(PDF) 60-0200 - Cloverdale Paint

TECHNICAL SPECIFICATIONS DATA SHEET
43174
Timberlox Super Spar Varnish Alkyd High Gloss
Product Description
Timberlox Super Spar Varnish Alkyd High Gloss is a transparent high gloss varnish specially formulated for
use in harsh marine and exterior environments. It contains an Ultra-Violet light absorber for extended life. It
is ideally suited for use on wood surfaces such as doors, trim, boat railings, exterior furniture, spars and
boat decks. Approved by the Master Painter's Institute under category # 28.
Intended Uses
Use on exterior wood surfaces such as doors, trim, boat decks, railings, furniture, spars, etc.
Product Data
Color:
Drying Time: (@20 o C 50% Relative Humidity)
Clear
Tack Free: 4 - 6 Hours
Finish: Re-Coat: 16 hours min
Full Gloss (>85 units @ 60 o )
Thinner:
Bases: 78001 Mineral Spirits
N/A
Flash Point (Tag Closed Cup):
42 o C - (107°F)
Vehicle Type:
Phenolic Varnish
Viscosity:
56 - 60 KU
Solids by Volume:
50% V.O.C. (Before Thinning):
398 g/L or 3.31 lbs/gal
Solids by Weight:
56%
Recommended Film Thickness
(Per Coat):
Wet: 2.0 - 2.7 mils (51 - 69 microns)
Dry: 1.0 - 1.2 mils (25 - 30 microns)
Theoretical Coverage (Per Coat):
600 - 800 ft 2 /gal (15.0 - 20.0 m 2 /L)
43174 Page 1 of 2
60-0200

Surface Preparation
All surfaces must be clean, dry and free from oil, grease, and wax. Previously varnished surfaces must be
sanded to a dull gloss after all loose and flaking varnish has been removed. Sand new wood with fine
sandpaper and remove sanding dust with a tack cloth. Multiple coats (3 or more) are recommended for best
results.
Recommended Primer
Drywall
- N/A
Method
- Brush (preferred), air or airless
spray. Airless tips: 0.007" - 0.011"
Wood
Masonry
- Self-Priming
- Not Recommended
Thinning
Cleanup
- Up to 20% with 78001 Clova
Thinner No. 1 (Mineral Spirits) for first
coat only
- Use 78001 Mineral Spirits
Steel
- Not Recommended
For detailed information please refer to MSDS
Check for recent amendments to this data sheet at www.cloverdalepaint.com/html/catalog_recent_ar.asp
Safety Precautions
Warning
CONTAINS PETROLEUM DISTILLATE. HARMFUL IF SWALLOWED. CAUSES EYE AND SKIN
IRRITATION. VAPOUR HARMFUL. COMBUSTIBLE. KEEP OUT OF REACH OF CHILDREN. Keep away
from heat, sparks, and open flame. Do not take internally. Avoid contact with eyes and skin, and breathing
of vapour mist. Wear an air supplied mask when applying in enclosed areas. Wash thoroughly after
handling. Close container after EACH use. USE WITH ADEQUATE VENTILATION.
First Aid
In case of eye contact, flush immediately with plenty of water for at least 15 minutes. Wash contaminated
skin with soap and water. If ingested, call physician or the Poison Control Centre immediately.
Warranty Disclaimer
Cloverdale Paint manufactures quality products. In the event that this product is defective or in any way
unsuitable for the application for which it is sold, Cloverdale Paint Inc. will replace the product free of
charge. The warranty provided by this data sheet is the only warranty or guarantee of quality made in
respect of this product by Cloverdale Paint Inc. By purchasing this product the customer accepts this
warranty in lieu of all others, and waives all claims to any other remedy arising from any warranty or
guarantee of quality, whether such warranty or guarantee of quality was made expressly to the customer or
implied by any applicable law.
6950 King George Hwy., Surrey, BC, V3W 4Z1
Web Site: www.cloverdalepaint.com Email: helpdesk@cloverdalepaint.com
Phone: (604) 596-6261 Fax: (604) 597-2677
60-0200v1 6/14/04
43174 Page 2 of 2
60-0200