ended Booster Cablewith PlugBattery Cable with PlugPlug-Ended Booster Cables12-376 15 ft., blue plug to 400 amp clamps,4 ga. duplex welding cable12-402 25 ft., blue plug to 400 amp clamps,4 ga. duplex welding cable12-476 15 ft., blue plug to 500 amp clamps,2 ga. duplex welding cable12-502 25 ft., blue plug to 500 amp clamps,2 ga. duplex welding cable12-602 25 ft., red plug to 800 amp clamps,1/0 ga. duplex welding cableStainless Steel Bumper Boxwith Plug12-401 5 ft., blue plug to terminal cable, 4 ga. duplexwelding cable with weather cap12-501 5 ft., blue plug to terminal cable, 2 ga. duplexwelding cable with weather cap12-601 5 ft., red plug to terminal cable, 1/0 ga. duplexwelding cable with weather capConnector Plugs with Contacts12-403 12 ft., 4 ga. duplex cable with plug on each endjoins with 400 Series plugs12-503 12 ft., 2 ga. duplex cable with plug on each endjoins with 500 Series plugs12-603 12 ft., 1/0 ga. cable with plug on each endjoins with 600 Series plugsWeather Caps12-296-5 5 ft., 1/0 ga. welding cable with red plug12-296 12 ft., 1/0 ga. welding cable with red plug12-297 12 ft., 2/0 ga. welding cable with red plug71-401 400 and 500 series (blue),with 2 ga. contacts71-402 600 series (red),with 1/0 ga. contactsOther contact sizes available. Please call for details.71-422 400 and 500 series connectorplugs with lanyard71-424 600 series connector plugswith lanyard800-328-7730 www.goodallmfg.com39

Power equipment for your service vehiclePlug-to-Socket KitsMADE IN THEUSA12-200 Start•All ® Plug-Socket Starter Kit 12-280 Heavy Duty Start•All ®Plug-Socket Starter KitA heavy-duty version of our popular12-200 Plug-Socket Car Starter Kit• Hot Socket (12-201) and Plug-in Cables (12-202)can be purchased separately• Installation of additional socket to rear of service truckadds to utility and safety in heavy traffic situations• Special lengths available (Antizap Upgrade Kits)• Consists of:12-202 25 ft., 4 ga. single welding cable with 400 ampclamps and non-reversible plug12-201 Polarity-protected pocket, weatherproof socketbox, 5 ft. battery connector cable12-284 12-28112-284 25 ft., 1/0 ga. welding cable with 800 amp clamps andnon-reversible plug12-281 Polarity-protected socket, weatherproof stainless steelsocket box, 5 ft. battery connector cable71-314 Metal Housing 71-311 Hot Socket PlugComplete with terminalsand fittings.12-301 Fleet BoostCable & FenderPanel Socket71-313 Hot Socket ReceptacleMetal housing for Hot Socket. Use 71-313to complete housing. Baked enamel finish.Includes weather cover andmounting hardware. Mountsin 71-314 housing.Mounts on flat panel. No box needed.5 ft. cable.12-201 Hot Socket12-202 Plug-In Cables/Clamps 12-302 Fleet Boost12 ft. Cable & PlugWeatherproof box, polarity protected socket,copper terminals, 5 ft. battery connector cables.25 ft., 4 ga. duplex welding cable equippedwith 400 amp clamps and non-reversibleplug for Hot Socket.40 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleBooster Cables and Battery Clamps USAMADE IN THEIndustrial Gauge• Our heaviest dutyjumper cables• Full powered jaws• All copper wire• Flexible to -40° F32-110 Booster Cable Upgrade KitsUpgrade those old jumpercables and booster boxesSurge protection with Antizap upgrade kitprovides safer boosting14-300 20 ft. 1/0 ga. welding cable with 1000 amp full-power jaws14-301 30 ft. 1/0 ga. welding cable with 1000 amp full-power jawsCommercial 2 and 4 Gauge, 400-500 Amp Clamps• Twin extruded jacket• Replaceable jaws• Cable remains flexible to -40ºF• All copper wireBattery Clamps14-254 25 ft., 4 ga. welding cable with 400 amp vinyl coated clamps14-204 20 ft., 4 ga. welding cable with 400 amp vinyl coated clamps14-154 15 ft., 4 ga. welding cable with 400 amp vinyl coated clamps14-124 12 ft., 4 ga. welding cable with 400 amp vinyl coated clamps14-252 25 ft., 2 ga. welding cable with 500 amp vinyl coated clamps14-202 20 ft., 2 ga. welding cable with 500 amp vinyl coated clamps14-152 15 ft., 2 ga. welding cable with 500 amp vinyl coated clamps14-253 25 ft., 4 ga. welding cable with 450 amp parrot-jaw clamps14-203 20 ft., 4 ga. welding cable with 450 amp parrot-jaw clamps14-153 15 ft., 4 ga. welding cable with 450 amp parrot-jaw clampsExtra Heavy Duty Battery ClampsCables & Clamps14-400 1 pair - 400 amp – For booster cables and chargers.14-450 1 pair - 450 amp – Heavy-duty spring. Vinyl Plastisol insulated grips14-500 1 pair - 500 amp – Solid copper jaws for starting units, heavy booster cables14-600 1 pair - 600 amp – Fully insulated, heavy-duty. Copper shunt14-800 1 pair - 800 amp – Solid copper jaws for diesel starting equipment14-406 6 pair of 400 amp clamps14-456 6 pair of 450 amp clamps14-506 6 pair of 500 amp clamps14-606 6 pair of 600 amp clamps14-806 6 pair of 800 amp clamps14-850 1000 amp power jaw clamps for 1/0 ga. cable14-900 1200 amp power jaw clamps for 2/0 ga. cable14-950 1400 amp power jaw clamps for 4/0 ga. cableCable runs to each side of clamp powering both jaws.Allows higher amperage flow. Easy to install in field withsimple butt connector.14-615 Battery Clips Replacement JawsBulk Welding CableSold by the foot• Suits smaller battery chargers, memoryminders and general 12 volt accessories• Rated to 12 volt, 15 amp• Blister packed, 1 pair70-176 500 amp capacity, solid copper70-177 800 amp capacity, solid copper70-056 6 ga., bulk, single70-053 4 ga., bulk, single70-051 2 ga., bulk, single70-403 2 ga., bulk, duplex70-404 4 ga., bulk, duplex70-407 1/0 ga., bulk, duplex70-409 1/0 ga., bulk, single800-328-7730 www.goodallmfg.com41

