Unimog U 500 Technical Data - Mercedes-Benz UK

Unimog U 500Technical DataWheelbase 3350 mm (BM 405.201)Wheelbase 3900 mm (BM 405.221)70 207434502670Top edgeImlementmountingplateIMPUpperedgeof frame400293329451018103029°53°39°940952119812101474148644145311503350539039006120Centre oftrailer coupling23002400 [R 59]/[R 61]1828With Tyres 365/85 R 20Engine• Emission class Euro 4• Type (LA = turbochargerOM 906 LAwith intercooler)• No. and arrangementof cylinders (upright inline) 6• Working method:Diesel-direct injectionturbo charged/intercharged4 -stroke• Power output Standard OptionalkW/(hp) 175/(238) 210/(286)• At rated speed rpm 2200 2200• Max. torque Nm 850 1120• Total displacement cm 3 6374• Coolant – waterHydrostatic fanwith thermostat• Exhaust brake2-step for headcylinder valve and throttlevalve in exhaust stream• Fuel tank liters 200• Compressor310 l/min. at 18 barTransmissionsMB-All synchromesh reversing transmission, 8 gearsforward and 6 gears reverse, single-disc dry clutch• Permanent all-wheel drive with lockable interaxledifferential• Telligent ® shifting (Elec.-Pneumatic Shifting)• Cruise control/Speed limiter• Electronic Quick Reverse (EQR)Axles:• Portal axles, i = 6,38; helical springs, telescopicshock absorbers, stabilizers on front and rear axle• Differential locks on rear axle, engageable elec.pneumatically while in motion• Helical springs with progressive characteristic lineFrameStraight ladder shaped frame with transverse boltedu-chanel and welded transverse tubular cross member,rigid designBrake:Dual circuit brake system, high pressure, springloaded parking brake• Antilock Brake System (ABS)• Autom. Load responsive Brake system (ALB)• Compressed air connection for aux. use• Tire inflation connection• Disc brakes on both axlesSteeringHydraulic power steering; type: LS 6Turning circle Ø15,1 (16,9) mElectrical System:• Alternator• Starter output• Battery• Trailer socket rear• Constant current plugCabType:Doors:Glazing:Driver’sseat:Multi-shelled cab made of fiber compoundedmaterials. Built on steelframe, which is mounted, shockabsorbingly,to the chassis.2 side doors made of fiber compoundedmaterials with integratedarm-rests, storage compartmentsand bottle holders. 2 deep viewpanorama windows and manual windows.Front windshield made of laminatedglass, deep windows for optimalview onto front implements. Largerear window for excellent visibilityonto the rear mounting areas.Contoured seat with integrated headrest, height, reach, tilt and seat backadjustable. Integrated 3-point safetybelt. Storage for personal itemsbehind driver’s seat.Same as driver’s seat, with integra-ted 3-point-safety belt and headrest.Passenger’sseat:24 Volt2 240 W, 28 V, 80 A4 kW135 Ah (2 x 12 V, inline)15-pin24 VRear viewmirrors:Foldable, electrically adjustableand heatable exterior rear viewmirrors (Wide angle rear view mirrorand ramp angle rear view moirror).Storage box on rear cab wall underdashboard, right.3-setting blower fan, A/C (stan-dard), dust-free ventilation, air recycling.Storagepossibilities:Heatingand A/C:Instruments:• Elec. controls located in centre console• Dash board illumination• Multi-combination lever- steering column, right: hand throttle,cruise control, speed limiter and exhaust brake- steering column, left: headlight beams, blinker,windshild wash/wipers, horn• Large instrument panel LCD-displays, driverinformation systemMulti-Function-Display (MFD)Driver-Information-System (DIS)Tyres:4 tyres, 315/80 R 22,5, LI 156 L,rim 22,5 x 9,00WeightsBasic executionGross vehicle weight kg 11990Permissible front axle loads kg 6700Permissible rear axle loads kg 7200Maximum permissible loads incombination with mountedimplements, only for roadmaintenance services:Gross vehicle weight kg 16000Permissible front axle loads kg 7500Permissible rear axle loads kg to 9500

