Digitally signed by KHANDKAR SHAHAJI E 1013186 Date: 2012.09 ...

More documents

Recommendations

Info

Tender No. : 12000040-HB-10730 Tender Published On : 29-Sep-2012 11:17 Srl. No. Line Details Of Tender Line Description UOM Schedule Rate Mandatory PaintingNE Manadatory: Yes 1 Acrylic emulsion paint Square Meters 72 Yes DESCRIPTION => Providing and applying Acrylic emulsion paint as per following:Paint to be applied in the flats and in bungalows for internal painting of Hall,Bedrooms,common lobby,staircase area and kitchen except otherwise specified . Painting shall be carried out in the Following stages :a. Scrapping using sand paper.b. Application of water based cement primer (1 coat).c. Filling with putty.d. Surface preparation.e. Finishing with two coats of Acrylic Emulsion paint applying roller to get a proper finish. If required, third finishing coat also to be applied without any additional cost. Minimum 6hrs interval to be maintained between two finish coats of acrylic emulsion paint.Surface preparation shall be carried out as follows : Ensure the surface is clean,dry,free from all defective or poorly adhering material,dirt,grease,wax etc. Remove all the poorly adhering materials by rubbing down using a suitable abrasive paper and thereafter wiped off. Treat fungus affected areas like bathroom,toilet and balconies with pretreatment coat solution. Then apply a coat of cement primer. Use putty to fill cracks and dents to make the surface uniform. After smoothening the surface with sandpaper,and finishing with two coats of Acrylic Emulsion paint applying roller to get a proper finish all complete as per direction of Engineer - In - Charge.Make and brand to be used are : 1. ASIAN- Premium Emulsion ( Asian Paints) 2. GOODLASS NEROLAC - Equivalent to Premium Emulsion of Asian Paints 3.BERGER- Rangoli easy clean 4. ICI -Dulux acrylic emulsion. 5. Nerolac - Equivalent to premium Emulsion of Asian Paints. 2 Synthetic Enamelpaint for flat Square Meters 68 Yes DESCRIPTION => Providing & applying synthetic enamel paint as per following:Synthetic Enamel paint to be applied to all kitchen/toilet/bathrooms or as directed by EIC. Surface preparation : Clean and dry the surface. Remove all the loose foreign material by rubbing down using a suitable abrasive paper followed by wipe off. (Normally for rough use180no. and for finer finish 320no. paper are used or combination of both paper as required). Apply putty as required to make the surface smooth all complete as per direction of Engineer - In - Charge.The procedure to be followed should be as follows:1. Scrapping2.One coat of primer3.Application of putty and making the surface smooth.4.Application of two coats of synthetic enamel, and finished completely.1. Asian:Gattu 2. Berger:Butterfly3. ICI:Gloss4. Nerolac. 3 Synthetic Enamelpaint -wood Square Meters 68 Yes DESCRIPTION => Providing & applying synthetic enamel paint as per following:Synthetic Enamel paint to be applied to all doors/'windows/grills/kitchen/toilet/bathrooms (in areas required). Surface preparation : Clean and dry the surface. Remove all the loose foreign material by rubbing down using a suitable abrasive paper followed by wipe off. (Normally for rough use180no. and for finer finish 320no. paper are used or combination of both paper as required). Apply putty as required to make the surface smooth all complete as per direction of Engineer - In - Charge.Procedure to be followed after surface preparation : 1. Apply Wooden surface Primer (1 coat)- wood primer and finish (2 coats ) of Synthetic Enamel Paint of Asian / Berger / ICI Dulux / Nerolac. 4 Synthetic Enamelpaint -metal Square Meters 62 Yes DESCRIPTION => Providing and applying two coats of synthetic enamel paint of approved colour quality to steel work or other metal surface including removal of loose material by rubbing down using a suitable abrasive paper/wire brush , applying zinc chromate primer all complete as per direction of Engineer - In - Charge. 5 French polishing Square Meters 126 Yes DESCRIPTION => Providing and applying french polish in three coats after application of appropriate sand paper before and after each coat to prepare smooth surface to new/old woodwork as directed all complete as per direction of Engineer - In - Charge. 6 Ceilling fans painting Each 54 Yes DESCRIPTION => Providing & applying 1 coat metal primer and 2 finish coats of Synthetic enamel Paint of approved make and shade as per instructions of Engineer-In-Charge over Ceiling fan/Exhaust fan body and blades after thorough cleaning of the surfaces using sandpaper to remove dirt and loose material, oil stains and also to smoothen the surface all complete as per direction of Engineer - In - Charge. 