View Batteries Cross Reference Guide

VOLTS
VOLTS
CAT ® BATTERY SPECIFICATIONS
CAT ®
GENERAL SERVICE BATTERIES
— AVAILABLE WORLDWIDE —
VALVE REGULATED LEAD ACID (VRLA) BATTERIES
GENERAL INFORMATION
BCI
GROUP
SIZE
PART NO.
CCA ≈
RC
MINS
†
AMP HR
CAP.
@ 20
HRS.
CONST.
NOTES
LENGTH
IN (MM)
GELLED (GEL) ELECTROLYTE - MARINE / RECREATIONAL - DEEP CYCLE CAPABILITY
BCI OVERALL DIMENSIONS
WIDTH
IN (MM)
HEIGHT
IN (MM)
NOMINAL
WEIGHT
WET
LB (KG)
4D 152-8006 970 375 12 183 MF-G/VRLA 20.8 (528) 8.5 (216) 10 (254) 129.8 (59)
8D 152-7242 1150 475 12 225 MF-G/VRLA 20.8 (528) 11.1 (282) 10 (254) 160.8 (73)
MF-G/VRLA - Maintenance Free-Gel Battery. Sealed, Valve-Regulated Lead
Acid (VRLA) battery with gelled electrolyte.
≈ - Cold Cranking Amps for 30 seconds at 0°F (-18°C)
† - Reserve Capacity Minutes minimum of 25 amp output at 80°F (27°C)
• Starting/Deep Cycle Marine or Recreational Use Battery. Could be used
for Gen-Sets or UPS type applications requiring a sealed battery.
• VRLA batteries use recombination reaction to prevent the escape of
hydrogen and oxygen gases normally lost in a flooded lead acid battery.
They are non-spillable, never need watering and should never be opened.
BCI
GROUP
SIZE
PART NO. A B
C
CONST.
NOTES
TERM.
LENGTH
IN (MM)
BCI OVERALL DIMENSIONS
WIDTH
IN (MM)
TERMINAL
HEIGHT
IN (MM)
CONTAINER
HEIGHT
IN (MM)
NOMINAL
ABSORBED GLASS MAT (AGM) BATTERIES - DESIGNED FOR HIGH-RATE UNINTERRUPTIBLE POWER SUPPLIES (UPS) OR STANDBY APPLICATIONS
U1 250-0474 116 62 1.63 12 MF-AGM/VRLA 1 7.7 (196) 5.1 (132) 7.1 (182) 6.2 (157) 24 (11)
45 250-0475 156 84.3 2.75 12 MF-AGM/VRLA 2 8.8 (225) 5.3 (135) 8.7 (221) 8.1 (207) 38.5 (18)
24 250-0476 262 140 3.95 12 MF-AGM/VRLA 2 10.2 (259) 6.8 (173) 9.1 (232) 8.1 (206) 53 (24)
27 250-0477 304 165 4.61 12 MF-AGM/VRLA 2 12.7 (323) 6.8 (173) 8.7 (220) 8.1 (206) 63 (29)
31 250-0478 350 186 5.25 12 MF-AGM/VRLA 3 12.9 (329) 6.7 (171) 8.7 (222) 8.5 (218) 69 (31)
31 250-0479 475 261 6.66 12 MF-AGM/VRLA 3 13.5 (342) 6.7 (172) 11.2 (286) 11.1 (281) 98 (45)
4D 250-0483 624 338 9.91 12 MF-AGM/VRLA 4 21.7 (552) 8.8 (210) 9.3 (237) 8.7 (22) 129 (59)
A - Power Watts per Cell for 15 minutes to 1.67 Volts Per Cell
@ 77°F (25°C)
B - Amp Hour @ 20 Hour Rate to 1.75 Volts Per Cell @ 77°F (25°C)
C - Amp Hour @ 10 Hour Rate to 1.80 Volts Per Cell @ 68°F (20°C)
MF-AGM/VRLA - Maintenance Free-Absorbed Glass Mat (AGM) Battery.
• Sealed Valve-Regulated Lead Acid (VRLA) with electrolyte absorbed in
separators consisting of a sponge-like mass of matted glass fibers.
• Preferred for high-rate performance in uninterruptible power supply
(UPS) or standby applications.
• VRLA batteries use recombination reaction to prevent the escape of
hydrogen and oxygen gases normally lost in a flooded lead acid battery.
They are non-spillable, never need watering and should never be opened.
Terminals:
1 - Lead terminal. L Shaped. Terminals have square holes.
2 - Lead terminal with brass inserts. 1/4-20 x .25 Deep Female Thread.
3 - Lead terminal with brass inserts. 1/4-20 x .25 Deep Female Thread.
4 - Lead terminal with brass inserts. 1/4-20 x Female Thread.
• Ratings conform to IEEE-485 Standards.
1 - BCI
Group U1
2 - BCI
Groups 45,
24, 27
3 - BCI
Group 31
4 - BCI
Group 4D
Transit Bus Terminal for 8D Part # 250-0473
One piece end terminal. Right end of Battery.
1/2" - 13 Steel Postitive Stud
3/8" - 16 Steel Negative Stud
Battery Accessories:
• Group 31 - Charging Posts for Stud Terminals - Part # 4C-5637
• Screw-in Charging Posts for Side Terminals - Part # 4C-5638
• Wing Nut for Part # 175-4390/175-4370/175-4360/8C-3628 - Part # 2B-9498
• Wing Nut for Part # 8C-3638 & 8C-3639 Marine Batteries - Part # 3B-0723
• Digital Battery Analyzer - Part # 177-2330
• Battery Voltmeter - Part # 4C-6600
• Battery Load Tester - Part # 4C-4911
• Booster Cable 12' (3.66 m) - Part # 4C-4933
• Booster Cable 20' (6.00 m) - Part # 4C-4937
* Note: Ratings and Part Numbers are subject to change without notice.
4