Coastal All-Purpose Grease MSDS Page 1 of 4 ... - Dilmar Oil

Coastal All-Purpose Grease MSDS Page 2 of 4PHYSICAL AND CHEMICAL PROPERTIESBoiling Point 760 mmHg: N.A. Melting Point: 310-320°FVapor Pressure mmHg @ 100F: N.A. (dropping pt.)Solubility in H 2 O%: Insoluble Vapor Density (air=1): N.A.Specific Gravity (H 2 O): 0.97 pH: N.A.% Volatile by Volume: N.A. Evaporation Rate: N.A.Viscosity (method, temp): 9.36-12.57 cSt @ 100 °C Odor: Mild petroleum odorAppearance:Greenish Brown GreaseN.A. = Not AvailableFIRE AND EXPLOSION DATAFlash Point:460°F (Cleveland Open Cup)Flammable Limits in Air % by Vol.: Lower: N.A. Upper: N.A.Autoignition Temperature:N.A.Extinguishing Media:Dry chemical, foam, carbon dioxide or water spray.Special Fire Fighting Procedure:Unusual Fire or Explosion Hazard:Water spray my be ineffective on flames but should be use to keepfire-exposed containers cool. Firefighters should wear self-containedbreathing apparatus.Will not flash spontaneously. May ignite if exposed to open flame.REACTIVITY DATAStability:Hazardous Polymerization:Conditions to Avoid/Incompatibility:Hazardous Decomposition Products:StableWill not occur.Strong oxidizing agents, heat, spark, flame and build-up of staticelectricity.Incomplete combustion can yield carbon monoxide and varioushydrocarbons.HEALTH HAZARD DATAThis product has not been tested as a whole to determine its specific health hazards. The information provided inthis section is based on health hazard information on the product components.Carcinogenicity: NTP: No IARC Monographs: No OSHA Regulated: NoOccupational Exposure Limits:See COMPOSITION section.Effects of Overexposure:Acute:Eyes:Skin:Inhalation:Ingestion:An irritant, based on health hazard data of components.The primary hazard associated with use of grease is its accidentalinjection under the skin with a high pressure gun. If injected underthe skin, necrosis could occur.Due to the low vapor pressure of this product under ambientconditions, inhalation is not normally a problem.Ingestion hazards include possible irritation, nausea, or diarrhea.

Coastal All-Purpose Grease MSDS Page 3 of 4Chronic:Additional Medical andToxicological Information:Frequent or prolonged contact may cause skin irritation.May aggravate pre-existing dermatitis.EMERGENCY FIRST AID PROCEDURESEye Contact:Skin Contact:Inhalation:Ingestion:Flush thoroughly with water for at least 15 minutes, occasionallylifting the lower and upper lids. Get medical attention if redness orirritation occurs.Remove contaminated clothing. Wash affected areas with soap andwater. If irritation occurs, get medical attention.Remove to fresh air. Apply artificial respiration if not breathing.Get medical attention.Do not induce vomiting. If spontaneous vomiting occurs hold thevictim's head lower than hips to prevent aspiration.SPECIAL PROTECTION INFORMATIONEye Protection:Skin Protection:Inhalation:Ventilation:Remove contact lenses and wear chemical safety goggles, safetyglasses, or face shield where contact with the product or mist mayoccur.Wear impervious gloves such as nitrile or neoprene or othermaterials resistant to petroleum oils when contact with skin mayoccur.Use approved respiratory protective equipment for situations whereexposure to mist may exceed occupational exposure levels.Provide adequate ventilation to keep mist or vapors belowoccupational exposure levels, if applicable.SPILL OR LEAK AND DISPOSAL PROCEDURESSpill Procedures:Waste Disposal:Remove sources of heat or ignition, including internal combustionengines and power tools. Remove spilled material and place incontainers for disposal. Use approved respirator whereoccupational exposure limits for oil mist may be exceeded.Dispose through a licensed waste disposal company. Follow federal,state and local regulations.SPECIAL PRECAUTIONS AND COMMENTS

Coastal All-Purpose Grease MSDS Page 4 of 4Storage Requirements:Store in tightly closed containers in a dry, cool place, away fromsources of heat, ignition or strong oxidizers. Ground and bond alltransfer and storage equipment.SARA TITLE III INFORMATIONSection 311/312 Hazard CategorizationAcute Chronic Fire Pressure ReactiveXSARA Hazardous SubstancesIngredient CAS NO. % WT Sec 313 Sec 302 RQ, lb TPQ, lbNoneKey: Sec 313 = Toxic Chemicals, Section 313Sec 302 = Extremely Hazardous Substances (EHS)RQ = Reportable Quantity of EHSTPQ = Threshold Planning Quantity of EHSCALIFORNIA PROPOSITION 65 WARNINGChemicals known to the State of California to cause cancer, birth defects or other reproductive harm may befound in the petroleum products. Although it is possible to sufficiently refine the petroleum products to removethe potential for cancer, we are advising that one or more of the listed chemicals may be present in somedetectable quantities. Read and follow directions and use care when handling these petroleum products.THIS INFORMATION RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR SUCHMATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN ANY PROCESS. SUCH INFORMATION IS TO THEBEST OF THIS COMPANY'S KNOWLEDGE AND BELIEVED ACCURATE AND RELIABLE AS OF THE DATE INDICATED.HOWEVER, NO REPRESENTATION, WARRANTY OR GUARANTEE IS MADE AS TO THE ACCURACY, RELIABILITY ORCOMPLETENESS. IT IS THE USER'S RESPONSIBILITY TO SATISFY HIMSELF AS TO THE SUITABLENESS ANDCOMPLETENESS OF SUCH INFORMATION FOR HIS OWN PARTICULAR USE.