WAUKESHA Manuale Inglese UNIVERSAL 1 - Asco Pompe Srl

More documents

Recommendations

Info

611 Sugar Creek Road Delavan, WI 53115 USA Tel: (800) 252-5200 (within the USA) • (262) 728-1900 Fax: (800) 252-5012 (within the USA) • (262) 728-4904 E-mail: info@processequipment.spx.com Website: www.spxprocessequipment.com Information contained in this manual is subject to change without notice and does not represent a commitment on the part of Waukesha Cherry-Burrell. No part of this manual may be reproduced or transmitted in any form or by any means, electronic or mechanical, including photocopying and recording, for any purpose, without the express written permission of Waukesha Cherry-Burrell. Copyright © 2006 All Rights Reserved. Gore-Tex is a registered trademark of W.L. Gore & Associates, Inc. Kalrez is a registered trademark of DuPont Dow Elastomers. Chemraz is a registered trademark of Greene, Tweed & Co. Revised Date: January 2006 Publication: 95-03002
Table of Contents Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 1 Warranty and Receiving . . . . . . . . . . . . . . . . . . . . . . . . . . .4 2 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 3 Start-Up Check List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10 4 Troubleshooting a Pumping System . . . . . . . . . . . . . . . .11 5 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 Fluid Head Disassembly All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18 Model 320-324 Body Disassembly . . . . . . . . . . . . . . . . . . .19 Model 323A Aseptic Body Disassembly . . . . . . . . . . . . . . .19 Fluid Head Assembly Most Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20 Flushing Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21 6 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22 Visual Checks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22 “Feel” Checks. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23 Seal Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24 O-Ring - Seals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24 Mechanical Seals Universal Series. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26 Model 320, 324 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29 Model 323A Aseptic. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30 Annual Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32 7 Factory Reconditioning. . . . . . . . . . . . . . . . . . . . . . . . . . .33 8 Disassembly Procedures . . . . . . . . . . . . . . . . . . . . . . . . .34 Shaft Bearing and Gears All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .34 Shaft Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .34 All Models except 320,323A and 324 . . . . . . . . . . . . . . . . .35 Models 320, 323A and 324 . . . . . . . . . . . . . . . . . . . . . . . . .36 9 Assembly Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . .37 Models 6, 12, 15, 18, 22, 30, 32, 34 and 33A Aseptic . . . . .37 Models 320, 323A, 324 Shaft . . . . . . . . . . . . . . . . . . . . . . .39 Gear and Gear Cover Assembly All Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43 Back Face Clearance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .44 January 2006 Table of Contents 95-03002 Page 1
Page 1: Operation and Maintenance Manual Un
Page 5 and 6: Safety Warnings, Cautions, and Note
Page 7 and 8: Section 2 - Installation The instal
Page 9 and 10: Inlet Vacuum Service — use check
Page 11 and 12: Check rotation direction of drive t
Page 13 and 14: Section 4 - Troubleshooting a Pumpi
Page 15 and 16: Problem Probable Causes Solutions I
Page 17 and 18: Problem Probable Causes Solutions
Page 19 and 20: NOTE: For hot or cold extremes use
Page 21 and 22: MODEL 320 AND 324 BODY DISASSEMBLY
Page 23 and 24: Flushing Connection NOTE: Flushing
Page 25 and 26: Wear Area Cause Extended running wi
Page 27 and 28: Double O-Ring Service 1. Remove O-r
Page 29 and 30: Service - Single Outer Seal Seat O-
Page 31 and 32: Pin Wave Spring Body O-Ring Assembl
Page 33 and 34: Seal Retainer Seal Seat Inner Seal
Page 35 and 36: Section 7 - Factory Reconditioning
Page 37 and 38: 9. Remove front bearing retainer bo
Page 39 and 40: Section 9 - Assembly Procedures ALL
Page 41 and 42: Rear Seal Assembly 1. Install space
Page 43 and 44: Cup Spacers 4. Apply Molykote greas
Page 45 and 46: GEAR AND GEAR COVER ASSEMBLY - ALL
Page 47 and 48: Not Enough Back Face Clearance A (A
Page 49 and 50: Section 10 - Reference Tables and R
Page 51 and 52: Three types of Relief Covers are av
Page 53 and 54:
Jacketed Cover Available on Models
Page 55 and 56:
006 - 014 - 015 - 018 - 024-UI Pump
Page 57 and 58:
006 - 014 - 015 - 018 - 024-UI Comm
Page 59 and 60:
006 - 014 - 015 - 018 - 024-UI Comm
Page 61 and 62:
006 - 014 - 015 - 018 - 024-UI Seal
Page 63 and 64:
006 - 014 - 015 - 018 - 024-UI Vent
Page 65 and 66:
030 - 034 - 033-UI Common Parts Dia
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
030 - 034-UI Seal Parts Diagram O-R
Page 75 and 76:
030 - 034-UI Vented Cover Diagram (
Page 77 and 78:
040-UI Common Parts Diagram January
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
040-UI Seal Parts Diagram O-Ring Se
Page 87 and 88:
040-UI Vented Cover Diagram 101 101
Page 89 and 90:
060 - 064 - 130 - 134 - 133-UI Comm
Page 91 and 92:
060 - 064 - 130 - 134 - 133-UI Comm
Page 93 and 94:
060 - 064 - 130 - 134 - 133-UI Comm
Page 95 and 96:
060 - 064 - 130 - 134-UI Seal Parts
Page 97 and 98:
060 - 064 - 130 - 134-UI Vented Cov
Page 99 and 100:
Page 101 and 102:
220 - 224 - 223-U1 Common Parts Dia
Page 103 and 104:
Page 105 and 106:
220 - 224 - 223-U1 Common Parts Dia
Page 107 and 108:
220 - 224-U1 Seal Parts Diagram O-R
Page 109 and 110:
220 - 224-U1 Vented Cover Diagram (
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
320 - 324 - 323-UI Seals Parts Diag
Page 119 and 120:
Universal I PD Pump Dimensions - Re
Page 121 and 122:
Tru-Fit Universal I PD Pump Dimensi
Page 123 and 124:
Tru-Fit Universal I PD Pump Dimensi
Page 125 and 126:
Tru-Fit Universal I PD Pumps Diagra
Page 128:
611 Sugar Creek Road • Delavan, W
show all

WAUKESHA Manuale Inglese UNIVERSAL 1 - Asco Pompe Srl

Create successful ePaper yourself

Delete template?

Save as template?