75/90/115/115 Pro XS/125 OptiMax - Mercury

More documents

Recommendations

Info

Mercury MarineWARRANTY INFORMATIONAttn: Warranty Registration DepartmentBrunswick Asia Pacific GroupPrivate Bag 1420Dandenong South, Victoria 3164AustraliaUpon processing the transfer of warranty, Mercury Marine willsend registration verification to the new owner of the product bymail. There is no charge for this service.You may change your address at any time, including at the timeof the warranty claim, by calling Mercury Marine or sending aletter or fax with your name, old address, new address, and hullidentification number (HIN) to Mercury Marine’s WarrantyRegistration Department.26 eng
GENERAL INFORMATIONBoater's ResponsibilitiesThe operator (driver) is responsible for the correct and safeoperation of the boat and the safety of its occupants and generalpublic. It is strongly recommended that each operator read andunderstand this entire manual before operating the outboard.Be sure that at least one additional person onboard is instructedin the basics of starting and operating the outboard and boathandling in case the driver is unable to operate the boat.Before Operating Your OutboardRead this manual carefully. Learn how to operate your outboardproperly. If you have any questions, contact your dealer.Safety and operating information that is practiced, along withusing good common sense, can help prevent personal injury andproduct damage.This manual as well as safety labels posted on the outboard usethe following safety alerts to draw your attention to special safetyinstructions that should be followed.! DANGERIndicates a hazardous situation which, if not avoided, will resultin death or serious injury.! WARNINGIndicates a hazardous situation which, if not avoided, couldresult in death or serious injury.! CAUTIONIndicates a hazardous situation which, if not avoided, couldresult in minor or moderate injury.NOTICEIndicates a situation which, if not avoided, could result inengine or major component failure.eng 27
Page 6: vi eng
Page 10: MaintenanceOutboard Care...........
Page 13 and 14: WARRANTY INFORMATIONWarranty Regist
Page 15 and 16: WARRANTY INFORMATIONFor help or ass
Page 17 and 18: WARRANTY INFORMATIONHOW TO OBTAIN W
Page 19 and 20: WARRANTY INFORMATIONFor additional
Page 21 and 22: WARRANTY INFORMATIONHOW TO OBTAIN W
Page 23 and 24: WARRANTY INFORMATIONWarranty Covera
Page 25 and 26: WARRANTY INFORMATION16.Our limited
Page 27 and 28: WARRANTY INFORMATIONWHAT IS COVERED
Page 29 and 30: WARRANTY INFORMATIONExpenses relate
Page 31 and 32: WARRANTY INFORMATIONAs the outboard
Page 33 and 34: WARRANTY INFORMATIONGuarantees Unde
Page 35 and 36: WARRANTY INFORMATIONHow to Obtain W
Page 37: WARRANTY INFORMATIONNo individual o
Page 41 and 42: GENERAL INFORMATIONPropeller Select
Page 43 and 44: GENERAL INFORMATIONDetermining the
Page 45 and 46: GENERAL INFORMATION! WARNINGImprope
Page 47 and 48: GENERAL INFORMATIONImportant Safety
Page 49 and 50: GENERAL INFORMATIONProtecting Peopl
Page 51 and 52: GENERAL INFORMATIONBOATS WITH FRONT
Page 53 and 54: GENERAL INFORMATION• The boat cou
Page 55 and 56: GENERAL INFORMATIONGOOD VENTILATION
Page 57 and 58: GENERAL INFORMATION• Follow a reg
Page 59 and 60: GENERAL INFORMATION• The operator
Page 61 and 62: GENERAL INFORMATIONModels 75 90115/
Page 63 and 64: TRANSPORTINGTrailering Boat/Outboar
Page 65 and 66: FUEL AND OILThe fuel system compone
Page 67 and 68: FUEL AND OIL• An air inlet that o
Page 69 and 70: FUEL AND OIL4. Follow Filling Fuel
Page 71 and 72: FUEL AND OILCapacityFluid TypeOil t
Page 73 and 74: FEATURES AND CONTROLSRemote Control
Page 75 and 76: FEATURES AND CONTROLSENGINE GUARDIA
Page 77 and 78: FEATURES AND CONTROLSWith most boat
Page 79 and 80: FEATURES AND CONTROLS3. Disengage t
Page 81 and 82: FEATURES AND CONTROLSIf adjustment
Page 83 and 84: OPERATIONIt is illegal to operate a
Page 85 and 86: OPERATIONBreak‐in Procedure• Do
Page 87 and 88: OPERATION6. For the initial start o
Page 89 and 90:
Stopping the EngineOPERATIONReduce
Page 91 and 92:
MAINTENANCEEMISSION CERTIFICATION L
Page 93 and 94:
MAINTENANCEEVERY 25 HOURS OR EVERY
Page 95 and 96:
MAINTENANCENOTE: The engine can be
Page 97 and 98:
INSTALLATIONMAINTENANCEPosition the
Page 99 and 100:
MAINTENANCEBefore servicing any par
Page 101 and 102:
MAINTENANCESteering Link Rod Fasten
Page 103 and 104:
MAINTENANCEOpen the fuse holder and
Page 105 and 106:
MAINTENANCE• Do not use deep‐cy
Page 107 and 108:
MAINTENANCE4. Place a block of wood
Page 109 and 110:
MAINTENANCE4. Secure the propeller
Page 111 and 112:
MAINTENANCEd. When it is necessary
Page 113 and 114:
MAINTENANCE• Propeller shaft ‐
Page 115 and 116:
MAINTENANCE2. Remove fill cap and c
Page 117 and 118:
MAINTENANCE3. Remove fill/drain plu
Page 119 and 120:
STORAGE3. Pull the drain hose off t
Page 121 and 122:
STORAGE• Touch up any paint nicks
Page 123 and 124:
OWNER SERVICE ASSISTANCESERVICE AWA
Page 125 and 126:
OWNER SERVICE ASSISTANCEUnited Stat
Page 127 and 128:
TROUBLESHOOTINGStarter Motor Will N
Page 129 and 130:
OUTBOARD INSTALLATIONMercury Marine
Page 131 and 132:
OUTBOARD INSTALLATIONStart in Gear
Page 133 and 134:
OUTBOARD INSTALLATIONPermanent Fuel
Page 135 and 136:
OUTBOARD INSTALLATIONSteering Cable
Page 137 and 138:
OUTBOARD INSTALLATIONDetermining Re
Page 139 and 140:
OUTBOARD INSTALLATIONTransom Drilli
Page 141 and 142:
OUTBOARD INSTALLATIONUse a dial tor
Page 143 and 144:
OUTBOARD INSTALLATIONIMPORTANT: Cle
Page 145 and 146:
OUTBOARD INSTALLATIONA decal on the
Page 147 and 148:
OUTBOARD INSTALLATION4. Install the
Page 149 and 150:
OUTBOARD INSTALLATIONREMOTE BOAT HA
Page 151 and 152:
Dual OutboardsOUTBOARD INSTALLATION
Page 153 and 154:
OUTBOARD INSTALLATION1. The water p
Page 155 and 156:
OUTBOARD INSTALLATIONFuel Hose Conn
Page 157 and 158:
OUTBOARD INSTALLATION4. Push in on
Page 159 and 160:
OUTBOARD INSTALLATION5. Lock the re
Page 161 and 162:
OUTBOARD INSTALLATION3. Turn the ig
Page 163:
Maintenance LogMAINTENANCE LOGRecor
show all

75/90/115/115 Pro XS/125 OptiMax - Mercury

Create successful ePaper yourself

Delete template?

Save as template?