Concrete Products Catalog - Oldcastle Precast

More documents

Recommendations

Info

ASPHALT PAVEMENT OR CONCRETE COMPACTED FILL FIELD PREPARATION Installation Procedure Installation in Concrete or Pavement for driveways, parking lots and off-roadway applications where subject to occasional non-deliberate light vehicles. Prepare the excavation approximately 6" deeper than the overall height of the enclosure. The length and width of the excavation should be determined by adding 4" to 6" to the overall length and width of the box. INSTALLATION RECOMMENDATIONS Placement of approximately 3" to 6" of compacted material such as sand or gravel is the recommended material because of its drainage characteristics. The compacted material should be leveled so the top of the box is flush to grade. BACKFILLING Place selected backfill into the excavation at 12" lifts and compact. The backfill should be discontinued approximately 8" below the finish grade. The final 8" of the excavation should be finished with concrete. This should be accomplished by providing a form around the enclosure that would produce a 8" wide collar (see sketch). 8" Oldcastle Precast ® Enclosure Solutions Madera 801 S. Pine St. Madera, California 93637 Tracy 10304 Linne Road Tracy, California 95377 Roseville 9600 Antelope Oaks Court, Suite D Roseville, California 95747 Portland 11402 NE Markx Street Portland OR 97220 CONCRETE COLLAR AROUND BOX Meter Box or Pull Box with Cover Gravel Base (Approx. 3" to 6") CONCRETE COLLAR Note: Minimum concrete collar strength is 3,000 psi. QUICK-SPECIFICATION QUIK-SPECIFICATION Underground enclosures shall be manufactured by Oldcastle/Christy. Boxes and covers shall be concrete and have a pedestrian rated minimum vertical test load of 350 pounds per square foot. The concrete shall test to a minimum of 4500 psi compressive strength.
Mouse Hole Opening (1 Each End) Typical Utility Box No. B03 BOX 74 lbs. Oldcastle Precast ® Enclosure Solutions Copyright © 2011 Oldcastle Precast Inc. Reinforced Concrete Lid No. BO3D 12 lbs. 3 www.oldcastleprecast.com Copyright © 2011 by Oldcastle Precast Inc. 3 B03P OPES B03C B03-61D B03 BOX B03 UTILITY BOX 9-3/4" x 15-5/8" 3 Utility and Value Boxes
Page 1 and 2: Concrete Products Catalog February
Page 3: Table of Contents Utility and Valve
Page 7 and 8: Utility Box No. BX09 BOX 90 lbs. Mo
Page 9 and 10: Utility Box No. B16 BOX 112 lbs. Mo
Page 11 and 12: Utility Box Assembly No. B26 BOX Ol
Page 13 and 14: Utility Box No. N36 BOX 172 lbs. Ol
Page 19 and 20: Curb Valve Box No. F08 BOX 34 lbs.
Page 21 and 22: Curb Valve Box No. F22 BOX 38 lbs.
Page 23 and 24: Electrical Box No. N09 BOX 90 lbs.
Page 29 and 30: "T" BOX Electrical Box No. N52 BOX
Page 31 and 32: Telephone Box No. P44 BOX 290 lbs.
Page 33 and 34: "T" BOX Telephone Box No. N52P BOX
Page 35 and 36: Traffic Box Caltrans No. 3-1/2T Sta
Page 37 and 38: Traffic Box Caltrans No. 6T State S
Page 39 and 40: Traffic Box No. B3048 BOX 434 lbs.
Page 41 and 42: Traffic Valve Box No. G04 BOX 60 lb
Page 43 and 44: Traffic Valve Box No. G08T BOX 90 l
Page 45 and 46: Traffic Valve Box No. G05T BOX 58 l
Page 47 and 48: Drain Box No. V12 BOX 177 lbs. Oldc
Page 49 and 50: Drain Box No. V64 BOX 194 lbs. Oldc
Page 51 and 52: WDOT J-BOXES - STANDARD Steel Cover
Page 53 and 54: • • • • Oldcastle Precast
Page 55 and 56:
Utility Box No. TSN FULL BOX 74 lbs
Page 57 and 58:
"R" SERIES PITS Concrete Pit Oldcas
Page 59 and 60:
"T" SERIES ELECTRICAL VAULTS Concre
Page 61 and 62:
T95 ELECTRICAL VAULT Electrical Vau
Page 63 and 64:
CATCH BASINS Catch Basin No. U21CB-
Page 65 and 66:
U37 CURB INLET w/ 5" WALLS Concrete
Page 67 and 68:
Fibrelyte Box No. FL08T 6 lbs. Oldc
Page 69 and 70:
Fibrelyte Box No. FL12T Box 26 lbs.
Page 71 and 72:
Fibrelyte Box No. FL36TBox-12 40 lb
Page 73 and 74:
Oldcastle Precast ® Enclosure Solu
Page 75 and 76:
Splash Block - 1 No. M50SPB1 48 lbs
Page 77 and 78:
Cross Reference Guide Curb & Traffi
Page 79 and 80:
Cross Reference Guide Electrical Bo
Page 81 and 82:
Cross Reference Guide Water Meter B
Page 83 and 84:
Cross Reference Guide Water Meter B
Page 85 and 86:
The Christy brand R-Series lid is t
show all

Concrete Products Catalog - Oldcastle Precast

Create successful ePaper yourself

Delete template?

Save as template?