This symbol marks such tractor

More documents

Recommendations

Info

86TRACTOR RUNNING INAFTER 70 HOURSAt tractors Z 8621 - 10641drain the hotoil from engine and exchange the fullflowengine oil filter. Fill in the enginewith new oil to the prescribed level(upper mark of oil dipstick - inspect itafter cranking the engine and stabilizingthe oil level). It is necessary to let theengine run few minutes before refillingthe oil.F 126 F 127 F 128AFTER 70 HOURSCheck the torque of cylinder head (at thecold engine, by prescribed torque inprescribed sequence of screws).Do checking, adjustment, head retighteningand adjustment of valveclearance in an authorized service.AFTER 70 HOURSRemove and clean:- magnetic element of transmissionsuction filter (1)- strainer element of transmission oilsuction cleaner (2)Exchange:- paper element of full-flow fine cleaner(3)
87TRACTOR RUNNING INAFTER 100 HOURSAfter running in you can work with thetractor without any restrictions.The operating regime at tractors Z 8621- Z 10641:recommendedoperating speed 1400 - 2300 RPMlow idle speed 700 - 650 RPMoperating oil 0,2 - 0,5 MPapressureoil pressure atlow idle speed min. 0,05 MPacoolanttemperature 80 - 95“CF 129 F 130AFTER 100 HOURSAfter running in you can workwith the tractor without anyrestrictions. The operating regimeat tractors Z 11641:maximal speed 2350 RPMrecommendedoperating speed 1400 - 2450 RPMlow idle speed 700 „ 10 RPMoperating oil 0,35 MPapressureoil pressure atlow idle speed min. 0,05 MPacoolanttemperature 80 - 100“C
Page 3 and 4:
ZETORThis operator’s manual will
Page 5 and 6:
5CONTENTSPageLocation of serial num
Page 7 and 8:
7Zetor 8641 Forterra turbo - 60 kWZ
Page 9 and 10:
9LOCATION OF SERIAL NUMBERS Z 8621
Page 11 and 12:
11LOCATION OF SERIAL NUMBERSWheneve
Page 13 and 14:
15. Pay special attention when driv
Page 15 and 16:
15PREVENTIVE DAILY SERVICEDo this s
Page 17 and 18:
17PREVENTIVE DAILY SERVICEFLUID SER
Page 19 and 20:
19PREVENTIVE DAILY SERVICECAB FILTR
Page 21 and 22:
Tractor user must be properlyacquai
Page 23 and 24:
23SAFETY CABSAFETY CABUse steps and
Page 25 and 26:
25SAFETY CABOPENING FOR IMPLEMENTAT
Page 27 and 28:
27DRIVER’S SEAT MARSSEAT ADJUSTME
Page 29 and 30:
29DRIVER’S SEAT - COBODRIVER’S
Page 31 and 32:
31CONTROLSCONTROL PANEL OF HEATING,
Page 33 and 34:
33CONTROLS∗ AC CONTROLThe switch
Page 35 and 36: 35LOCATION OF DASHBOARDAnalogue das
Page 37 and 38: 37LOCATION OF DASHBOARDDigital dash
Page 39 and 40: 39CONTROLSLIGHT SWITCH (a)a - Light
Page 41 and 42: 41KEY SWITCHKEY SWITCHKey switch is
Page 43 and 44: 43CONTROLSTHROTTLE CONTROL LEVERA -
Page 45 and 46: 45CONTROLSPTO SELECTION CONTROL LEV
Page 47 and 48: 47ACQUAINTANCE WITH TRACTORAVERAGE