7 Tube lights painting Each 31 Yes DESCRIPTION => Providing and applying tube lights painting as per following:1. Cleaning the surface with the wire brush, sand paper etc.2. Apply one coat of zinc chromate primer prior to application of two finish coat of Synthetic enamel Paint of approved make and shade over tube light batterns all complete as per direction of Engineer - In - Charge. 8 Cement Paint Square Meters 36 Yes DESCRIPTION => Providing and applying two coats of cement paint of snow cem or approved equivalent of approved shade on old/ new plastered surface to wall and ceiling and any other surfaces as directed by EIC including scaffolding,scrapping and cleaning the surface by brushing,to remove the fungus growth,dust and brooming down.Cleaning the surface including filling all cracks,undulations with suitable filling material and curing the same all complete as per direction of Engineer - In - Charge. 9 White / Colour Wash Square Meters 18 Yes DESCRIPTION => Providing and applying two coats of white / colour wash of approved make and shade to old/ new plastered surface including scaffolding,scrapping,step ladder,brushing, brooming down and adding adhesives to get proper bonding,cleaning the surface including filling all cracks,holes and undulations with filling material and curing the same all complete as per direction of Engineer - In - Charge. 10 Wall mounting in POP Square Meters 152 Yes DESCRIPTION => providing and applying wall mounting in POP with a minimum thickness of 10 mm . The scope of the job includes maintining of levels and wall mounting on newly made surfaces and any other surfaces as per the standard procedure all complete as per direction of Engineer - In - Charge. 11 Lettering Inch Height 4 Yes DESCRIPTION => Painting of letters of approved type on the name boards on any surface in English and Hindi of desired font in synthetic enamel paint of approved quality, brand and shade including background paint two coats/polishing on metal or wood surface as directed. The width of the letter should be proportional to the height. Height of the letter only will be measured for payment purpose. Commas, hyphen shall not be measured. Letters should be clearly visible from a distance all complete as per direction of Engineer - In - Charge.Job includes supply of material, labour etc.. 12 Tree Trunk with 3 bands Square Meters 27 Yes DESCRIPTION => Providing and applying two finish coats of tree trunk paint with three bands as per following: 1. White colour for upper and lower band 2. Red colour for middle band to suit the trunk size including cleaning the surface. Application should be exterior cement paint of snowcem or approved make all complete as per direction of Engineer - In - Charge. 13 Speed breaker painting Square Meters 62 Yes DESCRIPTION => Providing and applying two coats of road marker of approved make in approved shade for speed brakers or zebra crossing with industrial paint of approved make all complete as per direction of Engineer - In - Charge. 14 Lines and arrows providing Painting line,arrows on roads in two coats with ready mixed road marking paint including cleaning the surface from all dirt ,dust and foreign matter,outline marking at site and traffic regulation etc. complete upto 10cm in width (white and yellow) all complete as per direction of Engineer - In - Charge. 15 Lines and arrows>10cm Square Meters 45 Yes DESCRIPTION => Providing Painting line,arrows on roads in two coats with ready mixed road marking paint including cleaning the surface from all dirt ,dust and foreign matter,outline marking at site and traffic regulation etc. complete over 10cm in width (white and yellow) max upto 20 cm all complete as per direction of Engineer - In - Charge.. 16 Exterior Emulsion paint Square Meters 94 Yes DESCRIPTION => Providing and applying exterior emulsion paint as per following:External Painting shall be carried out as follows :1. Pre treatment coat 1 coat.2. Latex based 100% Acrylic Paint of Asian, Berger, ICI or Goodlass Nerolac make with primer of the same make.Dilution : As per manufacturer's recommendation.Stages of Painting:1. Scrapping. 2. Washing of the surface. 3. Pre - Treatment Coat (anti fungus solution)4. Primer of water based exterior wall primer. 