McConnel Magnum 130 Flail Mower Operators and Parts Manual

GEARBOX LUBRICATIONThe photo opposite shows the lubricationaccess point for the gearbox – this accesspoint is used for both filling and lubricantlevel checking.Lubricant level should be checked on adaily basis during work and topped up onlyif required.Checking the level is by removal of the plug– lubricant should be inline with the bottomof the aperture. ‘Topping up’ the lubricant isperformed via the same aperture to a pointwhere the oil starts to ‘dribble’ out. Replaceand tighten the plugs before using themachine.Gearbox oil should be replaced annually.Gearbox Capacity & Lubricant TypeLocation of gearbox lubricant access plug0.8 Litre SAE90FLAIL REPLACEMENTThe rotor and flails should be inspected for wear or damage on a regular basis – missing,damaged or worn flails should be replaced immediately. When replacing a flail thediametrically opposite flail should also be replaced at the same time in order to maintainrotor balance.DANGER: Machine and tractor should be switched off and the starting key removed at all times wheninspecting or maintaining the machine – Never work on a machine that is switch on and running.Always replace flails in opposing pairsROTOR VIBRATIONIf vibration of the rotor is experienced the machine should be stopped immediately – this isoften a sign that a flail is either missing or severely damaged, if this is the case do not usethe machine until the problem has been rectified. If vibration continues, or occurs for noapparent reason, the rotor must be checked and, if necessary, rebalanced before usingthe machine again. Contact your local dealer for further advice or assistance on thissubject.16