12/05 - City of Melbourne, Florida
12/05 - City of Melbourne, Florida
12/05 - City of Melbourne, Florida
Create successful ePaper yourself
Turn your PDF publications into a flip-book with our unique Google optimized e-Paper software.
PW/Utilities Connection<br />
December 20<strong>05</strong><br />
Utilities Data from Nov. 20<strong>05</strong><br />
<strong>Melbourne</strong>’s drinking water —<br />
not too hard, not too s<strong>of</strong>t<br />
Water hardness<br />
is usually<br />
observed by its<br />
ability to form<br />
scale and make<br />
suds with soaps<br />
and detergents.<br />
The operating<br />
instructions for<br />
some domestic<br />
applicances,<br />
particularly<br />
dishwashing machines,<br />
refer to<br />
water hardness.<br />
Hardness in<br />
water is defined as the sum <strong>of</strong> the calcium and magnesium<br />
concentrations, expressed as calcium carbonate.<br />
The hardness <strong>of</strong> the water varies with the amounts<br />
<strong>of</strong> these salts.<br />
The hardness <strong>of</strong> the water produced by the <strong>City</strong> <strong>of</strong><br />
<strong>Melbourne</strong> averages approximately 85 milligrams per<br />
liter (mg/L) or five grains per gallon (gpg).<br />
The U.S. Geological Survey has developed a generalized<br />
water hardness scale that rates s<strong>of</strong>t water as<br />
between 0 and 60 mg/L (0-3.5 gpg), moderately hard<br />
as between 61 and <strong>12</strong>0 mg/L (3.6 - 7 gpg), hard water<br />
as being between <strong>12</strong>1 and 180 mg/L (7.1 - 10.5 gpg),<br />
and very hard water as being above 180 mg/L. (>10.5<br />
gpg). Milligrams per liter is converted to grains per gallon<br />
by multiplying mg/L by 0.06.<br />
Home water s<strong>of</strong>teners, when used in conjunction<br />
with <strong>City</strong> water, can cause the water to become too<br />
s<strong>of</strong>t. This can cause corrosion <strong>of</strong> the plumbing, allowing<br />
copper to enter the home’s water supply.<br />
As a result <strong>of</strong> the leaching <strong>of</strong> copper pipes in the<br />
residence, sinks and bathtubs would begin to develop<br />
a green or blue coloration.<br />
Water delivered by <strong>Melbourne</strong> contains trace copper<br />
amounts that are below the level determined as safe<br />
by the federal Environmental Protection Agency.<br />
<strong>City</strong> <strong>of</strong> <strong>Melbourne</strong> Public Works & Utilities Department<br />
Monthly Report<br />
PW & Utilities department show<br />
care through United Way giving<br />
The annual United Way campaign has been completed<br />
and the <strong>City</strong>’s Public Works & Utilities Department<br />
contributed $10,750 that will used to help fund 87 local<br />
health and human services programs.<br />
While the employees in the department are 25 percent<br />
<strong>of</strong> the total 935 <strong>City</strong> employees, they contributed<br />
30 percent <strong>of</strong> the <strong>City</strong>’s overall total contribution <strong>of</strong><br />
$36,146.<br />
“Public Works & Utilities did exceptionally well this<br />
year,” said Sue Fallon, the <strong>City</strong>’s United Way campaign<br />
manager.<br />
<strong>City</strong> gets ready for the holidays<br />
The Facilities Maintenance Division takes care <strong>of</strong> preparing<br />
<strong>City</strong> Hall for the holiday season. Don DeLoach,<br />
inside the bucket, is shown hanging the large Christmas<br />
wreath at <strong>City</strong> Hall. A sailboat, which is part <strong>of</strong> the<br />