5. Filling the gaps, if any with Elastomeric Putty.6. Two Coats of approved make and shade Latex based 100% Acrylic Emulsion Paint all complete as per direction of Engineer - In - Charge.Asian:Apex Ultima ExteriorBerger:Weather all guard coatICI: Dulux weather shield sun reflectNerolac: Equivalent to Premium Emulsion of Asian Paints. 17 Al Painting of electric poles Square Meters 200 Yes DESCRIPTION => Providing and applying Aluminum paint of electric poles as per following:Street Light Pole Paint - Metal SurfaceClean and dry the surface. Remove all the loose material by rubbing down using hard tools like scrappers , wire brushes, chipping tools, emery paper to remove hard scales . Providing and applying two coats of aluminium paint of approved quality over primer coat to steel / metal surface of street Light Poles all complete as per direction of Engineer - In - Charge.. 18 Single coat-emulsion Square Meters 45 Yes DESCRIPTION => Providing and applying single coat emulsion of approved make & shade including roughening of surface using emery paper of five grade, wipe off loose dust after that application of primer,touch up putty,smoothening of the same and apply touch up paint of particular shade after this apply one coat of acrylic emulsion paint full area using a roller/brush all complete as per direction of Engineer - In - Charge.
19 Single coat-enamel Square Meters 38 Yes DESCRIPTION => Providing and applying single coat of enamel of approved make & shade including roughening of surface using emery paper of five grade, wipe off loose dust after that application of primer,touch up putty,smoothening of the same and apply touch up paint of particular shade after this apply one coat of synthetic enamel paint full area using a roller/brush all complete as per direction of Engineer - In - Charge.. 20 Aluminium paint Square Meters 45 Yes DESCRIPTION => Providing and applying Aluminum paint as per following:Manual cleaning using wire brush, chipping, scraping, emery papering, removal of loose dust and painting of sturctural members, elecrical poles etc with one coat of zinc chromate primer with two coats of ready mixed aluminium paint all complete as per direction of Engineer - In - Charge. 21 Scaffolding Cubic Meters 62 Yes DESCRIPTION => Supplying and erection of bamboo scaffolding as and when required as per the instructions of the EIC. The bamboos used should be in good shape, strong. The horizontal member should be tied at adequate spacing with proper bracings at regular intervals all complete as per direction of Engineer - In - Charge. For any type of scaffolding the party should obtain written instructions from EIC. 22 Vinyl ltr replacement-Bldg Each 225 Yes DESCRIPTION => Supplying and replacing vinyl letter in building as per following:(i) Removing PU coated matt finished acrylic sheet with existing vinyl letters from Anodized Aluminum frame by using contractor's tools, tackles and manpower etc. (ii) Removing the existing vinyl letters from this acrylic sheet and replacing them with vinyl computer cut letters of same height as that of removed letters and of approved colour and size as per the instructions of Engineer in charge. (iii) After replacing the vinyl letters, contractor shall fix this acrylic sheet to appropriate position in aluminium frame, covering it with existing transparent acrylic sheet and re-fixing the arrangement all complete as per direction of Engineer - In - Charge. All the tools, tackles, manpower, transportation etc. required for this job is in the scope of contractor no separate payments for any other heads will be paid to contractor. 23 Vinyl ltr replacement-Bung Each 247 Yes DESCRIPTION => Supplying and replacing vinyl letters for bungalows as per following:(i) Removing transparent vinyl sheet over 5 mm thick acrylic sheet by dismantling 0.5" x 0.5" aluminium channel/ angle fixed on box type aluminium frame.(ii) Removing the existing vinyl letters from this acrylic sheet and replacing them with vinyl computer cut letters of same height as that of removed letters and of approved colour and size as per the instructions of Engineer in charge. (iii) After replacing the vinyl letters, contractor shall fix the existing transparent acrylic sheet back at its original position and fixing existing 0.5" x 0.5" aluminium channel/ angle fixed on box type aluminium frame all complete as per direction of Engineer - In - Charge.All the tools, tackles, manpower, transportation etc. required for this job is in the scope of contractor no separate payments for any other heads will be paid to contractor. 