Power equipment for your service vehicleAntizap ® Surge Protection for vehicles and equipmentEliminates the need to disconect the batteryfrom the terminals while welding on a vehicle.*Simply clip on the Antizap ® Surge Protectorand you’re ready to weld. Protects sensitiveelectronics, reduces labor time, and pays foritself after one or two uses.* See vehicle manufacturer guidelines42 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleAntizap ® Surge Protection32-020 12 Volt Antizap ® Surge Protection32-030 12/24 Volt Antizap ® Surge ProtectionService MinderSimply clip the booster clamps across the battery, and when the green LEDilluminates the system is then protected from spikes and surges while thevehicle is being worked on.Body shops and muffler shops can use the Service Minder when carrying outall forms of electric welding, including Tig, Argon Arc and Mig, on a vehicle—with the battery connected! The Service Minder not only protects the on-boardelectronics but dispenses with the need to disconnect the battery resulting inlost stereo and other electronic memories.Fully insulated booster clamps with 2-function Antizap protection. Red indicatesNO Antizap protection, while green indicates CORRECT Antizap protection.32-040 24 Volt Antizap ® Surge Permanent Mount32-050 12 Volt Antizap ® Permanent MountThese units are easily mounted to the side of the vehicle battery, or bodywork, withthe unit connected to the negative and positive battery terminals. Once this is in place,the vehicles original electronic accessories are protected from on-board or externallygenerated voltage spikes.Commercial Heavy Duty• Designed for passenger cars, buses, marine vessels, heavy industry,and agriculture• Heavy-duty weatherproof and shockproof housing• Green LED indicates correct connection and Antizap surge protection• Red LED indicates NO Antizap surge protection• Crimped, tin-plated, heavy-gauge, solid copper lugs• Provides full-time electronic surge protectionAntizap32-110 Antizap ® Commercial Booster Cable UpgradeAdd to your booster cable – Protect delicate electronics• 12/24 volt heavy-duty with LED control• Fits cable up to 3/8" diameter or 2/0 ga.• Protects while jump starting:– EFI and Engine Management System– Climate control– Stereo and CD players– GPS and alarms– SRS airbags– ABS brakes– Instrumentation– Mobile phones– Both donor and dead vehicles800-328-7730 www.goodallmfg.com43

