Download 1980 Volkswagen VW Transporter / Caravelle Instruction ...

More documents

Recommendations

Info

Do-it-yourselfService installation of beltsSeat belts can be service installed for allseats in vehicles which are not fitted withbelts in the factory.FrontThe front anchorages are marked with ringsin the illustration. On vehicles with a twoseaterbench the anchorages for the centreplace are on the inside of the seat boxes.RearAnchorages are provided for all seats in thepassenger compartment. Depending onmodel they are either in the seat frames orthe side panels.The holes for the belt bolts are covered by theinterior trim and the holes in the carpet are fittedwith plastic plugs or covered with adhesivetape.These plastic plugs must not be used toattach the belts.Anchorages which are not being used shouldbe fitted with plugs.V.A.G. workshops have all the necessary informationon the fitting of belts.The installation of seat belts should thereforepreferably be done by a V.A.G workshop.www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans
Do-it-yourselfHints on fault findingSome hints on fault finding are given in various parts of this manual.These hints are summarized again here.Fault Possible cause RemedyEngine is hard to start orwill not start at allEngine tends tostall when warming upOil pressure warning lampcomes on or flickers whenengine is runningGenerator warning lamp comeson when engine is runningIncorrect starting procedureBattery flat (starter notturning)Carburetor icingOil pressure too lowV belt slack or brokenIf belt is in order thegenerator may be defectiveUse correct procedure (page 21)• Start with booster battery (page 74)• Have battery charged (page 58)• Push or tow start vehicle(not possible with automatic gearbox)Mix Volkswagen-Audi Petrol Additivewith the fuel (page 44)Stop engine immediately and checkoil level. Further notes on page 47Adjust tension or fit new belt.Without belt, drive slowly (max. 50 km/h)to nearest V.A.G Dealer.Further notes on page 22Drive to next V.A.G Dealer. Batterywith discharge continuously.77www.WestfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 / Vanagon Campervans
Page 1 and 2:
Instruction Manualfor theVolkswagen
Page 3 and 4:
Instruction Manualfor theVolkswagen
Page 5 and 6:
IntroductionAmong the publications
Page 7 and 8:
ContentsOperating instructionsPage.
Page 9 and 10:
Instrument panelPage1 - Vents for s
Page 11 and 12:
OperationThe sliding door can only
Page 13 and 14:
OperationRear flapTo openUnlock wit
Page 15 and 16:
OperationSeats in passenger compart
Page 17 and 18:
OperationSeat belts*Vehicles with t
Page 19 and 20:
Operationotes:eat belts are only be
Page 21 and 22:
OperationGear leverManual gearboxSe
Page 23 and 24:
Operation:arting the engine• care
Page 25 and 26:
Operation(©) Brake systemOn vehicl
Page 27 and 28: OperationFuel gaugeThe tank holds a
Page 29 and 30: OperationC- Emergency light switch*
Page 31 and 32: Operation"he windscreen wipers and
Page 33 and 34: OperationF - Warm air vents for sid
Page 35 and 36: Operation0Temperature regulating sw
Page 37 and 38: OperationVehicles with sliding roof
Page 39 and 40: Driving tipsThe first 1000 km - and
Page 41 and 42: Driving tipsDriving economically_-
Page 43 and 44: Driving tipsEngine oiltends to thic
Page 45 and 46: Driving tips"owing a trailer places
Page 47 and 48: Operating instructionsFilling tankT
Page 49 and 50: Operating instructionsEngine oil le
Page 51 and 52: Operating instructionswww.Westfalia
Page 53 and 54: Operating instructionsWheelsWheels
Page 55 and 56: Operating instructionsChanging whee
Page 57 and 58: Care and maintenanceCare of carRegu
Page 59 and 60: Care and maintenanceAiring the inte
Page 61 and 62: Care and maintenanceClimateTropical
Page 63 and 64: Care and maintenance37 kW engine•
Page 65 and 66: Care and maintenanceAir cleanerThe
Page 67 and 68: Care and maintenanceLifting vehicle
Page 69 and 70: Do-it-yourselfChanging a wheelPrepa
Page 71 and 72: Do-it-yourselfFusesTo prevent damag
Page 73 and 74: Do-it-yourselfHeadlights (Normal) A
Page 75 and 76: Do-it-yourselfNumber plate lightThe
Page 77: Do-it-yourselfTowingSo that you can
Page 81 and 82: Do-it-yourselfThe Automatic Gearbox
Page 83 and 84: Automatic GearboxDriving tipsStarti
Page 85 and 86: Automatic GearboxLubricationThe tor
Page 87 and 88: Technical DescriptionEngineLocated
Page 89 and 90: Technical DataFuel consumption*37 k
Page 91 and 92: Technical DataCapacities 37 kW engi
Page 93 and 94: Technical DataWeightsVehicles with
Page 95 and 96: Identification Plate, Chassis Numbe
Page 97 and 98: Alphabetical Index-tank capacity 45
Page 99 and 100: Alphabetical IndexWaxing 56Weights
show all

Download 1980 Volkswagen VW Transporter / Caravelle Instruction ...

Create successful ePaper yourself

Delete template?

Save as template?