Chemical Compatibility Guide - Dalton International

International, Inc.ChemicalCompatibilityGuideThe Leak Stops Here.11542 Davis Creek Court • Jacksonville, Florida 32256 USA(904) 292-1611 • 1-800-353-1611 • FAX (904) 292-1325E-Mail: UltraTech@SpillContainment.comWeb Site: www.SpillContainment.com

XR-5 ® , Urethane & Copolymer 2000 ®CHEMICAL COMPATIBILITY GUIDE*For Ultra-Containment BermsAccording to EPA guidelines, spills must be cleaned up within 24 hours and any secondary containment areas must be inspectedonce a week. The chart below lists chemical compatibility of XR-5 ® , Urethane, Copolymer 2000 ® and Polyethylene. The informationhas been developed from industry available data and offers compatibility based on exposure of one week or less.The rating system is indicated as:A - Fluid has little or no effect at Room TemperatureB - Fluid has minor to moderate effect at Room TemperatureC - Fluid has severe effect at Room TemperatureChemical XR-5 ® Urethane Copolymer 2000 ® PolyethyleneKerosene A A A ADiesel Fuel A A A AOhio Crude Oil A A A AHydraulic Fluid- Petroleum Based A A A ANaptha A A A AConc. Ammonia Hydroxide A C A A50% Acetic Acid C C C A50% Phosphoric Acid A C A A50% Hydrochloric Acid A C A A50% Nitric C C C B50% Sulfuric Acid A C A A60% Sodium Hydroxide A C A AMethyl Alcohol A A A AJP-4 Jet Fuel A A A ASalt Water 180 o F A B A APhthalate Plasticizers B A B ASAE-30 Oil A A A ARaw Linseed Oil A A A AThe above ratings were arrived at by visual and physical examination of the membrane samples after their removal from thetest chemical. When considering XR-5 ® , Urethane, Copolymer 2000 ® , or Polyethylene for specific applications, it is importantto study the requirements such as permeability, service temperature, concentration, size to be contained, etc. Samplesof XR-5 ® , Urethane, Copolymer 2000 ® , or Polyethylene should be tested close to actual service conditions and also yourdistributor should be consulted.*IMPORTANT USER NOTICE FOR XR-5 ® , URETHANE, COPOLYMER 2000 ®& POLYETHYLENE CHEMICAL COMPATIBILITY GUIDEThis listing is offered only as a guide and utilizes information which, to the best of UltraTech’s knowledge, is accurate andreliable. Due to variables and conditions of application beyond the control of UltraTech, none of the data shown in this guideis to be construed as a guarantee, expressed or implied. UltraTech International, Inc. assumes no responsibility, obligationor liability in conjunction with the use or misuse of the information herein.

forULTRA-SPILLBERMS ® , PART# 2100, 2051, 2052ULTRA-SPILLBERM ® CONNECTOR, PART# 2101ULTRA-SPILLBERM ® CORNER, PART# 2102ULTRA-SPILLBERM PLUS ® , PART# 2054ULTRA-SPILLBERM-LOW PROFILE ® , PART# 2052ULTRA-TABLETOP SPILLBERM ® , PART# 2051ULTRA-DRAINSEAL ® , PART# 2124-7, 2127, 2130-3, 2134-7ULTRA-DRAINPLUG ® , PART# 2113, 2114, 2115, 2116Key:Swelling:Visually rated from 0-2;0 = none1 = slight2 = significantDegradation:Visually rated from 0-2;0 = none1 = slight2 = significantPOLYURETHANECHEMICAL COMPATIBILITY GUIDE*Ratings:NR (Not Recommended):Significant degradation or swellingFAIR: Slight swellingGOOD: No swellingVisibleSwelling DegradationChemical Chemical Class (0-2) (0-2) RatingAcetone Ketones 2 0 NRAcetonitrile Nitriles 1 0 FAIRAluminum Salts Aluminum Compounds 0 0 GOODBarium Salts Barium Compounds 0 0 GOODBenzyl Alcohol Hydroxyl Compounds 1 1 FAIRBoric Acid Inorganic Acids 0 0 GOODButanol Hydroxyl Compounds 0 0 GOODCalcium Chlorite Calcium Compounds 0 0 GOODCarbon Disulfide Sulfur Compounds 1 0 FAIRCupric Chloride Copper