Mineral Spirits Rule 66 - Colonial Chemical Solutions

Colonial Chemical Solutions, Inc.Material Safety Data Sheet – Mineral Spirits Rule 66SECTION I · PRODUCT IDENTIFICATIONCHEMTREC – 24HR Emergency Telephone 1-800-424-9300Manufacturers Address: Information Phone: (912) 443-6702916 West Lathrop Avenue Date Prepared: 19 Sept 08Savannah, Georgia 31415Preparer: F.SpaethSynonym: Stoddard SolventChemical Family: Petroleum Hydrocarbon SolventNFPA Rating0- Minimal 1- Slight 2- Moderate3- Serious 4- Extreme21 0SECTION II · HAZARDOUS INGREDIENTSCHEMICAL NAME CAS Number %WT TLV PELMineral Spirits R66 8052-41-3 100 100 ppm 500 ppmSECTION III · HAZARDOUS IDENTIFICATIONPotential Acute Health Effects: This material presents a fire hazard.Potential Chronic Health Effects: None listed for this material.SECTION IV · PHYSICAL and CHEMICAL PROPERTIESBoiling Point Range: 320-383°F Vapor Density (Air=1): 5pH: Not applicable. Vapor Pressure (mmHg): 3Solubility In Water: Slightly VOC %: 99+Appearance/Odor: Colorless to light yellow liquid with hydrocarbon odor. Specific Gravity (H 2 O=1): 0.78Melting Point/Freezing Point: No Data.SECTION V · FIRE FIGHTING MEASURESFlash Point: 108 0 FAuto Ignition: 445 0 FExtinguishing Media: Water spray, water fog, dry chemical, CO2 to extinguish flames.Flammable Limits: Lower: 0.6 Upper: 6Fire Fighting Procedures: Cool fire-exposed containers with water spray to prevent container weakening and possiblerupture. Do not enter Fire Zone without a positive pressure self-contained breathing apparatus (SCBA) and full bunkerfirefighter’s protective clothing.Unusual Fire and Explosion Hazards: Burning liquid will float on water. Cover liquid pool with foam.SECTION VI · STABILITY AND REACTIVITYStability: Stable under normal use conditions.Conditions to Avoid: Prevent vapor accumulation and keep away from heat, open flames and other ignition sources.Incompatibility: Avoid contact with strong oxidizing agents, alkalis or strong acids.Hazardous Decomposition Products: Oxides of Carbon and various organic compounds.Hazardous Polymerization: Will not occur.Page 1 of 3

Colonial Chemical Solutions, Inc.SECTION VII · STORAGE AND HANDLINGPrecautions To Be Taken In Handling and Storage: Do not expose to heat, sparks and flames. Wash with soap andwater after contact. Always store in tightly sealed, properly labeled, original container. Containers should be groundedto prevent electrostatic accumulation hazard. Store in a cool, dry well ventilated area. Use non-sparking tools andequipment. Never siphon by mouth.Other Precautions: Follow Label Instructions and Precautions.SECTION VIII · HEALTH AND FIRST AIDSkin: Mildly irritating. Causes transient skin irritation with short time exposure.Eyes: Causes transient eye irritation with short time exposure from contact with liquid sprays or mists.Inhalation: Irritating to respiratory system. Breathing of vapor may cause headaches, irritation of throat and may causecentral nervous system depression.Ingestion: May be harmful if swallowed. Cause gastric distress, diarrhea and vomiting.FIRST AID PROCEDURES:Eyes: Flush with large amounts of cool running water for at least 15 minutes. If irritation persists get medical attention.Skin: Wash skin with soap and water. If irritation persists seek medical attention.Inhalation: For excessive inhalation remove to fresh air. If breathing is difficult seek medical attention.Ingestion: DO NOT induce vomiting. Drink large amounts of water. Seek medical attention immediately.SECTION IX · EXPOSURE CONTROLS / PERSONAL PROTECTIONEye Protection: Eye Protection when pouring. Goggles, safety glasses with side shields are recommended.Respiratory Protection: Where adequate ventilation is not available an approved respirator (NIOSH) for organic vaporsmust be worn. In confined areas, use a self-contained breathing apparatus (SCBA).Skin Protection: Use protective clothing which is chemical resistant to this material. Selection of PPE depends onpotential exposure conditions and may include gloves, boots, suits and other items.Ventilation: General Mechanical ventilation to prevent TLV from exceeding control limits.Protective Clothing: Selection of protective clothing depends on potential exposure conditions and may include gloves,boots, suits and other protective items.Other Equipment: Eye wash station and shower in close proximity to use are advisedSECTION X · ACCIDENTAL RELEASE MEASURESSmall Spill: Stop source of spill. Absorb on inert media and collect into suitable container.Large Spill: Eliminate potential sources of ignition. Shut off or plug source of spill. Dike area to contain spill. Salvage asmuch liquid as possible into a suitable container. Absorb residual on inert media and collect into suitable container.Personal Protection in Case of Large Spill: Wear protective equipment and/or garments as described in Section IX asconditions warrant.SECTION XI · DISPOSAL CONSIDERATIONSWaste Disposal Method: Maximize material recovery for reuse or recycling. Avoid contaminating ground and surfacewater. Do not flush to drain.Follow local, state and federal regulations for disposalPage 2 of 3

Colonial Chemical Solutions, Inc.SECTION XII · TRANSPORTAIONProper Shipping Name: Petroleum Distillates, N.O.S.Hazard Class: 3UN Number: 1268Packaging Group: IIICarcinogenicity: No data available.Mutagenicity: No data available.Reproductive: No data available.Sensitization: Not found to be a sensitizerSECTION XIII · TOXICOLOGYSECTION XIV · REGULATORYRMP/PSM: Not listed.CERCLA-RQ: Not established for this product.EPCRA 311/312: Yes, See Section III.EPCRA 313: No components identified.FIFRA:No documented information available.RCRA-CODE: None listedTSCA: ListedSECTION XV · OTHER INFORMATIONThe information contained on this Material Safety Data Sheet is considered accurate as of the date of publication. It isnot necessarily all inclusive nor fully adequate in every circumstance. The suggestions should not be confused with, norfollowed in violation of applicable laws, regulations, rules or insurance requirements. No warranty, express or implied, ofmerchantability, fitness, accuracy of data, or the results to be obtained from the use thereof is made. The vendorassumes no responsibility for injury or damages resulting from the inappropriate use of this product.Page 3 of 3