...and this is the standard equipment list for the new U 500:• Additional side indicators• Air filter with pre-separator• Air-intake chimney• Air pressure, spur gear driven, water cooled,300 l/min at 18 bar• All-round heat reducing glas• Aluminium fuel tank• Anti-corrosion fenders• Antilock Brake System (ABS)• Anti-slip steps with handle for windshield cleaning• Armrest integrated in door molding• Ashtray with cigarette lighter• Autom. Load responsive Brake system (ALB)• Batteries 2 X 12V/135Ah, low maintenance• Bio diesel capable (RME)• Cab tiltable• Cab suspension with shock absorbers, rear• Centrally located elec. box, protected within cab• Cigarette lighter• Clearance lamps• Compound fibre cab – corrosion free• Compressed air connection for aux. use• Compressed air drier• Cooling fan, elec. regulated, hydraulic drive• Cruise control/Speed limiter• Dash board illumination• Deep windows in door• Differential locks on rear axle, engageable elec.-pneumatically while inmotion• Disc wheels on both axles• Driver seat height, tilt, backrest tilt and longitudinal adjustable• Dual circuit brake system, high pressure (18,5 bar)• Elec. controls located in centre console• Electric and electronic parts (elec. magneticcompatible)• Electronically governed max. speed of 85 km/h• Electronic accelerator• Electronic Hand throttle• Electronic powertrain management system with diagnostic interfaceand onboard diagnostics• Electronic Quick Reverse (EQR).• Engine with exhaust turbo charger and air cooled, electronic injectiongovernor (MR)• Ergonomic middle console, centrally arranged, with all controls• Exterior mirrors heatable (disengageable) elec. adjustable• Exterior noise dampening (according to EU reg. 70/157/EU incl.96/20/EU)• Extremely long maintenance intervals after 1200 (engine)service hours• Frame-integrated standardized mounting points for Unimog implementsand body building• Front integral support for fitting front mounting plate (adjustable)• Front towing jaw with pin• Fulfills Euro 4 emissions standards• Governor characteristic for driving (RQV) and implement operation(RSV) elect. controlable and switchable• Head rests• Headlight range adjustment• Helical springs with progressive characteristic line• Integrated air conditioner• Interlock Starter switch• Interior lighting with reading light for driver and passenger• Large instrument panel LCD-displays and gauges for:-Speedometer km/h and mph-RPM-Brake reservoir pressure-Coolant temperature-Fuel level-Hydraulic oil temperature-Differential locks-Outside temperature-Brake pad wear-Brake fluid level-Coolant level-Steering fluid level-Air filter maintenance-Engine oil level-Windshild wiper fluid level-Transmission gear-Service hour counter-Km and trip km counter-Clock• Large rear window• Level cab floor• Middle console with 2 installation shafts ie. for CB• Multi-setting heater and blower, with dust filter and air recycling• Multi-combination lever-steering column, right: hand throttle, cruisecontrol, speed limiter and exhaust brake-steering column, left: headlight beams, blinker,windshild wash/wipers, horn• Onboard tools• Panorama windshield multi-layered• Panoramic headlights• Permanent all-wheel drive with lockable interaxle differential• Power steering• Rear trailer socket 24 V, 15 pin• Roof console with 2 shafts for radio and speedometer-recorder• Seats with integrated 3-point safety belts• Service hour counter• Spring loaded parking brake• Stabilizers on front and rear axles• Storage compartments:- large storage compartments under dash- bottle and can holder integrated in door molding- storage box on rear cab wall- storage area behind driver’s seat• Structural integrity of cab according to EU reg. ECE-R-29• Six rear chamber lights with clearance lamps, blinker, rear lights, rearfog lights, rear reflector reversing lights• Telescopic shock absorbers• Telligent ® shifting (Elec.-Pneumatic Shifting)• Tire inflation connection• Transmission: MB-All synchromesh reversing transmission, 8 gearsforward and 6 gears reverse• Under vehicle protection, side• Underbody coating (Dinol) for anti-corrosion• Vehicle elec. system, 24V• Windshield wipers-3 settings with intermittent settingand windshield washer• Wheel chocks• 2-step exhaust brake, with exhaust cut-out andcylinder head valve• 28V/80A (2240 Watt) generator• 3 sun visors• 3 clothes hooksIn addition to the extensive, standard equipment range we offer specialequipment to customize your Unimog. Your competent Unimog agencywill be more than happy to consult you.http://www.mercedes-benz.com/unimogDaimlerChrysler AG Special Truck Division, 76742 Wörth, Germany. 6703 . 0220/Euro 4 . 02 - 01/0207We reserve the right to make any changes, Printed in Federal Republic of Germany. Imprimé en République fédérale d’Allemagne.