A Flow Controls & Accessories

More documents

Recommendations

Info

Catalog MRO-6WICheck ValvesFlow Controls & Accessories“3047” Series & “VC” SeriesA“3047” – 1/4" Male Pipe“VC” – Check Valve13/16 Hex35/64 Flats.22 (6)Dia.General Information“3047” Series check valves allow free flow in one directionand provide positive checked (zero flow) in the reversedirection. This valve is available with a male 1/4" NPTFconnection and is recommended for pneumatic service.Valve SpecificationsMaximum Operating Pressure:250 PSIGCracking Pressure: 1 to 2 PSIGOperating Temperature:Standard: 0° to 180° F** Ambient temperatures below freezing require moisture-free air. Ambienttemperatures below freezing and above 180° require lubricants especiallyselected for suitability at these temperatures. Pneumatic valves should beused with filtered and lubricated air.Component MaterialsBody Material................................................................BrassInternal Components........................Brass / Stainless SteelSeals...............................................................................NitrileModel SelectionModelNumber2.31(59)PipeThreadFlow †(SCFM)03047 0099 1/4" 30General InformationPush-to-Connect check valves that ensures protectionagainst reversal of flow. The valves have an arrow moldedinto the body to indicate the direction of flow. Valves aredesigned for connection with either thermoplastic or softmetal tubing and are intended for use with liquids only.Valve SpecificationsWorking Pressure:Up to 150 PSI depending on tubing being usedTemperature Range:+34°F (1° C) to +150°F (65°C)Cracking Pressure: 1/3 PSIAssembly Instructions1. Cut tubing squarely, be certain the tubing is clean and freeof debris.2. Insert tubing into check valve until it bottoms. A slighttwisting motion will ease the insertion. Pull on tubing toverify it is properly retained in the fitting.3. To disassemble, simply push in the release button againstthe body and remove the tubingComponent MaterialsBody..............................................................................AcetalO-ring............................................................................EPDMMetal Grip Edge............................................... 300 StainlessModel Selection and DimensionsPart No. Tube Size L O.D.A4VC4-MG 1/4 2.00 0.66A5VC5-MG 5/16 2.10 0.70A6VC6-MG 3/8 2.15 0.80L† At 100 PSIG inlet pressure with full pressure drop.O.D.A16Pneumatic DivisionRichland, Michiganwww.wilkersoncorp.com
Catalog MRO-6WIFeatures & Part NumbersTank ValvesFor tanks, steel barrels, compressors and otherpneumatic containers where a dependable automaticair valve is needed. Equipped with standard valve coreand sealing cap. Maximum operating pressure is 185PSIG. Temperature range is -40°F to 220°F.Flow Controls & AccessoriesTank Valves & Air ChucksAir ChucksFor regular airlines.AModel No. 09166 0060Has a 1/8" pipe thread at bottom for minimumprotrusion. N/P finish, dome shaped cap.Packed 25 to a box.Model No. 05499 0000Ball-foot air chuck, 1/4" female port.Packed 10 to a box.7/16" HEX23/32"1-9/32"1/8"Model No. 00645 0060A 1/8" pipe thread at bottom permits maximumprotrusion. N/P finish, screwdriver type cap.Packed 25 to a box.Model No. 06739 0000Ball-foot air chuck with clip. Fits standard valvemouth. Saves holding on by hand. Has 1/4" port forconnecting to hose.Packed 10 to a box.1-1/8"7/16" HEX1-3/4"1/8"Model No. 01468 0006Has a 1/8" pipe thread part way up the stem whichallows for minimum protrusion. N/P finish, hasscrewdriver type cap.Packed 25 to a box.Model No. 06658 0000Ball-foot air chuck with clip. Fits standard valve mouth.Shank fits 1/4" I.D. hose.Packed 10 to a box.7/16" HEX13/16"1/8"1-3/4"A17Pneumatic DivisionRichland, Michiganwww.wilkersoncorp.com
Page 4 and 5: Catalog MRO-6WIIn-Line Flow Control
Page 6 and 7: Catalog MRO-6WIFlow Control ValvesF
Page 9 and 10: Catalog MRO-6WIMicrometer Flow Cont
Page 11 and 12: Catalog MRO-6WIFlow Control ValvesF
Page 13 and 14: Catalog MRO-6WINeedle ValvesFlow Co
Page 15: Catalog MRO-6WICheck ValvesFlow Con
Page 19 and 20: Catalog MRO-6WIBreather Vents, Sile
Page 21 and 22: Catalog MRO-6WIAir Line Silencer -
Page 23 and 24: Catalog MRO-6WI(Revised 10-19-07)Au
Page 25 and 26: Catalog MRO-6WIQuick Exhaust & Shut
Page 27 and 28: Catalog MRO-6WIQuick Exhaust & Shut
Page 29 and 30: Catalog MRO-6WIPressure Switch - P0
Page 31 and 32: Catalog MRO-6WI(Revised 07-02-07)Au
Page 33 and 34: Catalog MRO-6WIExternal Compressor
Page 35 and 36: Catalog MRO-6WISafety GuidePneumati
Page 37: Catalog MRO-6WIOffer of SalePneumat

A Flow Controls & Accessories

Create successful ePaper yourself

Delete template?

Save as template?