24 Interior Decorative Painting Square Meters 900 Yes DESCRIPTION => SPECIAL EFFECT PAINT: Providing & Applying Special effect for interior surfaces of Asian Royal make or approved equivalent makes Painting the specified area in 3 coats of special effect paint by making the necessary surface of wall to receive the special effect paint as per direction of manufactures of approved quality, shade over one coat of primer and levelling course. Rate to include scrapping wall surfaces, applying Birla putty for proper finish, applying necessary coat of primer to get firm surface to receive paint all complete as per direction of Engineer - In - Charge. 25 Exterior Decorative Painting Square Meters 1080 Yes DESCRIPTION => SPECIAL EFFECT PAINT: Providing & Applying Special effect for exterior surfaces of Asian Duracoat or approved equivalent makes Painting the specified area in 3 coats of special effect paint by making the necessary surface of wall to receive the special effect paint as per direction of manufactures of approved quality, shade over one coat of primer and levelling course. Rate to include scrapping wall surfaces, applying Birla putty for proper finish, applying necessary coat of primer to get firm surface to receive paint all complete as per direction of Engineer - In - Charge. 26 Lift Door Spray Paint Square Meters 180 Yes DESCRIPTION => Providing and applying synthetic enamel paint by airless spray as per following: Clean and dry the surface. Remove all the loose material by rubbing down using a suitable abrasive paper/wire brush , applying redoxide and then, Providing and applying two coats of spray paint of approved colour quality to steel work or other metal surface including necessary spray machine, compressor, labour, tools & tackles all complete as per direction of Engineer - In - Charge. 27 Elastomeric Painting Square Meters 180 Yes DESCRIPTION => Providing & erecting of double legged scaffolding /Jhula, cleaning & wire brushing the wall, removing moss, fungus, oil ,grease etc, opening cracks with grinder, washing the surface with clean water & filling the same with Crack filling compound. Providing & applying an Acrylic based elastomeric painting as per the manufacturers specifications and instructions. Job also includes cleaning of drain Pipeline from outside & removal of any creepers/small trees on walls. Using of safety belts for painter at any height is compulsory & it will be provided by vendor. Payment shall be made only for the actual area painted.Mode of measurement: In Sqm. Of actual surface area painted all complete as per direction of Engineer - In - Charge.Make and Brand to be used are:1. STP.2. BASF.3. PIDILITE.4. POLYGEL. 28 Bitumastic Painting Square Meters 58 Yes DESCRIPTION => Supplying & Painting two coats of bitumastic paint of STP or approved make over a coat of primer including necessary surface preparation all complete as per direction of Engineer - In - Charge. 29 SS Name Plates Each 810 Yes DESCRIPTION => Supply of SS plate 18 guage thickness including engraving letters and border linesfor name plate and fixing with required size nuts all complete as per direction of Engineer - In - Charge. 30 Stone Paint Square Meters 247 Yes DESCRIPTION => Providing & applying silicone based protective coat of Dr. Fixit Repellin WR / Nito cote SN522 (FOSROC) or approved equivalent over exterior / interior bricks / stone masonry surface by airless spray to achieve semigloss / gloss surface finish along with preserving natural colour / texture of material by wire brushing / compressed air, degreasing existing surface by using solvents if require, removing existing paint all complete as per direction of Engineer-In-Charge.Note: Application of coats as per manufacturing specifications. 31 Thermo Plastic Paint Square Meters 1100 Yes DESCRIPTION => Supply and painting yellow/white thermoplastic road marking paints of approved make at asphalted/pavered and RCC driveways with HPCL approved symbols, signages and letterings.
Page 1: Tender No. : 12000040-HB-10730 Tend
Page 5 and 6: Tender No. : 12000040-HB-10730 Tend
Page 7 and 8: INSTRUCTIONS TO BIDDERS due date an
Page 9 and 10: INSTRUCTIONS TO BIDDERS 27) HPCL ma
Page 11 and 12: INSTRUCTIONS TO BIDDERS material de
Page 13 and 14: SPECIAL TERMS AND CONDITIONS UNPRIC
Page 15 and 16: 1. PRELIMINARY GENERAL TERMS & COND
Page 17 and 18: GENERAL TERMS & CONDITIONS OF WORKS
Page 43 and 44: Important Notes for Taxes and Dutie
Page 45: Tender No. : 12000040-HB-10730 Tend

Digitally signed by KHANDKAR SHAHAJI E 1013186 Date: 2012.09 ...

Create successful ePaper yourself

Delete template?

Save as template?