Power equipment for your service vehicleWheel-type battery charging for shop applicationsGoodall’s wheel type battery chargers are the perfect choice for repair facilities needing a reliableshop battery charger. Models available for automotive use, fleets, commercial and heavydutyapplications. Have a charger in each of your bays.44 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleBattery Charging 6/12/24 Volt51-810 Charger / StarterIdeal for small shops, cars, pick-ups and vans• 40/15/2 amp charge rates• 200 amp engine start• 6 and 12 volt modes• Volt meter and amp meter• 2-hour timer• Automatic shut-off• Cooling fan51-860 Charger / Starter with TesterThe perfect fit for automotive and trade shops• 60/40/2 amp charge rates• 250 amp engine start• 6 and 12 volt modes• Volt meter and amp meter• Multi-function tester• 2-hour timer• Automatic shut-off• Cooling fan• Chrome handle51-890 Charger / StarterGreat for commercial and heavy-duty applications• 60/40/30 amp charge rates• 225 amp engine start• 6,12 and 24 volt modes• Volt meter and amp meter• 2-hour timer• Automatic shut-off• Cooling fan• Chrome handleCharge•Alls51-620 Benchtop Battery Charger 51-998 100 Amp Battery Tester• 15 amp fast charge• 2 amp slow charge• 100 amp engine start• Charges 6 and 12 volt batteries• Automatic shut-off• Green LED signals battery fully charged• Red LED signals reverse connection• 100 amp load testing capacity• State of charge test• Starter motor test• Tests battery charging and systems• 0-16 volt load test range• 12" cables with color-coded clamps• Handles up to 1000 CCA800-328-7730 www.goodallmfg.com45

Power equipment for your service vehiclePowrlite – Portable AC Generators and Generator/Welder67-105 Powrlite Portable Generator67-606 Wheel KitMADE IN THEUSA• 10,000 watt maximum output,9500 watt continuous rate• Totally brushless with automaticvoltage regulator (+/- 2%)• Two 120 volt, single-phase, 20 ampgrounded duplex receptacle outlets• One 30 amp, 120 volt twistlock receptacle• One 30 amp, 240 volt twistlock receptacle• One 50 amp, 240 volt straight blade receptacle• Five circuit breakers• Grounding lug• 79.2 amp rating at 120 volt• 39.6 amp rating at 240 volt• 16 HP electric start Briggs & StrattonVanguard engine• Low oil shutdown• Overhead valve engine• Super low tone muffler• Oil pressure lubrication• Oil filter• Push button starter• Battery cables• Electric start with recoil (battery andrack not included)• Full wrap around roll cage carrying frame• 7.8 gal. fuel tank• 9 hrs. running time at half load, 6 hoursrunning time at full load• Shipping weight: 245 lbs.• Dimensions: 31"L x 25"W x 26"H67-150 Powrlite Portable GeneratorMADE IN THEUSA• 15,000 watt maximum output,12,000 watt continuous rate• 120/240 volts• 60 Hz• Single phase• Totally brushless generator with automaticvoltage regulator• Remote control panel with two 15 amp,120 volt ground fault receptacles• One 30 amp, 120 volt twistlock receptacle• Two 20 amp, 120 volt receptacles• One 30 amp, 240 volt duplex twistlock receptacle• One 50 amp, 120 volt twistlock receptacle• One 50 amp, 240 volt twistlock receptacle• Individual circuit breakers• Auto idler• Engine hour meter• Electric start key switch with panel-mountedchoke control• 23 HP Briggs & Stratton Vanguard performer2-cylinder engine with low oil shut down• Low tone spark arrester muffler• 8 gal. fuel tank• All mounted on 1-1⁄2" diameter weldedtubular frame with lifting eyes• Shipping weight: 333 lbs.• Dimensions: 33"L x 25"W x 31"H67-240 Powrlite Portable WelderWelding cable not includedMADE IN THEUSA• 240 amps DC, 6000 watts AC• Welding voltage: 22-30 volts• Variable amperage adjustment• Thermal overload protection with indicator light• One 20 amp, 120 volt duplex receptacle• One 30 amp, 240 volt twistlock receptacle• 1" welded steel roll cage• 8 gal. fuel tank• Electrode and ground clamp included• Will accept up to 2/0 cable• 9.9 hour running time at half load,• 6.0 hour running time at full load• Shipping weight: 321 lbs.• Dimensions: 33"L x 25"W x 31"H46 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleCommon Replacement PartsFor technical assistance, please call 800-328-7730 or e-mail techsupport@goodallmfg.comVoltage Control ModuleBrush Set70-600-K Voltage Control70-405 For 79-375 and 79-406 GeneratorsBrush SetBrush Set70-396 For 79-371 and 79-373 Generators 70-046 For 70-360 and 70-050 GeneratorsSolenoidResistor77-181S Solenoid for use on all Start•Alls77-321S Resistor AssemblyGenerator PulleyGenerator70-041 Generator Pulley for use onall Start•All generators79-375S Case Ground Generator79-406S Isolated Ground Generator48 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleCommon Replacement PartsFor technical assistance, please call 800-328-7730 or e-mail techsupport@goodallmfg.comBeltsReplacement Cable Sets70-408 Long for 11-716, 11-718 and900 series DC generators70-628 Short for 11-716, 11-718 and900 series DC generators71-819 For 11-610 and 11-620Call for additional beltsRegulator Upgrade Kit70-436S 30 ft. 1/0 ga. replacement cable set70-441 30 ft. 1/0 ga. cable set with red plug(not shown)70-439 50 ft. 1/0 ga. replacement cable set70-437S 30 ft. 2 ga. replacement cable setIncludes Antizap Surge ProtectorWelder Replacement PartsConvert existing models that use two70-600 regulators to one newly designedrobust regulator (70-635) offering moredurability and a reverse polarity shutdown feature. Some re-wiring required.Kit includes: Voltage control, necessarywires and instructions61-784 For 11-620 Start•All61-785 For 11-610 Start•All950-021 End connectors950-022 Stinger950-023 Ground clamp350-043 25 ft. welding cableTune-Up KitBriggs & Stratton Vanguard V-Twin Tune Up KitIncludes:• Air filter/pre-cleaner• Spark plugs (2)• Fuel stabilizer• Fuel filter• Oil drain bag• Oil filter• Engine oilReplacementParts800-328-7730 www.goodallmfg.com49