Compounds 0 0 GOODCyclohexanone Ketones 1 2 NRDichloromethane Halogen Compounds 2 2 NRDiethylamine Aliphatic Amines 1 1 FAIRDimethylformamide Aliphatic Amides 2 2 NREthyl Acetate Carboxylic Esters 1 0 FAIRFormaldehyde Aliphatic Aldehydes 0 0 GOODGasoline Aromatic Hydrocarbons 0 0 GOODGycol Ether Ethers 0 0 GOODHexane Aliphatic Hydrocarbons 0 0 GOODHydrochloric Acid (37%) Inorganic Acids 0 2 NRHydrogen Peroxide (30%) Peroxides 1 0 FAIRHydrofluoric Acid (48%) Inorganic Acids 0 2 NRJet Fuel (JP-5) Aliphatic Hydrocarbons 0 0 GOODKerosene Hydrocarbons 0 0 GOODMetahanol Aliphatic Hydroxylic 0 0 GOODCompoundsMethyl Ethyl Ketone Aliphatic Ketones 2 0 NRMineral Oil Aliphatic and Alicyclic 0 0 GOODHydrocarbonsNaphtha Hydrocarbons 0 0 GOODNitrobenzene Nitro Compounds 0 2 NRPhenol Aromatic Hydroxylic 0 2 NRCompoundsPropylene Glycol Hydroxylic Compounds 0 0 GOODSodium Hydroxide (50%) Inorganic Bases 0 0 GOODSulfuric Acid (98%) Inorganic Acids 0 2 NRSulfuric Acid (50%) Inorganic Acids 0 2 NRTetrachloroethylene Halogen Compounds 0 0 GOOD(Vinyl Halides)Tetrahydrofuran Alicyclic Ethers 2 2 NRToluene Aromatic Hydrocarbons 1 0 FAIR1,1,1-Trichloroethane Aliphatic Halogen 1 0 FAIRCompoundsTrichloroethylene Halogen Compounds 1 0 FAIR(Vinyl Halides)Triethylamine Aliphatic Amines 0 0 GOODTurpentine Hydrocarbons 0 0 GOODWater Misc. 0 0 GOOD*IMPORTANT USER NOTICE FOR BOTH THE POLYURETHANE& POLYETHYLENE CHEMICAL COMPATIBILITY GUIDESThe data contained herein is a compilation of existing published data from leading manufacturers of polyethylene andpolyurethane and does not represent actual testing performed by UltraTech International, Inc.This listing is offered only as a guide and utilizes information which, to the best of UltraTech’s knowledge, is accurate andreliable. Due to variables and conditions of application beyond the control of UltraTech, none of the data shown in thisguide is to be construed as a guarantee, expressed or implied. UltraTech International, Inc. assumes no responsibility,obligation or liability in conjunction with the use or misuse of the information herein.

POLYETHYLENECHEMICAL COMPATIBILITY GUIDE*for Ultra Environmental Containment ProductsThis listing was prepared to provide guidance to the chemical compatibility of Ultra EnvironmentalContainment Products ® which are manufactured and constructed of a molded polyethylene.Polyethylene is susceptible to attack by some chemicals which may cause stress cracking, swelling, oxidation or may permeate thepolyethylene. These reactions may reduce the physical properties of polyethylene.When considering an UltraTech polyethylene product for use in secondary containment applications, it is important to note that mostsecondary containment products are designed to hold leaked chemicals for only hours, a day, at most a week. These secondarycontainment units would then be cleaned of any chemical. In these short term applications, a greater variety of chemicals may be usedwith the polyethylene since the exposure time of the chemical to the polyethylene is limited.A = Suitable for long term storage at 100 degrees F or less.B = Suitable for short term storage less than one year.C = Do NOT store these chemicals in UltraTech containers.User testing may prove some of these chemicals are suitable for secondary containmentapplications with exposure time of one week or less.ACETALDEHYDE (40%)AACETAMIDEAACETIC ACID (50%)AACETIC ACID ANHYDRIDEBACETIC ETHERBACETONEAACETYLENE TETRABROMIDE BACRYLIC EMULSIONSBACRYLONITRILEAADIPIC ACIDAALIPHATIC HYDROCARBONS AALKALINEAALLYL