<strong>City</strong>’s logo, has been placed in lights in the center <strong>of</strong><br />
the wreath. Greg Valenti observes from the ground.<br />
Other decorations include lights on the trees in front<br />
<strong>of</strong> <strong>City</strong> Hall. The division has also hung a large wreath<br />
at the <strong>Melbourne</strong> Auditorium and holiday banners in<br />
downtown <strong>Melbourne</strong>.<br />
<strong>City</strong> <strong>of</strong> <strong>Melbourne</strong> Public Works & Utilities Department<br />
One
PW/Utilities Connection - Dec. 20<strong>05</strong><br />
www.melbourneflorida.org<br />
Monthly Water Usage and Raw/Finished Water Quality Statistics<br />
Water Usage<br />
♦ Chlorides: 31 mg/L<br />
♦ Water pumped to service: 464,874,000 gallons or<br />
15.496 MGD average<br />
♦ Maximum finished water pumped to service:<br />
16.380 MGD on Nov. 5, 20<strong>05</strong><br />
♦ Fire hydrant flushing: 20,517,700 gallons<br />
♦ Committed capacity: 2.8758 MGD<br />
♦ Capacity available for development: 8.1186 MGD<br />
(Based on <strong>12</strong>-month average daily flow)<br />
Water Quality Statistics<br />
Lake water quality<br />
♦ pH: 7.3<br />
♦ Alkalinity: 43 mg/L<br />
♦ Total hardness: 60 mg/L<br />
Public Works/Utilities Data from Nov. 20<strong>05</strong><br />
♦ Color: 201<br />
♦ Total dissolved solids (TDS): 131 mg/L<br />
Well water quality<br />
♦ pH: 7.7<br />
♦ Alkalinity: <strong>12</strong>2 mg/L<br />
♦ Total hardness: 648 mg/L<br />
♦ Chlorides: 774 mg/L<br />
♦ Color: 7<br />
♦ TDS: 1,669 mg/L<br />
Finished water quality - pumped to service<br />
♦ pH: 8.3<br />
♦ Alkalinity: 31 mg/L<br />
♦ Total hardness: 45 mg/L<br />
♦ Chlorides: 36 mg/L<br />
♦ Color: 3<br />
♦ Total dissolved solids (TDS): 146 mg/L<br />
New well at RO plant to provide backup to existing wells<br />
Design has<br />
recently begun<br />
for a backup well<br />
at the Joe Mullins<br />
Reverse Osmosis<br />
Treatment Plant.<br />
When construction<br />
is completed,<br />
the new well will<br />
provide a more<br />
flexible and reliable<br />
source <strong>of</strong> groundwater.<br />
In 2002, the <strong>City</strong><br />
identified the need<br />
to construct an<br />
additional <strong>Florida</strong>n<br />
Aquifer production<br />
well as a backup<br />
due to the occasional extreme water quality issues in<br />
Production Well #3A.<br />
Water Production Superintendent Fred Davis in front <strong>of</strong> Well #2.<br />
In addition, the new well can be used to backup any<br />
<strong>of</strong> the other three wells in case <strong>of</strong> power outages, mechanical<br />
problems or regular preventive maintenance,<br />
and if the backup generator fails.<br />
“This was a problem during the 2004 hurricane<br />
season,” said Water Production Superintendent Fred<br />
Davis. “We lost service on one <strong>of</strong> the generators during<br />
Hurricane Frances<br />
and we could only<br />
use one well.”<br />
The new well will<br />
also be a first step<br />
toward an expanded<br />
wellfield needed to<br />
support the potential<br />
future expansion <strong>of</strong><br />
the RO facility.<br />
L.S. Sims & Associates,<br />
a hydrogeological<br />
firm, is providing<br />
the design, which<br />
should be completed<br />
in February. Construction<br />
<strong>of</strong> the well<br />
should be completed<br />
by early summer.<br />
According to Larry Sims, the new well will descend<br />
700 feet underground. “Like the others, the minimum<br />
flow will be 2,500 gallons per minute and it will be a<br />
16-inch well with piping from the well to the RO Plant,”<br />
Sims said.<br />