Page 49 and 50: 49ACQUAINTANCE WITH TRACTOR7. warni
Page 51 and 52: ELECTRONIC ENGINE GOVERNORPageSchem
Page 53 and 54: 53ELECTRONIC ENGINE GOVERNORPUSH BU
Page 55 and 56: 55ELECTRONIC ENGINE GOVERNORWith su
Page 57 and 58: ELECTRONIC ENGINE GOVERNORa - by ha
Page 59 and 60: 59ELECTRONIC ENGINE GOVERNOR4. RESE
Page 61 and 62: 61ELECTRONIC ENGINE GOVERNOR4. TEMP
Page 63 and 64: Be familiar with shiftingpattern an
Page 65 and 66: OPERATIONBEFORE STARTINGBefore star
Page 67 and 68: 67OPERATIONIF ENGINE DOESN’T STAR
Page 69 and 70: 69OPERATIONIMMEDIATELY AFTER STARTI
Page 71 and 72: 71OPERATIONSHIFTING FROM LOWER TO H
Page 73 and 74: OPERATIONACCELERATIG THE TRACTOR1.
Page 75 and 76: 75OPERATIONFRONT DRUM BRAKESFront d
Page 77 and 78: 77OPERATIONSINGLE HOSE AIR TRAILER
Page 79 and 80: 79OPERATIONCONTROL OF FRONT DRIVING
Page 81 and 82: NOTE81
Page 83 and 84: 83TRACTOR RUNNING INPageGeneral rul
Page 85: 85TRACTOR RUNNING INAFTER 10 HOURSW
Page 91 and 92: 91TRANSPORTATIONStranaFront hook ..
Page 93 and 94: 93TRANSPORTATIONAUTOMATIC MOUTH OF
Page 95 and 96: TRANSPORTATIONMECHANICAL UNLOCK OF
Page 97 and 98: 97TRANSPORTATIONTypeAllowed vertica
Page 99 and 100: 99Speed(km/h)203040F (kN)TireF(kN)T
Page 101 and 102: DRIVING THE AGRICULTURAL MACHINESPa
Page 103 and 104: 103DRIVING THE AGRICULTURAL MACHINE
Page 107 and 108: 107HYDRAULIC SYSTEMStranaHydraulic
Page 109 and 110: 109HYDRAULIC SYSTEMINNER CIRCUIT CO
Page 111 and 112: 111HYDRAULIC SYSTEMCAB CONTROL SWIT
Page 113 and 114: 113HYDRAULIC SYSTEMREAR OUTLETS OF
Page 115 and 116: HYDRAULIC SYSTEMCONTROL OF DOUBLE-A
Page 117 and 118: 117HYDRAULIC SYSTEMSELECTIVE CONTRO
Page 121 and 122: 121ELECTRO-HYDRAULICPageSchema of e
Page 123 and 124: ELECTRO-HYDRAULICLOCATION OF ELECTR
Page 125 and 126: 125ELECTRO-HYDRAULICFAST LOWERINGLe
Page 127 and 128: ELECTRO-HYDRAULICFLOATING POSITIONP
Page 133 and 134: 133HITCHESPage(A) rear three point
Page 135 and 136: 135HITCHESSAFETY REGULATIONS FORWOR
Page 137 and 138:
137HITCHESBoth stabilizers must alw
Page 139 and 140:
139HITCHESFRONT THREE POINT HITCHFr
Page 141 and 142:
HITCHESFRONT THREE POINT HITCHFOR Z
Page 143 and 144:
NOTE143
Page 145 and 146:
145WHEEL TREAD SETTINGPageBlocking
Page 147 and 148:
147CHANGE OF WHEEL TREADSETTING THE
Page 149 and 150:
149SETTING THE FRONT WHEEL TOE-INFR
Page 151 and 152:
151SETTING THE WHEEL STOPSWithout f
Page 153 and 154:
NOTE153
Page 155 and 156:
BALLAST WEIGHTSPageFront ballast we
Page 157 and 158:
157BALLAST WEIGHTSREAR WHEEL BALLAS
Page 159 and 160:
159FILLING LIQUID INTO TIRESDRAININ
Page 161 and 162:
NOTE161
Page 163 and 164:
Driver alone can do almost any work
Page 165 and 166:
165MAINTENANCE INSTRUCTIONSDISASSEM
Page 167 and 168:
