PressureGuard Installation Manual - Fleet Air

Recommendations

Info

Connecting Air Lines to Regulator Assembly Step 8 – Connecting Air Lines to Regulator Assembly 8-1 Refer to the following page for the `Air Flow Hook Up’ diagram. 8-2 Connect the two lengths of air line tubing from the top of the rear axle with an Air Line T-Fitting 12 . To avoid cutting the tubing, do not over tighten the fitting nuts. 8-3 Secure this T-fitting in the location chosen in step 5, with 6” cable ties 10 . 8-4 Repeat steps 8-1 through 8-3 for all remaining axles. 8-5 Connect the air line from each axle T-fitting to the fitting on the exit end of the Regulator Assembly 6 .The regulator is marked to show flow direction. To avoid cutting the air line, do not over tighten the fitting nuts. When cutting this air line to length and securing, keep in mind the 14” additional length required for suspension travel. 8-6 Secure these air lines using the 6” Cable Ties 10 . PressureGuard recommends securing to the brake hoses. 25
Air Flow Hook-Up Air Tank Pressure Protect Regulator T-Fitting T-Fitting T-Fitting Front Axle Rear Axle Axle Vent 26 Axle Vent
Page 1 and 2: PRESSURE UARD T I R E I N F L AT I
Page 3 and 4: PressureGuard System Overview Warni
Page 5 and 6: Item # Description 1 2 3 4 5 6 7 8
Page 8 and 9: Pressure Protection Valve Step 1 -
Page 10 and 11: 1-5 Install the 1/4” Tube x 1/4
Page 12 and 13: Wheel End Preparation Step 3 - Whee
Page 14 and 15: 3-5 Repeat steps 3-1 through 3-4 on
Page 16 and 17: 4-2 Tap each hole using a 1/8” -2
Page 18 and 19: Axle Air Line Installation Step 5 -
Page 20 and 21: 5-5 Slide the Axle Air Line Fitting
Page 22 and 23: 6-3 Screw in and tighten the Axle V
Page 24 and 25: 7-3 Push the tubing into the Spindl
Page 28: Hubcap Installation / Rotating Shaf
Page 31 and 32: 9-2 Install the provided gasket ont
Page 33 and 34: Connecting Air Hoses to the Tires S
Page 35 and 36: 11-4 Connect the two wires of the W
Page 37 and 38: Pressure Switch Connector (+) ( -)
Page 39 and 40: System Troubleshooting Guide Air le
Page 41 and 42: No air flow through regulator. Prob
Page 43 and 44: Warning light on. Problem: 1. Syste

PressureGuard Installation Manual - Fleet Air

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?