The construction estimate for the well is between<br />
$350,000 - $500,000. The pump house and control<br />
system is expected to add another $150,000 to the<br />
construction cost.<br />
<strong>City</strong> <strong>of</strong> <strong>Melbourne</strong> Public Works & Utilities Department<br />
Two
PW/Utilities Connection - Dec. 20<strong>05</strong><br />
www.melbourneflorida.org<br />
Wastewater Treatment Operational Summary and Reuse Statistics<br />
D.B. Lee WWTP<br />
♦ Treated this month: 137.72 MG<br />
♦ Treated daily: 4.59 MGD<br />
♦ Reuse production — total month flow: 35.99 MG<br />
♦ Reuse average daily flow: 1.24 MGD<br />
♦ Reuse number <strong>of</strong> days run: 21<br />
♦ Plant efficiency, BOD removal: 98.5%<br />
♦ Committed capacity: 1.3654 MGD<br />
♦ Capacity available for development: 0.0345 MGD<br />
(Based on <strong>12</strong>-month average daily flow)<br />
Public Works/Utilities Data from Nov. 20<strong>05</strong><br />
Grant St. WWTP<br />
♦ Treated this month: 113.42 MG<br />
♦ Treated daily: 3.78 MGD<br />
♦ Reuse production — total month flow: 4.26 MG<br />
♦ Reuse average daily flow: 0.14 MGD<br />
♦ Reuse number <strong>of</strong> days run: 30<br />
♦ Plant efficiency, BOD removal: 97.8%<br />
♦ Committed capacity: 1.0<strong>12</strong>4 MGD<br />
♦ Capacity available for development: 0.8450 MGD<br />
(Based on <strong>12</strong>-month average daily flow)<br />
SUMMARY OF WASTEWATER TREATMENT<br />
AND REUSE PRODUCTION<br />
400<br />
40<br />
375<br />
350<br />
325<br />
WASTEWATER TREATED (MG):<br />
D.B. LEE WWTF 137.72<br />
GRANT ST WWTP 113.42<br />
TOTAL TREATED 251.14<br />
REUSE PRODUCTION (MG)<br />
D.B. LEE WWTP 35.99<br />
GRANT ST WWTP 4.26<br />
TOTAL REUSE 40.25<br />
35<br />
300<br />
30<br />
MILLION GALLONS PER MONTH<br />
275<br />
250<br />
225<br />
200<br />
175<br />
150<br />
<strong>12</strong>5<br />
25<br />
20<br />
15<br />
100<br />
10<br />
75<br />
50<br />
5<br />
25<br />
0<br />
0<br />
JAN<br />
FEB<br />
MAR<br />
APR<br />
MAY<br />
JUN<br />
JUL<br />
AUG<br />
SEP<br />
OCT<br />
NOV<br />
DEC<br />
2004 TOTAL FL OW TR EATED 20<strong>05</strong> TOTAL FL OW TR EATED TOTAL P ER MITTED FL OW CAP ACITY TOTAL R EUS E FL OW P ER MITTED<br />
2004 TOTAL R EUS E P R ODUCED 20<strong>05</strong> TOTAL R EUS E P R ODUCED TOTAL R AINFAL L<br />
Streets and Stormwater Management Monthly Summary<br />
♦ Daytime street sweeper — hours run: 130<br />
Cubic yards <strong>of</strong> material removed: 164.5<br />
♦ Nighttime street sweeper — hours run: 48<br />
Cubic yards <strong>of</strong> material removed: 58.5<br />
♦ Asphalt repairs made: 43<br />
♦ Tons <strong>of</strong> asphalt used: 45.75<br />
♦ Feet <strong>of</strong> canals cleaned mechanically: 4,250<br />
♦ Acres treated through aquatic spraying: 21<br />
♦ Feet <strong>of</strong> storm drain pipe repaired: 300<br />
♦ Concrete repairs: 25<br />
♦ Cubic yards <strong>of</strong> concrete used: 28<br />
<strong>City</strong> <strong>of</strong> <strong>Melbourne</strong> Public Works & Utilities Department<br />
Three
PW/Utilities Connection - Dec. 20<strong>05</strong><br />
www.melbourneflorida.org<br />
Utilities Data from Nov. 20<strong>05</strong><br />
November Highlights<br />
The level <strong>of</strong> Lake Washington decreased during<br />
the last month. At the end <strong>of</strong> November, the lake<br />
level was 16.64 feet above sea level. This compares<br />
to the lake level at the end <strong>of</strong> October, when<br />
it was 17.88 feet above sea level.<br />
The D.B. Lee Wastewater Treatment Plant recorded<br />
1.4 inches <strong>of</strong> rain during six days in November.<br />