167MAINTENANCE INSTRUCTIONSLUBRICAT
Page 169 and 170:
169MAINTENANCE INSTRUCTIONSFILLING
Page 171 and 172:
171MAINTENANCE INSTRUCTIONSREGENERA
Page 173 and 174:
173MAINTENANCE INSTRUCTIONSCHANGING
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
179MAINTENANCE INSTRUCTIONSFILLING
Page 181 and 182:
181MAINTENANCE INSTRUCTIONSDRAINING
Page 183 and 184:
183MAINTENANCE INSTRUCTIONSRECOMMEN
Page 185 and 186:
185MAINTENANCE INSTRUCTIONSRECOMMEN
Page 187 and 188:
NOTE187
Page 189 and 190:
ADJUSTMENTPageInspecting the tensio
Page 191 and 192:
ADJUSTMENTADJUSTMENT OF VALVE CLEA-
Page 193 and 194:
193ADJUSTMENTBLEEDING THE SERVICE B
Page 195 and 196:
195ADJUSTMENTBLEEDING THE FRONT CAR
Page 197 and 198:
197ADJUSTMENTADJUSTMENT OF PARKING
Page 199 and 200:
199ADJUSTMENTADJUSTING THE LIFTING
Page 201 and 202:
NOTE201
Page 203 and 204:
203ELECTRICAL INSTALLATIONPageElect
Page 205 and 206:
205ELECTRICAL INSTALLATIONBATTERYBa
Page 207 and 208:
207ELECTRICAL INSTALLATION3. Interv
Page 209 and 210:
209F 301FUSE BOXFuse box is accessi
Page 211 and 212:
211ELECTRICAL INSTALLATIONCHECKING
Page 213 and 214:
213WIRING HARNESS DIAGRAM OF TRACTO
Page 215 and 216:
2151. Right roof headlight2. Front
Page 217 and 218:
NOTE217
Page 219 and 220:
219PLANNED TECHNICAL MAINTENANCEPag
Page 221 and 222:
221PLANNED TECHNICAL MAINTENANCEINS
Page 223 and 224:
223PLANNED TECHNICAL MAINTENANCEINS
Page 225 and 226:
225Note :PLANNED TECHNICAL MAINTENA
Page 227 and 228:
227PLANNED TECHNICAL MAINTENANCE
Page 229 and 230:
229PLANNED TECHNICAL MAINTENANCE
Page 231 and 232:
NOTE231
Page 233 and 234:
233PLANNED TECHNICAL MAINTENANCEPoz
Page 235 and 236:
235PLANNED TECHNICAL MAINTENANCEPoz
Page 237 and 238:
NOTE237
Page 239 and 240:
239MAIN TECHNICAL PARAMETERSPageTec
Page 241 and 242:
241MAIN TECHNICAL PARAMETERSTECHNIC
Page 243 and 244:
243MAIN TECHNICAL PARAMETERSTECHNIC
Page 245 and 246:
245MAIN DIMENSIONS(mm)WEIGHT(kg)MAI
Page 247 and 248:
247MAIN TECHNICAL PARAMETERSMAIN DI
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
277MAIN DIMENSIONS(mm)WEIGHT(kg)Tra
Page 279 and 280:
Page 281 and 282:
Page 283 and 284:
Page 285 and 286:
Page 287 and 288:
Page 289 and 290:
Page 291 and 292:
Page 293 and 294:
Page 295 and 296:
Page 297 and 298:
Page 299 and 300:
Page 301 and 302:
Page 303 and 304:
Page 305 and 306:
305MAIN TECHNICAL PARAMETERSFront t
Page 307 and 308:
307MAIN TECHNICAL PARAMETERSTRACTOR
Page 309 and 310:
309MAIN TECHNICAL PARAMETERSTRACTOR
Page 311 and 312:
311MAIN TECHNICAL PARAMETERSREAR IN
Page 313 and 314:
NOTE313
Page 315:
315Operator’s manualZ 8621, 8641
show all

This symbol marks such tractor

Create successful ePaper yourself

Delete template?

Save as template?