Power equipment for your service vehicleFirst Aid KitsMADE IN THEUSA18-140 Travel First Aid KitThis 107-piece first aid kit is ideal for contractors, fleet vehicles, work sites or small companies with up to 25 employees. It meets federal OSHA recommendations andcarries 17 critical products including a 4 oz. eye wash and a Rescue Breather CPR one-way valve faceshield. The strong metal case is wall mountable, yet has a handlefor easy carrying.Contents:(50) 3/4" x 3" adhesive plastic bandages(3) 1-3/4" x 3" large fingertip fabric bandages(2) 1-1/2" x 3" knuckle fabric bandages(6) 2" x 2" gauze dressing pads, (3) 2-pks.(1) 5" x 9" trauma pad(1) 2" conforming gauze roll bandage(1) 36" triangular sling/bandage, with 2 safety pins(12) aspirin tablets, (6) 2-pks.(12) antiseptic cleansing wipes (sting-free)(6) triple antibiotic ointment packs(3) insect sting relief pads(1) 1/2" x 5 yd. first aid tape roll(1) 4" x 5" instant cold compress(1) sterile eye pad(1) eye wash, 4 oz.(1) CPR one-way valve faceshield, latex-free(2) exam quality vinyl gloves, 1 pair(1) 4-1/2" scissors, nickel plated(1) 4" tweezers, plastic(1) first aid guideKit dimensions: 10-1/2" x 7-1/2" x 2-1/2"18-100 18-12018-130Travel First Aid Kit Auto First Aid Kit Premium First Aid KitThis 62-piece first aid kit is ideal for contractors,vehicles or small companies with fewer than 10employees. It meets federal OSHA requirements1910.151b (state requirements may vary). Sturdyand convenient, the 10-unit plastic case containsthe first aid essentials to prepare you for work-relatedaccidents. The partitioned, water-resistant plastic caseis wall mountable, yet has a handle for easy carrying.This 93-piece vehicle kit is designed for fleet andcommercial vehicles. Its hard metal with gasketholds quality brand products that are easilyaccessible in an emergency. This kit meets federalOSHA recommendations and offers easy refillingwith the help of a full-color re-ordering schematic.This 106-piece first aid kit is ideal for contractors, fleetvehicles, work sites or small companies with up to25 employees. It exceeds federal OSHA requirements1910.151b (state requirements may vary). The sturdyand convenient plastic case contains the first aidessentials to prepare you for work-related accidents.50 www.goodallmfg.com 800-328-7730

Power equipment for your service vehicleLIMITED WARRANTYGoodall products are warranted to the original purchaser againstfailure due to defective material and/or workmanship for a period ofone (1) year from the date of purchase, except for gasoline engines,hydraulic motors, flow control valves and air compressors, whichare warranted solely by the manufacturer of such items.This warranty does not cover any product altered, used for apurpose other than that for which it is intended or used in a mannerinconsistent with any instruction regarding its use. The exclusiveremedy for any product found to be defective under this warranty islimited to the repair, or replacement of the defective product withoutcharge, and Goodall shall not be liable for any consequential orincidental damages, including labor charges.In order to qualify for this warranty, all returns must receive priorauthorization from the factory and be returned directly to theGoodall factory (or authorized service center) postage or freightprepaid. Goodall will make final determination of defects. No agent,employee, or representative of Goodall has any authority to bindto any affirmation, representation or warranty concerning Goodallproducts, except as stated herein.All specifications are subject to change without notice.NOTESFirst Aid Kits800-328-7730 www.goodallmfg.com51

Power equipment for your service vehicleDC Welding Air Compressor AC Power Jump Starting7558 Washington Avenue South, Eden Prairie, MN 55344 800-328-7730 www.goodallmfg.comPRINTED IN THE USAForm No. 675