The Grant Street Wastewater Treatment<br />
Plant received 1.76 inches <strong>of</strong> rain over 10 days<br />
during November. A total <strong>of</strong> 40.25 million gallons <strong>of</strong><br />
reclaimed water was produced during November.<br />
This represents 16% percent <strong>of</strong> total plant flows for<br />
November.<br />
What’s Done, What’s Underway and What’s Coming Up<br />
Water Projects<br />
Recently Completed:<br />
Turtlemound North waterline<br />
extension, $471,200<br />
Aurora elevated water tank<br />
rehabilitation, $82,000<br />
Eau Gallie River sub-aqueous<br />
crossing, $<strong>12</strong>4,535<br />
Under Construction:<br />
Phase II surface water treatment<br />
plant improvements,<br />
$11,322,000<br />
Chlorine scrubber at Avenue B<br />
booster station, $102,000<br />
Miscellaneous two-inch to sixinch<br />
waterline upgrades, $874,857<br />
Under Design or in Bid<br />
Process:<br />
Wickham Road ground storage<br />
tank and booster pump station<br />
Automatic transfer switch and<br />
generator enclosure at the surface<br />
water treatment plant’s belt press<br />
building<br />
A1A water main interconnect<br />
Pineda Causeway 16” water<br />
main<br />
Babcock Street water line<br />
relocation between Fee Avenue and<br />
<strong>Melbourne</strong> Avenue<br />
Wastewater Projects<br />
Recently Completed:<br />
Demolition <strong>of</strong> old treatment<br />
units at D.B. Lee WWTF, $624,700<br />
New monitoring network for<br />
reuse system at DB Lee WWTP,<br />
$<strong>12</strong>,503<br />
Under Design or in Bid<br />
Process:<br />
Reuse master plan<br />
Water & Wastewater Operations<br />
maintenance building<br />
Lift Station #55 upgrade<br />
Grant Street Wastewater Treatment<br />
Plant lighting upgrade<br />
Sarno Road force main upgrade<br />
Electrical upgrade to the sludge<br />
belt press building at D.B. Lee and<br />
Grant Street WWTPs<br />
D.B. Lee WWTP administration<br />
building<br />
Lift Station #43 (Front Street)<br />
upgrade<br />
Garage doors at Grant Street<br />
WWTP<br />
Bell Street sewer aerial crossing<br />
Reuse interconnect<br />
Pictured are pallets <strong>of</strong> ISO board, which is a type <strong>of</strong><br />
Styr<strong>of</strong>oam insulation used for ro<strong>of</strong>s. Stored at the Public<br />
Works Complex, the material will be used for four different<br />
ro<strong>of</strong>ing projects at <strong>City</strong> facilities. The ISO board improves<br />
energy efficiency.<br />
Streets & Stormwater<br />
Projects<br />
Under Construction:<br />
Sherwood Park drainage improvements,<br />
$358,285<br />
Eber Road widening from<br />
Babcock Street to Dairy Road,<br />
$3,840,879<br />
Paradise Cay CIPP, $325,835<br />
Laurie Road drainage improvements,<br />
$363,510<br />
Fabri-Form at Nicklaus ditch,<br />
$16,316<br />
Under Design or in Bid<br />
Process:<br />
Hoag Avenue paving and drainage<br />
improvements<br />
Upgrade <strong>of</strong> stormwater system<br />
at Charles Dr./Almar Subdivision<br />
Upgrade <strong>of</strong> existing culvert<br />
crossing under Pirate Lane<br />
Misc. CIPP lining projects<br />
General Public Works:<br />
Under Construction:<br />
Public Works & Utilities Administration<br />
Building, $5<strong>12</strong>,391<br />
For more information about this report, please contact the <strong>Melbourne</strong> PW/Utilities<br />
Administration Department at (321) 674-5761 or send an e-mail to utilitiesadmin@melbourneflorida.org<br />
<strong>City</strong> <strong>of</strong> <strong>Melbourne</strong> Public Works & Utilities Department<br />
Four