Installation & Operation Manual: Portable Premier Series

More documents

Recommendations

Info

Figure C-10 OHV 85E Wiring Diagram (w/o Governor) C-8 Premier OHV Series MN2410
Appendix D Premier OHV100E Series Information in this Appendix applies to the OHV100E Baldor Generator. Caution: The brass connecting tab on some 120VAC duplex receptacles have been removed. Each receptacle is powered by a separate generator winding. When replacing a receptacle, inspect the brass tab that normally links both receptacles. If it is removed, be sure to remove the brass tab from the replacement receptacle before it is installed. Failure to remove the tab will cause a direct short to the generator windings and cause possible generator damage. Operator Panel Configuration ELAPSED TIME AC VOLTMETER AC CIRCUIT BREAKERS ON AUTO IDLER OFF NEMA L5−30R 30 AMPS 120 VOLTS 30 AMPS 120/240 VOLTS 50 AMPS 120/240 VOLTS NEMA L14−30R Figure D-1 OHV100E Operator Panel Auto Idler Switch. ON − Auto idler is active, engine RPM will reduce when load is removed. OFF − Engine runs at fixed speed (set by governor). Elapsed Time. Displays the total run time hours of the generator set. AC Voltmeter. 120 VOLTS This voltmeter displays the voltage level being produced by the generator set. AC Circuit Breakers. Provide overload protection for the generator set. 120 Volts NEMA 5−20R GFCI Receptacle. This ground fault circuit interrupter duplex receptacle is rated at 125VAC, 20 Amps. 30 AMPS 120 Volts NEMA L5−30R Receptacle. Twist−lock style receptacle rated for 125VAC, 30 Amps. 30 AMPS 120/240 Volts NEMA L14−30R Receptacle. 120 VOLTS Twist−lock style receptacle rated for 125/250VAC, 30 Amps. 50 AMPS 120/240 Volts CS6369 Receptacle. Twist−lock style receptacle rated for 125/250VAC, 50 Amps. MN2410 Premier OHV100E Series D-1
Page 1 and 2: Premier POW’R Products Generator
Page 3 and 4: Table of Contents Section 1 Product
Page 5 and 6: Section 1 Product Safety Informatio
Page 7 and 8: Operation Warning Statements Contin
Page 9 and 10: Warning Statements Continued Mainte
Page 11 and 12: Section 2 General Information Thank
Page 13 and 14: Section 3 Receiving & Installation
Page 15 and 16: Electrical Connections Continued Ta
Page 17 and 18: Battery Connections Continued Note:
Page 19 and 20: Section 4 Operation Operator Contro
Page 21 and 22: Section 5 Troubleshooting and Maint
Page 23 and 24: Appendix A Premier K Series Caution
Page 25 and 26: Table A-1 Generator Set Parts List
Page 27 and 28: Figure A-6 K5000 Wiring Diagram MN2
Page 29 and 30: Figure A-8 K6500 Wiring Diagram MN2
Page 31 and 32: Appendix B Premier R Series Informa
Page 33 and 34: Table B-1 Generator Set Parts List
Page 35 and 36: Figure B-6 R45/45E Wiring Diagram M
Page 37 and 38: 8022 8020 ST M+ M− TO MAGNETO 802
Page 39 and 40: Appendix C Premier OHV Series Infor
Page 41 and 42: Table C-1 Generator Set Parts List
Page 43 and 44: Figure C-7 OHV40 / OHV50 / OHV60 Wi
Page 45: Figure C-9 OHV 85E Wiring Diagram (
Page 49 and 50: Table D-1 Generator Set Parts List
Page 51 and 52: Figure D-5 OHV100E Generator Output
Page 53 and 54: Appendix E Premier OHV110E Series I
Page 55 and 56: Table E-1 Generator Set Parts List
Page 57 and 58: Figure E-5 OHV100E Generator Output
Page 59 and 60: Appendix F Special Information for
Page 61 and 62: UNITED STATES ARIZONA PHOENIX 4211

Installation & Operation Manual: Portable Premier Series

Create successful ePaper yourself

Delete template?

Save as template?