MSDS - Kobo Products Inc.

MATERIAL SAFETY DATA SHEETSECTION 1: CHEMICAL PRODUCT IDENTIFICATIONManufacturer/DistributorAddress: Kobo Products, Inc.: 690 Montrose AvenueSouth Plainfield, NJ 07080Emergency Telephone # : (908) 757-0033Facsimile Number : (908) 757-0905Trade Name: MTM3K50XZ4Chemical Name/ Synonyms : Zinc Oxide (And) Methyl trimethicone (And) PEG-10 Dimethicone (And)MethiconeSECTION 2: COMPOSITION / INFOR MATION ON INGREDIENTSChemical Name CAS # EINECS #Zinc Oxide 1314-13-2 215-222-5Methyl trimethicone 541-02-6 208-764-9PEG-10 Dimethicone 68937-54-2 PolymerMethicone 9004-73-3 PolymerSECTION 3: HAZARD IDENTIFICATIONEMERGENCY OVERVIEW:Caution! Combustible Liquid and Vapor.Keep away from heat, sparks, and flame.Refer to other MSDS sections for detailed information.SECTION 4: FIRST AID MEASURESEmergency First Aid:Eye ContactSkin ContactIngestion: Flush eyes with water for at least 15 min. See physician if irritation persists.: Flush skin with soap and water for at least 15 min.: None needed for small amounts. For large amounts, if conscious, give milk todrink and call physician. Do not induce vomiting.SECTION 5: FIRE FIGHTING MEASURESFlashPoint (Closed Cup)Flammable Limits LEL/UEL %Extinguishing MediaSpecial Fire Fighting ProceduresUnusual Fire And Explosion Hazards: >76.6 ° C: N/A: CO2, Water spray, Dry Chemical, Foam: Self-contained breathing apparatus and protective clothing.: Vapors are heavier than air and can travel along ground to remote ignitionsources.SECTION 6: ACCIDENTAL RELEASE MEASURESPersonal PrecautionsEnvironmental Precautions:: Avoid skin and eye contact: Prevent material from contaminating soil or entering sewerage and drainagesystems.Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves,goggles, and lab coat. Carefully contain spilled material . Deposit spilledmaterial in appropriate waste container. Wash spill area with soap and water.SECTION 7: HANDLING AND STORAGEHandling :Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling and before mealtimes.Follow all MSDS and label precautions even after container is emptied since it may contain residual material.Page 1 of 3

KOBO Products, Inc.MTM3K50XZ4Storage :Store containers closed in ambient location.SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTIONExposure Levels: OSHA ACGIHComponent TWA PEL TWA TLVZinc OxideNuisance Dust 15.0 mg/m 3 10.0 mg/m 3Respirable Dust 5.0 mg/m 3 5.0 mg/m 3Personal Protection:Eye ProtectionSkin ProtectionRespiratory ProtectionVentilationSECTION 9: PHYSICAL AND CHEMICAL PROPERTIES: Safety glasses with side shields or goggles: Rubber gloves, wash at meals and end of shifts: Use NIOSH/MSHA approved air purifying respirator as needed to controlexposure.: Provide adequate general mechanical exhaust.Boiling Point (°C) : 210 o C Percent Volatile By Vol. (%) : N/AFreezing Point (°C) : N/A Vapor Density (Air=1) : N/AMelting Point (°C) : N/A Evaporation Rate (Buac=1) : N/AVapor Pressure (mm hg) : N/A Solubility In Water : InsolubleBulk Density (g/cbi.) : N/A Appearance & Odor : Viscous White Liquid,Specific Gravity (H 2 O=1) : 1.62 Slight OdorSECTION 10: STABILITY AND REACTIVITYStableHazardous PolymerizationConditions To AvoidIncompatibilityHazardous Decomposition Products: Yes: Will not occur: Open flames and sparks: Oxidizing material can cause a reaction: SiO2, CO, CO2. May form acetaldehyde when heated which can causeirritation to nose, eyes, and throat.SECTION 11: TOXICOLOGICAL INFORMATIONZinc OxideSkin Irritation : None when 0.5 mL/patch of 50 % water dispersionEye Irritation : Slight stimilus, Draize Score= 6.67Oral (rat): Non-toxic, LD 50 > 2 g/kg (rat)Sensitization : No dataSECTION 12: ECOLOGICAL INFORMATIONNo data is available.SECTION 13: DISPOSAL CONSIDERATIONSMethod of Disposal: Dispose of in accordance with all applicable federal, state, and local regulations. Materialmay be sent to an approved landfill or licensed treatment, storage, and disposal facility.SECTION 14: TRANSPORT INFORMATIONDOT SHIPPING NAME:FOR BULK CONTAINERS (>119 GAL) ONLY: COMBUSTIBLELIQUID N.O.S. (DECAMETHYLCYCLOPENTASILOXANE)11 DOT HAZARD CLASS: BULK CONTAINERS ONLY: COMBUSTIBLE LIQUIDDOT LABEL(S):NONEPage 2 of 3

KOBO Products, Inc.UN/NA NUMBER:PLACARDS:IATA:NOT REGULATED BY IATAIMO IMDG-code: NAEMS No:NAEUROPEAN CLASS:RID (OCTI):NAADR (ECE) :NARAR (IATA):NAMTM3K50XZ4FOR BULK CONTAINERS ONLY: NA1993FOR BULK CONTAINERS ONLY: COMBUSTIBLESECTION 15: REGULATORY INFORMATIONNo information availableSECTION 16: OTHER INFORMATIONDate Prepared : July 25, 2005Note:The statements made here are intended to describe the product with regard to necessary safety precautions. They donot guarantee special characteristics. This information is furnished without warranty, expressed or implied, exceptthat it is accurate to the best of our current knowledge.Page 3 of 3