ALCOHOL (96%)AALUMINUM CHLORIDE (20%) AALUMINUM FLURIDEAALUMINUM HYDROGEN SOLUTION(10%) AALUMINUM HYDROXIDEAALUMS (ALL TYPES)AAMMONIA (AQUEOUS)AAMMONIUM SALTSAAMMONIUM ACETATEAAMMONIUM BIFLUORIDEAAMMONIUM CARBONATE (50%) AAMMONIUM CHLORIDEAAMMONIUM HYDROGEN FLUORIDE(50%) AAMMONIUM HYDROXIDEAAMMONIUM METAPHOSPHATESAT'DAAMMONIUM NITRATE SAT'D AAMMONIUM PERSULFATE SAT'D AAMMONIUM PHOSPHATEAAMMONIUM SULFATE SAT'D AAMMONIUM SULFIDE SAT'D AAMMONIUM THIOCYANATE SAT'D AAMYL ACETATEAAMYL ALCOHOL (100%)AAMYL CHLORIDECANILINE (100%)BANILINE HYDROCHLORIDEBANTI-FREEZEAANTIMONY SALTSAANTIMONY TRICHLORIDE (90%) AAQUA REGIACAQUEOUS ALKALIES (NaOH) AARSENIC ACIDABARIUM SALTSABARIUM CARBONATEABARIUM CHLORIDEABARIUM CYANIDEABARIUM HYDROXIDEABARIUM NITRATEABARIUM SULFATEABARIUM SULFIDEABATTERY FLUID, ACIDBBENZALDEHYDEABENZENEBBENZENE SULFONIC ACIDBBENZOIC ACIDABENZYL ALCOHOLABENZYL CHLOROFORMATE ABORAX COLD SAT'DABORIC ACID DILUTEABORIC ACID CONC.ABROMINE, LIQUIDCBROMINE, WATERBROMOBENZENEBROMOFORMBUTADIENEBUTANEDIOL (100%)BUTANOLBUTYL ACETATEBUTYL ALCOHOL (100%)BUTYLENEBUTYLENE GLYCOLBUTYLENE LIQUIDBUTYL PHENOLBUTYRIC ACIDCALCIUM CARBONATECALCIUM CHLORIDECALCIUM HYDROXIDECALCIUM HYPOCHLORITECALCIUM NITRATE (50%)CALCIUM SULFATECARBON BISULFIDECARBON DISULFIDECARBONIC ACID (AQ. C02)CARBON MONOXIDECARBON TETRACHLORIDECAUSTIC (AQUEOUS)CAUSTIC POTASH SOL. (50%)CAUSTIC SODA SOL. (10%)CHLORAL HYDRATECHLOROETHANOLCHLORIC ACID (10%)CHLOROACETIC ACIDCHLOROBEZENECHLOROFORMCHLOROMETHANECHLORSULFONIC ACID (100%)CHROME ALUM SAT'DCHROMIC ACID (50%)COPPER CYANIDECRESYLIC ACIDCROTONIC ALDEHYDECUPROUS CHLORIDE SAT'DCYCLOHEXANECYCLOHEXANOLCYCLOHEXANONEDEXTRIN SAT'DDEXTROSE SAT'DDIBUTYL ETHERDIBUTYLPHTHALATEDIBUTYL SEBACATEDICHLOROACETIC ACIDDICHLOROBENZENE, LIQUIDDICHOLORETHYLENEDIESEL FUELDIESEL OILDIETHYL CARBONATEDISODIUM PHOSPHATEDIETHYLENE GLYCOLDIETHANOLAMINEDIGYCOLIC ACID (30%)DI-ISOBUTYL KETONEDIMETHYLAMINEDIMETHYL FORMAMIDEDINONYL PHTHALATEDIOCTYL PHTHALATEDIOXANEDIPHENYL OXIDECCCAAAAACACCAAAAAAACCAACAAAAAAAACCCABAAAAAABAACBBBCCBBAAABABBBCCACELECTROLYTEETHANOLETHERETHYL ACETATE (100%)ETHYL ALCOHOLETHYL BUTYRATEETHYL CHLORIDEETHYL ETHERETHYLENE CHLORIDEETHYLENE CHLOROHYDRINETHYLENE DIAMINEETHYLENE DICHLORIDEETHYLENE GLYCOLETHYLENE OXIDEFATTY ACIDSFERRIC SULFATEFERROUS SALTSFERROUS SULFATEFLUOBORIC ACIDFLUOSILICIC ACID(ALL CONC.)FORMALDEHYDE (40%)FORMAMIDEFORMIC ACID (ALL CONC.)FUEL OILFURFURAL (100%)FURFURYL ALCOHOLGALLIC ACID SAT'DGASOLINEGLUCONIC ACID (ALL CONC.)GLYCERINEGLYCOLGLYCOLIC ACID (ALL CONC.)HEPTANEHEXANEHYDRAZINE HYDRATEHYDROSULFITE (10%)HYDROXYLAMINE SULFATEHYDROZINE (35%)HYDROZINE HYDROCHLORIDEHYDROIODIC ACID (ALL CONC.)HYDROBROMIC ACID (50%)HYDROCYANIC ACID SAT'DHYDROCHLORIC ACID(ALL CONC.)HYDROFLUORIC ACID(ALL CONC.)HYDROFLUORISILICIC ACID(ALL CONC.)HYDROGEN BROMIDE (10%)HYDROGEN PEROXIDE (90%)HYDROGEN PHOSPHIDE (100%)HYDROQUINONEHYDROGEN SULFIDEHYPOCHLOROUS ACIDISO-OCTANEISOPROPYL ACETATEISOPROPYL ALCOHOLISOPROPYL ETHERJET FUELKEROSENELACTIC ACID (ALL CONC.)LEAD ACETATE SAT'DMAGNESIUM SALTSMAGNESIUM CARBONATEMAGNESIUM HYDROXIDEAACBABCCCAACACAAAAAAAAAAACAAAAAAAAAAAAAAAAAAAAAAAAABAACBBAAAAAMAGNESIUM NITRATEMAGNESIUM OXIDEMAGNESIUM SULFATEMALEIC ACIDMETHANOLMETHYL ACETATEMETHYL ALCOHOL (100%)METHYL AMINE (32%)METHYL BROMIDEMETHYL CHLORIDEMETHYLENE CHLORIDEMETHYL ETHYL KETONEMETHYL ISOBUTYL KETONEMETHYL ISOPROPYL KETONEMETHYL SULFATEMETHYL SULFURIC ACID(ALL CONC.)MINERAL OILSMONOCHLOROACETIC ACIDETHYL ESTERMONOCHLOROACETIC ACIDMETHYL ESTERMOWILITH DNAPTHANAPTHALENENICOTINE DILUTENICOTINIC ACIDNITRIC ACID